220250060001M11634Employee was climbing a ladder to access a screening plant when the ladder moved. EE reached out to grab the chain to steady self and heard a pop in EE's shoulder.
220250060009M12385EE was sliding a small and thin piece of grout (around 10 lbs) on the conveyor in order to grab it. While EE was doing so, it flipped while falling between the two sections of conveyor and the sharp edge cut EE's wrist (above glove line).
220250060010M12385Employee was pulling a piece of curb (with an end piece attached, coming out of the straight joint saw). While they were pulling, the end piece broke and fell right on the top of their right foot. The end piece was weighing around 90 lbs.
220250060011M11965Changing wear bars in head box. When the bolts were loosened the bar flipped hitting the thigh of the operator. The employee was given an Ibuprofen injection by the attending physician at the ER. 
220250060012M11363EE was walking on the ground and had a fall from the same level. EE sustained a broken rib on right side. Restricted duty for 2-3 weeks.
220250060013M12836Miner was standing on a conveyor catwalk and leaned a piece of 1/4" thick, 3" angle approximately 46" long against the handrail. The piece of angle fell on its side on the walkway with the corner of the angle landing on the miner's foot just behind the steel toe section of the boot.
220250060018M13738Employee was lifting a gas cylinder bottle on the welding trailer. EE lost grip due to a light frost; the cylinder fell back into the mounting slot with EE's right hand positioned on the bottom end of the bottle to allow EE to guide it down. EE's finger was in-between the bottle and metal rack resulting in injury to the tip of EE's right Pinky Finger, needing 4 stitches.
220250060021M11403Employee was at 071-01 pan feeder pulling a rock to unplug. While pulling the rock the employee felt a pop near their belly button.  Hernia.
220250070012M10892Customer truck driver found unresponsive in the cab of the customer truck driver's truck.
220250070013M13638The drive pulleys on the conveyor had become built up with frozen material. The conveyor was started to make sure all of the frozen material had been removed. A large pry bar was left on the conveyor belt when it was started. EE saw it and reached in to grab it when it was grabbed by the drive pulley and smashed EE's hand against the side of the conveyor frame.
220250080004M12115EE utilizing a folding pocketknife in the upside-down position to cut a 6" hose. Knife folded back on itself, pinning the EE's finger between the handle & blade, resulting in a laceration to right index finger. 
220250080012M13638At the completion of a job on the Bypass Dust Collector the Production Coordinator was ensuring all valves for the system were secure. As they walked to the discharge valve on the bypass compartment (which was closed) a blast of dust came out from the Benetech inspection door. The material hit the employee in the face and head causing an injury to the left eye.
220250100004M12305An employee was getting off of the Track Mobile and stepped off onto a piece of loose tin that had been blown off the track shed and was laying on the ground, causing EE to fall to the ground on EE's knees injuring EE's left knee.
220250100005M13748While placing a diester insert and attempting to maneuver in place, IP went to grab a tool and as placed right hand along the top railing area to maintain three points of contact, the suspended load shifted as it was shimmied in place, causing load to come down approx. 3-6" on hand, causing lacerations to top of fingers, and comminuted fractures to ring and pinky fingers.
220250100006M12666Employee was assisting in moving a portable gravity roller conveyor. Was carrying one end walking forward and the other employee was carrying the other end walking backwards. The conveyor snagged the floor and stopped suddenly, causing employee to jar EE's shoulder.
220250100007M13347Mill Maintenance Mechanic (M1) bent down on their right knee to observe the rotary gate valve at the #6 calciner. M1 began feeling pain in their right knee as they attempted to stand back up from the kneeling position. M1 was transported to the onsite clinic and was later transferred to an offsite facility for additional evaluation.
220250100008M13207While drilling an I-drift round, the injured miner's drill steel broke causing them to fall forward. As miner fell, miner reached out to catch themself on the rib and miner's hand contacted the edge of a bolt mat causing a laceration on the left palm/hand. The miner was taken to the doctor where miner received sutures.
220250100011M10441EMPLOYEE LEFT HAND INJURY FROM CONVEYOR BELT
220250100017M11844Ee hit finger on glass sample tube in the lab causing a small laceration. Seen at the clinic, diagnosed with a laceration, closed with sutures and released to return to work full duty.
220250100018M13047Ee reports walking to blue room and felt pop in left knee. Reports immediate pain and inability to bear weight. Seen at ER, diagnosed w/knee pop and possible ligament injury, and put off work pending an orthopedic consult. Does not appear to be an injury by accident. No uneven ground, no slip/trip/fall.
220250100020M11864Closing a clay belly door on airslide when it went positive and blew cement dust out and went into eyes.  Employee was wearing safety glasses it was just an unexpected plume of material.
220250100021M11884Transformer blew on surface, which caused power to drop on the surface and in the mine. Outage was reported to Cleveland Public Power (CPP) and mine was evacuated until power was restored.
220250100026M12385Employee was getting off the vertical drill and slipped off the last rung of the entry ladder. Employee fell on employee's right side and arm. Employee was taken to the ER as a precautionary method and x-rays were negative for rib injury.
220250100028M13648EE was using an impact wrench to remove bolts from the wear segments on a loader. EE placed a hand on the bottom edge to hold the carriage bolt up while using an impact gun. It spun the nut off. The bolt head spun causing a laceration to EE's left index finger and middle finger. EE was wearing protective gloves at the time. EE received stitches and restrictions.
220250100029M12516Employee was breaking off some rail cars and as EE was walking, EE's foot shifted in EE's boot. EE continued to work and making the switch. After going home and taking their sock off, EE saw that their foot was swollen and tight after about two hours.
220250100035M13588While repairing track on continuous miner, employee's thumb was caught between wooden block and gathering pan of continuous miner. Employee was wearing gloves at time of incident. Immediate Action Taken: First aid was performed, and incident was reported to supervisor. Employee was transported to local hospital for further treatment. Investigation started.
220250130005M11564Employee while performing normal duties slipped on the bottom rung of a ladder slightly twisting EE's knee. EE had three points of contact and did not fall.
220250130008M10722Coolant line located under the dash broke and sprayed the operator's leg
220250130011M10862Employee smashed and lacerated right hand ring finger attempting to unplug feed chute.
220250130012M12285Employee was tracking a conveyor belt on the return side of the conveyor using a small sledge hammer to adjust the return rollers. Employee missed EE's target and smashed EE's middle finger tip, resulting in a broken finger tip.
220250130014M11073While performing clean-up duties, employee stepped on rock and turned EE's right ankle resulting in sprain.
220250130015M13708An employee was at desk working on a stainless-steel junction box. While attempting to move the box off the desk, the box slipped.  When regaining control of the box, a sharp edge on the hinge of the box cut the employee's left middle finger.  The employee was taken to the local occupational clinic to have the wound cleaned and 3 stitches were used to close the wound.
220250130016M11804Employee stepped over a trailer hitch and caught boot on the hitch which caused employee to trip and fall to the ground. Employee was diagnosed with a fracture in the left humerus.
220250130017M12636There was a fire in the GAR facility.  The employee was fighting the fire and suffered smoke inhalation. The employee went to the hospital and received Vitamin B IV. They were just getting over Pneumonia. The employee was released from the hospital after 2 hours.
220250130018M12897The employee overreached a guard to spray a head-pulley with brake cleaner to prevent the conveyor belt from slipping. As employee was spraying the head-pulley the pulley became in contact with the spray can, causing the can to get pulled in. In the process employee fractured right thumb.
220250130021M12536Employee stepped on a piece of ash ring debris and sprained right ankle. Orthopedic doctor diagnosed torn ligaments, prescribed boot, crutches and physical therapy and restricted duty to no climbing steps or ladders. MLC is accommodating restrictions.  
220250130027M12355Employee was pulling a sulfur boat out of the leako with a pair of tongs and dropped it. Natural instinct was to try and pick it up, when EE reached to grab it  EE barely touched the sulfur boat and burned right index finger and thumb.
220250130028M10892While moving a ladder, employee knocked dust off of light. Dust got into employee's eyes.
220250130029M13468Supervisor was walking the 14hg area of the mine to ensure that there was no equipment, or tools that needed to be removed before the stoppings were installed.  During EE's inspection EE noticed that the top was looking like it was deteriorating.  EE contacted engineering and when they arrived, they walked the area and discovered the roof fall.
220250130034M11143EE was removing chutes from wash plant, while unbolting a chute EE stepped backwards and down when back seized up.
220250130035M13307Miner was attempting to loosen a bolt on a jaw crusher wedge bolt using a crescent wrench and having another miner strike it with a hammer. When the miner struck the wrench with the hammer, the wrench slipped off the nut and smashed the finger of the miner holding the wrench. Miner was wearing gloves. Left index finger fracture.
220250130037M13768On 1/2/2025 employee was removing QR caps from a rotary crusher. As EE was removing one of the caps it fell before EE had a good grip smashing EE's right middle finger between the cap and housing. EE received 4 stitches and also a fracture. Employee was on restricted duty for three weeks. Other workers were in the area. Communication and readiness were contributing factors.
220250130039M11684Employee's shoe became untied and employee tripped as a result.  Upon hitting the ground during the call, the employee's glasses broke and cut employee's right eyebrow.
220250130043M11894Trench was dug to repair drain pipe.  No sloping or shoring protection system was in place.  Trench was approximately 10 foot deep and 8 foot wide.  Side wall collapsed and crushed worker. 
220250130044M10471Uneven snowy terrain, snow packed/covered ice. 
220250130047M11193EE was lining up a bulky bag strap. When EE stepped off the bag, EE's foot slipped causing EE to fall to the bag below.
220250140001M11403The employee was performing mechanical task when employee sustained a head injury due to the use and unassessed height of the safety helmet.
220250140004M12596The accident occurred while the miner was attempting to adjust a piece on a forklift. The piece rolled over, causing minor injury to fingers #2 and #3 on EE's right hand. Finger #3 sustained a small amount of bleeding, with no significant impairment reported.
220250140005M12275While moving a slusher block, the nipper slipped on the muck pile and fell causing EE's left number 5 finger to get pinched between the slusher cable and the slusher block. EE was taken to the doctor where EE received stitches.
220250140006M13538Two employees were lowering the upper handrail of a scissor lift. When one employee pulled the 4th pin holding the handrail, the handrail assembly fell unexpectedly and pinched the injured employee's left pinky and ring finger between the upright and the mid-rail. The first employee then lifted the handrail up to release the injured employee's fingers
220250140011M12937Employee was cutting tin for a building and must have gotten filings on employee's person, the next day, a normal day off, employee felt something in eye but waited the weekend to see if it would go away.  It didn't so employee went into the eye Dr. on Monday and a piece of metal was removed.
220250140013M13738Employees were assigned to change out a bad gearbox on the drive end of the 208-01-2 filter. The gearbox wouldn't move with the hammer. They used a ram hydraulic puller. One of the puller fingers sheared off the gearbox sending the puller fingers flying into the left shin of one of the workers. The employee was lacerated by the puller and was transported to the hospital.
220250140014M12175Employee climbed out of a 988F loader for lunch break. When the employee's feet were on the ground, EE turned to walk towards the break room. As EE turned, EE's feet slipped out from under EE in the snow, and EE fell.
220250140015M12646EE was working advancing utilities. EE's hand was on wire mesh, and EE's hand slipped because the mesh was wet. EE hit hand on the cab hook, causing a laceration to EE's right palm. Seen at clinic, sutures required, and EE released to modified duty site can offer.
220250140016M11353While operating bagging machine, contract employee inadvertently pinched right thumb while adjusting the saddle of the bagging station.
220250140017M13347EE was stepping up onto a concrete pad approximately 4 inches high and felt pop in knee. Reported verbally to safety that EE had been having pain in that knee for about 2 weeks prior to the 13th. No slip/trip/fall, no uneven ground. Does not appear to be a hazard associated with work. Diagnosed with soft tissue injury, put off work.
220250140018M11844Employee placed hand in small place to remove chain and smashed right hand causing an abrasion and bruising.  EE called the supervisor and then we sent EE to Urgent Care for treatment.
220250150003M12285Two employees used a sledgehammer and a pry bar to remove a headliner from the ball mill. When the sledgehammer struck the liner, a sliver of the liner's edge came off and struck the employee holding the pry bar in the left arm.
220250150005M13087Employee was driving Lube Truck 09 to Lone Star Stemming Plant to service equipment when the rear brake caught fire. While the employee was crouched down trying to put out the brake fire with the fire extinguisher, the right rear inner tire blew out. The employee was taken to the ER, evaluated and released.
220250150008M12365While walking across a snow-covered, icy parking lot at the mine, an employee was taking EE's time and shuffling EE's feet due to the slippery conditions. Unfortunately, EE lost EE's footing and fell, landing heavily on EE's left elbow.
220250150010M11193The affected employee slipped and fell, injuring their right shoulder. The employee has been placed on restricted duty.
220250150011M11975While performing a pre-op inspection on a mobile screening plant, EE slipped off EE's step because EE's boots were covered in mud. EE caught self from falling but twisted EE's wrist in the process.
220250150012M10892While walking on a pallet EE's foot slipped through pallet boards and twisted EE's ankle.
220250150013M11173Hydraulic hoses on the ground made a slip trip and fall. After reviewing by doctor a torn Achilles tendon was found. 
220250150014M10562Removing drill motor when it fell on foot of the miner. 
220250150017M10983EMPLOYEE WAS LOADING ANFO POT, LIFTED 50 LB BAG OF ANFO WHEN EMPLOYEE FELT A POP IN RIGHT SHOULDER
220250150018M13628While trying to move a stone that was jammed on the feed conveyor of splitter #9 inside the CMF, the employee's hand slipped on some ice that was on the stone, and the employee's left middle finger was pinched between that stone and another stone that was on the conveyor. The finger was bruised, numb, and swollen after making contact between the two stones.   
220250150019M11103EMPLOYEE WAS FILLING EMULSION TANK, LOST FOOTING AND FELL HITTING RIGHT KNEE ON TRUCK AND LANDING ON RIGHT ARM
220250150021M11554EMPLOYEE WAS GETTING OUT FROM UNDER FENDER, MOVED THE HYRO RAM HOSE OUT OF WAY, RAM CAME OFF SUSPENSION ARM AND RAM HIT BACK OF RIGHT ANKLE AND RIGHT HEEL.
220250150022M10241Employee smashed finger.
220250150023M12726At approx. 0730 on 01/14/2025 employee was walking back away from a scrap pile of steel and slipped into a tire rut which was iced over. Employee landed on left side/shoulder. The employee was provided with restrictions and able to return to work adhering to restrictions.
220250150024M12135EE was removing a head pulley when it slipped and rolled onto EE's left pinky finger, causing it to get pinched, which resulted in EE receiving two sutures. EE was wearing thick gloves at the time of the incident.
220250150026M11714Employees were cleaning out the creek drainpipe. While attempting to remove a tree, part of the tree or a mud pile swung and hit the employee on the left side by EE's ear.
220250150029M10772Mill Maint Employee struck/injured by angle iron during maintenance activity.
220250160002M10983Employee was standing on third rung of ladder when EE slipped off. Contusion to knee and forehead.
220250160003M13828During an MSHA inspection of the "HP7 area", H2S gas was found near barricade points from the water containment area that fluctuated under and over 25 ppm around the barricade. A "K" order was issued. The inspector made a phone call and was directed to make this a reportable incident categorized as an "inundation" at approximately 2:02 p.m. I reported to MSHA hotline at 2:10 p.m.
220250160004M13307When pulling the center bar out, the miners lost their grip on the bar and dropped it on a miners foot just above the steel toe portion. X-rays were done at the time and no fractures were detected and fully released. The miner was still having pain and sent for a follow up on 1/11/25, a x-ray was redone and small fracture found.
220250160005M13758At 05:14 the Graymont kiln crew noticed a Quarry Services truck was on fire. 911 call was made at 05:16. The MSHA hotline was called at 05:24. At 06:05 after the fire diminished a loader dumped limestone fines on the truck which extinguished most of it. The Fire Dept. responded at 06:10 and put out what fire remained. The fire resulted in a total loss of the shuttle truck.
220250160013M10872Employee was cutting a tube of grease with utility knife and cut the tip of left thumb.
220250170001M12005Opened the side panel on the loader and was punctured by the edge of the panel or the handle, resulting in a 2.5 cm cut on EE's right hand in between the thumb and first finger.  EE needed 3 stitches.
220250170004M12085Operator was cleaning tripper for maintenance. Operator was traveling on tripper walkway when the operator slipped and fell on water/ice formation. Operator sustained dislocation of their right fifth finger. 
220250170005M12616Plant repairperson was discarding worn return roller into dumpster when the employee pinched their left index finger between the return roller and the dumpster. The employee sustained crushing injuries to their left index finger resulting in medical treatment. 
220250170006M10983Operator was stepping down off of a ladder after closing a valve when EE rolled their right ankle.
220250210001M12055Employee was using a chipping motion with a bar to knock ice off of a screen deck prior to running. While doing this, employee's hand made contact with the plant causing a "right fifth metacarpal fracture"
220250210003M10983Employee was shifting a 55 gallon drum on a pallet when EE's finger got pinched between two drums.
220250210004M10672Employee smashed EE's hand between flange on discharge suction pipe
220250210005M11383Employee was assisting delivery drive in offloading conveyor to jack stand. Conveyor shifted unexpectedly and crushed employees left hand.
220250210007M13448Employee had a periodic screening chest x-ray read by two B-readers using the ILO procedures. The X-ray was characterized as consistent with pneumoconiosis with readings of 2/3 and 3/2. Damage or impairment cannot be determined solely by reading chest x-ray films. This report is being submitted to satisfy MSHA program policy letter P92-III-2.
220250210008M12365Employee was walking to locker room at the end of EE's shift to go home. Incident occurred by the Sweco/Duavac in Building #02. Employee was walking and felt a sharp pain in left knee and lower back making EE unable to walk on left leg.
220250210009M13418Employee was using a Front End Loader to feed material to the plants.  As EE backed up to get another load of material, the employee backed into another parked front end loader.  The employee received a work restriction due to a muscle strain to EE's neck and right shoulder from the impact.  Employee is due back at the doctor on 1/17/2025.
220250210010M12015Loader operator missed the last rung on the ladder while dismounting the loader, falling to the ground (Operator did not use three-points of contact, carrying pre/post-shift book in one of EE's hands).
220250210011M13257Employee was preforming routine duties by picking up deliveries, when they lifted a package up hitting their head on the garage door. While the employee was wearing a hard hat at the time, they felt a pain in their neck as a result. Employee is currently resting at home after medical attention, expected to return next week.
220250210012M13608EE reports packing #9 lift on the #2/4 matrix line closing the matrix bleed-off valve to release the line back into operation when low back pain was experienced. EE reported the injury the next morning by calling as the EE was unable to get dressed to return to work. EE requested off-site evaluation and was sent to Company Care for evaluation and treatment. 
220250210013M12846Employee was repairing a handrail, when the opposite end they were adjusting slipped out of the joint and their ring finger was smashed between the handrail and I-beam. The employee sustained a finger fracture under their nail bed. Employee sought medical treatment the following day.
220250210014M13838Contractor employee was moving a ramp into the preheat tower elevator, when it fell in a small gap between the elevator car and floor they were on. When the plate hit the basement of the elevator shaft, the allowing governor cable to become free, stopping the car. The employee using the elevator became stuck between the 1st and 2nd floors at the tower and was retrieved in an hour.
220250210015M11955EE was using water truck to wet down area when loader operator who was back dragging roads backed into the water truck EE's chest struck the steering wheel. EE has some strained muscles in chest.
220250210016M12275EE was pulling a hydropak out of the walkway in the tool room. They felt pain in their right groin area while pulling. CT scan negative for hernia, ee diagnosed with muscle strain and released to modified duty site can provide.
220250210017M12486EE was dismounting a piece of equipment. They missed the first step and did not have a good grip on the handrail. They fell to the ground, onto left wrist. Diagnosed with a fractured scaphoid, put in brace, released to modified duty site can offer.
220250210026M12355Employee exited a front end loader and was walking over to group of employees when they slipped on ice. Employee sought medical treatment and was diagnosed with fracture to their lower tibia. They were placed on restricted work duties.
220250210027M10762Pushing object to align positioning for bolt. Felt a strain in back muscles 
220250210038M11423While dismounting a loader, the employee slipped on the bottom rung of the loader and ruptured their left bicep tendon as EE's weight shifted.
220250210039M10351Employee hit pothole & injured arm.
220250210042M11153Was working inside of crusher chute when a lodged piece of metal fell striking EE below EE's hardhat causing a cut.
220250210043M10852Employee was on fourth rung of ladder when EE jumped off when employee above EE fell.
220250220007M11494While performing the daily inspection of the Alimak (secondary escapeway elevator) it was found to be faulted and inoperable due to overheated VFD.  
220250220009M11083Employee was conducting pre shift inspection on sand plant, slipped on ice, fell and broke their left wrist.
220250220011M13448EE was cleaning out a chute due to material being clogged. After EE unclogged the chute they communicated this to the control operator. When the material began to clog up again EE reached into the chute to clear the material. At this time the control operator closed the gate crushing EE's hand. EE received three stitches in their right thumb.
220250220017M13688While removing bolts from haul truck cab, employees finger was smashed between wrench handle and frame of truck causing a small laceration on left pinkie finger requiring 4 stitches. Employee put on modified work duty until stitches can be removed in 7-10 days. No bending, pushing, pulling, or repetitive movements with 5th finger until healed or sutures are removed.
220250220023M12245Employee had a pipe wrench up to chest while working on a pipe and was trying to use body weight for leverage when employee felt a pop in ribs. On 1/13/25, the employee was taken off of work after further medical evaluation.
220250220025M13468Hammering on a block, the hammer skipped on the edge and ended up hitting the employee's right hand/wrist.  Employee did not seek medical attention until 01/20/2025.  With this appointment employee was placed on restrictions of 10lbs push/pull, 10lbs carry/lift with right wrist.  Employee came back to work after appointment with brace on wrist.
220250220029M11884Employee was holding the grinder in one hand. Employee was looking at the screen and the grinder had drifted down touched the screen and then skipped over cutting through employee's glove.
220250220032M12345EE was walking across primary flex. EE's right foot unexpectedly slipped, resulting in a "pop" sound emanating from the right groin region. Restrictions place on 1/21/2025. No bending at waist, no squatting, No lifting over 20 pounds.
220250220033M12175Employee was attaching a trailer mounted pump to a track hoe bucket in order to move the pump into position.  The track hoe bucket unexpectantly lowered, catching the employee's hand between the bucket and pump frame.
220250220034M11574Employee was lifting a steel plate. The plate slid on the concrete floor at which point the employee had their finger pinched in between the floor and plate.
220250220035M13648Employee was clearing the opening of a vertical discharge pipe for the Cement Kiln Dust (CKD). The discharge of previous ckd had prevented the flow of discharge and had created a back-up. Employee used a rake to remove blockage at which point the material quickly flowed from pipe causing ckd to go airborne dusting the employee. The employee inhaled the material.
220250220036M11704Employee got dust in is eye on 1-17-2025 and over the weekend the employee had medical treatment which changed the treatment process to a medical to a lost time incident.
220250220038M12736EE called another EE around 7:00 am as EE was pulling into the plant explaining IE was not feeling well and a bit lightheaded, When EE went up to check on IE who seemed out of it and confused at which point immediately had other EE call 911 between 7:15 & 7:30 am 01-17-25.
220250230001M11283EMPLOYEE WAS CLIMBING STEPS INTO EE'S DRILL, FOOT SLIPPED, EMPLOYEE FELL AND CUT LEFT FOREARM TRYING TO CATCH SELF FROM FALLING.
220250230003M13368EE was hitting a stuck drill head hammer with a pin hammer and a brass hammer. A piece of the drill head hammer metal fractured off, and entered EE's left leg on EE's inner thigh between EE's knee and groin.  Doctor's wanted to wait a few days before performing the removal of the metal, in order to have a good OR room for the removal.
220250230005M12135Employee was working underneath a silo load out, while a tanker truck was parked. The tanker truck pulled forward without the employee knowing and ran over their foot causing a break in their pinky toe metatarsal.
220250230008M12626EE reports driving their carbon truck, hit dip in road, bounced in seat, hitting head against top of cab. Seen at ER, diagnosed with head injury/neck strain, released to full duty. On 1/17/25 ee referred to physical therapy, making this reportable for treatment.
220250230010M11053Working on crane barge, knocking board off of pallet with sledge hammer, board broke and hit in the mouth
220250230012M12576While working on welding plate lid into chute, plate lid slipped off and hit R ring finger of employee causing a partial amputation between plate and angle iron. After evaluation surgeon decided to complete amputation at 1st knuckle and close up amputation.
220250230013M13287Employee was utilizing a grinder to cut a bearing sleeve.   This task was necessary to replace the bearing on the head pulley of the C1 belt. Midway through the task, the grinder unexpectedly kicked back towards the employee, causing the grinder's disk to make contact with the employee's left forearm resulting in a laceration.
220250240004M13317An employee was assisting in replacing slurry pump PU6. While hoisting the new pump into place with a telehandler and chain hoist, it became stuck. The employee attempted to reposition it by placing EE's right-hand underneath. When the bind released, the pump shifted, crushing EE's right ring finger between the pump and the skid.
220250240005M10592Hearing test showed a standard threshold shift in left ear.
220250240006M13438Employee was stepping down from the last step of the haul truck EE had in the truck shop for repair. They took the last step to the clean dry and level cement floor and felt pain in EE's right knee. Employee stated the knee had been surgically repaired from a prior incident that happened outside of work. Employee was taken in for evaluation.
220250240007M12957While in the process of de-coupling the bucket of a 903C clean-up loader in the shop on a cold winter day by trying to work the bucket release levers, the bucket unexpectedly de-coupled and fell to the shop floor striking the mobile mechanics right foot.   The right foot was broken in 2 places.
220250240009M11143Employee was trying to turn a butterfly valve when they lost footing and fell. They felt pain in their upper back.
220250240010M13368Employee was walking behind the block press fencing (newly installed) and tripped on an 8x8 timber that is in the process of being removed. Employee fell onto left forearm on the ground and tried to catch themselves with  right hand against the robot fencing. When trying to catch themselves they strained the right inner forearm/elbow.
220250240011M12696At around 8PM on January 22nd, the Jet Mill Bagger was attempting to cut open a pallet of new bags and slipped causing a finger laceration that required stiches to repair. The bagger was using a box cutter to cut off the plastic banding used to secure the pallet loads.
220250240013M11233Dump truck driver slipped on black ice approaching their truck. When they landed, they broke two bones in their right hand.
220250240015M12085A haul truck operator was jarred, while being loaded by a loader, when the loader bucket made contact with the bed of the haul truck. On 1/16/2025, the employee was taken off of work due to continuous pain.  
220250240019M11664Employee was climbing ladder to go to upper level and when EE got near the top, employee stated wind blew lime dust in EE's eye.  Employee was wearing safety glasses.
220250240020M10892Employee was diagnosed with carpal tunnel of both hands.  Had surgical repair on 1/22/25.
220250240021M11955Employee was getting out of haul truck to load production and experienced spasms in their back.  Called supervisor for assistance and was taken for medical attention.  Placed off work for 1 week.
220250270001M11614As EE was climbing down the water pull EE missed the step and fell to the ground. When EE hit the ground there was a loud pop and EE's right hip started to hurt.
220250270002M10692Cold and Icy wintertime weather conditions, causing a trip and fall. 
220250270003M10772While walking across the parking lot, wind blew material into the miners eye.
220250270004M11504Operator was parking equipment at the end of their shift and as EE was climbing out of the frontend loader EE stepped on a rock and rolled EE's ankle.
220250270006M12506Employee was driving forklift 305 to EE's work area when the brakes failed. EE was unable to stop the forklift and came into contact with the barricade around a fire hydrant. As a result, EE experienced lower back pain and required medical attention.
220250270007M11213Miner was cleaning underneath a conveyor, bent down and stood up hitting EE's forehead on the conveyor, received stitches
220250270008M10772EE was climbing up a ladder and slipped causing them to hit their left elbow.
220250270009M10321Miner slipped on an icy surface.
220250270010M10321Miner slipped on an icy surface.
220250270012M10211Employee rolled ankle
220250270014M11393Employee was getting off a track screen and stepped on a frozen sand clod on the track and fell 24 inches to ground and twisted left ankle.
220250270018M11043Operator stepped off excavator and rolled foot in loose rock.  Initial assessment is sprain to left foot
220250270021M11474EE was changing bottom rollers on the Komatsu D65 Dozer when a roller fell on EE's right index finger. Resulting in a fractured right index finger.
220250270023M13648EE was cleaning the feed chute. EE repetitively struck and scraped the bentonite off the bottom of the chute. After performing the task EE felt pain in the right hand and wrist. EE did not seek medical attention at the time. EE sought medical attention on 1/21/25. EE was put on restrictive duty on 1/21/25. The diagnosis is possible tendinitis in the right wrist.
220250270024M10702Employee was helping move power cords and pulled a muscle in left arm.
220250290001M13257The door fell on the EE's ankle and the force knocked EE to the ground. It was determined the drain valve was plugged and did not drain as expected. EE had xrays that are negative. Seated duty.Allow for sit and stand PRN for pain control allow use of non-steel toe shoes and allow for elevation of right foot on chair or can
220250290002M11995Employee was installing new bearing on tail pulley and put EE's hand in pinch point between bottom of bearing and conveyor frame. Employee suffered laceration to middle finger requiring six stitches.
220250290003M10602EE had a hearing test and showed a standard threshold shift.
220250290006M11704Employee was making small adjustments to a v-belt drive system and pinched left index and middle finger between belt and sheave. Amputation of tip middle finger required.
220250290007M10461EE slipped and fell on ice, hitting EE's head.
220250290009M13518On 1/24/2025 a 777G Caterpillar haul truck caught on fire when the truck was at the crusher pad preparing to dump. The operator stated that EE felt heat and looked to EE's right and saw flames. EE engaged the fire suppression system and exited the truck. The fire department was called and contained the fire in 45 minutes. The truck was a total loss.
220250290013M11393Cable and hook was wedged between two rollers. Miner pulled the cable out and the hook struck EE in the mouth resulting in a chipped tooth.
220250290017M11444The employee was using a hook knife to cut zip ties from a band when the knife slipped lacerating the tip of the middle finger on the left hand.
220250290018M11033Employee assisting with caustic transfer when they smelled something funny triggering an asthma attack.
220250290019M11724The employee was walking up the stairs on the front (west end) of the building and missed the top/last step.  Employee fell face first and opened a 2" gash above right eye.
220250290020M12065While pulling a hitch pin from a loci, the hitch pin moved, pinching the motor operator's finger between the hitch pin and the wall of the loci. The incident resulted in a laceration that required stitches.
220250290021M13147PA was called to push stone into the feeders at the primary pile, after 30 minutes of pushing, the dozer went over the edge and nose first into the feeder. The employee called on the radio for help/they remained in the dozer while the fire department performed emergency rope rescue. MSHA was notified immediately.
220250290023M11353Employee was walking with boot laces untied. Employee tripped on untied laces. Employee broke a bone in their right ankle as they fell.
220250290024M10702USER ERROR. FINGER CUT ON BAGGING MACHINE. NO DAMAGE TO THE EQUIPMENT.
220250290025M10772Employee was slicing conveyor belt and cut their hand with a knife.  Stitches
220250290026M11965Miner had completed drilling hole in ore face, their right hand slipped from the D handle as the hammer cammed over and pinched right middle finger between the hammer and the leg connection point.
220250290030M12095EE was moving skimmers onto a flatbed truck. EE was pulling/pushing the skimmer when EE heard a "crunching" noise in shoulder. EE reported the incident & was taken off site. On 1/18 EE was issued restrictions.
220250290031M12536EE stopped for an operator break. EE went to the passenger door to get hard hat. When EE closed the door, EE's sleeve became caught on the door and EE hurt wrist. EE was taken to the emergency room and given a splint. On 1/27 EE was issued restrictions.
220250290032M12907Employee was entering skidsteer. Employee placed left foot on the skidsteer and used right foot to push off to get up into it. Employee felt a pop in right knee and was unable to put any weight on it. Employee received medical attention and was treated with x-rays, knee brace and crutches.
220250290034M11814Exiting cab of dump truck, foot slipped off of step causing to lose balance and fall. While trying to catch themself hit concrete floor with hand/arm resulting in fracture of wrist.
220250290035M13137EE was scaling the right rib with a CAT Excavator in 42 Face when a rock from the face fell and hit the FOPS of the machine and broke through the left rear glass and ended up on the seat behind EE. EE claims that EE does not believe the rock hit EE. However EE did have lower back pain before exiting the machine.
220250290038M13788Electrician was testing a breaker, the fuse box arc flashed throwing the electrician back causing minor FA treatment burns on R wrist and neck. The employee was taken to the ER for evaluation and was released with no serious injuries or restrictions. Employee was re-evaluated on 1/24/25 for aches and pains to R wrist and R knee and was prescribed sessions of physical Therapy.
220250290039M10401Mill operator fell causing lacerations. 
220250290040M11654EE was attempting to hang a 480 volt live cable. When EE lifted the cable, EE received a second degree thermal burn on hand, from being in proximity to an arc flash.
220250290042M13668During repair to a water pipe located under concrete. A jack hammer was used & connected to the welder/generator for power. The generator was turned off. When they went to use jack hammer again the generator would not start.  A forklift and jumper cables were used to crank the welding machine.  EE went to remove the jumper cables & EE's hand got caught in the fan.
220250290047M10602Employee was lifting a metal plate during daily maintenance.
220250290050M11033Employee was walking along a conveyor and felt their knee pop. Knee swelling and pain. Restricted duty.
220250290051M11163Employee was evaluating areas for material storage and found a roof fall above the anchor points at 458N in #1 room.
220250290052M12275Employee injured right shoulder while install a piece of screw conveyor during the second shift on 1/27/25. EE reported it to the supervisor on 1/28/2025 at 10:30 am. EE called Teladoc and was referred to see a clinical doctor.
220250290056M12726Employee was placing paper bags on 50 lb. bagger spout when the bag on the spout to EE's right ruptured.  The bag ruptured in such a way that the clay was directed towards the right side of the employee's head.  This dislodged EE's safety glasses and got clay in EE's eye.
220250290057M13047EE was putting a safety brace on a mill door. EE didn't have the 2 pins in place that holds the brace in place causing the brace to fall back striking EE's forehead. EE's hard hat was taken off minutes before the accident and would have most likely taken the hit. Instead, the brace struck EE's forehead.
220250290058M13137A forklift operator had loaded a supersack bag (1 ton) on a pallet. A coworker later noticed the bag was leaning and attempted to straighten it up by pushing on the bag and felt a sharp pain on the left side of EE's neck and had to seek medical attention. The employee was treated at the ER and taken out of work.
220250300004M12676Dump truck was being loaded with dry clay.  The clay was leaking out of areas of the tailgate.  Employee attempted to shove the tailgate closed.  When the employee attempted to close the tailgate EE's right middle finger was caught between the truck bed and tailgate.
220250300006M13698An employee was observing a drag chain conveyor. EE's left hand was holding a drill with chisel attachment, the chisel slipped, and EE's finger contacted the corner casing of the elevator that carries coal to the conveyor. The emergency department classified this injury as a laceration/open fracture to EE's left-hand ring finger, requiring surgery to close the wound.
220250300012M11564Miner was putting in a seal on a bucket elevator by hammering it in place with a brass punch when they missed the punch and hit their hand with the hammer. 
220250300013M11423Employee injured left pinky finger while trying to disengage a gear. Employee went to medical facility, was treated and release to light duty.
220250300014M10842Employee was cleaning around plant when they slipped on ice and pulled a leg muscle.
220250300015M11043Employee was evaluating materials and found a roof fall above the anchor points at 299 15HG #1 crosscut.
220250300017M11444While pushing snow/dirt employee backed off a 17-foot wall in D8T CAT Dozer. Employee was removed from dozer and attended to until EMS arrived. 
220250300022M11393Employee was climbing the front ladder (drivers side) on the Terex 45 Haul Truck, company number 26.671401 when EE felt a pop in left knee.
220250310006M11684Employee was performing work with a sledgehammer on 1/25/25. Due to increasing pain, medical attention was requested on 1/27/25 and the employee was taken off of work. 
220250310007M13337The genset broke down on 01/23/2025. The hoist was inoperable while we were waiting for parts and a repair person. MSHA inspector arrived on site on 1/27/2025- citation was issued per above conditions.  Table Rock Minerals was unaware that MSHA needed immediate notification.  Genset was repaired on 1/29/2025- hoist is now operable.
220250310008M10341Crushed finger while on a harness.
220250340001M11053Employee was tarping a truck. When climbing down employee slipped and fell. Conditions were cold & snowy.
220250340004M11353Electrical fault on our #4 Hoist. Trouble shooting determined there was crossover power from 480v to 20v that burnt up a circuit board.
220250340007M12987Mechanic/Operator was assigned to come in a half hour early with another guy to check fluids and start up mobile equipment. The injured worker had just started up a dozer and was climbing down when EE's right foot missed the bottom step, causing EE to fall rolling EE's ankle and bruising EE's hip.
220250340009M10461Employee was stung by a bee on EE's right hand
220250340014M11914The CLG truck driver was attempting to dump a bulk load of ash at Giant Cement. The unit turned over while at the 3rd stage level. The driver was evaluated and issued prescription medication.
220250340015M11283Employee in the thin veneer area was crushed by a pallet of stone that was placed on them by another employee in a wheel loader.
220250340018M11904Employee fell approximately 5 feet down from scaffolding while working on primary crusher. Employee has 2 fractured vertebrae and a hematoma in thigh, all of which are non-surgical injuries.
220250340021M13758On 1/25/25 at approx. 8:30am a drill operator was injured when a hook from the drill winch cable fell from the top of the drill mast. The hook struck them over the left eye causing a laceration over their left eye. EE was taken to the ER, receiving multiple stitches. The operator had a follow-up appointment on 1/27/25 was released back to work 1/28/25 without Restrictions.
220250340026M13688IP works as a diamond drill helper, IP was scheduled to work night shift 1/30 (starting at 5:45 PM), IP reports waking up at 11:00 AM on 1/30 with pain and burning in forearm and had a numb hand. The IP reported to the mine site clinic at about 3:00 PM, rested 1/31 on site and went to a Dr. appt where IP was given work restrictions and rescheduled Feb 7 to reassess.
220250340031M12917Employee was helping a co-worker lift and place a rotex screen onto a rotex rolling cart. Employee had their right hand between bottom of screen and framework of cart during the lift movement. The employee's right index finger (at fingernail location) was pinched into the frame of the cart.
220250340033M11454The employee tripped/slipped carrying a connection joint on a cable and landed on their left leg. The cable landed on the employee's leg as well.
220250340034M13628Employee was checking fluids on a haul truck. EE was in between the door and haul truck frame when another employee got into a skid steer and backed into the open hood on the haul truck pinning EE in between. Upon evaluation there were no visible cuts or lacerations, the supervisor told EE that EE needed to get medical attention, which EE refused at that time.
220250340036M11113Employee stepped on the bottom end of a frozen berm behind the shop causing EE to fall injuring EE's right leg.
220250350001M11123Employee was welding when welding slag fell into EE's shoe causing 1st degree burns to the top of EE's left foot
220250350004M10391Chemical exposure to the eyes and face 
220250350005M11444Employee's right hand was caught in between a come-along chain and a conveyor frame when removing a bend pulley. Cutting the right index finger.
220250350007M11243The employee was closing the hood of the semi truck they were preparing to drive after completing their vehicle inspections.
220250350008M11734The mine site was thawing out from a recent cold weather spell that allowed for the roads and pads to thaw. This created an increased instances of thick mud around the mine.
220250350010M10762Employee was in the process of replacing panel when debris got in their eye.
220250350012M12185While driving through SH3 pit, a haul truck trainee employee hit a rough spot in the road. Initially the employee stated they were ok but after another run, they told their mentor that they were experiencing back pain.
220250350013M12666While loading Haul Truck 36, a shovel operator trainee made contact with the back of HT36 with the dipper. After dumping the operator continued onto an additional run at Shovel 3.  After another full load/dump cycle, the operator stated they felt neck and back pain.
220250350014M11063As EE was splitting stone a chunk broke off and landed on top of EE's right foot and broke the right foot.
220250350015M10401Employee was rough loaded in haul truck.
220250350018M13598On 2/3/2025 at 11:20 a.m. the shaft elevator was taken out of service due to having run down over the travel position. A broken wire feeding an electrical switch was determined to be the cause, and no miners were in the car. MSHA was notified at 11:47 a.m.  A spare wire was used to replace the broken one and the elevator was put back in service at 1:15 p.m.
220250360002M10862Had a roof fall above the anchor points in the return of the tailgate of the longwall.
220250360003M12516Excavator was working to bring down boulders from top deck of mud-cell #1 of all the fresh shot and boulders. EE came down to the bottom and tried pulling boulders. The boulder was in back and sloughed off and rolled down into cab. breaking the glass.
220250360004M11904Miner was using an impact wrench to remove the bolts from the tail bearing. When they removed the last bolt, the bearing jumped up, trapping a hand between the bearing and the take-up guard.
220250360011M12255EMPLOYEE WAS DRIVING THE LHD TRACTOR LOADER BACK INTO A ROOM WE ARE MINING.  EE HIT A RAISED CUT IN THE FLOOR WHICH CAUSED THE TRACTOR TO BOUNCE.  EE'S HARD HAT FELL OFF AND EE HIT HEAD ON THE CEILING/ROOF OF THE TRACTOR CAB.
220250360012M11834Employee was replacing haul truck tire in tire shop on a flat surface. Getting into the tire rim to work with the air stem they stepped down and twisted their left ankle spraining it.
220250360014M12987The employee was walking back to the loader and stepped on the loader's parking mound. EE slipped and lost balance. While falling forward EE hit left knee on the ground and put left arm out onto the loader to stop self from falling forward, hyper-extending the left shoulder and scraping left knee.
220250360015M12967Haul truck dumped out and was traveling to the next assignment. As EE headed down the Power ramp, EE's truck began to slide due to the roads being slick from the weather event just before the shift. Driver tried to correct the slide, and EE made contact with the berm with the right front corner.
220250360016M12796Employee was lifting a 300lb propane gun with two other employees when EE felt a pain in the shoulder. EE worked through the remainder of the shift thinking the pain would subside, and when it hadn't, EE reported the incident to supervisor at the start of the shift the next day.
220250360018M10892EMPLOYEE WAS OPERATING A MT85 WALKBEHIND AND PINNED SELF BETWEEN THE RIB AND THE MACHINE.
220250370001M13788Injured was changing a hose on a Cat 773F from a 6 foot fiberglass ladder. It appears as EE was making EE's descent EE caught EE's pants (rip in pants) on the cover of the quick fuel connector. Causing fall backward, hitting shoulder and head on ground. EE was disoriented but answered basic questions correctly. Back of EE's head was bleeding somewhat, sent to ER to be checked
220250370002M10712Miner did not follow protocol. Therefore causing the death of the same.
220250370003M12095Operator was attempting to fix leaking packing on #7 washer under flow pump by loosening the nuts on the packing gland. EE got sprayed in EE's face with mud and liquor. This incident occurred in Clarification.
220250370005M11724Employee was laying on ground for maintenance on wash plant. When employee was getting up off the ground they felt discomfort in their left knee when standing up straight. 
220250370006M10802Employee was cutting rope for filter cloth and accidentally cut Left 4th finger.
220250370007M12776Sunny, incident occurred indoors with full lighting. The injured party suffered burns to both hands (non-life threatening) while installing a ground inside an MCC. The ground wire recoiled due to line memory and rebounded once let go into the adjacent bus bar creating the arc.
220250370009M12626EE parked mucker to set up in auto. Took 4 steps up a slight incline and felt a pop and instant pain in left calf. Seen at clinic, diagnosed with a sprain, and released to modified duty, seated work only, on crutches. Does not appear to be an injury by accident.
220250370010M13458EE trying to close the passenger side door of haul truck reports using "a lot of force" to "slam it as hard as they could". When they did this, they felt a sharp pain under right thumb, shooting down towards the wrist. Seen at clinic, given a brace and released to modified duty, no operating equipment or driving any light vehicle on mine site.
220250370011M11874Ee was climbing ladder on grader when ee slipped, falling about 3 feet to the ground, landing on buttocks. Seen at ER, diagnosed with contusion to back/pelvis, released with restrictions.
220250370012M12736EE was attempting to clean spilled material with a dingo skid steer with one hand when EE's left hand was cut by a metal plate used to hold a motion sensor.  Medical attention was sought and the EE received stitches and placed on restricted duty of no use of the left hand.
220250370013M13678Employee was going to swap lines on top of C tanks and stepped in a 6" trench that had been dug at the base of the steps for water to drain. Employee felt stress on hip and groin area. Employee initially didn't want to go to doctor but pain worsened and on 2/5/25, employee wanted to seek medical attention.  Was treated for strain and put on light duty restrictions.
220250370014M13378The employee walked into the pressure washer to retrieve the pressure washer wand and hose and when EE walked back out of the doorway EE slipped on ice. Falling backwards and reaching out with right hand to break the fall, resulting in a sprained right wrist. Located next to the door was a bucket of ice melt, ice scraper, and a shovel.
220250370015M13107Ee was cleaning a jammed piece of copper from the stripping machine. Wearing gloves and using finger to try to remove the jammed piece and felt a cut. Took off the glove in the restroom and left index finger was cut. Seen at clinic, diagnosed with a laceration that was closed with 4 sutures. Released to work.
220250370016M12315Ee was replacing transmission mounts. While positioning mounts in holes, the load shifted, pinching the ee's finger. Seen at ER, diagnosed with a left finger fracture, given a splint and antibiotics, and released with restrictions.
220250370017M10942Operator was changing cloth on the # 3 filter and struck their L Index Finger with the hammer.
220250380002M10872Miner was driving haul truck, when miner started feeling discomfort on their lower back
220250380005M11804Employee failed to follow policy and entered a restricted area during truck loading by forklift. They walked into the path of a forklift and was struck. They broke their right leg.
220250380013M13488A contractor employee (NBD Industrial Services LLC - MSHA ID # C6519), was installing a wedge into the crusher by using a hammer to drive it in. The hammer head slipped off the wedge, causing EE's left index finger to get caught between the hammer handle and a beam. EE was taken to the ER where EE was treated for a finger fracture and laceration.
220250380027M11323Employee experienced a minor stroke and an aneurism during the start of the shift. EE called the acting foreman and they called 911.
220250410002M12285EE's were replacing troughing roll assemblies from under a screen deck, EE was using a 2ft pry bar to flip a roll out for replacement, as the roll flipped out the frame of the roll frame came down on the EE's right index finger.
220250410004M11123Employee was putting a steering cylinder on the back of a service truck when it slipped, fracturing EE's finger.
220250410005M10602Employee smashed EE's finger between equipment and conveyor.
220250410006M11373employee was pushing 7 pieces of curb from the splitter to the plunge saw, with another person, when EE felt a pop, EE stopped instantly.
220250410007M10311Employee fell and hurt shoulder
220250410008M10281Employee fell and hurt ankle
220250410010M12355Temporary employee was accessing pickup after lineout meeting. As the worker approached the vehicle, they misplaced a foot in a parking ditch, resulting in an ankle sprain. Worker was provided with a splint and placed on modified duty.
220250410012M13287Employee was lifting a 70lb battery from a pickup truck into the cabinet of an excavator. No pain was noted at the time, but later in the evening while taking a shower, employee noticed a protruding lump on the right side around the belt/waistline area.  This has since been diagnosed as a hernia and surgery has been scheduled.
220250410013M12766The employee was welding a pump skid to a steel dredge pontoon when a pontoon hatch became displaced, pinching the top of the employee's foot just above the  protective toe of the required work boot. The incident resulted in a metatarsal fracture in the employee's right foot.
220250410017M12907During a screen change, employee was standing on middle deck screen.  EE put foot on the top deck crown bar to brace self while pulling the screen off the forks.  While pulling, EE's foot slipped and EE hit shin on the crown bar.  This caused a laceration that required 8 stitches to close.
220250410023M11935Employee hit a troughing roller on a conveyor with a hammer and struck hand fracturing EE's right thumb and index finger, as well as lacerating EE's right index finger requiring seven stitches.
220250410026M12155Employee was holding a bolt with the left hand and started to use an impact wrench to loosen the bolt. The bolt head began to spin in the hand resulting in a laceration of the left middle finger requiring sutures.  
220250420005M11323Miner was bolting when loose material fell from the back causing a laceration on the right forearm. The laceration required sutures.
220250420006M11053Miner was picking up a panel by EE's drill and when EE stood up and turned EE heard a crack in EE's back.
220250420007M10311CARPAL TUNNEL SURGERY LEFT HAND
220250420010M13838While attempting to clear a buildup of material in a chute, the EE used a pry bar to dislodge the obstruction. During the process, the employee struck downward with the bar, causing the material to break loose unexpectedly. As a result, the EE's hand made contact with the side of the chute, leading to a laceration on the middle finger of the right hand that required three sutures.
220250420012M11935Worker was pulling themselves up on ladder to the Haul Truck and felt a sharp pain in their left shoulder. Medical provided restrictions. Able to perform all normal duties but at a slower pace.
220250420013M10592Employee slipped on material that was dropped on the floor.
220250420014M10983Employee was working with porta-power when reservoir failed causing debris to hit them in the arm.
220250420015M12385The fire started about 5:15. The pit had been closed and crusher that caught on fire was not running. No employees were there and gates to the pit was locked. Crew left about 4:30 pm.  No injuries, just equipment damage (portable crusher)
220250420016M13057Employee was working on grader replacing cutting edges. The employee over torqued a bolt causing it to break loose. The bolt hit the underside of employee's hardhat ricochet to employee's forehead striking employee above the right eyebrow, creating a laceration. The laceration needed 5 stitches to close.
220250420019M11433EE was bending down to pick up a shovel when EE stood up EE felt a pop in lower back, EE was diagnosed with a back strain and issued light duty
220250420026M12876A mechanic and mechanic apprentice were horse playing in the maintenance shop. When the apprentice went to plant their right knee, EE fell and hit their right knee on the floor and heard a pop. The employee has been diagnosed with a fractured kneecap and will undergo further evaluation.
220250430001M11914EE reported pop sensation in lower back during climb into boom truck. EE states left shop and drove to work area before realizing that low back was too painful to allow standing up straight. 
220250430002M13337EE states stepped down into the mud on the way to the pit car. EE states that left foot went into mud and boot became stuck. EE states left ankle and left knee twisted and has pain in both. States hurts too bad to work on it. Denies previous injury or problem with left foot or knee. Left ankle with notable swelling on examination. 
220250430003M11644Steep grades, loose material, wet ground conditions with truck driving up steep grade, causing truck to slide back into the excavator and a rock to strike the cab. 
220250430006M10983While making adjustment on the Case Packer hand slipped and hit the guide which caused the injury.
220250430012M13408While going down the stairs of the haul truck, the operator's bag swung in front of operator causing operator to lose balance. Operator used left hand to help catch self and brace self from falling down the stairs and heard a "pop" in elbow. Did not call for a supervisor and went home. Pain became worse so operator went to an urgent care.
220250430013M12876Employee was changing the liner on the HP300 cone on the newly acquired crushing equipment. During this activity EE was swinging a 12lb sledgehammer to loosen or tighten the mantle to the head. Employee had an MRI and on 1/29/25. EE was given the results that EE has a torn rotator cuff.
220250440003M10642Shoveling piles of lime into hopper and strained a chest muscle.
220250440005M12335A miner was cutting a piece of skirt board rubber when the belt knife slipped causing them to cut through their jeans into their thigh.  The cut was not bleeding but clinic placed two stiches on the cut to prevent it from opening up.
220250440006M12195Employee got dust in their eye, scratched an eye and sought medical attention. Went to the eye doctor and was diagnosed with a conjunctival abrasion. There was nothing in the eye but was prescribed antibiotic eye drops.
220250440007M12446Employee was leaning across the drag line cable electrical box to verify there was no energy prior to performing work The door closed, hitting the employee. Incident date: 1/25/25. Became reportable when employee received restrictions on 2/7/25
220250440008M13618Employee was welding up two guards when EE took welding helmet off because it was flickering on and off.  Employee decided to finish the weld without helmet on.  On 2/6/25 EE reported to Supervisor that EE's eyes were bothering EE and EE wanted to go to the doctor.  Employee went to clinic and was diagnosed with welding burn and issued prescription eye drops.
220250440009M13588Caterpillar 988K wheel loader was maintaining a shovel dig site when the left rear corner of the loader was contacted by loose material that fell from the dig face. The loader operator reported neck and back pain from being jostled in the cab. The left rear loader's fender and boarding ladder were damaged. The loader was taken out of service for repairs.  
220250440010M10361Employee pinched finger moving liner
220250440011M12315EE was attempting to remove a drill bit from a drill basket when it became jammed. When the bit finally came loose, it struck the employee's right index finger, resulting in a chipped fracture and laceration that required stitches.
220250450002M10211Gloves were not worn.
220250450005M11514A return Roller fell off a Radial stacker as is was being moved over. Employee was moving it at the controls and looked up and it hit them in the face.
220250450006M12626While moving equipment, the EE pick up an electrical box and swung it to the opposite side of the room. While swinging the box, their glove became stuck. The momentum carried them to the wall, and they jammed their neck. EE was put on restricted duty on 2/12/25.
220250450010M10932Emp using a sledge to straighten track, sliver from sledge came back and cut employee's face.
220250450012M10993Employee sustained laceration to finger during maintenance activity on Filter Press #2 in the Mill.
220250450013M11534Employee's right index fingertip was amputated inside the pin hole of the Tube Press 6 ram when the Overhead Crane raised the yolk out of the candle eye.
220250450014M12826While unscrewing a bin-level probe by hand (without using a tool) for maintenance/troubleshooting, the employee felt pain in their right hand. The probe was threaded tightly and the employee applied force as it was not budging. It gave way quickly, resulting in the injury (sprain).
220250450015M12486Using a vac hose, the suction pulled EE forward strain/pulled EE's lower back.  Initially declined medical attention.  Pain increased and requested medical on 02/12/2025, which were able to schedule.  Restrictions were placed with that appointment.
220250490001M10231Reportable hearing loss
220250490002M13067Employee was preparing to climb up into the loader. EE placed EE's right foot on the bottom rung of the loader ladder, pushed up and felt some pain. Employee sought medical treatment and was Dx with a RT knee strain. On 2/3/25 we were notified EE was referred to Physical Therapy. Reporting within 10 Days.
220250490008M13227Employee was moving a 17" by 17" piece of broken shell liner (discharge liner) to place lifting sling around for removal. The Liners weight came over center, the injured reached for the liner, grabbed a sharp edge and cut EE's right palm area. The liner cut through the TIG welding glove. Cut was approx 2 inches in length
220250490009M10772Fall when cleaning loader bucket.  Broke Right Collar Bone. Surgery Required.
220250490015M10582Miner hit another miner with EE's fist fracturing EE's jaw
220250490020M12155Employee was walking down catwalk and felt a pop in EE's left knee. Employee was seen by doctor who found no injuries but requested further imaging and placed employee on restricted duty until imaging was completed.
220250490022M11413Employee stepping down from dozer when EE lost EE's footing causing EE to fall; in process of EE falling, employee started experiencing pain.
220250490031M13808Employee was working on the screen at Scrubber Tower 10SC002. After putting all the tools away, the employee went down to the MCC to remove the lock and commented to a coworker EE couldn't find EE's vaping device and rushed up the tower, climbing too quickly into the screen EE's right foot got caught in the screen panel and EE fell twisting and straining it, the ankle and knee.
220250490032M11674On 2/6/25, employee was working in the top deck of the wash screen, when employee stood up and hit head on the spray bar. Did not seek medical treatment until 2/11/25.
220250490033M11263Employee was cleaning out from under the end gate.  The gate slipped off of the prying tool and cut off employee's ring finger
220250490035M12977The affected worker began workday at 6:30 AM. While loosening a screw on the machine, EE lost control of the tool EE was using, causing EE to hit forehead, specifically on the left side, at the level of the eyebrow. As a result, EE sustained trauma and a wound that required a three-stitch suture.
220250490038M12225The employee was poking lumps out of a discharge chute with a bar. As employee was poling the material the bar broke through the material, the employee pinched right middle finger between the bar and the edge of the chute.
220250490039M11824Associate was placing a spud pin in the spud when left pinky finger became injured. Associate Received a Transverse Fracture to the left pinky finger. Associate treated and released.
220250490041M13077Employee was performing maintenance activities inside the Barge Jaw Crusher. EE was standing on a piece of plywood that shifted, causing EE to lose footing and fall into the jaw area. EE was wearing fall protection and SRL (Self-retracting lanyard) that stopped EE from falling farther into the jaw crusher.
220250490042M13378Employee was tightening the lid on a tank car with a wrench and the wrench slipped out of EE's hand and EE felt a pain in their lower back. The employee initially tried to treat with first aid but pain worsened and EE wanted to seek medical attention. Employee was seen at local ER and diagnosed with a back strain and taken out of work.
220250490043M12967On February 11, 2025, a mine maintenance employee was performing routine maintenance on a borer miner. While stepping onto the bore miner rotor bit block, EE's foot slipped, resulting in a fall and a laceration to EE's left calf from contact with the borer miner bit. The injury required sutures.
220250490045M11754One employee was holding an electrical box in place while a co-worker was using a drill. The saw slipped and punctured the left thumb of the person holding the electrical box.
220250490046M13798A miner was removing ice from a shaft wall when the miner slipped and fell catching self with their right arm. The miner was evaluated and given a full release with no restrictions. On Tuesday February 11, 2025, the miner was reevaluated and given a work release with restrictions pending an MRI. MRI results showed a partial tendon tear and small fracture in the right shoulder.
220250490047M11383Enclosed space with limited movement lifting and installing liners in velocity box. Lifting panels, oxygen bottles and using sledgehammer.
220250490049M12275While working on A/C unit for a mixer truck, a shop air hose crimp failed and shot out the air fitting. Hitting employee in the head, causing a head injury. Did not break the skin, but did cause swelling causing EE to go to ER.
220250490050M12796Contractor was painting an electrical box on 3rd floor of F Area. EE needed a paint brush, so EE entered the elevator going down. Contractor became lodged between floors, 911 was called and tech for elevator was called also. Contractor was retrieved from elevator without injury.
220250490051M11694EE was holding a hose while another employee was cutting it. When the knife blade passed through the hose, the knife carried momentum and cut the back of EE's left hand.
220250490052M13327Employee reported to the supervisor on 02/16/2025 that EE was in section 4 shipping unloading rail cars on 02/14/2025 when EE slipped and fell on liquid product on the ground while EE was walking towards the hook of the cable during the pulling up of the next rail car. Employee stated that EE sustained injury to left side and leg.
220250490054M11143Employee received a laceration from a screwdriver while reaching into a toolbox, The laceration required stitches.
220250490055M10852Employee was attempting to remove snow when EE slipped and landed on their right hip.
220250500002M13538Injured was on a step ladder investigating a coolant leak. Operator boarded the machine not knowing the injured was still looking into the leak. When moving the loader, operator noticed injured lying on the ground.  Operator immediately stopped the machine, and checked on the injured. This became a recordable on 2/17/25 when employee got restrictions.
220250500003M12776An Employee was opening the door for the mineral separator (Rotex), the door handle sprung unexpectedly catching the tip of EE's right pinky finger between the handle and door structure causing a laceration that required 6 sutures and an open fracture to the tip of the finger.
220250500005M11874Employee was doing maintenance on a blending gate when the ratchet EE was using slipped and hit EE in the mouth, causing a laceration. EE received 8 sutures and was released to full duty.
220250500008M12406While going down the steps in Robo 3 the operator's boot caught the grating causing operator to miss the last 2 steps. Employee fell to the ground and feels pain on both inside and outside of knees. Employee referred to a specialist on 2/17
220250500010M10762While removing a multi tone screw EE's left leg was stuck when load shifted.
220250500011M10532Lifting steel plates in to chutes for welding repair.
220250500013M11403Employee was found in pick up truck unresponsive. Site employees began First Aid/ CPR / AED measures until EMS and First Responders arrived.
220250500015M11754Miner injured their lower back while replacing return rollers on conveyor. Miner did not seek medical attention and documented purpose. Miner went to urgent care on 2/13/2025.
220250500016M10341Employee felt sick after cleaning.
220250500017M12927At 11 AM on 2/18/2025, an employee was working on a concrete pump, attempting to drive off the bearing housing. The employee put a wedge in place and hit it with a hammer, but the wedge flew off it hit the employee in the mouth. This resulted in a lower lip laceration which needed 3 sutures.
220250500018M12055While exiting vehicle in parking lot before shift start, employee slipped and fell. Employee hit their head and had minor abrasion on right pinky finger. On 2/10/25, employee was diagnosed with concussion.
220250510001M11073While employee was walking to haul truck for start of shift, EE slipped and fell injury EE's knee and ribs.
220250510002M10882Miner was climbing into powder rig man lift basket and hit EE's left knee on the basket.
220250510005M11263While using an unapproved tool for personal use a laceration was sustained to right hand which resulted in medical treatment. 
220250510007M13788Employee was servicing equipment, EE started to descend the ladder. When EE got to the last rung, EE's left foot going to the ground and as EE was letting go of the rails with EE's hands and stepping down with EE's right foot...EE caught EE's boot solidly on the last step which caused EE to fall back. EE's body twisted as EE was falling, landing EE on EE's right hip and back.
220250510008M11824EE was welding a piece of grating in on the 73 turbine platform which required EE to climb into a tight spot below the grating.  When pulling self back up EE heard EE's shoulder pop.
220250510009M11223While employee was drilling a line broke under EE's feet filling up the cab with fumes. Employee seeked medical attention.
220250510010M12476EE was stepping off the work boat onto the dredge when EE's foot slipped through the handrail of the work boat, pinning EE's leg up to the knee. EE didn't go to the clinic until 2/18/2025, they said EE has an infection in the lower part of the leg
220250510012M12375Employee was using a pipe wrench to break a rotary feeder free. EE was unable to break it free by hand. EE then used EE's body weight by standing on the wrench. EE slipped off and the impact to the flooring caused pain in EE's left knee.
220250510013M11043While operating a loader in the pit, the individual was jostled in the seat and felt pain in their back.
220250510015M11604Employee alleges was walking from scale house to employee's work truck and heard a pop in right foot.  Employee was diagnosed with a fracture to the right foot.
220250510021M13558#2 hoist (Primary) went down due to electrical problem, Maintenance Coordinator and electrician used #3 hoist to reach surface. Maintenance conducted troubleshooting and found a bad coil on the main brake. Maintenance replaced the bad coil on the main brake and #2 hoist was up and operating at 9:50 pm. #3 & #6 hoist were still operable during this time.
220250510022M12897The miner was injured prior to loading explosives at a header.  EE entered the basket on the powder truck and was manipulating the ANFO hose when the hose "whipped" and struck the face, causing small pieces of rock to break off.  One piece struck EE in the right palm causing a laceration.
220250510023M11955EE was underneath the surge bin trying to free frozen material by hitting the bin with a sledgehammer. On one of EE's swings the sledgehammer bounced back at EE striking EE in the right shoulder.
220250510024M12516As the employee was dismounting the haul truck, EE stepped off the last rung of the ladder and stepped on an unseen small rock and rolled EE's knee inward. First day of missed work was 02/06/2025, following revised restrictions from a follow-up visit.
220250520001M11955Employee was backing a dozer on the main dump and contacted a rock with the back of the dozer, this caused a sudden stop which jarred EE and caused neck pain. First day of work missed 02/19/2025.
220250520002M11413Employee was using an iron worker to shear a piece of 1/4"X2" strap when they pinched their finger between the workpiece and the shear table.
220250520007M11223Employee climbed on C20 counterweight guard to remove ice from bend pulley when EE slipped and fell fracturing right wrist
220250520008M11734A contractor without a contractor ID installing arc flash labels at the mine walked down a slight incline off a small cement pad, lost EE's balance and broke EE's right leg.
220250520009M12876The employee reports was traveling down the 75 fwl in a haul truck on good roads.  The parking brake set up on the truck while in motion causing the employee to twist lower back.  The employee was wearing seat belt at the time.  The employee was seen by a doctor and issued restrictions.
220250520010M11113Employee was putting a wheel chock into a chock holder when they smashed their finger resulting in a fracture. 
220250520011M12756Using a pipe wrench to break loose a plugged piece of equipment. EE stated EE was putting pressure on it, it broke loose and EE's left hand got caught between the pipe wrench and shiv. EE stated it crushed EE's hand in the same place of EE's previous fracture from last year.
220250520012M10732Employee was exposed to a caustic leak on the Mez deck in precipitation. 
220250520014M13688While dismounting from the driver's side of a water truck, the employee missed the bottom step and fell backward, landing on their backside. Initial injuries included a scrape to the arm and leg and back soreness (first aid). On 2/11, they reported neck stiffness, received medication, and were recommended physical therapy starting 2/21. Work status: No restrictions.
220250520016M10812Employee pinched their right pinky finger between two bars requiring 4 stitches. 
220250520021M11594Employee slipped in the ice and caught self before falling. Strained the right shoulder. Physician prescribed physical therapy on 2/12/25 making it reportable.
220250520024M10752MIS Employee felt a popping sound while ascending stairs, felt pain in leg.
220250520026M12225EE was coming down from the back of the water truck with a hose in hand. The high velocity fire hose valve opened up and the employee lost their footing. EE did make it to the ground on both feet, but the landing was hard.
220250550001M12265Employee had tied EE's sweater with a zip tie and used a blade for cutting. When EE was cutting EE pointed the blade toward EE's body and cut EE's hand. EE should have pointed the blade away from body to prevent this incident.
220250550002M12165Employee was installing equipment with crane assist. While walking employee tripped over a dunnage block and fell down. Employee sought medical treatment and was Dx with a rotator cuff tear. Reporting within 10 days.
220250550004M11544Stored coal spontaneous combustion resulting in a fire within the silo. No injuries were sustained. The fire was extinguished within an hour of discovery.
220250550010M11193Miner grabbed slusher cable near the block and got EE's hand stuck in the block causing a laceration of EE's left hand.
220250550011M12606Employee was crouched down and felt a pop in EE's knee when EE stood up. Employee was seen by a doctor on 02/06/25, where EE did not receive any treatment and was not placed on modified duty. EE was seen again on 02/17/25, where EE was placed on modified duty.
220250550018M11043Employee received laceration on lower right leg from high pressure water lance that required 6 stitches.
220250550020M10582Tripped on lip of grating and fell forward onto left knee.
220250550025M11844Employee was standing next to the hood doors on K2 Burner Floor when a 6" metal braided hose that was being suspended broke loose causing it to swing striking the employee in the face.
220250550026M10281Lost drive module on Phoist.
220250560001M10321Bad multi-conductor in #4 shaft.
220250560003M13458Customer Truck Driver became engulfed in Stone (DGA) when unloading excess material after being weighed out. Driver at the rear of EE's vehicle when slope of stone pile gave out trapping EE under the pile. EE was removed by Quarry personnel with assistance from Emergency Response Units. EE was evaluated and released from Hospital the same day.
220250560004M13067EE texted Plant supervisor that the excavator operator was dropping large rocks too hard in EE's haul truck. EE did not report and injury at that time but after EE's shift EE called HR and said EE's back hurt. EE to Texas med clinic and the ER and was diagnosed with possible muscle and vertebrae injuries.
220250560005M12375Employee hurt EE's shoulder while dragging a fuel hose. We were waiting upon diagnostics to figure out what was wrong to know whether it was reportable or not. Employee has been placed on light duty until surgery for a torn rotator cuff.
220250560015M10792EE was on ladder fixing hydraulic lines on the Excavator and fell on the ground
220250560018M12025Worker was opening a gate on 02/20/25 when the gate's latching mechanism dropped on right hand crushing their third finger. Worker worked remainder of the day and reported injury to site EMT on 02/21/25
220250560019M11494Employee was diagnosed with a standard threshold shift by Dr. on 02/13/2025. The hearing loss is consistent with noise induced loss in the right ear.
220250560022M13327At the end of shift a worker had been disposing a section of drill rod into the steel waste bin. While attempting to throw over a T45 drill rod into the steel waste bin, the worker felt a strain in their right shoulder. The injured person (IP) reported that their left footing had slipped while throwing the rod into the waste bin. 
220250560023M11253Coveralls got caught and tripped the person involved causing the person to fall and puncture hand when falling to the ground.
220250560026M12436A fire started within the engine compartment of a CAT 390D Excavator; fire moved then moved to encompass entire piece of equipment. Operator that was running equipment was able to safely get away from the equipment. Equipment was a total loss.
220250570001M11213Employee was kicking rocks off the undercarriage of a conveyor belt when EE felt pain on the back of EE's lower left leg.
220250570002M10722The employee was climbing on a drill rig and strained EE's shoulder area
220250570005M11925The injured employee was walking down a catwalk at the feed station and slipped on some ice. As EE fell, EE grabbed the handrail, pulled EE's shoulder, and landed on EE's right knee and elbow.
220250570007M12185Employee was opening the door to #2 crusher to clean it out when EE felt pain in the shoulder. The employee went to the doctor on 2/18/25 when they diagnosed EE with a rotator cuff sprain and needs to be on light duty.
220250570008M12235Employee went to stand up in work area when employee felt pain in ankle. The employee was taken to the ER and found to have a sprained ankle. Employee has been removed from work as of 2/24/2025 until 3/6/2025 as per doctor.
220250570009M11824Injured was moving a 55 gallon drum in the warehouse when the injured felt pain in knee.  Incident occurred on 2/16, but not reported until 2/18 when medical attention was requested.
220250570011M12766Employee was washing under the 219 ball mill. Employee crossed over the 212 cyclone feed pump discharge line by stepping on the angle iron brace supporting the pipe. While stepping over, employee slipped and rolled an ankle.  Employee was placed on restricted duty 02/18/2025.
220250570014M11213Employee strained muscle in shoulder during act of swinging sledgehammer. Task was to drive bolts out of 24" pipe flange.
220250570015M11784The employee swung a pickaxe to break the built-up clinker Build up. Then, they felt a sharp pain in their right shoulder, stopped using the pickaxe immediately, and reported it.
220250570018M12355Employee was drilling a hole in a 1/2" bolt. As EE was applying pressure to the drill, the drill bit broke, resulting in the pinkie finger of EE's right hand striking the broken drill bit, with a laceration of EE's right pinkie finger.
220250570020M11113Employee removed side port hole to remove rocks and cement rushed out of port hole and got into EE's right eye.
220250580001M13157A fire started within the engine compartment of a CAT 390D Excavator.  The fire moved to encompass the entire piece of equipment.  While the Operator that was running the equipment was able to safely get away, EE was unable to use the steps on the equipment and had to jump off and landed awkwardly in wet material.
220250580004M10983While reassembling the centrifuge at #3 steam turbine the operator smashed EE's Left Pinky Finger.
220250580005M11223Miner was walking when the miner tripped over a 10' piece of 6" steel C-channel lying along side the opening to a walkway.
220250580008M13708Employee was at the 3090-refuge chamber pulling the 3/C #10 AWG cable around to the back of the refuge chamber to land the cable into the junction box. Employee threw the cable towards the back of the refuge chamber and stepped down from the first rung of the ladder. Employee slipped as employee stepped down and felt a sharp pain in right ankle and fell to the ground.
220250580009M11253Assigned to change out a steering pump and in process used a come-along to hoist up pump into place, felt a pop in left bicep
220250580011M11464EE was working on a metal tube sleeve for protecting a sensor. Bending in awkward position felt tightness in lower back. Prescriptions prescribed.
220250590001M11093Employee was washing out the sand screw when EE lost control of the hose. The hose struck EE in the left eye.
220250590005M11925While operating the Volvo 550 excavator a hydraulic leak started during operation that led to a fire in the engine compartment. The operator observed the fire and safely exited the equipment. 
220250590006M10942EE was tightening the clip on EE's radio when the screwdriver slipped and punctured EE's hand.
220250590008M11804The millwright reached down to pick up a 2" high-pressure steam valve, but it got hung up on another valve that was wrapped in plastic. EE then felt a slight pain in EE's shoulder.
220250590009M12526Employee slipped on ice, fell and struck EE's head on the ground. Initial complaints were of pain in EE's head and right shoulder. Several days later, EE still didn't feel well and went to the ER. Possible head injury, will be off work at least 5 days.
220250590011M13438The operator replaced the 612 A strainer and then proceeded to switch the 612 B Strainer. While turning their back to switch the strainer valves, a loud noise occurred, causing slurry to spray out of the strainer housing toward the operator. This incident caused the operator's hard hat to come off & them hitting their head on the beam above.
220250590012M11454While stepping onto a parking pad outside of the electrical shop building, the employee slipped and fell to the ground. Employee landed on torso.
220250590013M13057Ee was dismounting scissor deck underground. Ee slipped and fell, landing on left wrist. Ee was seen at the ER, diagnosed with a left distal radius fracture, given a brace and released to modified duty pending ortho consult. At ortho consult, ee put in cast and put off work for 3 shifts, then restricted.
220250590015M11734Employee was drilling a hole in a new disconnect box. The drill bit got caught and pulled the box into employee's hand. Caused a cut and tuft fracture to right index finger.
220250590016M10752EE was diagnosed with Carpel Tunnel Syndrome after 40 plus years of mining.
220250590017M12005Miner was adding a section of drill steel using a wrench to tighten the connection.  The miner's left thumb was caught between the drill boom and the wrench causing a small avulsion to the left thumb.
220250590020M12516EE was trying to clear an elevator bucket from a screw.  Another EE was twisting the drive belt when first EE pulled the bucket out, causing the screw to rotate.  The screw hit the first EE's left hand.  First EE suffered a broken hand and laceration.
220250590024M114742 employees were changing screens in the screener. Employee 1 was pulling screen from one side and felt 2 pops in their right bicep when EE did it.
220250590025M10321Employee pinched and cut finger.
220250590026M10251Employee smashed fingers.
220250590027M12516Two employees were attempting to light the Kiln burner when it flashed blowing hot gas and dust onto the employees. One employee received first and second degree burns to the left of their face and neck, the second employee received only a minor burn.
220250590028M11764Miner was placing scrap in recently emptied dumpster while wearing hand protection when EE smashed their right thumb.  EE's fingernail became loose and EE's thumb looked split.
220250590029M11093Employee was using a tool to remove frozen material from a conveyor. Struck hand on framework injuring thumb.
220250590030M11724Employee was scrapping frozen material in a coal barge. When doing this EE jarred their back. Was taken to OMP for evaluation for a strained back and given restricted duty.
220250620001M12576EE called and reported left knee pain while getting on and off a D8 Bulldozer. EE states that the incident happened on Friday night and that the pain has increased since becoming bad enough that it prevented EE from being able to work Sunday & Monday night.
220250620004M13618EE flip a manual gate to chute EE opened the metal door and secured the safety chain; EE bumped the metal door causing the chain that secures the door to come loose, the door fell back down and smashed the employee's finger The EE was wearing safety gloves when incident occurred Employee's finger index nail was smashed and employee sustained a fraction finger
220250620008M11183Employee's hand made contact with discharge water from nozzle of pressure washer wand that the employee was operating.
220250620009M11894Employee was cleaning with a shovel at the tail of PRCV04 (primary conveyer), and with force hit some hardened material with the tip of the shovel, causing a strain to the right groin area.
220250620011M12746An employee was walking underneath the finish screens on EE's way to repair a water line on a finish conveyor. As EE was walking under the screens EE slipped and fell on some fine dust and water that was on the concrete pad. This resulted in a fracture to EE's right fibula.
220250620012M11574EE Slipped of access latter of WA500 loader as EE was dismounting falling 4 1/2 feet to ground. EE sustained tear to ACL and fracture to fibula to right leg.
220250620013M13257Two shop mechanics were working on placing a rod end pin into excavator cylinder while replacing new stick cylinder. 1st mechanic was approximately halfway down an A frame 6' ladder when the cylinder fell striking the mechanic in EE's upper chest causing a contusion. Mechanic did not seek medical attention until 02/19/2025.
220250620014M12436Employee was troubleshooting issues with material flow at a cement finishing product mill. During this process the employee opened an inspection door to an air slide and when EE opened the door a flush of material came out and got in EE's eye.
220250620018M12265Employee was using index finger of right hand to move rollers on a transition between two jug conveyors in clumping packaging department when employee's finger was pinched resulting in a laceration requiring stitches to close.
220250620022M13788The miner was adjusting a conveyor belt. Miner was injured when the pipe wrench miner was using slipped & mashed finger. Miner was wearing ppe. Miner was taken for a medical exam & diagnosed w/ a contusion but only received 1st aid treatment. Miner was restricted from lifting weight with hand.  On follow-up appt. miner was told to only work in a splint & would be reevaluated.
220250620025M12245EE was assisting moving a portable heater (salamander) when lost balance and crushed pinky finger on RT hand between heater and cross member on rotex deck. EE was taken to ER resulting in finger fracture and nail avulsion.  
220250620026M12536Heavy equipment maintenance employee opened roll door for heavy equipment fueling and used more force than necessary. Hand bumped into top of door frame causing some bruising of right hand/bones restricting ability to squeeze and lift with right hand.  
220250620027M11183A Miner was injured while separating the forks on a Skid Steer that resulted in a sprain to Miner's left index finger.
220250620028M12586Two maintenance employees were working to replace broken bolts on the longwall stage loader chain flights.  One employee was swinging a hammer to free the flight and the other employee was pulling the chain and was struck by the hammer requiring 13 stitches.
220250620029M10602EE was pushing a roller and felt pain/pop in right shoulder.
220250620030M13518Employee did not seek treatment until 02/25/2025.  A pin for the excavator bucket was being knocked out and when it came out, instead of letting it fall, the employee held onto it, not realizing the weight.  Employee's left ring finger was smashed in between the pin and the excavator bucket.  The employee received a fractured finger and two sutures.
220250620031M12145While backing the 548 production truck into the 5 shovel loading position, the dipper bucket contacted the truck box. The employee felt pain in their neck and shoulders and sent needle like pain down their left arm
220250620032M10762Maintenance repairman performing non routine tasks, improperly moved object.
220250630001M12135Employee was using a manual post pounder to install a grounding rod. Pounder came off rod and went in between pounder and employee's hand. Causing laceration to employee's right hand. employee received 6 stitches.
220250630003M12866The employee was in the process of loosening a bolt on a piece of machinery. While pulling back on the wrench to loosen the bolt, the wrench slipped off the bolt and hit the operator in the mouth, striking EE's upper right central incisor tooth causing a hairline fracture in the tooth.
220250630006M10542EMPLOYEE WAS MOVING A PUMP, SLIPPED AND TWISTED KNEE. 
220250630007M10732EMPLOYEE OPENED SCALER DOOR AND CAUGHT FINGER BETWEEN DOOR AND HANDRAIL. 
220250630008M12786At approximately 18:18 after pre-shift meeting, an operator was exiting the lineout tent on their way to the tie-line buses. Then, the operator caught EE's left leg on the boot scrubber that was being used as a door stop, causing the operator to fall and land on EE's left knee.
220250630009M12375Worker was driving a haul truck at the 101 shovel pit and received a load unexpectedly, causing the worker to be jostled. Worker reports experiencing immediate back pain (7 out of 10) that has improved over the past 4 hours (3 out of 10.
220250630011M13478Two employees were going to top of tower while elevator tech was performing work and got stuck in between floor 7-8. Employees failed to notify supervision, once made aware of the situation over an hour had passed and employees were removed within 15 minutes. Employees were offered a way out from the electrician but said no that they would wait.
220250630014M13788Miner was drilling a hole through some rubber flashing. Miner was operating the hand drill with left hand while supporting the section of flashing material from the back side with right hand. When the drill bit cut through it contacted the palm of the miner's right hand causing a laceration resulting in 6 stitches, antibiotics, and Tetanus shot. Restricted duty for 7-14 days.
220250630016M12927Tracking and arcing developed on the MMT-3 transformer, faulting the transformer phase to phase. The vacuum breaker at MMT-1 failed to open to disconnect power to the underground power system. Resulted in a fire on the Neutral Ground Resistor on  MMT-1 and a failed 12.47kV cable in the mine.
220250630017M11083EMPLOYEE WAS WALKING ACROSS MILL CONTROL ROOM WHEN EMPLOYEE FELT A POP IN LEFT CALF MUSCLE FOLLOWED BY PAIN.
220250630018M10672Accident conditions are Unknown. Tractor and trailer were totaled. 
220250640006M13808Ee was dispatched to assist w/reagents offload delivery. Ee arrived on scene & had difficulty breathing. Contractor that was waiting to be offloaded recognized ee was having trouble & asked if everything was ok. During the interaction, ee used their asthma inhaler, was unable to take deep breaths, & asked contractor to get help. Contractor helped ee to ground & called a MAYDAY.
220250640007M12516While swinging a sledgehammer to remove the roll pins on the blow bars of the secondary crusher the employee felt a sharp pain in the lower right back. Was seen by the doctor on 2/26/25 and placed on restrictions for a muscle strain in the lower back.
220250640010M13378On 2/25/25, Vista employee was cleaning material buildup under conveyor with a dingo. The employee caught EE's right hand between the handle of the dingo and the conveyor resulting in lacerations. The employee was taken to Granbury Medical Center where EE received stitches. The employee was released the same day able to return to work.
220250640014M11744EE was cutting zip ties with a knife and when EE cut through the zip tie EE jabbed self in the forearm. EE needed stitches and was released back to work with no restrictions.
220250640017M13688On February 3rd, 2025, at 4:30 AM, an employee pulled back a hose with excessive force, lost balance, and rolled their left ankle while trying to stabilize. A crunching and popping sound was heard. Unable to bear weight, the employee's foot was dangling. Work partners, the foreman, and safety were notified. The injury was classified as recordable on March 2nd, 2025.
220250640018M11854The employee was manually clearing material out of the cone crusher (choked), as employee was doing it a rock fell and struck employee's right forearm. The employee received 9 stitches.
220250640019M10271Employee fell injuring knee
220250640021M11584Employee felt a pop in their hip while picking up a paint bucket on 2/23 and then again while changing filters on 2/24 that resulted in additional back pain. 
220250640022M13808Employee started job at around 12 Noon, the job was to replace the flashing on belt 3. Employee locked out the belt & tried to start, after test employee grabbed the tools required to do the job, entered the manlift, put it into position & started removing the bolts on the guard. When removing employee felt pop in right shoulder. Reported it to the Mine Manager & Safety Manager
220250640024M12095EE was swinging a pick and hitting a frozen chunk of stones and mud, trying to breakup, and remove it from the catwalk. When EE hit the frozen pile, EE felt something snap/pop, and a sharp pain in right wrist.
220250640026M13277Employee was removing snow and ice from a conveyor belt with a flat nosed shovel.  While pushing the ice off the belt, the shovel caught on the belt and employee's body weight went forward.  The wooden handle came back and hit employee in the mouth. This caused 2 teeth to break and had to be extracted.  Antibiotic prescribed.
220250650001M11804While changing rolls employee had a piece of clinker dust get behind EE's safety glasses and in EE's eye.  EE was given antibiotic eye drops after removal of particle on 03/03/2025
220250650005M10862Alignment hand tool hit injured person in the chin while EE was attempting to free it.
220250650006M11784While dismounting a trailer, Temp employee encountered a loose step causing EE to fall 3 feet onto ground scratch on left elbow and left foot pain resulted in left foot fracture.
220250650008M11003Employee tested and had a standard threshold shift on EE's hearing test. Employee came in on day off
220250650010M10401Tripped while replacing Rollers on plant
220250650011M12245An employee became entrapped in the Step 3 Fines Crusher Elevator.  The control room because aware of the entrapment at 4:06pm CST.  MSHA was notified at 4:34pm.  The employee was able to exit the elevator unharmed at 5:15pm
220250650012M12125Three employees became entrapped in the Step 3 Fines Crusher Elevator at approximately 10:15am.   MSHA was notified at approximately 10:42am.  The employees were able to exit the elevator at approximately 11:11am
220250650013M10983TM was stripping wire insulation with a utility knife when the employee cut the pad of left thumb.
220250650015M13147An employee attempted to throw a 3 pound rail anchor into the back of a grapple truck, but the rail anchor ricocheted off the sideboard of the truck instead of landing in the back and struck another employee standing nearby in the mouth, lacerating the employee's upper lip and fracturing the employee's upper jaw.
220250660006M12586EE was closing the doors on the Finish Mill 2.  While using a hammer to help close the door EE accidently hit EE's right index finger.  Medical attention was sought, and EE was diagnosed with a fracture and placed on restrictions of no use of the right hand.
220250660007M12446Employee was rigging a lifting chain to a section of conveyor that was connected to the mini excavator and the operator moved the excavator stick and pinched employee lower arm between conveyor section and excavator stick and bruised lower arm.
220250660010M11544Employee was cleaning out a chute with a shovel when EE slipped hitting EE's right side of EE's abdomen on a handrail. EE was seen 1 week later at doctor.
220250660011M11263Mill Manlift gearbox broke. Miner was entrapped in manlift for 38 minutes. Miner egressed out emergency exit of manlift roof. 
220250660012M11444Employee was operating a skidsteer when it lost power and began to slide. Employee jumped for the equipment causing a sprain in employee's knee.
220250660013M13237EE and another worker were lifting a belt for a conveyor repair. After completion of work, EE sat in EE's office and felt discomfort in EE's back. On following days EE stated condition was improving. On 3-6-25 EE stated that on 3-3-25 EE bent over in the shop and felt strong pain. On 3-6-25 EE's back was hurting severely.
220250660014M11534Employee rolled their left ankle while getting out of a pickup. The injury became reportable after a doctor placed employee on restrictions on 02/26/2025
220250660015M10912Haul truck operator backed into the dipper of the shovel causing pain in their lower back. 
220250660018M12105The detonator had a dead battery. In order to set off the shot, employee brought up a loader. The loader battery was used to set the shot off. Employee was unable to be inside the shelter provided for blasting.
220250660021M13237Employee was stacking 8x8xRandom tumbled material.  While an employee was stacking the rocks, one slipped catching employee's index finger and smashing it and almost tore it completely off.  The remaining part of the index finger was surgically removed.  The employee was not hospitalized.  There was no equipment involved.
220250660022M10963Over the past 3 weeks operator developed pain in right shoulder, the pain became worse over time
220250690001M12105Employee was underneath the primary shaker area when the chute door was left open causing large rock to bounce out. In the process of this action employee was stuck back of the head causing a small laceration. 
220250690002M11634ee was spotting a haul truck, and as the ee was walking backwards, tripped over some loose stone/uneven ground and fell resulting in lacerations to hands and legs.
220250690003M12506An employee was ascending a stairwell prior to the start of their shift when the employee experienced a personal medical issue. The employee subsequently tripped and experienced a stair fall impact sustaining injuries to their left upper extremities.
220250690005M11664The miner was using a welding torch when the oxygen hose burst and ignited.  The fire burned through the miners' jacket and shirt resulting in a burn to EE's stomach.
220250690009M13498Employees had a shaft in the upright position in the elevator. when they arrived their floor, one ee held the top while the other bent down to pick up the bottom end.  Upon lifting, the ee felt a pop sensation in the groin area.  The shaft weighed appx 100 lbs according to ee's.  EE sought medical treatment on 3/6 and was put on work restrictions.
220250690010M13768On 2.20.24, EE was pulling & lifting on an empty battery tray on a CAT 349 Excavator trying to remove it. It did not move, so EE used pry bar to remove. EE reported back soreness the next day but did not want to go to doctor. EE requested to see doctor on 2.24.25 & doctor released to return work. On 2.25.25 doctor required physical therapy and allowed EE to return to work. 
220250690012M11604Employee felt a pop in EE's knee when EE was climbing up to check shims on a hazemag. EE worked full duty until EE had surgery on March 7th for a meniscal tear.
220250690014M13257The employee was heating a bolt for extraction when a piece of paint flaked off and entered employee's eye. At the time, employee was looking over the top of employee's prescription safety glasses, which were tinted due to their transition lens feature. The piece was removed with a swab and antibiotic drops were prescribed.
220250690015M12315Ee stepped off ladder w/rt leg, reports ee misjudged the last step and ee's lt foot caught, hit the ground, and ee heard a pop. Reports pain when moving at 8/10. Seen at clinic, diagnosed with sprain, and released to modified duty.
220250690016M12977Ee reported ee's back feeling tense ee's entire shift. When ee moved a sample bag towards the end of ee's shift, ee felt a "crack" sensation. Went to break, felt "warm sensation" and couldn't move. Went back to work, pain got worse, reported. Cumulative tense feeling in back cumulative in nature.
220250690018M11604Telehandler fork stuck on concrete foundation under pressure, fork gave way in upward motion and employee had foot on fork. Upward motion broke employee's heel.
220250690023M13798Night shift EE decided to retrieve EE's RC car from the employee parking area. The EE retrieved the RC car, placed it in the company truck, and stopped by the granite sand pile. EE began operating the RC car and during this process, EE lost control of the RC car and it jumped off the ramp at approximately 20 mph and struck the EE in the face, causing a laceration on EE's chin.
220250700001M11774Employee was pulling back a piece of flex pipe when they felt a pop in their elbow. The employee sought medical treatment and was given an immobilization sling to use as needed.
220250700006M13207IP was riding bus back to park at lark when bus turned corner from the mine entrance road and hit a hole causing IP to experience neck pain. IP was assessed by EMT and denied transport to clinic. Follow-up appt on 03.04.25 wrote "avoid neck movements that cause pain". Able to perform all normal duties at a slower pace.
220250700007M11985IE was filling bags at bagging station and moving to conveyor. The following morning EE reported soreness in EE's right shoulder.  Sent IE to clinic and diagnosed with right trapezius muscle strain.
220250700008M13368IP was driving haul truck when they hit a pot hole and began to experience neck pain. Was assessed by EMT. IP went to clinic with supervisor for further evaluation. 03.04.25 visit "Avoid neck movements that increase pain. Avoid overhead shoulder movements that increase pain." Worker able to perform all normal duties at a slower pace. 
220250700010M10712Struck right hand on stationary equipment causing soft tissue contusion
220250700012M12596EE was using the drive belts to rotate log washer tubes for maintenance on a cold day, EE's glove caught the drive belt and EE's finger was pinched between the drive belt and the motor sheave.  X-rays at med center on 3/4/25 showed a broken left index finger.
220250700014M13007Employee was in Pit #3 of Plymouth Meeting Quarry to take pictures. EE was walking back to EE's vehicle and stepped on a rock while crossing 6' wide mud wash. The rock gave way, and the employee fell sideways. EE struck the left side of EE's head on a rock. Left ear was lacerated requiring stitches.
220250700015M10492CARPAL TUNNEL BILATERAL AND RIGHT CUBITAL TUNNEL 
220250700017M10772Employee suffered minor burns after coming in contact with diluted lime water
220250700018M11624A labor support tripped while crossing a grizzly cover and fell causing a dislocation of the shoulder. The injured person was placed on light duty by the provider
220250700020M13317While bolting the back, loose material fell causing the miner to move backwards. This caused miner's machine to fall toward miner, knocking backward. As miner fell backward, left hand came into contact with the post of the bolt deck which resulted in a hematoma on the hand. The miner was placed on restricted duty by the provider.
220250700022M13508Employee was at the breaker on the receiving end. Employee was turning around a stone to be processed into small pieces. Employee admitted to being distracted/looked away, the tip of employee's right index finger was smashed by the shifting stone. Employee was wearing gloves, employee was sent to the ER to evaluate. Awaiting results from follow up.
220250700023M12816Employee was cleaning along 19 belt when a gust of wind blew stone dust into EE's eyes. EE washed out eyes and assumed there would be no further issues. The eye irritation continued and got worse over the following days.  Employee was given prescription eye medication on 3/8/2025.
220250700026M10963Stepping down off bulldozer employee's right knee buckled causing employee to fall to the ground
220250700027M11253Haul truck operator was getting loaded and on the last bucket EE experienced a jolting feeling that caused pain in EE's back.
220250700029M13518Management was made aware at approximately 9:40 pm on 3/10/2025 that material was on the primary escapeway track. MSHA was notified and miners were evaluated using the secondary escapeway. It was determined material from the adjacent conveyor had spilled the material. Primary escapeway was put back in service at 12:25 am on 3/11/2025 after cleaning.
220250700030M12345Miner was cleaning rocks out of the apron feeder in the tunnel. The left index finger was smashed between the bar the miner was using and the apron feeder wall. The contact resulted in the tip of the left index finger being fractured.
220250700031M12606Employee was greasing an excavator, after finishing greasing employee started to retract the grease line. In the process of retracting the line employee lost control of the line causing the grease gun handle to whiplash striking the employee's left wrist area.
220250700032M11644EE was coming down the plant from cleaning the walkways. When EE got behind the old #1 screen EE slipped on ice. EE went to catch self and tore muscles in shoulder.
220250710002M10702While lifting airbag above shoulders felt a pinching sensation on neck
220250710003M10401Employee was struck by excavator bucket 
220250710004M11724employee was going checking air hoses on a truck.  when EE went to step up onto the platform, the step broke and the employee fell into the trailer injuring EE's right arm.
220250710005M11564EMPLOYEE WAS WALKING THROUGH THE NORTH SIDE OF THE PB FILTER VACUUM PUMP AND SLIPPED IN DRY FLOCCULANT THAT HAD FALLEN FROM FLOOR ABOVE THROUGH THE GRATING.
220250710008M13518At around 5:10pm, employee was re-installing a cover plate after inspecting the inside of a rock transfer chute between two conveyor belts.  All the fasteners on the cover plate were removed except the safety chain.  As the employee was installing the first fastener, the plate slipped, and EE reacted by trying to catch the fall with EE's right hand.
220250710009M13187Employee was rolling a piece of pipe on the welding table and it hit a piece of angle that was also on the table causing it to fall off and land on employee's left foot just behind the steel toe leaving it bruised and swollen. Employee did not seek medical attention until a later date- ee was put off work eff 3/6/25.
220250710011M13548Miner was lifting motor and base plate for replacement, as EE lifted and twisted to put the motor in place, EE felt a strain in right side rib cage. EE reported the incident, but thought EE was fine.  Miner did not sleep well.  The next day at work, EE reached to pick up a tool and felt a tearing sensation in the area EE felt the strain the day before.
220250710018M11674While throwing out shards of metal a piece of metal got caught on the employee's glove, ripping it causing a small piece of metal to become embedded in employee's hand
220250720002M11293Employee was stacking empty paper bags on a flat working surface when EE rolled EE's right ankle as EE was making a turn to walk.
220250720003M11093The employee was climbing down the ladder of a haul truck, missed the last few steps and fell to the ground. 
220250720005M12646Employee states EE was using a safety knife to cut suction hose to length.  The hose and knife slipped and contacted the miner in the leg.  The contact resulted in a ~2 inch laceration requiring suture to close.  The employee returned to EE's next scheduled shift.
220250720006M11454Employee was reaching over a table to install bolts into a probe flange while standing in mud.  right foot slipped and EE felt a pop in EE's knee
220250720007M10381Employee felt continuous pain in wrist
220250730002M13598While rotating a haul truck final drive during re-assembly per service manual instructions, two employees were using long pry bars to rotate hub assembly. One of the employee's bar slipped out of its position on the hub causing the employee to fall backwards to the ground, rolling EE's right ankle causing a fracture to the employee's right tibia and fibula.
220250730003M12546Employee was using cutoff tool on sheet metal project.  Work was performed outside with favorable conditions.  Cutoff tool was inadvertently powered on while connecting hose to tool, making contact with left thigh causing laceration requiring 5 stitches.
220250730007M13227Employee was removing screens (est. weight of approximately 70 lbs each) from the manlift when the screens began to slide. While attempting to prevent them from falling, the screens slid across the employee's wrist, causing a laceration that required 8 stitches. The employee was returned to work with medical restrictions
220250730008M10822Machine was fine.  Hydraulic line blew and ignited the hydraulic oil on the turbo.
220250730010M11403Employee was walking over scrap metal in laydown when EE lost footing and when EE landed on right foot EE felt a pain in the bottom of foot.
220250760002M12235Employee was removing panels from screen media with Air Tugger, when employee was holding Air Tugger chain with EE's left hand. Employees left hand became lodged in the Air Tugger Block causing laceration to EE's left hand.
220250760006M11524Employee was found entangled in conveyor 12 tail pulley. Responding authorities pronounced the employee deceased. Incident is still under investigation.
220250760008M10842While operating a haul truck, a bump was struck resulting in a numbness to left arm.
220250760009M12245Employee was washing the calciner area with a straight tip lance in the upward position. A piece of build up dislodged and hit the lance, jarring it and pushing it backwards into EE's left shoulder area. Causing a contusion.
220250760012M12866Scale Attendant fell on ice going to car.  Employee has been performing normal job duties but has had consistent discomfort.  Employee became reportable on 3/14/2025 after a follow up doctor's visit indicated a nondisplaced fracture of the left tibial spine requiring restricted duty.  
220250760015M10572Blown fuse caused the production hoist to be inoperable. 
220250760016M12466Worker was cleaning the plant floor and encountered a guard that had fallen from a  head pulley on a conveyor. EE attempted to replace the guard and the active conveyor caught it. EE's hand was smashed between the guard and adjacent steel casing.
220250760017M13688Employees were unclogging a baghouse and a hard hat fell into the screw at the bottom of the baghouse. The hard had was drawn into the screw and stopped at the rotary valve. They workers locked out the screw and valve and attempted to retrieve the hard had. When the hard hat came out, there was stored energy in the valve and it turned and caught the workers fingers.
220250760018M10652Kneeling left knee on frame, right foot slipped and lost balance.
220250760019M12806Loader Operator was operating a 980 CAT Wheel Loader. While driving through the facility in the Loader, the Operator drove over an uneven road causing the air suspension in the Driver Seat to lower. As the seat lowered to full extension, the Operator felt pain in EE's lower back.
220250760022M11854EE was unrolling torch leads, and was walking backwards. EE slipped on a loose rock and fell. As EE was falling, EE put right hand out to catch self and in doing so dislocated shoulder.
220250760025M13618The worker received a foreign body in the left eye following grinding. Visited medical clinic. Remove Foreign Body Cornea (with slit lamp): saline irrigation and anesthetized by 2 gtt(s) of Proparicaine. Foreign body removed with a needle. The eye was irrigated with saline after the procedure. Release full duties, may perform regular work. Released from care.
220250760027M10461EMPLOYEE TWEAKED RIGHT KNEE WHILE EXITING CAGE
220250760028M10471CARPAL TUNNEL SURGERY IN LEFT AND RIGHT WRISTS 
220250760029M10632CARPAL TUNNEL SYNDROME IN LEFT AND RIGHT WRIST, AND LEFT ELBOW.
220250760030M11704Employee was stuck by shop bay panels due the high winds experience on that day. Employee started to have shoulder and head pain due to the impact of the flying object.  
220250760031M11824Employee was assisting shoveling a pile - EE fell into the pile and got lime in eyes. EE went to local medical center to get eyes flushed. Treating physician prescribed EE eye drops.
220250760032M11203Employee was working on a mud pump, slipped in the mud and fell on left shoulder. Fracture to upper end of left humerus.
220250760035M13217EE was walking a man lift down a pit road when the tires hit a 3-4 inch deep washed out rut caused by rain while traveling 2-3 feet off the ground. The rut caused the basket to bounce causing EE to be lifted into the air, when EE came down EE's right foot landed on the throttle assembly causing EE's right knee to twist.
220250760036M11343EE was taking apart a lube line and twisted wrist. After a few minutes EE reported pain in wrist and was checked out by EMT on shift. 
220250760037M12395The employee was removing/replacing the guard while the bucket elevator ran. The guard slipped into the opening, getting caught by moving buckets, causing the guard to slam down on employee's lower leg, causing a tibia and fibula fracture.
220250760039M12315An employee lifted a bucket of dust to top of handrail and as they lowered the bucket of material, the employee felt a pull or strain in their right shoulder. First aid until 3/14/2025 when they received light duty and script meds.
220250770001M13157IP stated while they were operating the haul truck, they hit a bump and got pulled by the wheel of the haul truck when they hit the bump. Felt a pain in their shoulder which worsened as they were required to pull hard on the steering wheel to get the truck to move. IP was assessed by EMT and was referred to RMMC. 
220250770003M13398While attempting to tighten down a bolt with a washer the Employee failed to use a tool in a rush to secure the nut down to the bolt, the Employee used a half inch battery powered impact gun using EE's left hand while trying to hold a washer with EE's right hand run the nut up and caught EE's right index finger while wearing EE's gloves.
220250770004M10592Maintenance door swung closed and hit mechanic in the face.
220250770007M12055Ee pulled the top door mechanism of the hot change bus to close the door and pinched finger against the rod. Seen at ER, diagnosed with a fracture to the tip of the pinky finger, and released to full duty.
220250770008M13838Individual was pulling on a hose they felt a pop reported to their supervisor on 2/5 indirectly with no issues went to chiropractor & doctor with no notification to employer until 2/13. This incident was under investigation for happening on mine site & with no diagnosis until further medical imaging is required. Waiting for exact diagnosis treated as first aid until further detail
220250770009M13217Ee lifted a pump weighing approximately 30lbs and carried it. Ee reports feeling a "thud" in ee's back and having back "lock up". Ee reported this to workers' comp on 3/10 and was seen at the clinic on 3/11. Diagnosed with sciatica and a strain, aggravating a pre-existing work related injury. Released with restrictions.
220250770010M13808Individual stated that they were picking up a paint can out of a pickup & felt their shoulder pop still had pain Reported at end of shift which is not our company policy The individual has been seen at the local clinic with no diagnosis & this was treated as first aid incident now there is an MRI requested so we are reporting today still with no diagnosis until MRI is completed
220250770011M13127While utilizing flanged clamps to connect a section of rubber hose 14"dia. x 4' long to rigid steel pipes w/ loose flanged ends above and below the hose, the top steel pipe section flange slipped downward smashing and breaking an employee's right hand middle finger while first connecting the lower pipe flanges.
220250780003M11143Employee was cutting an old chute down in pieces and putting them on the ground when a sharp edge cut EE's finger.
220250780004M12446Worker was shoveling spilled material underneath an enclosed conveyor and, forgetting that they were under the conveyor, stood up quickly and hit the back of their head on a sample valve that extended out of the bottom of the enclosed conveyor.
220250780005M10712Employee was carrying an acetylene tank when they felt a pulled muscle.
220250780007M10371Reportable hearing loss in right ear.
220250780008M10461EE was ascending ladder & twisted right ankle.
220250780010M11183While employee was ascending a piece of equipment, EE lost EE's balance causing EE to pivot and twist EE's right knee.
220250780011M11614Employee was repositioning PPE when a small piece of metal went into right eye. After flushing eye, employee received medical treatment for a scratch to cornea. 
220250780013M10872Employee was moving a bar holder from one area to another, bar holder fell on left foot
220250780014M11484Employee was assisting loading VSI hammers from a pallet to a loader bucket. Employee moved 1 hammer (118 lbs.) and complained of back and leg pain.
220250780015M13828The equipment operators were helping with the continuous miner move in the last open cross-cut. The water and power cables that trail the miner were part of the move. The injured employee tripped and struck EE's rt. knee on the uneven ground. Soreness and swelling developed but EE managed to complete EE's shift. An exam occurred. No treatment or RX were required. 7 days off work.
220250780016M12947employee was removing a skid steer bucket in order to switch to a different attachment. while bucket was propped up to release tension of the locking implement the bucket skipped off of the machine and bucket contacted employees' foot with the cutting edge, causing 4 broken bones in left foot.
220250780017M11784Security Officer was at the main gate conducting a routine vehicular inspection. During the process the employee was struck by 18-wheeler truck causing injuries to the right leg.
220250780018M10922OPERATOR WAS CLOSING SCREEN BOX WHEN TANK 104 OVERFLOWED AND MADE CONTACT WITH THE OPERATOR.
220250780019M11514Employee was heating up a keyway to remove from a valve bushing. In the process of doing so the key popped and hit the employee in their right forearm.
220250780020M13828Employee operating loader dumped sand into hopper with grizzly over top. A large object rolled off side of grizzly onto cover on electric motor. The cover rolled onto feeder belt running beneath hopper. EE parked loader, went to edge of plant, reached over guard to retrieve motor cover. EE did not shut down plant or feeder. While attempting to grab motor cover it snagged the belt
220250780021M10241Employee got dust in eye
220250780025M12426Employee was going to help clean at the top of the penthouse.  While walking to the area one of the plugs for a clean out hole was laying on the catwalk and the employee tripped over the plug and hit their knee on the expanded metal flooring.
220250780027M10872EE slipped while climbing into their truck and slammed their left foot into the ground.
220250780033M12385Employee was standing on a piece of metal used as a temporary scaffolding. They were lowering a wear plate 2' X 3' X 3/8" from above when the scaffolding moved causing them to drop the plate from above, striking them on top of their head.
220250780034M10592At 12:37 AM the hoist tripped due to a communication fault.
220250780035M10652The incident is currently believed to be a health related matter.
220250790001M13468The underground Utility Crew was taking structure down from a panel.   As they were bringing in the forklift EE noticed a rail was close to the forklift tire and was going to run over it.  EE bent down to move it out of the way, but the tire of the forklift ran over the end of the rail picking up the other side, hitting the employee in the lip.
220250790002M12215Crew had started shift, they were heading out to the panels they passed the shop, usually lights are on, noticed they couldn't see any light and turned around, saw it was smoke blocking the lights, started evac procedures
220250790004M11243Pry baring door open on hopper car, gate was stuck and trying to break free. The bar slipped and EE fell and hit the ground.
220250790007M11183Pulling the pins changing out quick attach on loader, went to set one down slipped out of grip and twisted left wrist.
220250790011M12786EE was attempting to close passenger elevator door, in the process of doing so EE smashed middle finger. Injury was treated as a first aid. On 03/10/25 EE requested medical evaluation which resulted in EE's duties being restricted. EE was also given splint to immobilize finger.
220250790012M13287While lowering the anvil into the Remco, EE was holding the anvil and a co-worker was pulling with a strap to move it into place. It wasn't lined up, so they were trying to maneuver into place. At some point the cable of the crane got some slack and then released smashing EE's left pinky finger between the anvil and the rotor.
220250790013M13368Miner was working on top of a water tank that was approx. 7' tall. Miner was removing an Air Compressor that inserts pressure into the water tank. As miner proceeded to remove it, the compressor suddenly propelled forward with enough force to strike miner on the face and chest area. Miner fell sideways to the ground hurting right leg.
220250790014M11884Injury occurred to a customer (Xcel Bulk) truck driver.  When trying to pull up on a Customer Service SafeRack safety cage, the injured truck driver felt some pain in their right shoulder.
220250790015M10642Employee was changing the screens when EE felt pain in EE's back
220250800001M11684#3 Hoist was having some electrical problems, so crew was troubleshooting it, we still had our #4 and #2 for escapeways. It ended up being 2 bad fuses. and was repaired
220250800004M10902Employee in the NTV area was moving a stone off a conveyor belt when it fell on EE's foot.
220250800008M12416Temperature 76 d sunny wind16 mph employee was working in the shop with the door open little to no debris on the ground and a slight dust covering the ground. Employee was tightening bolts on the crusher. The air hose slipped off the fitting
220250800009M11303Employees were moving a divider box with a front-end loader and chains. One of the chains broke and stuck the employee in the arm.
220250800010M10692Employee was pulling hose up on loader and felt pain in left shoulder
220250800011M11253Employee went to move a hose and punctured finger using a wire hanging off of the hose. Employee did not use appropriate PPE 
220250800012M10451Lifting metal off of a forklift, twisted back
220250800013M12876EE was climbing down a ladder while holding jacket and water bottle and fell off the ladder. EE did not have 3 points of contact on the ladder as EE began climbing down. EE reached for the ladder with hand that was holding the jacket, couldn't grasp the ladder, and fell from the ladder.
220250830002M12165Utility operator was cutting a piece of vacuum hose towards EE's body and cut self in the upper abdominal area. Employee received approximate 1.5" long laceration and was taken to the hospital and received 8 staples.
220250830004M12005EE WAS LOOSENING A CUTTER BAR RETAINING BOLT WITH A 36" WRENCH.  THE WRENCH SLIPPED CAUSING EE'S HEAD TO WHIPLASH AS EE CAUGHT SELF.  BACK & NECK PAIN.  CLICKING IN NECK.  NUMBNESS IN LEFT FINGERTIPS.
220250830005M12756The employee sought medical treatment for feeling ill and was misdiagnosed, received treatment, and released from care. The employee returned to work for two days and felt unwell again, returning to the ER on 3/12/25. Further testing confirmed a different illness on 3/16/25.
220250830007M1330703/18/2025 Employee was standing near the Deister screen when the wind blew dirt into the employee's right eye. First Aid measures were provided on site. The employee was seen by a Banner Health clinic on 03/18/2025. Prescription eye drops were prescribed by the physician. The employee did not have any lost time or restrictions.
220250830008M10682Employee was performing maintenance on a fork truck and was injured 
220250830009M12776EE was cleaning under a conveyor belt when EE stood on the bucket of the skid steer EE was operating.  EE began to cut part of the belt and material fell on EE causing EE to lose EE's balance and fell aprox. 24 inches on EE's left side injuring EE's shoulder, left hip and rib.
220250830010M11774Miner slipped as they were getting into the haul truck due to icy conditions. Miner caught themselves from falling and pulled muscles and tendons in their arm and shoulder area.
220250830014M13548Arsonist suspected of setting fire that expanded onto quarry property. Quarry employees did not know about fire until fire department arrived and asked to access back of property. Once fire was discovered on the property, 800 number called. Local responding agencies contained and extinguished the fire. They confirmed they were seeking an arson suspect.
220250830015M12676Arsonist suspected of setting fire that expanded onto quarry property. 911 called. Fire was confirmed to be on quarry property and 800 number was called. Local responding agencies contained and extinguished the fire. They confirmed they were seeking an arson suspect.
220250830016M11413Employee was putting bucket pin on a front end loader when it fell out of the pin boss smashing their left pinky finger against the boom arm.
220250830017M11123Employee was walking on the rail car, slipped and landed on a knee.  03/18/2025 employee had knee repair surgery
220250830021M12395This incident was a first aid that escalated into medication that was prescribed for inflammation and pain on 3/18/25.  The operator was training in a shovel when they fell against a box on the wall hitting their back impacting ribs area. 
220250830023M10281CARPAL TUNNEL IN RIGHT WRIST
220250830024M10482CARPAL TUNNEL SYNDROME BOTH WRIST AND LEFT ELBOW
220250830025M11103IP was washing off cv010 belt after getting grating off of cv10 IP smashed finger on grating that was dropped.
220250830026M10582Employee stepped off a piece of equipment and rolled ankle
220250830027M11363While detrashing the yard, the employee slipped on a mud puddle and fell backwards.  Employee felt pain and stiffness in left hamstring.
220250830028M13518Employee bent to check oil level at the crusher on 3/3/25 when employee started to experience discomfort in lower back. The employee reported the incident, but thought the discomfort would go away. The employee went to the local clinic on Friday 3/21/25. Restrictions; no more than 20lbs Occasionally, no climbing, no twisting, in effect until 4/7/25.
220250840002M11965EE was sweeping and shoveling material off of floor, felt pain in right forearm and elbow. 2/10/2025 was a report only. EE asked to see Dr on 3/17/2025, at which time it became a recordable event.
220250840003M12676EE slipped on a salt rock while pulling power cables to face panel. EE hyper extended left knee. EE was taken to ER for x-rays and full evaluation. EE was diagnosed with knee sprain. Given topical cream for pain and swelling. EE returned to full duty Monday 3/24/25. 
220250840004M11413An operator slipped and fell while exiting the 242D3 skid steer. Employee fell on right side with their right hand taking most of the impact.
220250840005M11484While roof bolting, the chair in the roof bolter collapsed.  Employee reached to stop the movement of the chair and fractured finger on left hand.  
220250840008M11614IW was using a cutting torch. A piece of metal came loose and struck IW right hand causing a laceration. The metal also struck IW right foot causing a contusion.
220250840009M13808Employee was operating a haul truck and was being loaded by the production loader and felt some discomfort in their back, the employee was reassigned to a different loading unit and finished the shift but after leaving the following morning, called their Supervisor and reported that they needed to visit the ER. The restrictions would not allow return to work for the next shift.
220250840010M10762Quality control Van caught fire on the weekend while no one was at job site.
220250840011M11464EE was pulling a ratchet strap over a load of ground support wire. Whan it came over the edge, the employee looked up resulting in a broken tooth.
220250840014M11564Employee was fusing branch saddles on pipe and lifted their head to check on the fuse. When lifting their head they felt a pain and tightness in their neck.
220250840015M13738the affected employee was in the process of hooking up a water hose. While hooking up the hose one cam lock would not fully seat. The affected employee then turned to the left to pick up a rock to use as a hammer to seat the cam, when they stepped to the left their head came into contact with an elevated beam on the front of head. Hard hat was not knocked off their head.
220250840017M11564The employee was removing a rock from the grizzly head pulley at the 551BC101 conveyor belt when another rock fell and smashed employee's left index finger.
220250840019M12856Employee hung a torch on a railing above the employee's head.  The torch fell and hit employee on the right temple causing a small cut by the right eyebrow.  Two (2) stitches were needed.  No restrictions were enforced.  Employee returned to work after medical treatment was performed.
220250840022M11584Employee had a Standard Threshold Shift of greater than 25 db HL on their audiogram from 3-10-2025. Right ear results were 36.3 and the left ear results 31.3.
220250840023M11283Employee had a Standard Threshold Shift of greater than 25 db HL on their audiogram from 3-10-2025. Right ear results were 26.6.
220250850001M11975Haul truck driver got out of truck to track a conveyor belt was using a hammer to hit return roller bracket got EE's hand sucked through return roller. Lost fingernail & scraped up hand was result.
220250850002M11794While adjusting the forks on the 6K forklift EE was pulling slide on a stuck fork that broke free back pinching EE's right ring finger between the fork and the rear support frame.
220250850004M12606EE was climbing a step ladder when EE's foot slipped and EE missed a step. To keep from falling, the EE grabbed on to a piece of machinery to steady themself. EE said that they felt like they may have pulled a muscle. The pain got worse over the next few days.
220250850009M11955Employee was up on 2nd floor of tower one stone plant. Welding on M606 Hazemag when walking tripped over welding leads falling on EE's face into the steel grating. Striking EE's head and shoulder
220250850011M11073EE was removing right boot using a boot jack. As they pulled their leg up, they felt low back and hip pain.
220250850012M13247Employee was on their way to deliver ground support mats to the miners with telehandler. One bundle of mats fell off the forks so the employee stopped to re-load and position the bundle of mats. While doing this the second bundle of mats slid down the forks and pinched the right hand injuring the rt middle and ring finger.
220250850014M13137EE was attempting to clear a dust collector vent line and in the process of doing so they got a fragment of material in eye. Although they were wearing safety glasses the material got into left eye. The material was removed at the clinic and the EE was given an eye patch and placed on restricted duty for 2 days.
220250850019M12035Overcast skies, temperature is 70 degrees, little to no wind, work area clean of debris with a little buildup in the chute. Technician was welding in the chute, lost balance and fell to the screen below.
220250860002M12095Coworker was replacing a cutting edge on a front-end loader. While tightening the new bolts, coworker bent over to move the 1" air impact gun from one bolt to the next and felt a "pop" in EE's right shoulder.
220250860004M11854Employee was cutting a 3" diameter steel pipe.  When pipe was cut free, the material supporting the pipe failed, causing the pipe to swing and struck the employee in the right shoulder.
220250860005M12446EE was operating an articulated haul truck. EE said that a large piece of material was dropped into the bed of the haul truck EE was operating, twice on 3/25/25. EE said the first time caused EE's back to hurt and the second time made it worse.
220250860006M12255EE was dumping in the drop box. As they were placing the cover back on it broke off & hit their little toe on right foot behind the steel toe cover. The contact caused a fracture to the little toe. EE was issued restrictions.
220250860007M13618EE was inspecting #2 drying air compressor. After they inspected the equipment, they stepped back off the concrete pad & their foot missed the lower step. Their foot caught a wood plank which gave way. They stumbled and fell to the ground. They reached back to brace their fall & injured left shoulder. They felt & heard a pop. Employee was issued restrictions.
220250860008M10852The evaporator operator was moving an air tool when they felt a strain in their back.
220250860009M12155Employee was walking out of the office and missed the bottom step on the stairs and had pain in their left calf. They heard a pop sound and had pain while walking. Employee is going to the doctor to get checked out.
220250860010M13788The operator was watering a road with a CAT 621G water pull. The operator was driving approximately 10 miles per hour when they drove into the equipment parking V-ditch. The operator stated that they knew it was there, but didn't notice it due to an optical illusion. The impact bounced them in the seat straining their lower back. The operator was having a hard time breathing.
220250860011M10391Employee was rough loaded in haul truck
220250860012M10351Employee injured by hitting pothole
220250860013M10461Employee injured back prepping floor at shovel
220250860014M10361Employee injured ankle loading tools
220250860015M11874EMPLOYEE WAS PULLING ON THE V BELTS AND MISUNDERSTOOD DIRECTION FROM SUPERVISOR.  EMPLOYEE'S HAND WAS IN HARMS WAY WHEN BELT ENERGIZED.  MIDDLE AND RING FINGERS OF RIGHT HAND WERE SEVERED
220250870001M11834One of the electrical systems failed on our primary escapeway shaft. There are redundant systems in place, the shaft was never out of operation. The hotline was called as a courtesy. 
220250870005M12887Employee was ascending an access ladder to the right-hand side of a 992K Cat loader to check engine fluid levels. Their left hand slipped on the wet hand hold on the ladder, they used their right arm to correct the fall. In the process they aggravated a previous non work shoulder injury.
220250870009M10983EE was bent over pulling a wheel chock to remove it from a truck tire and felt pain in lower back.
220250870010M11494Employee was reaching for tools next to a pallet of VSI shoes and one of the shoes fell off of the pallet and struck the top Rt hand of the employee.
220250870011M11003EMPLOYEE WAS CUTTING THICK RUBBER WHEN THE BLADE OF THE KNIFE SLIPPED AND CUT EMPLOYEE'S RIGHT SHIN.
220250900001M13247On 1/26/25, EE & 2 co-workers were at the worksite to install a conveyor belt. The conveyor belt was lifted from the back end to be suspended aprox. 20 ft in the air & the front was on the ground. EE walked up the conveyor belt while it was suspended to take some measurements. EE lost balance & fell around aprox. 10:00 AM.
220250900005M11604Employee was changing a screen panel on the #2 screen, while picking up the screen panel, EE was cut by a sharp piece of metal on EE's right hand middle finger.
220250900008M11574Employee was walking in a work area where pallets of rock are weighed when EE twisted EE's ankle on a rock. EE then fell backwards landing on EE's tail bone.
220250900009M13047EE was assisting other Mechanics lift one leg of the Finish Mill 1 duplex compressor north compressor with a crowbar so shims could be placed under the leg. While lifting the motor, the end of the crowbar broke and flung back against employee causing EE to fall and twist EE's right ankle in the process.
220250900011M11373Employee was cutting a piece of belting for a skirt rubber with a razor knife and slipped and cut EE's left thumb requiring two stitches.
220250900012M12255EMPLOYEE WAS TAKING BOLTS OUT OF THE BOTTOM OF THE TROMMEL SCREEN. EMPLOYEE HAD TO LAY DOWN WITH THE 3/4" IMPACT WHICH WAS IN RIGHT HAND AND SLIPPED OFF OF BOLT WHICH EXTENDED RIGHT ARM AND HEARD A POP IN EE'S RIGHT SHOULDER.
220250900013M12957The employee was removing a wall filter down off of the all-thread and a section of the wire mesh that wraps the outside of the filter caught the left hand of the employee. This caused a laceration to the employees left thumb pad. The employee was not wearing gloves at the time of the incident.
220250900014M12726The worker was reinstalling a spring onto a tension pulley system. During this process the worker was holding the pulley up with EE's right hand and installing a plate with EE's left hand, when the pulley slipped from EE's right hand and made contact with EE's left thumb.
220250900015M11313Employee was descending the steps of the loader and slipped and landed wrong twisting their right knee. Possible ACL or MCL damage.
220250900016M10451CARPAL TUNNEL SYNDROME BOTH WRISTS AND ELBOWS
220250900019M11834An employee was using the V-belts to rotate a pump by hand while troubleshooting. The employee's fingertip got pinched between the V-belts and the sheave, causing a small fracture.   
220250900020M11864Employee was conducting maintenance activities and was using a wrench and felt a pop in left wrist. Was seen at Occupational Medical Center where they were given a brace for their wrist.
220250900023M11754Employee was doing housekeeping duties as assigned and was cutting down a small tree when they lost footing and slipped and fell into railing and hit their ribs on right side.
220250900024M13378A customer truck driver stopped their truck at the entrance of the property. They got out of the truck and went to troubleshoot a vibrating noise. Then they were just behind the passenger side front wheel, the truck began to roll backwards. The truck rolled over the driver's foot and came to a stop on top of their foot, breaking a toe.
220250900034M11884Employee parked a skid steer loader, when employee was getting out of skid steer and stepping down, employee hung left foot in between the bucket frame and step for dismounting skid steer.
220250900038M10973Running loader, feeding plant bouncing in loader repeatedly. Sought treatment for claim on 3/28. 
220250900040M10752Was shoveling waste and turned and hit right hand on side of conveyor frame
220250900041M11874IE was cutting open Supersack of material, IE rested supersack on guard & cut open bag w/ knife, plastic liner inside SS slid out & pinched IE's right hand between liner and filter grate.
220250910003M13608Employee was descending from the Superior Guardian Tandem 7203 Screen Plant (Unit #273) using the ladder when EE felt a large pain in EE's left knee and it locked up. EE continued working until around 10 a.m. when EE decided EE needed to have it checked out. Per the doctor EE sprained EE's left knee from planting wrong while descending from the Screen Plant.
220250910004M12546EE reported left wrist pain from grabbing handrail during a near slip and fall. EE states that the area is very wet and slippery. EE describes popping sensation in left wrist at time of incident, and states that the pain has increased since the incident.
220250910006M12887EE reported left knee pain after working in the dragline tub replacing tub paper. EE states that the knee was hurting too bad to straighten all the way and that it hurts too much to bear weight on it. Upon presentation in clinic, there was notable swelling to the front of the left knee. 
220250910007M12897Employee was using an air chisel to remove a broken bolt and a piece of shrapnel came out from the area of work and got lodged into the worker's left forearm about an inch deep. The air tool was inspected by a service company and it was determined that debris did not come out of the tool.
220250910010M12826Upon arrival at the mine site a brush fire was located on the back side of the property between the pit and rail line. This area is away from the plant and consequently did not expose miners to the hazard. 800 number called. Fire extinguished and monitored by local fire department.
220250910013M11323Survey supervisor was opening the door to pickup when their pinky locked up and they jammed it on the door when grabbing the handle.
220250910014M10341Employee cut hand with pocketknife
220250910018M13468Operator was scooping GAB from the pile when the top of the pile sloughed off and filled the bucket, causing the loader to lose balance and tip forward.  The operator quickly dropped the bucket, causing the rear of the loader to fall back to the ground and jar the driver.  The driver reported experiencing soreness in their back after the event.
220250920003M11403Operator was opening a 2-inch valve to catch sample when EE swung the mull and miss the valve handle and hit EE's right little (5th) finger.
220250920005M12556Employee states rust entered EE's right eye while using a chain hoist at the surface wash plant. A piece of rust dislodged from the steel beam the hoist was attached to. The incident happened on 3/30/2025 but was not reported to management till 3/31/2025.
220250920007M13849A Mine Production employee was operating bolter drilling a 14 foot drill hole when the steel became stuck. EE placed EE's left hand on the drill steel to apply outward force to free the steel and reached for what EE thought was the lowering lever and inadvertently activated the rotation lever. In doing so EEs hand rotated with the drill steel causing a dislocated left pinky finger.
220250920010M11854Employee was exposed to caustic fluid during clearing of a plug and cleaning of the area to their feet when their boots and socks became saturated with the fluid causing chemical burns.
220250920014M13768Was going to help another employee lift an oxygen bottle into the back of a service truck and felt a pull in EE's abdomen. Reported to supervisor and denied observation. Stated EE would let them know if the condition worsens. Came to supervisor at a later date and requested to be seen by the doctor. Doctor placed on restrictions of not lifting more than 25 pounds for 7days.
220250920015M13257Hurt ankle on 2/12/25. Did not report injury till after EE went to ortho on 2/17/25. Claimed to step off haul truck and foot slipped and twisted ankle a bit 5 days later. Ortho found that there was a fracture in the foot. After our investigation EE was put on workmen comp for 24 days until EE was released back to full duty.
220250920017M11814The team member was assisting with the installation of a new Dredge bucket when their left index finger became caught in-between a becket and the work platform causing a laceration.
220250920019M12616EMPLOYEE WAS OPERATING A HAUL TRUCK WHEN THEY FELT SOMETHING WAS OFF WITH THE TRUCK. THEY PULLED OFF THE MAIN ROAD AND CHECKED THE SWAY BARS AND WAS GETTING BACK IN THE TRUCK WHEN A PIECE OF LOOSE ROCK FELL AND GLANCED OFF HARD HAT HITTING RIGHT SHOULDER BLADE.
220250920020M11313Employee opened a toolbox drawer when it fell down onto their right thumb and tool box door causing a fracture to their right thumb
220250920021M11644IW has had slowly progressing discomfort in right writs/forearm/elbow. Twisting motions seem to bring it on, IW twists sample jar caps on and off frequently in lab.
220250920022M13347EE reports hydraulic ladder pinched right leg between the handrail and the folding ladder. EE was assisting a third-party mechanic while the mechanic was troubleshooting the hydraulic ladder. Contacted WorkCare and after a few days of self-care, the EE was scheduled for a CV. EE was diagnosed with a torn ligament in right calf area.
220250920024M12666Ee was removing paste pipe. While removing the chain, the pipe moved, pinching the ee's hand between the chain and the pipe. Seen at Health for a 4 inch laceration to the hand, referred to hand surgeon. Ee released with restrictions site can offer modified duty for.
220250920025M13628Ee felt pain on left side of groin after lifting an oxygen bottle on a cutting torch into the back of a pickup truck. Seen at Health, referred to ER for confirmation of hernia. Ultrasound positive for hernia. Referred for surgery. Ee released with restrictions site can offer modified duty for, then termed for cause unrelated to the incident effective 03/31/25.
220250920026M11995EE was tightening a bolt when the wrench slipped and smashed right ring finger. EE was seen at the ER, diagnosed with a tuft fracture. Seen at Health the following day and released to return to work.
220250920027M10882The miner was picking up a broken ear from the crusher and cut their finger on the edge.
220250920030M11293Employee alleges was driving a haul truck and hit a bump and as employee was grinding teeth a tooth came out of employee's mouth.
220250920033M13147EMPLEADO INFORMA QUE ESTABA CERRANDO EL BONETE DEL BUGGY, RESBALO Y SE CAYO.   CAYO DEL LADO DERECHO DE SU CUERPO PRESENTANDO DOLORES FUERTES EN EL AREA DEL COSTADO.  EMPLOYEE REPORTS WAS CLOSING THE BUGGY'S BONNET, SLIPPED AND FELL. EMPLOYEE FELL ON THE RIGHT SIDE OF BODY PRESENTING STRONG PAIN IN THE SIDE AREA.
220250920036M11744A tree fell on mine property due to high wind, causing it to fall on a powerline, causing it to arc. This resulted in two brush fires to start burning on the mine property.  
220250920037M12195EE was climbing into a manlift and got tangled up in the twin leg lanyard causing EE to fall and sprained right ankle in the process. EE was treated and written out of work the following day making this MSHA reportable.
220250920038M12766A Mine Production employee was in the process of bolting at 8 BMR.  Employee noticed a bad top in the entry and exited the cab of the bolter to bar down the hazard.  As employee barred down, the arch behind the employee came loose and fell and struck the employee from behind.
220250920039M11433Employee's hand was pinched between a plate of steel and a block of wood resulting in a laceration approximately 2.5 cm that required stitches.
220250930002M11303The employee was loading out dirt from a ramp in the pit, when a large chunk of dirt fell into the bucket bouncing the loader.    
220250930003M10983While using a bench grinder with only safety glasses on an employee got metal debris in their eye.
220250930004M11494Employee was exiting the drill and when stepping down off the boarding ladder employee rolled right ankle. Sprained ankle. 3 days of restricted duty.
220250940002M11143EE was rushing to get a task completed and slipped hitting left hand on a grate in the floor causing a laceration.
220250940003M12776Throwing dust collector bags into the rear of the suck truck the employee felt a pop in right shoulder. Employee started treatment with our online Teladoc with no change in pain or discomfort. Employee was advised to seek medical attention with a clinic. Right shoulder strain.
220250940004M12526While trying to install piping for heat exchanger, the pipe shifted and the individual had hand in the proximity of the pipe. The employee's left, ring finger suffered avulsion at the tip from the pipe and pinch point of a piece of support steel/gusset
220250940006M10762Employee was torqueing studs at Finish Mill.  Employee dropped nut on foot. 
220250940009M11624While attempting to change the blade on a reciprocating saw, the employee's left index finger and thumb were pinched.  The resulting laceration required stitches.
220250940011M11343Changing a drill bit, employee pinched finger between bushing and lip on drill mast requiring sutures on EE's right middle finger tip.
220250940013M11233Employee was operating Jackleg when the gooseneck came apart and struck the employees left elbow resulting in a contusion. 
220250940014M10712Employee tripped over a rock and fell on right arm, dislocated shoulder
220250940015M11203The operator was adjusting the lime drag when they pinched a finger, resulting in a laceration that required 11 sutures.
220250940016M13077While removing the wear caps on a loader bucket, they struck the cap with a hammer which caused a metal fragment to fly off and embed in this left hand between the thumb and index fingers through a leather glove and the embedded metal had to be surgically removed. First missed shift occurred on 04/02/2025.
220250940017M12005Mine maintenance employee walked into Lube Truck Chock Holder on front of truck striking with hard hat. This caused bruising to face, nose, and a chipped tooth. Employee returned to work next shift.  
220250940018M10973Employee was lifting an equipment part out of a storage bin and felt a pull in their lower back. 
220250940019M11574While using a hand grinder to cut a hinge, tha hand grinder kicked out striking the EE on the left knee causing a laceration. the laceration required sutures
220250940021M11223Removing sheave from electric motor, while trying to pull sheave off, C-clamp slipped smashing employee's Rt middle finger
220250940022M12416Employee was tightening a bolt on a tail pulley and once EE was done, EE noticed mild pain in right shoulder. Incident was not reported to EE's supervisor until the following week. Diagnosed with right shoulder strain and given restrictions.
220250940025M12626Management was made aware at 5:00 am that the vertical hoist was being taken out of service. MSHA was notified at 5:03 am. It was determined a bolt had come out of the linkage with the bottom landing door. Repairs were made and put back in service at 10:00 am.  
220250940027M11293EE took off the top panel (lid) to EQ 215 screw auger. EE leaned the lid up against the wall. The lid fell and hit EE's shoulder.
220250940028M11844Crusher operator received a deep laceration from a metal plate on their left, inside forearm while routine cleaning. Operator was transported by EMTs to hospital and received stitches.
220250940029M13808Contractors were in the clinker passenger elevator, the car stopped abruptly halfway down, entrapping them. They contacted their manager at 11:37 to alert them that they were stuck. At 12:07, the Safety Manager called MSHA to report an entrapment. Plant electricians were called to reset the car, they were successful and were able to get them to the ground and extracted safely. 
220250970001M13388Employee worked on a loader bucket along with other employees where welding and grinding was required. The claimed when they got home the effect of the welding flash caused their eyes to become irritated to the point they went to the emergency room that night. Note: the employee did not know it was charged to WC until they got the bill.
220250970002M10722The employee cut their hand on a hose clamp while hosing down conveyors.
220250970005M10512Employee injured foot trying to unhitch light plant
220250970007M12796Employee was operating a drill and felt severe pain in EE's back on the left side.  Did not do anything out of the ordinary no heavy lifting no pulling did EE's pre-shift and started drilling.  Was on a slight incline with the drill.  No real reason concrete contributing factor.
220250970008M13538Surface employee tripped/fell near rail yard and suffered minor abrasions/contusions to left hand, right knee/thigh & right chest. Medical attention was offered and declined. 3 days later (3/28/25), employee requested to be evaluated and was diagnosed with abrasions/contusion to right knee, left hand & right chest wall. *Became reportable on 3/28/25**
220250970009M11083employee fell through ladder way.  Safety hatch was not used.  Upon investigation the hatch would not close.
220250970012M13788During the process of moving railcars an experienced employee needed to maneuver a rail switch to change the track. The shaft of the rail switch was not easy to maneuver, so the employee applied additional force by stepping on the switch. The switch went into place unexpectedly and the employee felt/heard a "pop" in left calf. The Employee was given a prescription medication.
220250970016M13638At 8:30 am the operator called supervision to report that at approximately 5:40 am they were pulling out the right-side fuel hose and after pulling out 10 feet of hose the reel stopped. At that time the employee stated they felt and heard a pop in their right elbow. A few hours later the employee felt more pain in their right elbow they called for supervision. 
220250970020M12165EE was splitting stone, and the teeth were too high on the bucket of the excavator. The stone fractured and folded landing on EE's ankle, between two stones.  EE was using a Chicago pneumatic jack hammer model CP4123
220250970022M12205Employee was using a pin from a clevis as a hammer to loosen tow rope from clevis. Employee went to an ER and received four stitches in left middle finger and medical glue on left ring finger. X-rays showed no fractures.
220250970025M11704Employee was stripping with trac hoe and wall caved in on trac hoe, busting window out, employee's knee was busted along with chin and broken glass cut up employee's hand
220250970026M12796Hoist tripped power due to incoming power interruption (Cleco) as it was travelling with personnel to 1500 ft level.  The brakes engaged, suddenly stopping the skip due to the power trip.  Drives were reset and personnel brought to surface. Lost time days started March 31, 2025.
220250980002M10662Operator was burned by hot coolant after removing the radiator cap
220250980004M10842Fire burned the tube belt and caused a galley to fall. Called in immediately to MSHA
220250980005M11043Cloudy 38 degrees light rain, employee tripped on a forklift fork and fell breaking a bone in left hand.
220250980006M12516A mine employee was ascending the line 100 Rotex stairs, when employee's right foot got caught between the steps which caused employee to fall and strike mouth against a step. Injury resulted in four sutures and caused a chipped central incisor tooth.
220250990002M12496EE was cutting a bolt off of the fresh water pump when EE's grinder got in a bind & kicked back cutting EE on the inside of the left leg below the knee. EE was taken to the hospital in Altus where EE received stitches in the left leg below the knee.
220250990003M12636employee walked down to service truck to get some magnets off back and when EE did EE dropped one and reached down to pick up when EE raised back up EE hit a piece of metal that was hanging from truck and it busted EE's head causing EE to have 2 staples to be in.
220250990004M10622Employee was doing quality control work and tweaked EE's knee.
220250990005M11884Driver Had a Diabetic episode and fell off the top step of EE's truck. Causing EE to become unconscious and stopped breathing temporarily and cpr was giving. And was taken to the hospital.
220250990009M12696Employee was attempting to hang hoses onto wall racks when the base of ladder slipped out from under EE. This resulted in employee falling from a height of 12' causing a broken femur and broken hand all on the left side of body. EMS was called to transport to hospital.
220250990010M10702Employee experiencing lower back pain after operating the Pit loader. 
220250990011M10963Employee was walking on ground surface by conveyor when EE slipped and fell twisting left ankle.
220250990013M10862Miner was climbing into a Dozer when they felt a sharp pain in their right groin area.
220250990015M13758The 1st shift hoistman had an issue with the hoist the afternoon of 4/8. Upon investigation it appeared that there was possibly something wrong with one of the brake valves. After troubleshooting, it was noticed that the brake arm linear position transducer was damaged. The team is currently investigating alternative means of control until a new transducer can be acquired.
220250990018M13468Employee was cutting a piece of belting with an oscillating tool. After completing the task they sat it down on the ground. While walking around to roll up belting they accidentally stepped on the battery portion of the tool and it flipped up and cut the back part of their calf. Supervisor took them to the hospital and they received 7 stitches.
220250990019M10872Koepe lower cage position switch and cable shorted causing the Koepe to be inoperable. 
220250990021M10612The miner was cutting a belt and accidentally cut left wrist.
220250990023M12325Cat Operator was fueling Cat D9 Dozer at the Heavy Equipment Yard. Operator fell from the dozer and landed on the driver's side blade tilt cylinder. As a result, operator broke three left ribs and bruising to the left side of body. 
220250990024M12746Employee was un-coupling a trailer mounted pressure washer from a pick-up truck hitch. The trailer tongue jack failed resulting in the tongue falling to the ground and striking the employee in the dorsal region of the right foot. This resulted in fracture to the right foot.
220251000001M12796EE accessed elevator platform using a manlift in order to perform task. Ladder access point door was left open to accommodate ladder access to platform. EE did not close ladder access door before proceeding. EE stepped into the open ladder access door, falling to below platform.
220251000003M12686A miner was lifting part of a cut up 55-gallon metal drum used as an oil catch from the ground to place it in the back of a service truck. After the shift ended, the miner notified EE's supervisor that EE had hurt EE's arm while lifting the oil catch earlier that day.
220251000004M11323Miner was working on a pipe fitting laying on the ground. Miner attempted to step over the fitting and tripped and fell on EE's arm.
220251000006M11413The mirror of a customer's truck contacted employee's hand while they were providing direction from portable steps, causing a hand contusion.
220251000007M13117On 3/24/25 at approximately 11:37 AM a mayday was initiated for an employee who passed out. CPR was initiated and the employee was shocked with an AED multiple times. WVFD arrived on scene and took over CPR but was unable to revive the employee. The scene was secured and legal notifications were promptly made.
220251000008M13157EE reports tripping while they were going into the locker room to get equipment for the day. EE reports pain in  left elbow and shoulder. Seen at clinic and referred for orthopedic consult. At orthopedic consult on 4/3/25, diagnosis of acute proximal radius fracture confirmed and employee put off work pending MRI.
220251000012M11013EE stepped on grating with accumulated mud on soles of their boots resulting in spraining left ankle.
220251010003M10652Employee got EE's arm caught in a troughing roller on a conveyor.
220251010004M12125Employee was leveling and digging trench on the leach pad and the tops of the hands turned red and were dry and appeared to be a sunburn. After being seen EE had a reaction to the process solutions on EE's hands.
220251010005M10492Employee injured back trying to get a bar unstuck
220251010006M10341Employee hurt forearm lifting pipe
220251010007M12836An employee was standing on a 17 inch two step working platform performing maintenance work.  As EE applied force to the box end wrench, the wrench slipped causing EE to lose balance and fall.  In falling, EE's right knee contacted a ceramic liner, resulting in a fractured knee cap.
220251010008M12566EL EMPLEADO ESTABA MIDIENDO UNA PIEZA VINIERON UNAS ABEJAS Y EL PARA ESQUIVARLAS SALIO CORRIENDO PERDIO EL BALANCE Y SE CAYO AL SUELO THE EMPLOYEE WAS MEASURING A PIECE, SOME BEES CAME AND EE RAN AWAY TO AVOID THEM, LOST EE'S BALANCE AND FELL TO THE GROUND
220251010009M12656Ee walking to place mill pan at mill press and EE tripped on rubber mat, falling to left knee on grating. Reported incident and practiced self-care. On 3/31 EE sought treatment and filed a workers' comp claim. Released to full duty and referred to physical therapy.
220251010010M11804The employee reports EE contacted EE's head while entering the rail mantrip.  The contact jarred EE's neck causing pain.  The employee was seen by a doctor and issued restrictions.
220251010012M12546EE was unloading truck. As they were walking, a foot caught on grating, twisting their ankle. Seen at clinic, diagnosed with ankle sprain, x-rays positive for fracture, referred to orthopedics. Released to sedentary work, site is providing modified duty.
220251010014M11754When exiting the mechanic's shop, they rolled an ankle when they stepped from the concrete shop floor onto the gravel parking lot, resulting in a closed fracture on left foot.
220251010015M10832As employee was stepping up and transferring their weight, they rolled their ankle.
220251010016M13568EE reports that while driving haul truck, they hit a bump/pothole. EE reports feeling a pop in their neck, and then pain down left arm and into their back. Seen at clinic, diagnosed with a muscle strain, and released to full duty. On follow-up on 3/31, EE was put on restrictions site cannot offer modified duty under, making this reportable for lost time.
220251010017M10942Fire at salvage yard, cardboard bailer/materials area - cause of fire still being investigated
220251010018M10391Employee rolled ankle coming down steps
220251010019M12155While installing emergency stop gate the gusset caught on the flange and the assembly came in contact with employee's left wrist. Originally thought to be a contusion but after MRI it was determined to be a fracture
220251010022M12165Employees were trying to lower the gates inside the rolling rock box. To lower the gate, 15 bolts needed to be removed. When the last bolt was removed, the gate slipped and landed on the foot of one of the employees.
220251010023M12516EE stepped on a chunk of salt and slipped, strained left knee. Went to DR 3/21/25 and 3/28/25 no work restrictions. Returned to DR 4/7/25 for MRI. Torn meniscus identified 4/9/25 after MRI was reviewed by DR. EE will be sent to Ortho Knee Specialist. 
220251010024M12746The employee was using a shovel to try and get a rock out of the #1 conveyor belt scraper when EE hit hand on the conveyor. The next day the hand started swelling up so EE went to see a doctor. They told EE EE fractured the thumb and put EE on restricted duty for two weeks.
220251010027M11223Operator reported that operator's right shoulder was hurting from beating on tanks tonight and operator couldn't lift arm.
220251010029M12065Miner was loading a round when a chunk came down and struck Miner on the right side of Miner's head and shoulder area. Miner was brought to surface and taken to the hospital with an ambulance and helicopter
220251010030M12836Employee was attempting to blow off a turntable in the packhouse between the grate using an air lance. As the employee was pulling the air lance from the grate they felt a sharp pain in the right shoulder. The employee received medical attention, and been place on restricted duties.
220251010031M11093Employee's finger was stuck on a table while operating machinery and was struck and smashed needing stitches.
220251040002M11554Employee was moving metal wear bars at the Gyro crusher. While moving the wear bars, EE smashed EE's left-hand ring finger against the stairs and wear bar.
220251040003M11514IP was maneuvering a small electrical motor for alignment when tool slipped and motor landed on EE's left hand index finger causing superficial damage.
220251040005M12917Employee was assisting another employee install a solenoid on a water truck when EE reached up to install bolt and felt EE's right shoulder dislocate. EE was taken to the ER, taken off work and referred to an orthopedic specialist. CURRENTLY ONGOING. (has dislocated 3 times prior elsewhere)
220251040006M11634Employee was trouble shooting a station on the sand classifier when the lid of the station fell on EE's right causing the employee to experience pain in EE's hand.
220251040010M10872WHILE MOVING A CRUSHER LINER, RIGGING SLIPPED & CRUSHED EMPLOYEE LEFT FIRST & 2ND  TOES
220251040011M12636Pin used to anchor saw track to the ground was stuck in a drill hole. Miner was using a sledge hammer to dislodge the pin when the hammer glanced the pin, bouncing off, and striking the left small finger. Fracturing the tip of the finger and causing a laceration.
220251040014M11323The employee fell 32 inches from the tracks of a portable crusher, landing on their left side, fracturing their left distal fibula. 
220251040015M13007EE was closing up a rail car by prying with a bar.  While doing this, EE felt a sharp pain in EE's left side. EE then noticed belly button started to swell twice the size. It is bright red and hard to touch. EE does not have a lot of pain in this area. EE will finish the shift out on the locomotive.
220251040019M11323Employee was tightening lugs on tire when employee set impact gun down and smashed left pinky finger between rim of tire and impact.
220251050004M12476Employee was cleaning out a toolbox in the shop. A utility knife with the blade open was in the bottom which EE cut EE's finger on. EE was taken to Concentra walk-in clinic where they medically glued the cut closed. No impairment and no lost time.
220251050005M12696Employee was unloading wooden pallets from F-150 truck bed. Employee stepped back with pallet in hands and stepped on another pallet causing EE to lose EE's balance and fall backwards catching self with EE's R hand causing a fracture to EE's R forearm requiring a cast.
220251050006M13017Employee was using 1 inch impact gun on bolt under truck. Bolt was not coming off causing the employee to adjust position. As employee was adjusting the impact gun it bounced back hitting employees face causing a small chip top of *R* tooth. 4/10/25 EE did elect to repair tooth, dental work completed
220251050008M11484A bolt from the cheek plate in the primary jaw crusher dislodged and struck the employee in the mouth, causing a laceration to lip and broken teeth.
220251050010M11373Victim was removing sand from the sand wall with a Volvo L120E loader and the wall sloughed off covering the loader and victim with sand.
220251050011M12596Employee was attempting to retrieve tools from the back of employee's pickup and cut right hand on an exposed, sharp, piece of metal located at the top of the tailgate. Employee received a cut to the top of right hand above the thumb which required 5 sutures.
220251050012M10522Crushing injury to thumb that resulted in a fracture
220251050013M12586Employee reports was changing steering valve assembly (approx 50 lbs).  Set unit on mucker hood to continue work.  It fell off the hood contacting employee's right pointer finger resting on mucker frame, causing a blow out type injury and fracturing the tip.
220251060001M12295While stepping out of pick-up employee slipped on small frozen puddle.  Employee fell congtacting pick-up causing fracture to left forearm.  Employee was given light duty restrictions and returned to work on next scheduled shift.
220251060007M11454Miner was unplugging a chute in the secondary finishing plant when a rock fell and hit the top of EE's right hand, causing swelling and bruising.
220251060008M10762Employee was walking down a slope, slipped on gravel and strained left knee.
220251060010M13207Miner was grinding off slag from a piece of angle iron, when the wind kicked up and changed direction and blew debri up under EE's safety shield and glasses, causing a piece of shard to get into EE's left eye. Eye was flushed and taken to Mercy health care. EE's eye was flushed at facility and given eyedrop medication.
220251060011M12005Closing a shipping container door and pinched left middle finger in door. Declined medical attention initially. Finger still sore 4/15/25 and went to get checked. No fracture, sprain/strain/contusion.
220251060012M11203EE was moving a jumbo drill steel and pinched left ring finger between the steel and the metal box on the loader fender.
220251060013M10632Employee rolled ankle on rock - injury became reportable 4/1/25
220251060014M10592Employee felt pop in back - injury became reportable 4/1/25
220251060015M13828Miner was mucking into a muck bay with a 2-Yard LHD. They had a full bucket and when attempting to dump it they got on uneven ground and as they raised the bucket the loader tipped over onto the right side. After it tipped, oil and fuel began to leak onto hot components of the exhaust and possibly the turbo which caused the fluids to ignite, resulting in the loader catching fire.
220251060020M11373Electrician was stripping wire with a box knife, when the electrician pulled the wire the knife caught pinky finger requiring 3 stitches.
220251060021M12416Employee was using a jig to install a pin in a loader. The jig has a nut at the end of threaded rod. The jig and pin tipped and the pin slid down the threaded rod and pinched employee's left pinky finger against the nut causing a laceration.
220251060022M12937Sandbagger was assisting with loading bags, and a bag fell off a pallet on the conveyor rollers. Employee made sure the conveyor was shut off and then stepped on the roller to adjust the bag. As the employee was lifting the bag back onto the pallet, they felt discomfort in their right groin. 
220251060027M10832Employee works at a natural stone quarry in Jarrell, Texas. No conditions reported.
220251060028M11073The maintenance employee was moving a heavy steel saddle piece on a work table when a back twinge was felt.
220251070001M10562Operator fell down a flight of steps and broke left arm.
220251070002M10772Employee suffered a laceration to EE's left forearm by a moving machine part.
220251070004M12716EE was fueling EE's loader and when EE finished EE went to lower the rubber cover over the fuel cap. As EE reached for the cover EE jammed EE's left thumb on a bracket EE didn't see. MRI reveals left thumb tendon tear. Tendon transfer surgery performed on April 11, 2025.
220251070005M11854while sawing the saw kicked back and inflicted lacerations to employee's face, EE received stitches. The kick back safety function worked and shut the saw off preventing further injury.
220251070006M11644While the employee was stepping off of a platform, stepped down with left leg and felt a pop in the right knee. On 4-7-25 Injury became reportable due to injection.
220251070009M13177EE was operating an electric power pack to remove the roll spring bolts from the roll crusher. EE was using a bolt and a ram to press the bigger bolt free. Once the EE relieved the pressure off the ram the bolt fell and struck the employee's right hand and pinky finger. The EE was wearing gloves during the incident.
220251070011M13849Individual attempted to lift a 5-6 ft. long chunk of I-beam (weighing approximately 150 lbs.) and toss it over the handrail of an elevated screen deck to the ground below. The I-beam shifted and pinched their right thumb between the beam and handrail. Individual complained of extreme pain and was transported to Urgent Care where an X-Ray discovered a broken bone in the right thumb.
220251070014M12566Employee stepped on a concrete floor scraper causing the wooden handle striking their thumb on 4/4/2025, medical treatment was sought later on 4/15/2025 and they were diagnosed with a strain to the thumb and was placed on restrictions and physical therapy.
220251070017M13297employee was stepping off machine and stepped wrong on the first step starting from the top, they slipped and fell on their back. Other employees helped them get up, they did get the wind knocked out of them, but felt ok. Their supervisor did ask them if they wanted to go to the emergency room and they denied medical attention.
220251070018M10602Employee was working on an electrical unit was electrocuted.
220251070019M10522Employee was working on the jaw and the cone crusher
220251070020M10822Broken Index finger on the right hand, as well as 2 stiches in the middle knuckle.
220251070021M12816While attempting to drill through a steel plate, drill slipped from plate, landing between member`s index finger and thumb. Drill entered approximately 1/4" into the skin. Drill bit was dull, requiring excessive downward force to be applied in order to complete drilling operation.
220251070023M13137The mechanic was climbing out of a small man door after making repairs to the chute when the angle grinder they were using inadvertently turned on, cutting the employee's arm.  The employee was taken to the hospital for treatment and returned to work today.  Installing another door for safer access to the chute.
220251070024M10562A roof fall occurred at a brow in L13/C74 intersection. 
220251070025M13648Employee was descending the MROT storeroom stairs carrying boxes. Once EE got to the bottom of the staircase, started walking to leave storeroom, and tripped over pallet that was in walkway causing EE to fall on EE's arms/shoulder. Employee had an MRI that showed a broken bone in the shoulder as well as a torn labrum after follow-up with orthopedic on 4/17/2025.
220251080001M10892While walking towards the wrapping station, the employee unexpectedly twisted EE's ankle.
220251080002M11253Employee alleges EE was cutting top of belt on a conveyor with a knife and the knife slipped and cut EE's left forearm/wrist.
220251080003M11794Employee was climbing down some steps, and when EE stepped off EE twisted EE's left ankle.  EE went to a prompt care facility, then was sent for x-rays.  EE broke EE's left ankle.
220251080004M10963EE was hosing off pad under feeder when a rock fell out of a hole and struck EE in the shoulder.
220251080005M12486Driver was offloading at the Vertical when the line became plugged. EE shut down the air and went to work the plug. The cam lock came loose, and lime blew into EE's face. Driver was wearing goggles.  Employee was prescribed medication for EE's eye.
220251080006M10602planning and communication issues contributed to the injury.
220251080007M11644After shoveling out the 100 mesh pit employee slid into the pit and landed on their right knee. This jarred their back causing pain that showed up the next morning.
220251080009M13788EE(1) and EE(2) were drilling holes in rubber to attach to the scalping screen. EE(2) was drilling while injured EE(1) was holding the rubber. Another EE(3) was just outside of scalping screen. EE(3) could have been used by EE(2) and EE(1) to communicate before drilling. This resulted in EE(1) getting their right palm injured by the drill. EE(1) got three heavy duty stitches.
220251080010M12536EE reported reaching up and pulling bag of rags weighing approximately 25 pounds and felt pain in shoulder. Seen at clinic, diagnosed with strain, released with restrictions. After medical and factual investigation, workers' comp accepted claim on 4/17.
220251080012M10752EE felt pain in back and was diagosed with chronic degenerative condition. 
220251080013M13287While Kinross employees were traveling from Tok to the Manh Choh mine site, the crew van in use lost oil pressure and was turned off. A fire was identified in the engine compartment. All employees exited the vehicle without injury and tried to extinguish the fire with two handheld 5# fire extinguishers but were not successful.
220251080014M10822Employee was operating a haul truck and was jarred while being loaded by a shovel.
220251080015M12115EE was taking a small boulder off of a locked-out conveyor. EE pinched the tip of right ring finger between the rock and the conveyor structure when removing the boulder. Stitches were needed for EE's fingertip.
220251110003M12726Employee was clearing blockage from a closed conveyor belt gate; employee attempted to clear blockage with hands, moving conveyor belt moved the blockage while employee had hand on it and hand became wedged between belt and blockage causing injury to fingers on left hand.
220251110004M13067while fabricating a new scraper for the south dock stinger EE over reached while holding the scraper in place. EE went to set the bolt and felt a burning sensation in EE's right elbow. EE was taken to urgent care for evaluation. EE was placed in a sling and has a restriction of no usage of EE's right arm.
220251110006M12015While repairing a damaged trunion tire, the employee needed to trim a piece of rubber in order to get the puller installed.  The box knife being used slipped lacerating the employee's left ring finger.
220251110007M12265Issue not immediately reportable, however NGM did report as ee was found unconscious in EE's truck at end of shift. Ee transported to ER, diagnosed with a non-occupational seizure, and released to full duty effective 04/12/25.
220251110013M11744Employee was welding at the Plant #1 Gyro and while doing so a piece of "slag" burned through EE's pants and went into EE's left boot and burned the bottom of EE's left foot.
220251110014M12696Scraping / cleaning hydrator product chute / duct.  After initially seeing Occupational Medicine department, with no pain not resolving, employee was referred to an MRI and saw an Orthopedic surgeon on 4/14/25 and was put on work restrictions and scheduled for surgery.
220251110016M13538Employee was entering Volvo haul truck and felt a pop in their right knee on 3/12. Employee informed operator on 3/25 of the injury. Employee was seen by company doctor on 3/27 and released with no restrictions. Restrictions were instituted after employee consulted with their personal doctor and had a follow-up exam with the company physician on 4/10.
220251110018M12746While moving/stacking a piece of rock, the tip of EE's little finger was pinched/smashed. Resulting in the skin, nailbed and underlying tissue to be removed. EE was taken to hospital, referred Orthopedics. 4/10/25. Remission amputation performed on the tip of little finger.
220251110019M12656EE was performing maintenance and repairs on center well of thickener/clarifier, while clearing mud off, the rake shifted and crushed right #3 middle finger resulting in cut/laceration without foreign body. EE was taken to medical facility and received stitches.   
220251110020M11724Employee slipped and fell while descending a sloped gravel embankment after completing an inspection at the screen tower.  The employee sustained a fractured left fibula.  
220251110022M12115On 4/5/2025, an incident was reported where an employee took off their hard hat to brush away dust, subsequently getting material in their left eye. The employee had reported the incident their following shift. 
220251110026M11073A train car wheel sparked on the tracks while leaving the site, starting a brush fire on the mine property.
220251110029M11403A FOG occurred in the 72 740 +280 west panel heading.  The miner was remote mucking at the time when the back fell in.  There was no injury.
220251110031M11774A miner traveled into the 56E 16,000 A2 lower stope to gather supplies.  Miner observed the FOG and reported it to the night shift GF.  The area was barricaded to prevent entry.
220251110033M11514Lifter on the drill that suspends the pipe down hole slipped and smashed the driller helper's finger between the pipe holder (or clamp) and the lifter.
220251110035M11804An employee sustained an injury to left thumb. The injury occurred when employee was using a pry bar to remove a rock lodged between the conveyor belt and its supporting structure.
220251120001M12977Miner was walking and rolled EE's ankle. EE did not trip or fall over anything or step up to nor down to any level.  EE was walking on flat ground.  Conditions were clear and dry at the time of event. Employee admitted to HR that EE has a hyper mobility condition that causes this to happen often.
220251120003M11193Operator was exiting trackhoe and stepped onto unstable footing and fell down twisting ankle and cutting hand on a rock
220251120004M12987Employee was walking through the clinker storage shed and while doing so walked across a spot of unlevel ground and slipped on some loose clinker, folding EE's right ankle underneath EE and landing on EE's right shoulder causing pain to both the ankle and shoulder. EE's right fibula was fractured.
220251120005M10612a miner was struck by a large rock on their hard hat and face
220251120006M10371Employee was struck by forklift forks
220251120009M13738Employee was organizing parts in a storage area. EE had a shaker screen counterweight on the tines of a forklift. EE slid the counterweight off the tines of the forklift, when EE did EE felt a twinge in right shoulder. Self-treated until Monday, when EE was seen at a clinic, diagnosed with a muscle strain, placed on restricted duty (no use of R arm) until follow up appt.
220251150001M119553rd shift loadout operator struck right shin on gate while exiting the top of a hopper car from the ramp. Operator slipped on the ramp causing the fall. Right shin contusion diagnosis on 4/18/25.
220251150002M11143Employee was driving a loader when bucket hit ground. Employee lunged forward hitting chest on the steering wheel.
220251150009M13378The miner was assigned the task of changing the drive pulley on Coal Mill Line 1 main drive ID fan when around 11:45am EE's left index finger was caught between the sheave and drive belt. Medical attention was provided. No fractures and 22 stitches were given to EE's finger. Miner returned back to work on same day with no restrictions.
220251150011M12596Ee was using torch to heat a part to remove it when flashback occurred. Ee burned on both arms and face. Seen at ER, diagnosed with 1st and 2nd degree burns on both arms and face, and referred to clinic. Seen at clinic following day, released to restrictions.
220251150013M12927Employee was welding on the bottom of a railcar. All PPE was being worn but a piece of slag dropped from the weld and rolled down EE's forehead and into EE's right eye coming to a rest on the bridge of EE's nose. Reportable due to prescription eye ointment applied. Released to work 4/22/2025
220251150014M11474Employee has used wrists to toggle joystick rather than fingers for the past 8-10 years resulting in pain & discomfort - Became reportable 4/8/2025
220251150015M13808A Crusher employee became entrapped in the Step 3 Fines Crusher elevator between the first and second floors.  Our safety department became aware of the issue at 12:05 AM.  The employee was originally trapped sometime after 11:30 PM on Saturday, April 19th. The employee was able to leave the elevator unharmed after the fire department responded and mechanically opened the doors
220251150017M12626Employee was wire stripping using a Klever Kutter when the plastic edge of the tool broke causing the tool to slip and lacerate the palm of the employees left hand. Employee was taken to the Urgent Care and received 5 stitches with a return to Work as Tolerated.
220251150018M12826The 3rd shift relief hoist man was performing a pre-shift inspection on the #2 emergency hoist. The hoist did not pass inspection on the caliper test for the braking system. Mine maintenance was notified and upon investigation it was determined that the brake chamber was faulty. 19
220251150019M11754Employee was walking in a dim area when EE tripped and fell over forks from a forklift, resulting in right shoulder pain. On 4/22/2025, employee was placed on Restrictive Duty
220251150021M11033Employee's annual audiometric test determined EE has a Standard Threshold Shift (STS) in EE's left ear.
220251150025M11033Employee's annual audiometric test determined EE has a Standard Threshold Shift (STS) in EE's left ear.
220251150026M13658Employee suddenly became nauseous, dizziness, and lightheaded. EE was taken to the shop and brought out of the elements and treated for over exertion. EE was given fluids and cooled down when EE started cramping. 911 was called while our first responders were treating for heat exhaustion. EE was then transported to the hospital and was diagnosed with dehydration.
220251150027M13688The employee was changing skirting rubber. They stepped up on a piece of the framework to look in a hopper and when they stepped back down their foot landed on a piece of material and they twisted an ankle.  It was initially treated as a sprain, but after not improving as quickly as expected, an x-ray was done on 4/22 and it was determined that there was a fracture.
220251150028M11514Against SOP employee carried metal up the belt manlift and was caught in a pinch point resulting in a fracture of their middle toe on their right foot.
220251150031M12907Injured EE(1) instructed EE(2)(Tower Operator) to bump the conveyor on to dislodge a rock. EE(1) had gone back to the tail-pulley and after the "bump" saw a rock and reached in to remove it, at that moment EE(2) "bumped" the conveyor again, pinching EE(1)'s left index finger in the pulley.
220251150032M12205Laborer was changing V-belt on Screen. Screen was locked out. They didn't loosen the the take up enough and tried to roll the belt on the pulley and got a finger pinched requiring stitches in their right ring finger tip.
220251150033M12997Walking up a ramp to loader. Their right foot slipped, they tried to recover using left foot, and left knee bent backwards. The doctors believe they sprained their MCL on left knee. MRI is scheduled for 04/24/2025 and they have a follow up appointment on 04/30/2025 to review the results of the MRI.
220251150034M13808On 4/7 while tightening a lug nut the impact wrench twisted workers right arm and slipped out of their left hand. Worker didn't report injury until 4/8. Declined medical evaluation at that time. Worker continued full duty. 4/18 the worker took themselves to a specialist without company knowledge. The injury became reportable on 4/21 when they reported to work with restrictions.
220251150035M10632Metal plate had a burr causing a laceration to EE right hand.  
220251150039M12275Lost incoming power to the mine site for a short period of time due to a weather event which caused the hoists to trip. The hoists and compressors needed to be reset and started back up. Hoists were back operational by 7:04 PM.
220251150040M10973Tripped over pipe while carrying samples. Worked without restriction until surgery on 4/23/2025. 
220251150041M12636The employee stated they stepped off a haul truck ladder to the ground and felt their knee buckle backward. The employee had ample time in the shift to report the injury to the supervisor and did not. We are unsure of the actual location that the injury occurred.
220251150042M12496While descending s set of steps, an employee lost balance stepping onto the landing and fell to the ground.  Employee felt pain in right knee and was taken for evaluation.  Diagnosed with knee strain, placed on restricted duty and PT was prescribed.
220251150044M11393EE tripped on concrete pad while loading product for a customer and landed on left knee and hand.  Swelling and pain in left hand and knee.
220251150046M13167The employee was performing the routine task of welding new wear plates in the feeder bin of the jaw crusher. The employee stepped out of the bin and felt a pop in right knee. After being seen at clinic the employee was referred to get a precautionary MRI, which revealed a torn meniscus requiring surgery to repair.
220251150048M11253Employee was operating a loader all day and there were some pot holes that they encountered causing bouncing and a sore back.
220251150049M10792Employee slipped on a wet platform as they stepped off the last step on stairs.
220251150051M11143pulled handle to close gate to screen plant distribution box, finger got in between handle and stop at pinch point
220251180006M11333EMPLOYEE WAS FEEDING A HYDRAULIC HOSE THROUGH THE LOWER PART OF THE SCALER WHEN EE FELT A TWEAK IN EE'S LOWER LEFT SIDE OF EE'S BACK.
220251180007M13618The hoist operator reported a chute issue. Production supervisor was notified at 9:18AM that maintenance was going to check the chute. The time reached the 30 minute mark at 9:48AM and an evacuation order was given. MSHA hotline was then notified at 9:56AM. Excess material was not allowing the chute to close causing a fault to the PLC. No miners were injured.
220251180009M13558EE was walking from EE's office to the front break room for the morning meeting. EE heard some voices from the direction of the break room. EE turned EE's head to see who was speaking. At this time, EE's foot went into a depression in the walkway, causing EE's knee to twist awkwardly. EE felt something pop in EE's knee and immediately began to feel pain
220251180010M11043EE was climbing down water truck steps and lost EE's footing causing EE to fall backward onto the ground
220251180012M10662The employee was trimming a piece of plastic with a razor knife.  
220251180013M12125While operating a loader, EE was cleaning the road with the bucket flat going downhill. The loader dug into the floor causing the loader to stop abruptly. Employee hit EE's head on the front window of the loader.
220251180016M11413Mid American Electrical insulator failed causing an arc flash, power wire fell to the ground. No damage/injury to the mine site or employees.
220251180017M11804Employee was packaging 50lb bags only 2-3 bags, happened at beginning of shift. Employee stacking height was 4.5 feet. Employee stated EE was swinging bag into place on the pallet.
220251180019M13227The employee was using a large hammer and striking wrench to loosen the locking nut on a crusher mantle.  The employee stopped to steady themselves and put a hand on the edge of the wrench.  A burr had been raised on the wrench edge due to the hammer blows, which cut through the employee's glove and into their left palm.
220251180020M12736The injured employee was attempting to blow argon through the VOCL3 transfer line to clean out the system's transfer pump. When they charged the line with argon, it ruptured the filter housing, spraying hot VOCL3 over the lower half of their body, burning their left ankle.
220251180023M13849EE reported on 4/21 that on 4/19 and then again on 4/21 they smelled ammonia in their work area. On 4/21 they reported cough and burning in their lungs. Gas readings from their monitor did not show overexposure. Seen at clinic, diagnosed with possible chemical exposure/pneumonitis and released to restricted duty, no working underground pending follow-up. Site offered modified duty.
220251180025M12085A mechanic was removing an old G.E.T tooth from a 993 bucket using a wedge tool. Mechanic hit the wedge with a hammer, causing the tooth to fall landing on their right foot behind the steel toe of their boot.
220251180026M13027The employee climbed off the excavator to relieve themselves. Employee fell when standing on the ground and hit their shoulder/back of their head. Ended with bruising on the shoulder and a hairline fracture of the L2 vertebral. No treatment provided or needed. This was the employee's last day of work.
220251180027M11053The 5 hoist mantrip had an unknown electrical issue which deemed it inoperable all miners were evacuated.
220251180036M13227Miner was repairing a belt on the main feed.  They attempted to get onto the belt and caught their left knee on a belt clip that was not secured down.  It caused a laceration to their left knee. Miner was sent to the urgent care and was given five stitches. Miner was put on restricted duty but did not lose any work time.
220251190001M11524Employee alleges as EE was climbing up a haul truck ladder EE's foot became stuck in the light hole and caused to lose balance, straining EE's shoulder.
220251190002M12696Employee was clearing a plugged chute between 2VS1 Screen and 2BC3 belt conveyor using a bar. The plugged 3/4 inch crusher run broke free while employee was prodding the chute with the bar, causing the employee to mash EE's left thumb on the lip of the inspection door.
220251190003M12325Employee was removing battery cable to lock out the John Deere 318G Skid Steer when the wrench EE was holding made contact with the the positive post and EE's wedding ring contacted the frame causing a burn to EE's left ring finger.
220251190004M12566PCS received a displaced rupture disk alarm in Forney indicating an explosion in the Coal Mill 1 system. The investigative process is continuing at this time to identify the root cause. All CM1 Recovery Phase work will be performed safely and methodically.
220251190011M13147Employee was picking up a chock block that was froze down and felt discomfort to their left shoulder. They continued to work and did not want to be seen by a doctor. On April 18th they reported that they were feeling a lot of pain and would like to be seen by a physical therapist. They then received dry needling.
220251190015M11634Employee reported pain in their left shoulder while moving a case of boosters from a service truck to a cart. Employee was later prescribed restrictions 4-17-2025.
220251200001M10652EE was opertating a MT436 and felt pain in low back when driving.
220251200002M13107Ee was moving forklift and placed EE's hand in a pinch point between the fork and the assembly. Reported and did not seek treatment. On 4/28 EE requested to be seen at the clinic. Seen and diagnosed with a fracture to the tip of the left index finger. Released with restrictions that do not preclude full duty.
220251200003M10952Walking and slipped in grinding aide liquid, hurt left ankle, 3 broken bones, immediate surgery
220251200007M11223Defective Radiator cap blew off water pump resulting with Burns on employees right side (Arm, armpit, back, stomach area).
220251200010M11604EE had just finished a repair to the surge. When coming out of the chute, some small rock slid off the shelf and slid across EE's head. This left EE with a cut.
220251200012M12406While disconnecting the rear hose attachment of the CCV003 (Vac Truck) to clear a plugged hose, the top part of the hose whipped back and hit the employee's front tooth, cracking the bottom part of the right front incisor (central) tooth.  
220251200014M11925Employee was trouble shooting a plugged line.  When the washout came free it sprayed hot liquid onto the employee resulting in 1st and 2nd degree burns on their forearm, neck and upper chest. 
220251200017M12736Employee was cleaning out the vault area of the kiln, scooped up a large piece of Hot Coating. It rolled over the back of the bucket striking a hydraulic fitting, causing it to break and spray Hot hydraulic oil , causing a flash fire that was extinguished in less a minute.
220251200018M10291Employee cut hand with wrench
220251200019M13187The employee was attempting to fix a cover over the hydraulic line connection between the wheels of a radial stacker while it was still in motion. The employee's right foot got caught by the rotating tires and was pinned under a mobile stacker tire and the surface. A possible broken bone in the right ankle/lower leg.
220251200020M13638A piece of framework was being removed with a cutting torch. When the framework was cut free it tipped in a manner which struck employee in the head. Employee was wearing a hard hat which was knocked off. They received approximately a 2 in laceration to the top of head. Employee was observed for approximately 15 min before they drove themselves to the Hospital.
220251200021M11203EEwassprayingahosewhenitslipped,hittingtherightforearm. The hose clamp caught their arm causing a laceration.
220251200022M12095Employee was trying to beat a slide gate on a silo closed using a sledgehammer.  Cement sprayed into their eyes and knocked off their safety glasses.  Employee was treated at the Hospital Emergency Department.
220251200023M13087While loading bolts from a pallet to a truck, the operator twisted an ankle but continued working and proceeded to move the truck to a new area. While at this new location, employee was removing the banding from a bundle of bolts, and the front stack of bolts fell onto the same ankle/foot, causing a sprain.
220251200024M12295Removing hydraulic block to prep the excavator for welding. The hoses were tangled, and during an attempt to untangle, hand got pinched between the main frame and the block. Open comminuted fracture of proximal phalanx of finger.
220251210001M12866EE was opening the front window on the Excavator and it got stuck.  As EE jerked it up real hard it slammed closed and got EE's right hand what was wrapped around the right side of the window frame and pinched EE's right index finger between the window and the metal frame, breaking it.
220251210002M13418Operator walked from grader to talk to oncoming shift grader operator. Talked for a minute then proceeded to walk to board the Burnell bus when operator turned left to board bus, they felt a pop and some pain in left knee. Operator failed to report incident to leader after event happened. Went into RMMC after shift for further evaluation. 
220251210004M11343Motor grader fire. Unknown cause. Operator exited equipment and issued a Mayday. Local fire department and FMI water trucks responded.
220251210006M13378Employee was raking oversize rock from the grating at the discharge of the Dryer. As EE was prying rocks from the grating, a rock fell from the end of the dryer kiln, bounced off the grating, striking EE in the mouth. This resulted in the chipping of two teeth and loosening of four teeth. Employee will need dental work to repair teeth.
220251210007M12145Employee was working on MRH #2 separator, employee was crouching under neath the catwalk when they felt the lower back tighten up. Employee reported incident on 04/21/2025, then received restrictions on 04/29/2025.
220251210008M11534While tightening a toggle bolt on jaw crusher, the bolt sheared off causing the wrench to spin and struck finger.  Laceration to finger needing stitches.
220251210010M13237EE stated they fell injuring a shoulder but when asked could not state how they fell, over a chalk ball or their own feet. There where employees within 100 feet of them at that time that did not see them fall. Once taken to the clinic the clinic informed them the issues with their shoulder from birth and not work related.
220251210011M10682cut finger while cutting large zip tie with with utility razor knife
220251220001M12907Ee was function testing the jackleg when a piece of drill steel popped out, falling on the ee's foot. EE reported the incident immediately, but did not seek treatment until 4/28. Xrays positive for fragmented fracture of the right 5th toe. Referred to ortho and released to restricted duty.
220251220003M12255Miner was using a grinder. A sliver of metal got behind EE's safety glasses and embedded in EE's right eye, requiring removal from EE's eye doctor. Miner was prescribed eye drops to use for one week and returned to full duty.
220251220005M10391Outside nightwork, dry, cold conditions
220251220007M12295Ee was working to dislodge mill balls from the discharge chute when one fell on EE's finger. Seen at clinic, diagnosed with a tuft fracture, left distal ring finger. Released to full duty and referred for orthopedic consultation.
220251220008M12826Ee was operating scissor deck. EE looked up, and something fell in EE's eye. EE reported it immediately and requested to be seen the next day. Seen at Total Eyecare, diagnosed with an abrasion to the rt eye with mild inflammation, given steroid eye drops, and released to full duty.
220251220009M11353Employee was attempting to position a motor base when it moved unexpectedly and pinched EE's finger between the base and a pivot table.
220251220010M12195Employee was in the kiln shack grabbing a pair of gloves & after a while of wearing them their hand began itching and had swollen up. Harvey believes the glove had a insect in it that had bit them irritating their hand.
220251220012M13808The 167 KVA 7200V-480/240V transformer failed due to age. The transformer had been in service for over 30 years and there was no evidence of a fault external to the transformer itself. The fire was contained within the transformer containment. EMS was notified but had to wait until the power company could turn off power to extinguish the fire, causing it to go over 30 minutes. 
220251220014M12005While performing maintenance work, an employee was welding a patch on the tub of the shaker when they noticed a fire coming from below the shaker.  Sparks from the welding, ignited the conveyor belt. 
220251220015M13578Employee was assisting another employee in cleaning drink coolers; the employees were using a pressure washer to do so. The injured employee reached to catch the cooler as it was falling out of reaction and was struck on the top of the hand by the water stream causing laceration to their left thumb. Employee was taken to ER where they received 6 stitches.
220251250009M13448While transporting a line with a forklift, an EE got debris in EE's eye, possibly from rubbing it. EE used the on-site eyewash station and reported it to EE's supervisor, who escalated the issue. After initial first aid, the EE was taken to a fire station, then to Archbold Corp. Care for further treatment and received prescription medication.
220251250010M13849EE was cutting a conveyor belt with EE's safety knife. As EE finished EEs cut, the knife came out of the belting and jabbed into EEs wrist, causing a small puncture through the glove into EEs left wrist. The EE removed EE's glove and saw blood. We wrapped the cut with a compression bandage at the office and transported EE to the ER where they placed two stitches to close the wound.
220251250011M12556A fall of ground in the 56E 16,300 A3 stope was found by a miner.  The miner called to report the fall to dispatch and the event was verified by management at 9:45 pm and called into MSHA.  The area was immediately guarded and barricaded to prevent entry.
220251250012M10983Employee suffered a shoulder strain that required medical treatment while opening mill body doors.
220251250013M12085Employee was lowering fork units to the ground and when it fell to the ground the other employee's finger that was in the expanded metal got bent and dragged causing a minor fracture to the tip of the finger.
220251250015M11423Cutting rope with retractable safety knife.  The rope slipped & EE lacerated the top of EE's left thumb.  Received 3 stitches at the hospital.
220251250020M13678At approximately 8:00AM employee noticed a piece of metal railing had fallen over at the main plant screen deck. At this time employee shut down plant and proceeded to the screen deck walkway to move the fallen railing. When employee went to lift the fallen section they felt a pop and pain in their right bicep. Metal railing section weighed approximately 50 pounds.
220251250021M10922EE lifting stone in quarry, stone shifted and pinched finger between stone and quarry floor.
220251250022M11073EMPLOYEE WAS CUTTING A BOX OPEN AND HEARD A POP IN RIGHT SHOULDER.   THIS BECAME LIGHT DUTY ON 04/28/2025. 
220251250023M11333EMPLOYEE WAS LOOKING FOR A HYDRAULIC LEAK AND SLIPPED ON ROCK AND HIT LEFT KNEE ON GROUND.   EMPLOYEE BECAME REPORTABLE ON 04/28/2025
220251250028M11844Employee wash unplugging a caustic line and got liquid on their pants causing a caustic burn.  Employee went for a follow up appointment on 04/26/2025 and was put off work for one day.
220251260001M11914Weather during the day created slick conditions around the plant. EE was walking from the parking area over to the plant when EE slipped and fell. EE was diagnosed with a lateral knee strain.
220251260003M12045Employee was Pulling drip line on pad 4 rehandle. Coupler gave out causing employee to fall backwards.  During fall employee twisted left knee and was not able to put full weight on that leg after fall.  
220251260007M11233EE WAS WORKING ON SKIDSTEER WITH ANOTHER EE WHEN STARTED- IT LUNGED FORWARD THE TIRE RUNNING OVER EE'S RIGHT ANKLE AND LEG.
220251260011M13849Weather forecasts predicted an excessive rain event, indicating a potential for the Red River to flood. The plant manager initiated emergency action planning, removing mobile equipment from flood areas and the shutdown of electrical power to the plant. All personnel were also made aware of the situation. On May 1, 2025 the Red River flooded, preventing access to the Waurika Plant. 
220251260013M13077Employee was out of the loader manually moving the face drill cable out of their way so that they could clean up. While they were working the cable out of the way they felt a strain in their abdomen that did not ease up throughout the day. They came out and reported the incident around their quitting time.
220251260014M13207EE was removing a valve stem cover plate. After removing the first 4 bolts, they proceeded to remove 2 more. As EE was removing the second, the knife valve split apart, causing slurry to shoot out the side. Slurry came into contact with the EE. EE sustained abrasions and multiple contusions. EE was issued restrictions.
220251260015M12446EE was conducting work in the mill underflow tubs by chipping away steel ball chips from the grating when a piece of metal went into their eye and began causing discomfort. EE was taken to get medical treatment and was prescribed an antibiotic.
220251260016M12897Operator went to fuel island and the pump 2 hose had been rolled back up. In the process of pulling hose back to the east side of fuel island, operator went to get more hose out of reel and in doing so strained their back as they were turning their body. First missed shift was 04/25/2025.
220251260017M13057Operator of drill 557 was leaving tie down attempting to go down ramp to Castle dome pit, during that walk Haul truck 531 was attempting to pass drill, When haul truck attempted to pass it struck rear of drill mast causing damage to both and injuring the drill operator. First missed shift was 05/30/2025.
220251260018M13167Employee was walking from the Main Gate to the Administration building and there was a pickup next to the gate, they walked around the pickup and turned to talk to the driver. As they turned back to continue walking, they stepped into a dip in the pavement, twisted an ankle, and fell resulting in an ankle fracture.
220251270001M12907Employee was involved in NWEM Training and being tasked training an operation of a haul truck. EE was riding along with another employee. They stopped and pited the truck. When employee was climbing down from the the haul truck EE reports that EE missed the last step and rolled EE's ankle.
220251270002M11534Employee is reporting bi-lateral carpal tunnel to wrist/hands from operating a Cat 992D pit loader. Employee is also complaining about shoulders hurting.
220251270004M13648Employee was cleaning out stone crusher before we started the plant. Employee was scraping compacted sand from the walls inside machine. They lost footing and their leg slipped between two metal pipes on the machine. Leg was bruised on either side where it was wedged against the metal. Sent them for x-ray to be safe, no damage found, leg was sore for a few days.
220251270009M10722Employee sprained EE's back while cleaning spillage near primary crusher
220251270013M13247An employee was cutting a zip tie off of a D-ring when the knife slipped and sliced the inside of EE's left forearm. The laceration was approximately 1" in length and required 3 stitches. The employee was permitted to return to work with instructions to keep the wound covered. This incident did not result in any lost time.
220251270015M11273Employee was operating loader and skidsteer and felt pain in their back. Later was diagnosed with a shoulder strain/tendonitis.
220251270017M12556Operator was removing spillage from a product reclaim tunnel utilizing high pressure water supplied by a 1.5" dia. heavy duty rubber hose. While performing this task, the operator pulled on the hose and strained muscle in the right side of the lower back.
220251270018M13798Employee was walking and tripped.  Fell on left shoulder and head on concrete surface.  Diagnosis through emergency room visit:  cervical sprain; contusion left shoulder, minor head injury (concussion). Employee will be off work at least two (2) days.  No witnesses, undetermined what employee actually tripped on.  Area in question as been reviewed and no obvious obstructions. 
220251270020M13378The hoist tripped due to the gap on the right brake stand-2 upper caliper was detected on the hoist control system to be outside of tolerance at 2mm. The gap was checked and adjusted to 0mm at which time the hoist was reset and back operational. The Silver Shaft Hoist (primary) and 2 Shaft hoist (secondary) were operational throughout.
220251270021M13307EE reportedly stepped into a small hole of missing grating causing a twisting fall to the decking floor. EE landed flat on back. EE found by ERT standing holding onto desk for support in control room. EE stated back pain that prevents normal walking. EE refused ambulance transport but did request transport to ER for evaluation. 
220251270023M12185Employee was in the process of installing the lock ring on a 240 ton haul truck tire when the ring snapped into place causing the clamp to make contact with the employee's right index finger resulting in a laceration. 
220251270024M10742EE was removing wheel chock from fender holder and felt pain in right arm.
220251270026M13227While removing the axle shaft from the right final for the final PCR, the shaft was stock. The technician started to move the shaft to release it. The shaft shot backwards, pinning the technician's right hand against the forklift and mast. The technician sustained a fracture to the hand. Employee was issued restrictions.
220251270027M12025EE was getting off a dump truck. As they stepped back, they slipped on mud from the top step. As they landed, they rolled their left ankle. EE sustained a sprain to an ankle. EE was issued restrictions.
220251270029M13307Employee was drilling vertical holes above head with a Hilti gun using a 1 " bit to install anchor bolts to secure a 10' pipe.  Employee was taking a break and wiped their face off with a rag, and got a piece foreign object in their right eye.  EE then attempted to flush it out. Foreign object was later removed by optometrists.
220251270030M12215Employee was checking motor on piece of equipment when the ladder they were standing on kicked out from underneath when they were climbing down ladder.  Employee stopped themselves from falling by reaching with right arm.
220251270032M13778Employee was walking from Line 4 performing routine rounds when they slipped on pellets. The employee caught themselves & jaw came down and locked inflicting pain to lower jaw area. The employee notified the supervisor and EMS was called. The employee was then transported to telemedicine and later returned to work with a sore jaw and will be followed up on next shift per EMS
220251270033M13618While washing the cable bolter, the operator had some grout come off the equipment and splash into their left eye. The operator flushed eye with a bottle of water and continued working. An hour later they told supervisor, and stated that they had no residual issues or pain. The following afternoon, they woke up for their shift and the eye was red and weeping.
220251270034M13217The injured employee was assisting to unstop the box above the 5 1/2 crusher. The material shifted and a rock spilled out of the box striking the employee on the hard hat and shoulder. The employee was taken to the hospital where they were examined. It was determined the employee had a concussion and shoulder contusion.
220251270035M11754Employee was attaching a hose to a portable water pump used for drainage. They pinched right pinky with the hoses attachment cam-lock while locking in the hose. Bruising only.
220251270036M10512Loading material into haul trucks from windrow pile
220251270039M13227EE putting out cones for shovel. Walking behind pickup driven by other EE. EE driving truck was backing up, did not see EE putting out cones, and they struck the EE on the left knee with the hitch. EE seen at clinic, xrays negative for fracture, diagnosed with a contusion, released to restricted duty that site can offer.
220251270041M11884Warm weather conditions in daylight. Shoveling on catwalk to clear bridged material.  Catwalk was free and clear of material where employee was working to clear bridged material in chute. 
220251270042M12826Worker was walking to a hole they were about to measure when they tripped and rolled their ankle on uneven ground. Worker was assessed by EMT at 10:21am. EMT provided worker with an ice pack and advised them to go Medical Clinic for further evaluation. Supervisor took worker to MC.
220251270043M12576While performing a belt change, the employee crouched down to retrieve tools. As they attempted to stand, they applied pressure to their left knee, which resulted in a sharp pain.  5/2/2025 upgraded to Medical Aid. Grade 2 Sprain, requiring Physical Therapy
220251280001M13618A set up crew employee was attempting to remove liners from a cone crusher, by striking the liners with a 10 lb sledgehammer. During this process, a shard of the manganese liner chipped off and went into the employee's left forearm. The employee was taken to the emergency room where the shard was extracted, wound was cleaned, and 5 stitches were administered.
220251280002M11784Employee was using vac truck to empty rail car. Had to use an air lance to break up the material. When the lance was moved to a new location it shot material back in to the face.
220251280003M12626The employee was laying on grating reaching to install a bolt on the bearing housing, while a Johnson bar was leaning on a nearby handrail. Another employee leaned against the handrail which caused the Johnson bar to tip over and strike the employee on the head.
220251280005M11534On 4/28/25, an employee felt a pop in EE's upper back while using a sledgehammer in the gyratory crusher. Did not seek medical treatment until 4/30/2025.
220251280006M10401Servicing truck and hit head on machine.
220251280007M12846Customer truck driver entered quarry entrance with bed raised striking overhead communication lines. This resulted in three poles breaking and the overhead power lines falling to the ground behind the truck. Driver was required to remain in truck until power company deenergized lines
220251280008M13408EE failed to follow known LOTO process for equipment in lab. EE opened doors to the unit reached inside to clean a press head when the machine activated and moved pinching their arm between a fix and moving part, this cause an abrasion to the forearm requiring first aid. 5/2 EE asked to be seen by Dr resulting in restricted  duty from Dr.
220251290001M11684The employee was unblocking the 11 launder and lifted a grate. After pulling the second grate, the first cover landed on the employee's right hand causing a laceration.
220251290002M11564employee was greasing lines on the C 20 conveyor belt, as EE walked to the counterweight guarding EE stepped on something making EE twist and roll EE's knee
220251290004M11103Maintenance employee was using a pipe wrench to loosen a drain plug when they felt a strain in their shoulder.
220251290005M11444Employee was walking under the Bemis reject line when a bag fell off the conveyor, striking the employee on the left side of neck/shoulder area.
220251290006M11444Employee was kneeling on a pile of product, as EE got up with EE's right foot, it slipped. Employee tried to break the fall with EE's right arm.
220251290009M12195Employee was removing old bits from the Trencor Surface Miner with a large chisel.  While the employee was hitting the chisel with a hammer, the chisel became dislodged from the holder striking the employee in the nose.
220251290010M11474Employee was changing the motor on feed conveyor, using grinder to cut off an old bolt when grinder shifted and made contact with left index finger
220251290012M10892Employee cut finger between door and door jam - did not become reportable until 4/24/2025
220251290013M10762Employee stepped into small hole and felt pain - became reportable 4/22/2025
220251290014M10311Employee smashed finger in door
220251290015M11664Employee was filling water tote on the back of a pickup and jumped off of truck spraining their left ankle.  Worked until 12:15pm and wanted to get ankle checked out.
220251320004M11864Employee was using a prybar to open the southeast door to raw mill separator. The prybar slipped causing EE's middle finger to become wedged between the prybar and the platform handrail.
220251320007M11033Employee received a cut to the left hand while using an electric angle grinder which required stitches.
220251320009M10642Little finger on left hand got pinched between pry bar and beam.
220251330004M10692Employee fell off of the dozer causing EE brake EE's left collar bone
220251330005M13097The employee was tightening bolts and aligning a motor on a compressor. EE felt fine during EE's shift but felt discomfort 27 hours later, after driving 5 hours on personal time. EE felt discomfort in EE's right rib area. The injury is still under investigation to determine whether it is work-related or not.
220251330008M12646An UG maintenance mechanic was using a soft steel hammer to break free a bucket tooth (G.E.T.) from a 9 yard loader bucket. When the soft steel hammer made contact with the tooth, a small metal shard sheered off and imbedded in the employees right leg calf muscle.
220251330011M13768On 2/20/2025, an employee reported pain/symptoms at the start of their shift. When asked if employee was aware of what caused the pain/symptoms or if anything occurred at work, they stated that on 2/18/25 they grabbed a loader handle when exiting equipment and the pain could possibly be from that event. The employee received a diagnosis for their shoulder pain on 4/29/2025.
220251330014M12456Employee was removing a conveyer belt when the right outrigger on the forklift they were using shifted downward causing the forks to hit an electrical box where they had their hand.  The impact caused a fracture / laceration to their left thumb.
220251330015M13197While setting a dewatering pump, the slope on the east side started to slough off into Rim Ditch. All were advised to extricate from this area. They egressed to the east slope and when it sloughed off to the bottom, they fell approximately 4 feet landing feet first on a rock. They hurt their right ankle and left knee.
220251340002M11714Employee was splitting stone on the splitter, standing too close. A stone was ejected out of the mechanism and fell on top of employee's foot above the safety toe portion.
220251340003M11173EE was cleaning a ladder at the secondary wet screen when material fell from the ladder and went into EE's right eye.
220251340005M13628While driving loader 600-181 down to the city base pit, the bucket slowly dropped until it dug into the road, bringing the loader to an abrupt stop. EE reported the incident to EE's supervisor after it happened but did not need or want medical attention at that point.  On 7 May EE stated that EE's right shoulder was very sore and requested to have it examined.
220251340007M12586The employee removed the calibration weight and it dropped onto the employee's hand, pinching it between the top of the guard and the weight. As a result, the employee sustained a cut that required 8 stitches and a hairline fracture to left hand ring finger.
220251340008M11804Hearing test were conducted on 4/22/25. Hearing Test results received 4/29/25: Left ear has moderately severe hearing loss at some high frequencies. Required placement on MSHA log 
220251340010M11734Employee was working on a buggy whip when the screwdriver being utilized slipped and penetrated the right index finger.  Employee received stitches and was released to work.
220251340011M11955A miner was mucking a recently blasted round.  While mucking, the mucker bucket contact and initiated a primer (blasting cap).  The miner was uninjuried and barricaded the area to prevent injury.
220251340012M11955EE was barring mud out a rail-car when EE slipped and hit the big toe area of EE's right foot on one of the interior ribs of the rail-car.  EE broke EE's big toe and bruised the top of EE's foot.
220251340015M11654An employee felt pain in their left knee while descending the stairway at the LKD Load-Out. Employee states they missed a step, but no damage was found to the steps.
220251340018M12947While trying to board the haul truck operator hit the right knee on the second rail on the ladder. EMT assessed IP and noted a purple mark on the front of their knee cap. IP was walking with a limp and said it was painful to press on the gas of haul truck. EMT sent IP to RMMC with supervisor. 
220251340019M12355Employee lost balance and fall off of the track to the ground. Employee first made contact with the ground on left shoulder/elbow area. They received 3 stitches in left elbow, has a sprained left shoulder, and a fractured left scapula.
220251340021M13778Guard on Cone was removed to replace skirt rubber, after employee adjusting conveyor while the guard was off for better visibility. Small amount of material was noticed inside the belt and tried to remove it with their crescent wrench, when the wrench became caught in the tail pulley, the employee's left arm was removed as a result of the entanglement within the tail pulley.
220251340022M12876An employee was relocating an excavator and chose to track it down an approximately 8-foot-high wall with a 10-degree slope. Due to recent rainfall, the soft ground caused the excavator to slide and tip onto its side at the bottom. The employee self-extricated and reported the incident.
220251340024M11464Lifted two excavator batteries into back of pickup truck. Felt discomfort at the moment but developed into back pain overnight. Working light duty
220251340025M12626A dust collector mechanic was changing out filter bags for a cement silo dust collector and after a two hour period noticed an eye irritation.  The employee stopped work and flushed eyes multiple times but needed off-site assistance from a medical care facility.
220251350003M12726A rejected bag hung up at the top of the rejects chute in Robo 2. The operator used a ladder to reach into the reject chute to free the bag but when EE reached for the bag the cutting wheel started. The operators right thumb contacted the cutting wheel resulting in a cut.
220251350004M12355Employee was walking through the plant to take inventory when dust blew into EE's right eye.  The employee was wearing safety glasses.  EE was prescribed an antibiotic for a corneal abrasion from the ACMH Hospital Emergency Department.
220251350005M12486The employee had removed the pin on the tooth and was tapping it with a small sledgehammer on top to dislodge it from the shank. In the process of striking the tooth, a fragment of metal splintered off the tooth, striking the employee in the thigh.
220251350009M13047Employee was in the process of pressure washing windows of the water truck EE was operating, EE started the pressure washer and as EE was backing up while unwinding washer hose/wand, EE attempted to turn around, as EE did, EE tripped over the tongue of the pressure washer trailer, falling to the ground.
220251350010M11193EE's left middle finger was smashed & lacerated between two parts of Komatsu 605 haul truck during removal of dampener.
220251350011M13277While walking to the S100 hopper to open the guillotine gate, the employee slipped and fell slightly backward, injuring their right ring finger. Employee was treated at urgent care, where X-rays confirmed a dislocation and minor laceration. Medical treatment was provided, and work restrictions were prescribed as of 05/11/2025
220251350012M11864Employee had finished loading pellet truck and flipped switch off to stop flow of material and notify trucker. Employee turned to right when they fell injuring left knee and right wrist.
220251350013M13818Individual injured while helping change out a bucket elevator belt. As the old and new elevators were being replaced, they got stuck together, causing them to bind. The tension caused them to abruptly come apart, striking individual on right hand thumb area causing a fracture to the thumb. Injured party was transported to get evaluated, x-rays taken confirming fracture to thumb.
220251350014M13798Employee reported on 5/6/25 that they had injured their back the previous day (5/5/25) while clearing a blockage of 5-8" stones over a small transfer hopper. We immediately filed a WC claim and directed EE to seek medical attention.  Miner returned on 5/7 saying back was fine but could not produce Dr's note clearing them to work.  EE has not supplied a Dr's note as of 5/14/25.
220251350016M10792Mill Maintenance Employee reported back pain upon lifting an acetylene bottle. 
220251350017M11614The employee was cleaning a cement coupling with a drill grinder.  The drill bit became dislodged from the drill and lacerated the employee's left index finger. 
220251360002M12556Employee got material/dust in EE's right eye when EE was pulling apart a hose connection. When the hose broke apart loose material was thrown up into the employees face/eye. The employee was prescribed antibiotic eye drops making this a reportable injury.
220251360003M11273At approximately 2pm EE was in the process of releasing a barge from the south dock when EE's right knee struck the mooring peg
220251360004M13828Employee was helping to remove an aqua ammonia (19% ammonia) spray lance. The tip of the spray was plugged up and pressure built in the closed, locked out line. When the connection was broke loose the residual line material blew out into the area contacting EE's head and EE inhaled some vapor causing irritation. Employee was monitored and prescribed an inhaler for the irritation.
220251360007M13327Employee was removing an aqua ammonia (19% ammonia) spray lance. The tip of the spray was plugged up and pressure built in the closed, locked out line. When the connection was broke loose the residual line material blew out into the area contacting EE's face and eyes. Employee was monitored and prescribed medication for EE's eyes.
220251360012M11233While unbolting a flange, a faulty bolt with threads coming off contacted the right index finger, resulting in 13 stitches.
220251360014M10942Employee was restacking bags of cement onto a pallet when they felt a pop in their lower back.
220251360015M12526Employee was walking on an uneven surface and felt pain in knee, sought medical attention and was released back to work.  On 05/10/2025 employee was still experiencing pain sought medical attention and was put off of work until an MRI can be performed.
220251360016M10842Operator placed thumb in pinch point while attempting to move forks on telehandler .
220251360017M10281Lime in eye during clean up.
220251360019M11033A rock fell from the back hitting a miner in the left shoulder, resulting in a fractured left clavicle.
220251390001M12125EE was carrying a piece of metal less than 50lbs to service truck when EE lost EE's balance and fell to the ground landing awkwardly on right hand resulting in a broken finger.  Area was free of debris and level.
220251390002M12105EE was cutting a piece of conveyor belting with a utility knife when the knife slipped stabbing the EE in the right thigh just above the knee. The EE received 3 stitches making this accident reportable to MSHA.
220251390005M13357While installing a deflection shield for under the redimat, employee was notching the belt to fit correctly around the gate foot with a box cutter. Cutting towards the foot/body, the box cutter slipped and cut employee through EE's work boot and cut into inside part of EE's R foot. Seeked medical care and no stitches or restrictions.
220251390006M13037While commissioning a tire chip rotary feeder, the fire protection system detection wire burned up, causing the system to shut down on interlocks. Employee in the area reported hearing a loud pop, feeling heat, and then equipment on the tire feeding system shut down. No injuries or damage to equipment.
220251390007M11474EMPLOYEE WAS WALKING DOWN THE STEPS TO THE 3020 BELT LINE AND THERE WAS WET MUCK ON STEPS, SLIPPED AND CAUGHT SELF BEFORE FALLING. HURT RIGHT KNEE.
220251390008M12917Employee was dumping a load at the tailings dump in the Mississippi Mine. After dumping the load EE watched for the light on the dash to go off signaling the bed was down. EE began to exit the mine and when EE got to the blacksmiths shop EE felt the bed contact a brow and ripped the bed off
220251390009M12997On Wednesday 5/14/2025, fixed maintenance employees were working on reinforcing a stacking conveyor, when the stacker failed. This resulted in a conveyor beam striking an employee on the right leg. Diagnosed with right leg contusion/abrasion, was prescribed medication and placed on restricted duty.
220251390010M11554An operator was in the process of completing a check on top of the bag house at the Hot End in calcination, when the employee fell and hit EE's left thumb.
220251390012M12806While cleaning cement out of haul truck bed, employee was struck on the eye by an air hose that came away from the air chipper. Employee received first aid by security and was taken to the hospital for further treatment; employee was prescribed medication and days away from work.
220251390020M11945Employee was exiting a 633D scraper using 3pts of contact when they felt a pop in right shoulder.  Employee did not think nothing of it until the following day when the shoulder felt much worse.
220251390021M12516ARC Crushing Supervisor sustained a fracture and laceration to the fingernail area of right index finger while manually adjusting conveyor skirting at Spring Butte Quarry. The injury required surgical stabilization and has resulted in restricted duty.
220251390023M10371Employee injured finger changing tire
220251390024M10421Employee was hit in the face injuring nose
220251390026M10973Employee was ascending steps and felt a pop in knee - experienced dislocation requiring alignment
220251390028M12476Employee was re-tightened a hose connection on the ground next to a 300 cone. Gathering belt was feeding the 300 cone crusher with 5-7" rock. A rock bounded out of cone and landed on employee left hand while they were re-tightening the water hose.
220251390029M10942Employee was in the back of the pit / service truck, was getting out and miss stepped and fell
220251390030M12496During a review of audiogram results by a third party Audiologist on 5/14/2025it was determined that an employee sustained a reportable threshold shift in their left ear. The employee is being re-trained in accordance with section 62.180 of the CFR 
220251390031M10842WHILE ATTEMPTING TO MOVE A VALVE HANDLE THE TOOL SLIPPED AND STRUCK THEM IN THE CHIN
220251390033M11474JCB Telehandler tires traveled over slight drop off causing vehicle to roll onto side. Employee suffered laceration to the head requiring sutures. 
220251400002M12927Employee was performing maintenance on conveyor belt. While removing a bearing with a mallet, a piece of metal broke off, became embedded into the EE's right pec. On 5/13/25 we were notified the employee had a piece of metal removed and was able to continue working. Reporting within 10 days.
220251400003M12235Employee was sampling 5" select larger stones which involves shoveling, carrying & loading buckets to a tailgate. on 05/09/2025 we were notified the Employee sought treatment and was prescribed PT. Reporting within 10 days.
220251400004M12395Employee was working near screen plant. Wind blew sand underneath safety glasses. On 05/07/2025 we were notified the Employee sought treatment and was Dx with a corneal abrasion. Employee was prescribed eye drops. Reporting within 10 days.
220251400007M11514Trespasser entered mine property and while attempting to climb down from bench 5 to bench 6, slipped and fell approximately 40 feet breaking both legs.
220251400008M11413Employee lost EE's footing and stumbled causing EE to lacerate EE's head on a steel window frame of a connex box. Employee received 6 Staples
220251400009M10963Employee was shoveling and felt a pull in back. Employee was put on restricted duty for a week. 
220251400010M13418Operator was changing the bottom deck top screen in our KPI screen as EE was climbing out from under the rubber flap on the rear of the screen the worn screen tipped over which struck EE on the back left portion of EE's head which caused EE to strike EE's right side of EE's head against one of the protruding bolts on the rear of the screen
220251400012M13768On 5/7/2025, an employee was injured while attempting to remove an Easy Skirt from the Feed Belt of Finish Mill #4. The worker was using a pry bar to detach the skirting from its mounting plate. During the task, the bar slipped while being forced downward, and the sharp end punctured the employee's right palm. The injury required medical attention, including three stitches.
220251400013M11393Employee experienced a stroke in EE's personal vehicle in the parking lot, before EE's shift started, and emergency services were notified.
220251400014M11864A Blasting Operations Technician was opening a bag with a utility knife and cut their leg. This caused a laceration that required stitches. The employee returned to work the next shift. 
220251400015M13418Employee was replacing a 120 pound grease drum on fuel truck. Employee decide to load grease drum by self without help and use of equipment resulting in strained lower back. Safety Manual states "Learn to lift the correct way, bend knees, keep back erect, and get help for heavy loads". Job description states "Able to lift up to 70 pounds".
220251400016M12265Associate was using an electric rail car opener when the reaction arm slipped from the rail car body and struck the associate in the head.  The associate was confused and had brief memory loss. Associate suffered a concussion.
220251400017M12175Miner was performing work on a 770G rigid frame water truck when EE walked into the water fill pipe on the haul truck cutting EE's right eyebrow. Miner was sent to urgent care where EE received 5 stitches for the cut.
220251400018M12275Employee was getting out of the 982-M5 front end loader to inspect the surge stacker, which had stalled.  They were climbing down the ladder and were on the second step from the top when they felt discomfort in their right leg.
220251400020M11985Employee's steel toe boot was caught between boxcar door and forklift support while exiting railcar causing damage to boot.  Exposed steel toe in boot then caused abrasions to fourth and fifth toes.
220251400021M12285Employee was descending into the pit when they lost control of the water truck they were operating. Employee attempted to turn up an old ramp and overturned the truck. As a result, the employee sustained two fractured vertebrae.
220251400022M12295Employee was welding liners into a discharge chute when they felt something hit their face. Later in the day they realized a piece of debris was in their eye. They sought medical attention the next day and the debris was removed.
220251400023M13277While conducting routine inspections, EO detected a smoldering inside of the coal building as they proceeded to investigate. EO made their way from the front of the coal building to the back, during this process EO sank into a hot ash pile up to their waist area, resulting in burns to their lower extremities & lower arm area.
220251400027M12456Employee was dumping a wheelbarrow on flat ground and felt a pain causing them to let go of the wheelbarrow, allowing it to pull on right arm causing pain to right shoulder. The initial pain was due to a hernia caused by dumping the wheelbarrow.
220251410001M11474Employee lowering manifold flange part into place. Finger was between the catwalk and the flange. Result was broken finger - left hand ring finger.
220251410002M13838Employee was riding in the basket of the manlift through the yard and hit a small bump. The employee struck EEs left elbow on the manlift basket cage. The injury started as a first aid incident and was being treated by Ortholive with conservative care. The incident became a reportable incident on 5/20/25 when the employee went to an urgent care facility and was given restrictions.
220251410003M10441cut hand while putting cutting edge bolts in
220251410006M13147Employee was helping a truck driver get a rock out of the tailgate of their dump truck. As employee and truck driver pulled the tailgate open, the rock fell out, truck driver let go of tailgate, the tailgate swung shut and struck the employee's right pointer finger. Employee's right pointer finger was fractured. 
220251410009M12466While installing a section of catwalk grating on a dredge, the employee pinched their left pinky finger between the end of the grating and a handrail while sliding the grating into place. The injury resulted in a cut that required three stitches.
220251410010M11794Operating a front-end wheel Cat 980M loader with a load  in chips hit a rut with the front wheels and bounced up in the seat and hit their ribs on the arm rest on the right side.
220251410011M11193Employee was putting drill steel in the chuck while hand was in a pinch point and closed the centralizer on their hand.
220251420002M11163Miner was washing the pins to disengage the bucket of skid steer.  The bucket disengaged and fell on EE's right foot
220251420004M11013TM fell while descending stairs and while attempting to catch themselves felt a pop in EE's left arm.
220251420005M11654After clearing the clinker chute, the employee attempted to exit the area and struck EE's nose on a cross member of scaffold. This resulted in a nasal bone fracture.
220251420006M13818The plant tower elevator stopped between floors due to a defective safety switch which failed (as designed) causing the elevator to stop. An employee was in the elevator and notified the control room that EE was not able to get the elevator to move. The employee was in the elevator for more than 30 minutes and the event was called in to MSHA. No injury associated with the event.
220251420007M13818Temporary employee was working in the bagging area when EE tripped over a piece of the exit conveyor at approximately 1:30 pm. EE landed on EE's right shoulder and was experiencing tingling/numbness, but no pain. Employee was taken to the ER to be medically evaluated. EE did not attend EE's follow-up appointment, as required, and did not return or call into work until 5/19/2025.
220251420009M13187Shift repair was working on the "small mills" FK pump to repair an air leak.  While walking from the repair truck to the west side of the FK pump, they tripped on uneven floor plates and fell hitting their right knee. Employee was taken to the emergency room and was diagnosed with a fractured right patella (kneecap).
220251420010M11894On 5/19/2025 at 3:00 PM, after working on FM1, an employee was leaving the Mill area when attempting to step down onto a platform 2 feet lower than the Mill, and they sprained their ankle. 
220251420011M124665-11-25 a fire started in one of our green slash piles. The state wild land fire crews that helped put out the fire suspect that the cause of ignition was lightning. We have submitted a request to receive a copy of the official investigation.    
220251420012M12456Employee is a laborer at our mine. They were repairing a chute. While removing a 2 foot by 3 foot section of a worn piece of metal, they lost footing and fell to their butt. In doing so, they hyper-extended their elbow, causing a ruptured bicep.
220251420013M12165The dozer Operator had dismounted the dozer using a three point contact body position. When their left foot contacted the ground, the dozer Operator felt and heard and felt a "pop" in their ankle with immediate pain.
220251430001M12746Miner was adjusting a hose when EE suddenly suffered acute pain in EE's knee. The incident was due poor posture. The working conditions were safe and adequate. The miner suffered a fracture in EE's meniscus. The miner suffered no impact, nor did EE slip before the incident.
220251430002M13828A tree blew over into the power lines near the Basin Shops building at approx. 11:27 AM next to the road. Basin employees expelled 4 extinguishers and called Keetac Fire to respond. Keewatin fire department was called and the DNR and Nashwauk fire department. Basin cat was used to assist in cutting access. Fire was extinguished before 3 PM.  MSHA was notified at approx. 11:56 am.
220251430003M10993Slip and fall when pulling wrench off bolt. Fell and landed on a rock in the employee's lower back.
220251430004M10602Haul Truck shifted hard causing pain in EE's right shoulder.
220251430008M12826Ee was emptying a dumpster. EE released the latch on the handle of the dumpster and it flipped over and pinched EE's hand. Seen at clinic and referred to ER. ER referred EE to ortho, seen by ortho and surgery done on 5/20. Released with restrictions and site offering modified duty.
220251430011M13528EE WAS CARRYING TWO 5 GALLON WATER JUGS OUT OF THE OLD OFFICE.  EE HAD THE JUGS IN BOTH HANDS.  EE HIT THE DOOR "PUSH BAR" WITH EE'S RIGHT ARM / SHOULDER TO OPEN THE DOOR.  THE DOOR WAS LOCKED AND EE HIT EE'S SHOULDER INTO THE DOOR.  SHOULDER WAS HURTING A BIT BUT DIDN'T THINK IT WAS A BIG DEAL.  WENT TO DR ON 05-19-2025 AND HAS NOT RETURNED TO WORK.
220251430012M11544Employee was moving around buckets of bolts by 9 and 10 heaters in digestion. They felt some discomfort in left lower side of back after they moved bolts.
220251430013M10952IP set hammer to the side to clean pieces of concrete when hammer slipped and smashed finger.  
220251430016M13828Conducting pressure checks on a brake valve, EE went between the right front tire and the frame to attach the pressure gauge. The other mechanic in the cab turned the wheel to the left, thinking they would check the valves in the same order as the previous truck, and this trapped employee between the tire and the frame. EE was diagnosed with four broken ribs and a punctured lung.
220251430017M10872Hot material flushed from dust collector hopper causing burns on left and right ankles.
220251430021M11444While working on a F-150 fuel tank fill nozzle, the mechanic felt a pop, instant pain in upper back, ribs and chest and the left side went numb.
220251430022M12696Employee was injured while attempting to dislodge a rock from the portable crusher. While standing on the short stub conveyor and using a pry bar, they lost balance and fell approximately 4 feet onto the stacker conveyor below, resulting in an injury to right shoulder.
220251470005M10812Mechanic was lifting a packout kit of tools and pulled something in EE's shoulder
220251470007M13177Ee reports about 3/4s through shift feeling irritation in right eye. Flushed eye, didn't notice anything on rag after drying eye. At end of shift, eye was very red. Woke up next morning, eye was crusted and puffy. Seen at Golden Health, diagnosed with conjunctivitis, given antibiotic eyedrops. Released to full duty.
220251470009M13578Employee was working in the preheater tower; EE was wearing a face shield and safety glasses. When EE lifted up the face shield the dust that accumulated on the rim of the shield fell into EE's face getting dust in EE's left eye. The employees' eyes were flushed immediately, the employee followed up with a clinic and was prescribed prescription eye drops.
220251470010M12656On Friday, May 16th, 2025 about 9:30am, it was observed that some of our ventilation structures on the lower west section had been compromised. As an abundance of caution, we evacuated the mine. Ventilation was restored and normal operations began Tuesday evening. 
220251470011M11183While removing rocks from side of crusher, a rock rolled down and pinched EE's left index finger against another rock.
220251470013M11303Two piles of mulch/strippings were discovered smoldering at a stripping operation.  Ignition source unknown, No damage or injuries
220251470017M11874Employee was accessing conveyor to clear rocks from the belt and slipped and landed on catwalk on EE's left shoulder and hip. EE was utilizing fall protection at the time of the incident.
220251470019M12856While employee was attempting to pick up wheel chocks, they felt a pop in their wrist. Employee was given first aid by security and was seen at occupational medicine days later for continued pain. Employee was prescribed a splint and work restrictions resulting in days away from work.
220251470020M12055EE reports pain and swelling to right knee.  EE reports was in the Komatsu truck 845 for 12 hours on Monday, recognized right knee pain and swelling on Tuesday morning upon waking up.  Reported on 5/16/25.
220251470021M13638The IP stepped up 18 inches to a semi-trailer, while stepping the IP heard a pop in left knee, then fell back landing on the hitch area of the semi tractor, ERT members stabilized and on site then transported to the ER to continue treatment. Employee was released from the ER on the 11th, then on the 15th, was released to restricted duty by a orthopedic surgeon.
220251470022M11784employee slipped on rocks and scraped their left arm and right hand. Initially it was a first aid, however few days later it got worse, and employee was diagnosed with cellulitis
220251470023M11363The IP arrived at the onsite clinic reporting apparent groin discomfort with an apparent hernia, they left site for further diagnostics.
220251470024M13768EE was sitting in cab being loaded. On last pass there was a large boulder that was too big to go through the opening of the shovel so the operator "shook it" off, the boulder hit the overshot on the bed of the truck, shaking and bouncing the truck. EE reported, asked to be seen by doctor on 5/20. Diagnosed with cervical pain and thoracic sprain, released with restrictions.
220251470025M10812Employee was shoveling when they felt pain in leg - became reportable on 5/9/2025
220251470026M12756Employee was dismounting from equipment. While activating the ladder to exit, they began descending before the ladder had fully reached the ground. As a result, the ladder accelerated rapidly. This sudden movement caused employee to lose balance and fall sustaining injuries.
220251470031M12756two employees were putting a floor jack onto a flat bed one was lifting the other was on the truck lifting with a strap when they got it on the bed and went to set it down the jack shifted and the handle hit the employee on the truck in the head on the ear giving them a cut.
220251470033M11844Scale Master, slipped and fell, walking down aggregate and dirt embankment. They fractured the right side of their left ankle and caused a hematoma on the left side of their left knee.
220251470038M13297Employee was working on housekeeping around the plant. While working with the vac-truck operator employee was giving hand signals to the driver during the backing up process. While doing this their feet slipped and they began to fall. during this process their right leg became entangled underneath them and they broke their leg.
220251470040M10842Barge loader was moving a piece of cable.  Pulled back while pulling to move cable. 
220251480001M12395Operator was leaning out of the cab of a mucker and was bracing self with EE's left hand against the rib when several rocks broke free and struck EE's left hand and arm, causing a laceration to EE's middle finger that required 10 stitches.
220251480003M13227Operator was assisting with metal cutting and handling. Afterward, EE felt irritation in EE's eye. EE attempted to flush EE's eye, but EE was unable to dislodge the object and was taken to the emergency room for treatment. The object work itself out on its own, but prescription antibiotics were prescribed (precautionary)
220251480006M11955A maintenance mechanic was troubleshooting a hydraulic leak on a Cat D10 dozer under the floorboard area. During this inspection, pain was felt in the knee that resulted in restricted workdays.  
220251480007M11153Employees arrived for the shift to find a backhoe on fire. Cause of fire was determined to be a lightning strike.  
220251480008M11043A wrench was struck with a hammer to loosen a nut. When employee's thumb was struck, causing a fracture.
220251480009M11654Driver and injured employee were removing a small amount of material from a dump truck to obtain a legal weight.  The tailgate pinched the injured employee's finger.
220251480010M13798The crew was laying 2" poly pipe, the end slipped, striking the miner in the face below right cheek bone. Employee refused treatment at the time of the incident. Several hours later it started to swell. Employee went to the emergency room Sunday (5/18/2025) as the swelling in the cheek would not subside. It was reported to me that employee suffered from a fractured cheek bone.
220251480011M11784Employee was cleaning out the grizzly with a sledge hammer when they were hit on the head with a rock that knocked their hard hat off, a second rock fell hitting them in the head
220251480012M12025EE was using a utility knife to cut a media screen. While cutting the screen, the utility knife slipped cutting the top of EE's left thumb. The EE was taken to the emergency room and received stiches.  
220251480015M13528Employee was operating an excavator, they felt some pain in left elbow/forearm area but continued working.  On Sunday, 5/25/25 EE was at home working on personal vehicle, and felt the same pain, and went to the emergency room to have it check out.  Possible left forearm muscle sprain, with doctor advising "avoid activity that causes pain for 7 days".
220251490001M13828Miner was assisting to shift the width of the forks on an extenda-reach forklift.  While moving the forks, the miner felt a pain in EE's right forearm. The injury was initially treated as a first aid sprain, but the extended healing process led to a need for imaging which revealed a tear requiring surgery to repair. The determination that surgery was required was made on 5/16/25.
220251490004M11904EE was pressure washing the welding truck and stepped up on the mounted tool box to get behind the cab. When EE stepped down, EE's foot landed on a angle iron bracket, and rolled EE's ankle.
220251490005M13798Plant operator suffered Dehydration/Heat Exhaustion while working outdoors. EE was drinking water all day but was not alternating with electrolyte rich fluids. After sitting in the shade for a while, the EE stood-up and felt light headed. When the EE experienced cramps requested medical attention. EE was transported to the local hospital where EE was administered 3 bags of IV.
220251490008M13648While lifting angle iron with a telehandler, a fork caught on a welded piece of metal on the side of the scale platform. When the weld broke, the fork sprang upward, jolting the angle iron upward, which struck the mechanic's jaw. First aid was applied, but on 5/21/25 EE reported ongoing pain. On 5/27/25, a CT scan revealed a closed fracture of the right maxilla.
220251490009M12696EE was closing the door to the passenger elevator. EE pulled the rope to close the door to the elevator, the door came down faster than expected and smashed EE's left hand between the top and bottom doors.  Left hand smashed. X-ray revealed 2 broken bones in EE's hand.
220251490012M12005EMPLOYEE WAS WORKING IN ZINC TUNNEL IN THE MILL MAKING SURE THE SUMP WAS GETTING ENOUGH WATER WHEN A 12' LONG 2-1/2" IN DIAMETER PIPE FELL AND HIT EMPLOYEE IN THE BACK OF HARD HAT / NECK / SHOULDERS. 
220251490013M10431CARPAL TUNNEL SURGERY RIGHT CTR / RIGHT UNT
220251490014M12446On 05/08/25 employee struck in arm by foreign object did not report the incident. The following week the incident was reported. Foreign body removed. 4 stitches received. Notified 05/27/2025 that the injury was accepted as an industrial injury.
220251490015M10902a miner's tip of EE's pinky was crushed between flanges while moving a large flexible hose
220251490016M11213Nipper tripped while carrying a small section of bull hose, put a hand out against the rib and injured their right wrist.
220251490017M12686During the heavy rain down fall near the end of the shift on 2nd shift, a rock from the rock pile came sliding down the pile and struck the right-side window of loader, breaking out the side window and striking operator on left knee area causing a laceration to knee. 
220251490021M11814Employee was walking in the tie down area around the water truck, when they slipped and landed on their right wrist, resulting in a fracture. Employee was placed on restricted duty.
220251490022M13167During installation of drive belts on Warman Pump employee received a laceration on left pinky finger. The belts had already been installed. Employee was manually turning the shiv to check belt tension when the tip of finger was pinched between one of the belts and the shiv. X-rays revealed a nondisplaced fracture.
220251490023M10762Employee was stepping off equipment, landed on a rock and sprained an ankle.
220251490024M12636During hoist checks, the tanks for the pneumatic system did not refill. Issue could not be resolved within allotted time frame, so EVAC was called. Cause of issue was found to be a rubber gasket from the oiler blew out and lodged itself in the #2 pneumatic valve.
220251490025M11704Miner was carrying a motor tophat to JetMill #6 and slipped on the 3rd step on the stairs. Miner was holding the handrail in one hand and the motor top hat in the other. 
220251490026M11083Employee was helping other employees carry a metal plate and they dropped it on their finger, fracturing it.
220251500006M11444Employee was performing EE's area work inspection when EE slipped and heard a pop in the right knee. Resulted in aggravation of old knee injury.
220251500007M10822EE lifted right arm preparing to lower a ladder and felt pain in right arm/elbow. 
220251500008M11734Employee was installing a new bearing using a 10lb sledgehammer when they hit their foot just past the steel toe. resulting in the fracture of the minimus pedis (Little toe)
220251500009M12726Employee was preparing ore samples in the ore prep lab. While using the "Mill Mate" to assist in carrying the sample the employee's left foot slipped which caused the employee's left knee to "twist". The employee reported the injury and was taken to Medic for evaluation. 
220251500010M11373Employee was operating heavy equipment when they started feeling pain in lower back - employee was unsure as to what initially caused it.
220251500011M13638Employee reported intermittent left knee soreness at the end of shift, but couldn't think of any incident or event that could have caused it and didn't think that it was work related.  The employee sought medical care when the issue didn't resolve, and was advised that it could be related to repetitive pushing of the clutch pedal on the site's front end loader.
220251500013M11614Employee was on the wash plant main screen deck cleaning off the walkway when a rock bounced out of a nearby in-feed drop box and struck the employees left hand.
220251530001M11774While working on classifier tank exchanging hydraulic cylinders. An employee didn't realize there was someone below and threw old cylinder over side.  Striking employee on head.
220251530002M11123Employee was cleaning a belt roller when it popped off and smashed EE's finger between the roller and angle iron
220251530013M12536The employee was removing a piece of concrete block that entered the feed hopper and got stuck under the angle iron on the conveyor guard. They tried pulling the block under the guard and heard a pop in right biceps with a sharp pain up into their neck.
220251530014M12085Operator was attempting to unplug the west silo (the south leg) with a hooked water hose, as employee was moving the water hose in and out of the opening, they started feeling pain in Left Lower Side of Back.
220251530015M12536Employee had finished servicing the dozer, climbed back on to remove lockout lock, slipped and jerked their shoulder. They refused treatment, but the next day took themselves to the ER, was taken off work until 5/27, was reevaluated and released to work
220251530017M13628At time of injury employee was operating an electric winch. Employee was operating pendant controller guiding the winch cable onto the cable drum with right hand as the grinding cylinder was being hoisted into position, when right  glove got caught on the cable and it pulled right index finger into the cable and drum. Employee has not missed anytime from work.
220251530019M1224510'x 4' metal sheet was being placed in crusher hopper when weld failed holding lifting device. Metal dropped approximately 8" landing on operators left foot above the steel toe. This broke 4 bones in top of operators foot. 
220251540001M10872Employee alleges that while cleaning a metal beam, a particle fell into EE's right eye.
220251540006M10892Employee has a confirmed STS in EE's left ear that has results in a loss of hearing >25dB
220251540009M12255Lowering a piece of grating and felt a pop in right elbow. Seen at on-site medical facility and released. Still felt pain a few days later and went to personal physician on 5/27/25 where it was found EE had a torn right bicep
220251540010M12155Employee was power washing the right port of the RK 1 Ram W, struck a pocket, causing hot material to blow back on EE. Employee jumped back to avoid material and hit EE's head on pin gate. Employee received sutures.
220251540012M13257While positioning a feeder for install with three other miners the employee pinched right middle finger when unhooking a chain hoist hook and the feeder moved unexpectedly. The pinch removed the tissue from the tip of the finger. The result was an partial amputation of the tip of the right middle finger performed at the ER.
220251540014M12035Employee was in the process of changing the bucket on the skid loader bucket. During this process the bucket came off of the mounting tab while in the air and the bucket came down on employees right foot
220251540015M10441Employee sprained ankle during normal travel
220251540017M13317A maintenance technician was performing work on an UG haul truck in the maintenance shop (located on surface). The mechanic needed to remove a rock that had fallen onto the top deck of the truck. While removing the rock, the rock slid out of their hand, causing a laceration to right thumb. The operator was wearing nitrile gloves.
220251550002M13548Operator was setting up to fill the hydraulic oil on the Wirtgen 2200 Surface Miner. This involves hinging a plate metal cover back to access the tank cap. After the cover was hinged back, operator placed EE's left arm on the top step. The cover swung down from it's position, striking the operators left arm causing a fracture to the forearm/wrist area.
220251550003M11363EE was trying to lift new bearing housing into place on take up. EE said EE was in an awkward position and said EE hurt EE's left wrist.
220251550004M12265EE was pulling the fuel hose out of the fuel truck, as EE was pulling the hose out of the fuel truck, EE was walking backwards pulling the hose and EE tripped on a couple of large rocks causing EE to fall and twist EE's ankle.
220251550005M13107While conducting R&R on a new conveyor (not energized) digging bar slid/fell onto a miner's hand causing a laceration to the miner's thumb. Initially it was believed to be controlled with gauze/bandage however due to bleed through etc the miner was sent to a clinic and was given 4 stitches to close the wound.
220251550006M11393The employee was clearing a material jam from the jaw crusher. EE lost EE's footing and fell onto the deck with EE's ankle bent beneath EE.
220251550007M10852EE's left foot slipped causing left hand to slide down the siding they were removing.
220251550008M11794While miner was disposing of hydraulic buckets, the handle broke off leaving a laceration on the miner's finger. The miner was transported to the hospital and received 3 stitches.
220251550010M10882Employee claims they slipped and lost footing and fell and hit their head on the ground.
220251550011M13267Employee was working on the Jaw Feeder and was removing the Jaw Grizzly Bars. EE was helping to remove the old Grizzly Bars. One of the bars hung up while EE was trying to move it. When the bar broke free, it rolled over and crushed left hand-index, middle, and ring fingers. This resulted in lacerations to all three fingers.
220251550012M10902Employee was coming down steps on haul truck and missed step - Became reportable 5/20/2025
220251560001M11674Employee was striking a steel pin when a metal shard broke off and embedded in EE's leg.  After metal shard was removed, a stitch was required to close the laceration.
220251560007M13147Supervisor decided to help out EE's crew with shoveling under the crusher for about 20 minutes. EE felt some tension on EE's lower back but did not think much of it. The next morning on 05/27/2025 EE decided to rest it off because EE felt pain. EE refused medical attention stating that it would go away with rest.
220251560008M12476Large bridged rock stuck in the jaw crusher. Crusher was lock/tagged out and employee was removing rock. Rock shifted and pinched EE's pinky finger causing a fracture. Finger was splinted at hospital and employee was returned to work at full duty.
220251560009M11914EE was attempting to unplug a triple gate at the coal mill with no success. EE then introduced EE's hand into the triple gate. The gate activated, nipping the tip of EE's right middle finger.
220251560011M13197Employee was inspecting a lube pump and removed the cover. After the inspection the employee proceeded to replace the cover when it slipped out of EE's hands. While attempting to catch the cover the employee's right middle finger went under the seesaw mechanism causing a fracture to the tip of the right middle finger.
220251560016M11003The over travel switch malfunctioned causing the service hoist to be unavailable. EVAC was canceled.
220251560017M11894EE Reports left shoulder pain from excessive vibration and movement in the heavy equipment that has become worse since. EE reports pain with decreased range of motion in the left shoulder. 
220251560018M12806Felt pop in left foot while walking across uneven, muddy, relatively flat ground. No other contributing factors or known causes.  Drove themselves to occupational health clinic which prescribed medication and advised to avoid prolonged standing which does not restrict job duties.
220251560020M11694Miner was using a pipe wrench to remove an incline water strainer, and when the fitting broke, the wrench to slam against an I-beam pinching the right-hand pinky finger.
220251560024M13668Employee was cleaning material off 117 conveyor belt when they felt a pull in is abdomen/groin they reported this to supervisor and denied care at this time. The employee reported to safety on the 27May2025 they were still experiencing pain and we called care and EE was given a home care plan with no relief they were scheduled a clinic visit for further treatment.
220251570001M11674Employee was walking through the plant, near the Raw Mill.  They slipped on wet, slippery ground and fell forward, landing on their hands (straining their left wrist).
220251570003M13137An operator was driving a haul truck down a heading when the haul truck started to slide on a downhill grade. The truck slid for roughly three headings then overturned in the travel way. The operator was wearing a seat belt and removed from the cab. EE was diagnosed with a hairline fracture on EE's left clavicle
220251570005M12716Employee failed annual hearing test on 5/9/25 and was retested on 5/28/25 where it was suspected of an STS in left ear, A 3rd party audiologist confirmed this to be a reportable shift of the left ear on 5/29/25 via e-mail to operator making this a reportable hearing loss
220251570006M13808MMGs were prepping belt for splicing PP-P3. MMG picked up 1/4" die grinder w/buffing wheel, pressed trigger to test prior starting work. The quick connect holding 3" buffing wheel sheared at the base of the shaft nearly instantly upon rotation, sent buffing wheel/quick connect spinning to the right side of the tool, striking a nearby MMG ~3 ft to top of left-hand knuckle area. 
220251570008M11083Employee felt a pop in their left knee when they were getting into the work truck at the end of their shift.
220251600001M12235Employee was walking up steps to get to 5-1/2' cone crusher when EE tripped on the 5th step and fell hurting EE's left leg above EE's ankle. EE was brought to the emergency room by EE's supervisor and put in a walking boot.
220251600002M10832Employee tripped over a pallet, fell to ground and caused a contusion to right arm.
220251600003M13287Miner failed to adequately support a worn cutting edge while trying to replace it from a scraper bucket. The worn cutting edge fell onto the miners leg causing a bruise and possible strained muscle in miners leg. The miner missed 5 days of work with sore leg and returned to work 6-4-2025.  Miner was released to work by doctor.
220251600006M10401experienced fire on CAT 982M yard loader
220251600009M11263EE1 was getting in the man basket. EE2 was already in man basket and moved it pinning EE1 leg between basket and concrete wall
220251600010M10892Guard crooked; shifted & caught finger between bolt & guard; fractured right index finger
220251600011M10482Tripped on pallet and EE kicked self in the calf
220251600013M11784A miner twisted their knee while moving a tank grate from a welding table to a cart. The miner was seen at a local emergency room and received a knee brace and job restrictions. 
220251600014M13428An underground employee was injured on 5/30/2025, during the unsafe operation of a Kawasaki ATV Mule. The employee was traveling in reverse and rolled the ATV with another employee on board. This incident was not reported to management until 3 days after the incident. The employee states they received medical treatment on the day of injury.
220251600015M13798At approx. 9:20 AM, EE was installing a side shift slide on FL177. While reattaching the carriage to the mast, it slipped and fell, pinching R index finger between the backrest and mast. EE sustained a fractured n lacerated finger, requiring sutures, x-ray, splint, and medication. Able to work-restricted from using (r) hand at work but later changed to limited use of (r) hand.
220251600018M13698An underground employee was injured during the unsafe operation of a Kawaski ATV Mule. The employee was traveling as a passenger on the ATV which was being driven in reverse by another employee. This incident was not reported to management until 3 days after the incident. The employee received medical treatment the day of notification, and after receiving suspension.
220251600019M11444Employee was walking and the ground was wet and muddy due to rain and slipped and twisted right ankle causing a break in one of the ankle bones.
220251600020M13127Mine Tech Employee mentioned a "twinge" in their leg to a co-worker approximately 30 minutes prior to the end of their shift. About an hour after their shift, Employee reports the pain their leg had intensified to the point that they could barely walk, at which time they contacted their supervisor to report it.
220251600023M11193Transfer case caught on the rear bed guard and then fell onto IP's finger causing a laceration to the left ring finger.
220251600024M10722EE was working on loader seat and got hand pinned between scissor frame.
220251600025M10892Electrical contactor failed on the production hoist causing the hoist to be inoperable.  
220251610003M13428Maintenance Mechanic working on a bearing to a fan completed the repairs and was re-installing a pulley guard, the guard got stuck and as the Mechanic pulley on the guard to free it to complete the installation EE's (R) ring finger and pinky finger got pinched between the guard and the fan. Causing a fracture to the tip of EE's ring finger.
220251610005M13568On 05-29-25 employee alleges a strain to the left lower back when operating a CAT 769D haul truck. EE states that the initial left lower back strain occurred on 05-28-25. While the employee was attempting to move a pallet with a pallet jack. On 05-30-25 employee was treated by a MD for a strain to the left lower back, resulting in modified work activity.
220251610006M10431Employee was cutting the rubber on a screen
220251610010M11714While scaling, loose material fell from the rib and rolled over the EE's ankle causing a sprain/strain of the ankle. The EE was placed on restricted duty by the physician.
220251610012M12917While scaling, loose material fell from the hanging wall and landed on the scaling bar. The scaling bar was pulled from the EE's hand causing the EE's arm to get pushed back and twist. This resulted in a torn ligament in the left bicep. The EE was placed on restricted duty by the physician.
220251610017M11043Employee was walking when they tripped and fell on metal grating walkway causing abrasion on right wrist
220251610018M11824Employee was fusing 4-inch T's when the employee bent over and grabbed the handle of the fusion machine. The employee's lower back locked up. The employee stated pre-existing injury.
220251610020M13818While collecting process solution samples from the leach pad an employee was descending down the ditch where samples are taken. While walking down the ladder used to travel up/down the ditch a step broke allowing the employee to fall backwards on the side. On 6-4-2025 it was determined they suffered a fractured L1 vertebra. The employee's first day missed from work was 6-6-2025.
220251610021M11634This injury was classified as a first aid and then later diagnosed on June 4, 2025, as a possible meniscus tear, and will need to be scoped to identify the injury.
220251610022M10892Bobcat operator struck a fixed object.  Reported to company on 5/29 when occurred on 5/5.
220251610023M11413While preforming an inspection on the Alimak, the cage surpassed a limit switch that caused a fault resulting in the Alimak to be inoperable.
220251610024M11644A maintenance employee was welding on a haul truck bed in wet conditions and received a shock. As a result, a physician has placed the employee on restricted duty. 
220251610025M10351Employee fell and broke right ankle
220251610026M11363Mechanic was assisting face drill operator remove broken drill steel.  The wrench slipped hitting the employees hand causing the injury.
220251610027M11534EE was loosening a drain elbow on the HP3 cone hydraulic tank. The pipe wrench EE was using slipped from the plug and EE hit their hand on adjacent beam.
220251620001M12716Ee was working to break sub loose on drill steel. The wrench they were using turned in the opposite direction the ee expected it to, and it struck the ee on the right ankle. Ee seen at the ER, diagnosed with a fracture, and referred to ortho. Released to restricted duty.
220251620002M11684While moving a troughing roller frame assembly on 10 Conveyor, Line 3 in the Tilden plant, an employee pinched left thumb resulting in a laceration requiring 2 sutures.
220251620003M10862While washing a glass beaker in the lab, the beaker broke and cut the employee's hand.
220251620005M12957The employee was assisting a co-worker in positioning the track mobile onto the tracks in alumina shipping. While EE's hands were resting on the top rail, the track mobile slipped off the tracks, causing EE's hands to drop onto the bottom handrail and resulting in an injury to this right wrist.
220251620008M13357The injured employee was assisting on stemming a shot by raking material from an excavator bucket into the holes. EE claims EE's right shoulder popped. EE continued working until the job was complete. EE then got in a haul truck to move material and said while EE was being loaded, the truck shook and EE's shoulder began hurting more.
220251620009M12215Right pinky finger got pinched between the spacer and the housing of the bearing unit. While trying to remove the lower shaft and bearing on a double screw material washer. Received 1 stitch at ER to close up laceration. 
220251620012M11143Employee was checking froth quality at cleaner cell when finger became pinched between froth paddle and cell weir.
220251620013M10852Weather was clear.  Right ankle. Cleaning belt; felt/heard snap then my ankle rolled.
220251620014M12776After completing shift, employee was walking to the parking lot, after a light rain shower, and while attempting to walk around puddles slipped but didn't fall. They reported off work that evening due to pain, was seen at the clinic the next morning and placed on restrictions.
220251620015M12125Employee was carrying a roller can walking down a slight incline when they slipped causing them to break their left ankle. There was loose material on incline, and work boot did not have sufficient ankle support.
220251620016M12576The employee was working with another employee replacing a conveyor roller. The injured employee was holding the roller as another employee was taping it in place with a 3-pound hammer. The injured employee moved their hand, and it was struck by the hammer.
220251620017M11444using a rachet wrench on a bolt and felt a pain in arm, was released full duty and the symptoms worsened. Employee was put off work on 6/10/2025
220251620019M11784Bent over to pick up a folded up 4 ft ladder and when they bent over they fell forward and caught themselves with left arm and strained or tore a tendon near bicep/shoulder area.
220251630002M11914Employee was climbing down from the cab of EE's loader and as EE got to the last step EE's right hand slipped off the handrail and EE fell to the ground causing injury to EE's right shoulder.
220251630008M13047During crusher maintenance that involved rotating crusher blow bars, one employee was using a sledgehammer to dislodge the blow bar wedges. While striking the wedge, the employee missed and inadvertently struck the rotor. As a result, a metal fragment broke off and struck a nearby employee in the chest.
220251630009M13849At 8:30 pm the driver on a water truck was watering a road and hit rumble strips. The truck hit the strips and the employee was thrown forward and then pulled them back in the seat causing pain in the neck. EMS was called went to the ER for further eval. The truck was taken out of service so seatbelt could be checked and the road was graded. became recordable 6/10 with restrictions
220251630013M11474Removing skid plate from a haul truck and the plate shifted. Struck IW in chest/shoulders. Contusions and general soreness, has follow up on 7/3/25
220251630014M11313While installing a heavy iron liner into the mixer at the batch plant, the employee suffered a muscular injury in their left bicep.
220251630015M13758Employee overfilled the Diesel Exhaust Fluid tank (DEF), causing it to spill on their clothing & glasses. A drop of DEF entered left eye. They immediately flushed with water, then changed into clean clothes. They requested a medical evaluation to ensure eye was okay. They were taken to ER, where they were examined & medically cleared to return to work without restrictions.
220251630016M11684While closing the spring-loaded lid on the pulverizer, an employee's hand slipped, causing the handle to pop up and make contact with their lip, resulting in 3 stitches
220251640002M10952Employee was pulling on a hydraulic hose to remove it from drill. Pulled left pectoral muscle. 
220251640003M13788An employee was WOMA Gunning the tower on the 2.1 level when a chunk of material fell on the wand and caused the employee's right arm to be jerked. Employee reported to supervisor, but did not want any medical treatment at the time of reporting the incident. On 3/13/2025, employee still felt soreness in their right shoulder and requested to be evaluated. Had surgery on 6/9/25
220251640004M12756Climbing into the 490 excavator.  EE placed foot on step, grabbed handle with right hand and then grabbed left handle with left hand.  As EE added weight to foot to hoist self up EE's foot slipped and EE's left hand lost grip, leaving EE's right arm to catch all EE's weight.
220251640006M12606On June 2, 2025, an employee was assisting with the installation of a packer intended to control a high-volume, high-pressure water leak at the mine face. During the operation, the employee began stepping back and turning, the employee twisted EE's right knee.
220251640007M10502Hand Scaling on JLG rock fell and struck employee.
220251640010M12706Employee was greasing when EE stepped down from elevated platform (2 step) EE's left ankle rolled fracturing EE's fifth metatarsal. Employee was initially being treated with conservative care however went for X-rays on 06/11/2025 where it was determined to be fractured.
220251640013M13458While feeding material into a material bin with a feed screw. the employee used a shovel handle to push the material into the feeding screw. The feed screw grabbed the handle and the handle hit the employees face and the employee received a cut that required first aid. There were no stitches; however, a 7 day cycle of antibiotics was provided.
220251640014M12486Employee was mining underground with a pneumatic chipping hammer.  The chipping hammer glanced off a rock causing the moil to puncture the employees right foot. Employee was treated with basic first aid on site and then transported to medical care.
220251640016M13598An employee was installing a spray bar on a wash screen. EE dropped the spray bar on EE's right index finger while attempting to bolt down the spray bar. It fractured the tip and caused a cut requiring approximately 6 stitches on EE's right index finger. Two other employees were on the other side of the screener, but neither visually witnessed the accident.
220251640018M12766The employee was lowering a coil of hose from on top of a silo to the ground using rope. the weight of the hose caused the employee to lose grip on the rope momentarily. When the employee regained grip on the rope, they hit their right thumb on a guardrail causing the injury.
220251640019M13368The coworker was carrying 2 flat plates of steel weighing approx. 22lbs combined weight when they felt a pain in right shoulder. They stated that it felt like they were stung with a rubber band. Their shoulder began to bother them and their fingers were getting numb. Health line was contacted and was advised to seek medical attention.
220251640020M11945Coworker was changing a troughing idler on conveyor.  As they were pulling it out, the idler dropped and their finger was pinched against the frame.  Resulting in 5 stitches and restricted duty.
220251640021M13838EE began experiencing pain in right shoulder while working on the control cards on the #5 dragline. EE states the repetitive movement & the work to get the cards in and out of the slots caused the problem with the shoulder as the work was difficult & repetitive. EE states decreased range of motion due to pain. Denies previous problems with shoulder & is unable to work due to this.
220251640022M12025Two employees had set a beater return roller on a lower frame part of the stacker frame of the conveyor; the roller slipped out from the frame and came into contact with injured employee's index finger.
220251640023M12015Worker was placing bag on fill spout and put their finger under the bag clamp. The clamp crushed the tip of their right ring finger causing an open fracture of the tuft of distal phalanx of the finger.
220251640024M12335The employee was assisting in connecting a bypass chute to a tub on a crushing cone. The chute became hung up on a catwalk and suddenly released, striking the employee's leg. The employee received a laceration on the upper left leg. 
220251640028M10552Employee slipped while walking out of enclosed trailer.
220251640031M12866Employee suffered chemical burns after work poking on 5 reject dust containing CKD. EE had initial skin irritation and didn't report the event. After the injury worsened on June 9th, they reported to their supervisor. On June 12th, the medical report stated it was a second-degree burn.
220251670003M11253While Opening a Rotex Door Employees hand was pinched by the latch of the door causing a laceration to the left Ring finger. 
220251670004M12466EE was performing general HK activities dumping wheel barrels in the cooler basement and bumped EE's right shoulder on a conveyor scraper. EE was in contact with the onsite nurse for conservative care. On 6/12/25 EE asked to be sent to Concentra.
220251670007M11955Employee was running skid steer when the machine came to a sudden stop. The employee's momentum did not stop and EE hit EE's head on the rear view mirror, causing a laceration requiring stitches.
220251670008M12726Employee was working restricted duty from a previous personal injury, failed to remember not to pull with right arm, and used the grab bar while mounting pickup and dislocated shoulder. Employee was taken to the ER, referred to ortho and taken off work. Currently ongoing.
220251670009M12666Employee was bumping the bottom of tank C1 on the 2nd floor of shipping department and the flop- gate assembly broke, fell off and landed on top of EEs hardhat.  EE's hard hat was displaced, and part of the assembly struck the left side of EE's head at the hairline.
220251670010M12375EE stepped out of the manlift basket onto the roof connected to a Miller retractable lanyard. The roof collapsed under EE and the lanyard did not engage to stop EE's fall. EE sustained broken ribs, punctured lung and scrapes and bruises.
220251670011M11083Employee was cleaning dump in dozer and ran over rock injuring back -- Injury became reportable on 5/31/2025
220251670012M11073Employee was operating shovel, swung shovel dipper around and felt back pain -- became reportable 5/31/2025
220251670013M10321Employee cut finger with grinder
220251670014M12075Employee was feeding a cathode through the roller when the end of the cathode grabbed the tip of their left middle finger and pulled their hand into the guard. Resulted in avulsion of left middle finger tip.
220251670015M11013Employee strained shoulder muscle while trying to remove a motor from the top of an air receiver tank
220251670018M13668An employee attempted to break a rake handle by stomping on it. During the attempt, the handle recoiled and struck the employee in the side of the stomach. The pain from the handle caused them to lose consciousness while walking back to the break area. The employee fell down approximately 10 stairs, sustaining two lacerations to the left knee requiring 19 staples.
220251670024M10552Ground fault shorted out #3 hoist motor causing arcing.
220251680003M13097Loader Operator backed down the feed ramp for the mill with a loader as a contractor dump truck was backing into the bay perpendicular to that ramp.  The dump truck struck the side of the loader tire and counterweight shifting it to the right and in the process strained the muscles in operator's lower back. 
220251680004M10963The miner's arm was caught between two blocks leading to pain and swelling of the right forearm.
220251680005M12105The employee was walking down the steps from the south Ottawa mine screenhouse when EE slipped and fell. EE caught self with EE's right hand on the handrail and felt immediate discomfort in EE's right shoulder.
220251680007M13598While descending from a roof bolter, EE planted EE's right foot at the edge of the cab when EE lost EE's footing and missed the top step, causing EE to fall approx. 5 ft. onto EE's right shoulder. On 6/3/25 EE was evaluated at Ohio Health Work Health where EE was diagnosed with a strain and given pushing/pulling/lifting restrictions of 10lbs with right arm.
220251680008M11303Employee was repairing a hose and accidentally hit the valve causing water from a pinhole in the hose to spray into EE's left eye.
220251680009M13107Employee was helping put a saw bar back on the saw as EE was adjusting the bolts to fit back in the bolt hole, a team member moved the bar by hand resulting in the bar shifting positions and pinching the employees hand in a pinch point. The employees palm and thumb were caught between the saw and bar briefly.
220251680010M10882Employee attempted to relocate a rattlesnake when the employee was bitten on the finger.
220251680011M11273Truck driver was walking toward line up room in parking area. EE rolled EE's right ankle which resulted in an avulsion fracture
220251680012M10582Employee was walking on crushed material and twisted ankle
220251680013M10812Production skip components failed causing the hoist to be unavailable for egress.
220251680015M13498Employee drove out into the field to fix a machine. When they got to the machine, the service truck they drove was smoking. Employee went to open the hood to examine the engine to determine the cause of the smoking, but when trying to unlock the hood, the antifreeze sprayed their left hand, causing a second-degree burn on index and middle fingers.
220251680016M12806At the beginning of the shift in the parking lot, an employee was moving their personal firearm from car's console to a discreet location when the firearm discharged. They sustained a minor wound to their leg that did not require stitches.  They was released to work on June 16th.
220251680017M11444Employee was cutting zip ties off a set of new loppers and as they were pushing on the box cutter, it went through the zip tie cutting a finger.
220251680018M10952Miner was climbing into the loader and slipped and hit their shin. Sustained a cut on the shin.
220251680019M13307A miner was performing housekeeping duties by sweeping material between two conveyors into an access hole to a bin. As they backed up and turned to get more material, they stepped into the access hole with their left foot causing their right ankle to bend. The miner was seen at a clinic and given a walking boot and restrictions.
220251680020M13227EMPLOYEE WAS TRYING TO UNCHOKE THE ZINC 1ST CLEANER LAUNDRY DISCHARGE LINE. A WATER HOSE WAS IN THE CHOKED-UP LINE, THE EMPLOYEE WENT TO PULL THE WATER HOSE OUT OF THE LINE. AS EE WAS PULLING THE WATER HOSE OUT OF THE PIPE, THE PIPE DISLODGED OUT OF THE PIPE CONNECTOR HUGGER AND FELL HITTING THEIR LEFT ARM AND LEFT HAND.
220251680021M10492Employee had foreign material blow into their eye
220251680022M11824An employee was working on an Auto Valve, when the handle was pulled, it came loose and the employee lost their balance causing them to fall. Resulting in a fracture on fibular head.
220251690003M11764Shovel Operator was exiting the cab when EE tripped and fell on the metal grating. EE has cuts to EE's eyelid, cheek, nose and lower lip. EE received two stitches to lower lip.
220251690006M11193EE was welding, and when EE finished with the rod, threw it from the holder. The rod fell into EE's boot and burned EE.
220251690008M10993Employee was setting up a conveyor when the landing leg fell on EE's foot causing a fractured bone.
220251690009M10742Normal working conditions. No outside contributing factors to the injury. 
220251690010M11914Employee knelt down to work on a forklift lift chain. While kneeling down, the Employee felt a pop in EE's left knee. On 6/10/2025 Employee sought medical treatment and received restrictions.
220251690012M10492CARPAL TUNNEL SYNDROME RIGHT ELBOW AND RIGHT HAND
220251690013M11955Employee was attempting to pull a hydraulic splitter up from a block.  It was stuck in the drill hole; they pulled with more force to free it and felt a pulling sensation in their abdominal area.
220251690015M12065While doing normal operations by the south high pressure back pressure to bring up the plant, employee had a hole in their left boot causing caustic to get inside. Their left great toe/foot started to hurt.
220251690016M10542EE had the post bar slip and hit them in the forehead.
220251690017M10782Pulling a pony motor and the cord recoiled quickly jerking the employees hand.
220251690018M12055Employee was shown how to remove the piston which needed the leaking O rings replaced, Using a little air pressure. Employee instead used for air pressure and the piston came down and injured their fingers
220251690019M13648Employee was cutting interior flooring of dump truck installing new ones and cutting to size. The blade slipped out of flooring and cut into left wrist which was holding flooring up to cut flooring easier. 911 was called and employee was transported to hospital where they received stitches in left wrist as well as prescribed 600mg of Motrin and 500mg of Tylenol.
220251690020M12135EE was dismounting dozer, fell backwards off track, landed on bed pad with left hand, causing puncture wound. Seen at Health, diagnosed with puncture, released with restrictions and site is offering modified duty.
220251690021M13849Operator of dozer was starting a new slot and as the material fall away ahead of the blade, the dozer operator quickly reversed and tracked over the previous slot embankment edge. The dozer laid over onto its left side, operator was wearing their seatbelt and was able to self-extricate. Operator was then sent for evaluation at an off-site clinic where they were issued restrictions.
220251690022M13167The crew was performing a screen change on our K300 Cone Crusher.  While exiting the manufacturers platform onto the factory installed ladder employee missed the second step down from the top of the ladder, lost grip on the factory installed handrail and fell to the ground.  They landed on their back and left side.
220251710008M11333While a maintenance employee was installing a spring on a fan belt, a ratchet slipped causing a deep laceration on EE's left forearm.
220251710010M12596Employee was shoveling off the primary belt at the crusher and when EE went through the railing to get onto the belt, EE felt a burning sensation in EE's back. This injury was originally a first aid incident, but on 6/17/25 the employee was taken out of work.
220251710011M11965At approximately 10:30 PM, the number one main fan went down due to mechanical issues. Based on the inspection, it appears the impellers came off, the bearing locked up and it went high amps/temp.
220251710013M11113It was a clear summer morning. Miner was working in a group replacing the impeller on a pump that had gone out.
220251710015M11965Miner was re-threading stretch wrap through the stretch wrapper and unexpectedly pinched the right index finger between two rollers.  The miner violated Barton Control of Hazardous Energy program.
220251710016M10482EE stated EE has a sore back from running loader
220251710017M11263Employee was shoveling material from underneath a conveyer in the Finish Mill area when EE felt discomfort in EE's lower back.
220251710018M12345Employee was clearing rocks from the dump site going to the primary plant. Was struggling with loading a rock, so EE picked the rock up and carried it over to the dump. Rock slipped from the employee's grip landing on EE's right foot.
220251710020M12305Employee was eating lunch when EE became strangled on iced tea. Employee stood up while coughing causing EE to loose EE's balance and falling & hitting EE's head on the concrete floor causing a laceration to the back of EE's head.
220251710023M10922Employee reported to supervisor EE was experiencing chest pain for a personal medical issue.
220251710025M12596Operator set down a grinder while cutting disk was still spinning, disk contacted the conveyor belt and jumped to the side.  The spinning disk contacted the back of the operators hand and caused a laceration to the hand.  Laceration required stiches to close.
220251710027M13758It appears that an employee experienced a personal medical event while operating a haul truck. This medical event is believed to have resulted in a loss of consciousness, leading to a loss of vehicle control and a rollover incident. Available evidence suggests that it may be attributable to a personal medical condition rather than factors related to the work environment.  
220251710029M11484Employee was operating the shear cutting out the Headgate, when a rock the size of a baseball came out of the panline and hit them in the left knee.
220251710032M10662The employee was attempting to open a hatch on top of a bulk truck
220251710035M12897The employee was lowering a guard in to position and the guard got hung up while it was being lowered.  The employee had hand positioned on the bottom section of the guard and when the guard freed up, it pinched the employee's right index finger, causing a hairline fracture to the finger.
220251710036M13287An operator, needed assistance getting a loader out of the shop. They had a 10ft stand under the lift arm, supporting the bucket. When I went to pull the stand out from under the loader, I injured my back. I felt a sharp pain in my lower back immediately. I laid down for a few minutes, then left work to go to the chiropractor.
220251710038M11133EE was removing large rock from catwalk and smashed finger between handrail and rock.  The EE was wearing gloves.
220251710039M11223Employee went for annual hearing test, showed hearing loss, was re-tested and continued to show a hearing loss over 25 dB.
220251710040M12305Crew was changing belt on BC-8 when the roll of belt being suspended by the boom truck shifted while pulling the belt and crushed little finger on right hand between the roll and the handrail of the man lift they was working from.
220251710041M11423While trying to disconnect fill line on the back of the water truck employee smashed left index finger causing a cut on the top of the finger.
220251710042M10983EE was attempting to remove a broken drill steel when the chain slipped pinching their right thumb
220251710043M10401CARPAL TUNNEL - LEFT HAND AND LEFT ELBOW
220251710044M12766EE was assisting another EE lifting a cathode. The prybar dropped and they went to catch it and felt pain in shoulder. Seen at clinic, released with restrictions, and referred to ortho. Diagnosed with possible rotator cuff tear and referred for MRI, continued on restrictions.
220251740004M12406EE was performing maintenance on a screen. While switching hard hats, they turned and struck their head on a bracket, causing a laceration. EE sought med. treatment, where they used medical glue to close the wound. Reporting within 10 days.
220251740005M12245Employee is the only one who knows why EE turned left, into an old pit not used in 10 years.  EE turned left, ran over a locked gate and drove over the edge.  EE fell 70' to the bench level.  Sudden impact is what killed EE.
220251740006M12486A member of the office cleaning company was cleaning a restroom in the administration building. EE mixed two chemicals in the restroom which caused EE to inhale fumes. The vendor employee was taken to the emergency room and released later that day.
220251740008M11914EE was cutting conveyor belting with a utility knife and was holding the belting with EE's left hand.  EE accidentally sliced through EE's left thumb above the top joint with a utility knife.
220251740011M11574emp was picking up trough roller and turning at the same time but didn't lift it high enough and struck the frame causing a jarring motion to EE's lower back
220251740012M10963EE was moving a stone when the edge of the stone broke and caused a laceration to EE's left arm.
220251740013M13257Employee felt over heated, took a break in the AC room, was drinking water with electrolytes, 40 minutes later EE stated EE felt better and returned to working on the plant later ended EE's shift and left work at 9 pm. While travelling home EE stated that EE's hands and feet began to draw up and cramping and went to the ER.
220251740014M12335EE lost balance while splitting a block and fell. EE was wearing working at heights protection, however EE's retractable failed to lock up. Before use inspection was conducted, it worked fine. Retractable has been put out of service.
220251740015M12786EE was walking on 2" rocks next to rail cars and felt a pain in the bottom of EE's foot. EE is in a walking boot that is for immobilization at this time causing it to be reportable. EE is performing EE's job functions. Possible stress fracture- waiting for further appointments.
220251740016M12225Loading 29IN face with #8 powder rig, employee was loading the top right corner of the face. The basket tilt cylinder rod snapped causing the basket to rotate forward freely 90 degrees. causing a laceration on right knee  
220251740017M109121 EE was inside the Primary Crusher elevator when it stopped. The elevator would not move. 
220251740018M12446Loading 29IN face with #8 powder rig, employee was loading the top right corner of the face. The basket tilt cylinder rod snapped causing the basket to rotate forward freely 90 degrees. Employee fell into handrail causing a fracture of 4 ribs  
220251740019M12385Miner lost footing exiting a box truck, while retrieving a jug of def. Fell from truck landing on left leg, resulting in a leg fracture. Miner was transported by private vehicle to FMH emergency department, where their leg was stabilized.
220251740028M12476Miner was leaving the office and traveling down a flight of stairs when they realized that they had forgotten something. Turned in the middle of the stairs and lost balance and fell scraping left shin on a boot scrubber mounted on the bottom step.
220251750005M11103Employee was walking on platform lost balance. Employee attempted to catch self and felt a tear in bicep area.
220251750006M12215Employee was using a pipe wrench and body weight to try and unjam a feeder. The pipe wrench slipped causing the employee to smash their left hand and splitting the tip of the ring finger open and needing to have stitches.
220251750007M11233Employee was climbing loader steps to enter cab when EE cut EE's leg. The cut became infected and caused a staph infection.
220251750014M11995Mine employee was welding and after they removed their welding helmet and safety glasses they felt a pain in their right eye. Tried to flush with solution on site and still had foreign object in eye.
220251750015M12706While an employee was standing up from their workstation, they hit their elbow on the corner of the table. After a short period of time, the affected area began to swell up and the employee was evaluated at the local hospital where they were prescribed days off of work.
220251750017M13698Employee was on the lower platform of the control house, assisting in freeing a rock obstruction from the mouth of the jaw crusher. Employee had opened the top of the crusher cage so that the operator could manually free the obstruction. After obstructions were freed, the rock entered the jaw and the vibration caused the guard to fall and impact employee's left hand.
220251750018M11965The employee was in the shop welding on a secured 988 loader bucket. The employee was working laying down on their left side and started to roll onto their right side and felt pain in their back. 
220251750019M13087As The operator was dismounting the haul truck, right hand stuck to the handrail as their foot reached the ground. At that time they felt a sharp pain from the front of right shoulder. Issued 2 lb lift restriction, no driving, no operating equipment, no climbing ladders. Began restricted duty on 06/13/2025.
220251750020M12095While waiting for shift to start employee was rubbing eyes when they felt a sharp pain in their eye after touching welding jacket. Employee was seen at the ER where a foreign object was removed from their eye.
220251770001M13047Main rotor of the crusher stopped plugging the crusher (2009 Inertia Impact Crusher 5066). Lock out tag out performed. Opened hood and locked hood in place. Had pin in the lock. Tried to dislodge enough material off the rotor to turn and align the lock pins better. Rotor slipped catching employees foot.
220251770004M12105Performing Conveyor Maintenance led to dust of work falling into the face of the miner. Some got behind the eye protection and was unfortunately rubbed in, causing imbedding of foreign material in the left eye.
220251770005M13277Employee was pressure washing the underside of the cone crusher. EE was utilizing a 5' ladder, the ladder shifted as EE was descending the ladder causing EE to lose EE's balance falling backwards off the ladder landing on EE's back. EE's left leg became entangled between the rungs of the ladder. Employee had a back contusion.
220251770006M10572Lost operation of the PHoist due to a failed drive module
220251770007M10732Lost use of PHoist due to drive fault/bad module caused by high moisture.
220251770009M13438EE was working on the 953i screen plant at Hardrock changing screens. While changing screens they had the discharge belt laying on the ground and EE went to step on the belt that was approximately 1.5 feet off the ground. while stepping up on to the discharge belt EE's left knee popped sending extreme pain in to EE's left knee and lower leg.
220251770010M13638On 06/23/2025, a 54-year-old employee with 7 years of mining experience was working in the mill near screen 2 packing off bags of finished material  When picking up a bag to place it on the pallet, EE felt a strain in EE's back and told EE's on-shift foreman, stating EE's back was bothering EE. The employee later informed the foreman EE was going to the clinic.
220251770011M10251It was a clear sunny day.
220251770012M11023Miner was performing mechanic work under a service truck. EE over-exerted self in an awkward position.
220251770013M13849At end of shift EE parked excavator in the pit. While completing post-shift inspection, the EE heard a noise and saw smoke from the engine compartment. EE tried to extinguish the fire with an extinguisher but was unsuccessful and evacuated the area. EMS was contacted. Fire continued beyond 30 minutes, at which MSHA Hotline was called. No injuries were associated with this incident.
220251770015M11894Maintenance employee was welding an inspection port in mill room 1 on feed chute when a piece of metal or slag came off the weld and down into EE's welding hood and underneath EE's glasses.
220251770016M10632EE pushing stone off forks onto a pallet and felt abdomen pain.
220251770018M12195While employee was walking under EE's truck on the driver's side for an air valve check, the right foot slid out from underneath EE. This caused all weight to shift to EE's left side and resulted in a left ankle sprain.
220251770019M11975The employee was using a crowbar to adjust a metal screen when the screen slipped down and pincered the employee's finger between the screen and the housing frame. Employee suffered a Broken thumb 
220251770020M13808On 6/13/25 employee received medical treatment in ER for a reopening of a surgical incision. While employee was inspecting a trench, the tripped on leveling rake and fell on right knee, reopening a surgical incision from a personal knee surgery. Employee required surgery, was released from the hospital on 6/15/25, placed on restricted duty on 6/16/25 which is being accommodated
220251770022M13398On 6/17/25 employee provided a modified duty work status report from their personal doctor dated 6/12/25. On 4/25/25 employee reported a first aid from pain to their right arm while placing a wear liner into position. Employee self procured medical treatment, was diagnosed with a ruptured bicep, and restricted duty is being accommodated.
220251770023M11043Miner was determined to be over the 25 decibel threshold during hearing test. Sending back for retesting
220251770025M13748Employee was entering water truck heard pop in their knee.  Employee filled out an Incident Report but did not want to seek medical attention. Employee went for their well medical visit for routine care and mentioned the knee still had some pain.  The MD ordered an MRI.  The MRI indicates surgical intervention is needed.  This turned the first aid claim into a recordable.
220251770027M10632Employee cut middle finger on Left hand while picking up trash.
220251770028M10762Employee cut right thumb through glove while changing worn out screen cloth.
220251770030M13357Replacing a return roller. Return roller, with a hole full of material was pulled from a sitting position by the miner. Twisting hard to move heavy object caused persistent soreness in lower left side/back. Miner did not report condition and medical visits until next scheduled shift after receiving a restricted work status 6/21/2025.
220251780001M11143EMPLOYEE WAS CHANGING REMOTE LOADER TIRE WHEN EE PUSHED UP AGAINST THE TIRE AND FELT A POP IN EE'S RIGHT SHOULDER.
220251780008M12065The employee was descending a stairway at the fly ash stamler. EE missed the last step and landed awkwardly. The next day the employee requested a medical evaluation which identified a lumbar (back) strain.
220251780010M11313pulling rocks out of crusher that was plugged, as EE was pulling some came out from the bottom and landed on the side of EE's foot.
220251780011M12907The employee was attempting to avoid being stung by a bee and hastily exited from a catwalk down the stairs. EE missed one tread and landed awkwardly causing knee pain. EE denied medical treatment. On Monday 6/23/2025 the employee did notify management that EE would seek medical treatment.
220251780012M13668The coal man elevator stopped between floors with one person in the elevator car. The shift supervisor and maintenance personnel tried to reset the elevator but were not successful. Thyssen Krupp Elevator company was called out to safely lower the elevator. The employee was in the elevator for longer than 30 minutes and the event was called in. No injury occurred 
220251780014M10852Silver Shaft hoist was down due to east pinion brake trip fault that would not reset.
220251780016M13207MSHA inspector issued citation forcing us to file even though we don't believe this is a recordable. Employee stated they had soreness in shoulder on Thursday, May 1. There was no lifting, pushing, pulling or striking incident that caused this shoulder soreness. States "I drove over a bump in my path and it jarred me".
220251780017M11243Mine Maintenance Employee struck/dragged across ground approximately 6 feet by SH22 hoist ropes during maintenance activity.
220251810003M12887An employee reported feeling unwell. Emergency medical services were contacted immediately. Upon arrival, EMS personnel evaluated the employee and recommended transportation to the hospital for further medical assessment. Testing indicated a non-life-threatening illness that was treated.
220251810005M13107Employee was exiting the #7 excavator. We have had several days of rain, it was a light drizzle and the ground was muddy. EE felt EE's left foot start to slip, and EE grabbed the handrails and caught self before falling. EE didn't fall, but EE's feet slipped around and EE felt a sharp pain in EE's lower back.
220251810006M12856Employee was operating mobile equipment (CAT 980K loader & John Deere 460 Haul truck) and came to work the next day complaining of tenderness in EE's back. Employee went to clinic and was placed on light duty on 6/16/25. Employee was re-evaluated on 06/27/25 and released to full duty.
220251810007M10441fell in wet stone dust and twisted left knee
220251810009M13849It rained and the mining pit needed to be dewatered. EE was at the mine site alone. It was reported that EE's spouse, was in the truck on the mine site while EE went into the pit. EE moved the telehandler into the pit, parked it on the bottom of the pit parallel on the ramp. EE exited the tele. While standing outside of the tele facing east, the tele fell over onto EE, crushing EE.
220251810010M11674Employee was utilizing a water truck on a haul road to wash out return rollers on conveyor and while driving lost control of the truck resulting in a vehicle accident.
220251810011M11624Employee was trouble shooting an FK pump and got dust in EE's eye causing EE's eye to get scratched. Prescription eye drops were prescribed (no work restrictions)
220251810012M12806Kiln Helper was operating a loader in the coal yard, the loader lunged forward irritating a pre-existing condition. The kiln helper requested not to see a Dr. at the time of the accident. On 6/24/2025 EE went to see the Dr., EE pulled a muscle and was proscribed a muscle relaxer.
220251810013M12335Nutrien Employee was in the process of loading a mines power cable PLM head into the reel of the reel loader. The cable snagged, causing NE to drop the PLM head. The head fell onto NE's right ring finger pinching it against the reel.
220251810014M11844The employee was operating a CAT 988K loader, with left-handed joystick, when the employee turned their hand outward, EE experienced pain. On 6.27.25 employee started physical therapy.
220251810015M13007While removing tires from a dump truck to perform maintenance, the miner felt a pop in EE's left shoulder and a slight tingling in EE's arm. Injury occurred on 05/12/25 and treated as first aid until 06/20/25. On 06/20/25 it was diagnosed as a tear requiring surgery and miner was given restrictions.
220251810016M11413Employee was exiting EE's car to start EE's shift and step on a rock in the parking lot and rolled EE's ankle, resulting in a sprained ankle.
220251810017M12175Employee was opening the water truck cab door to open the water tank fill valve when the tip if EE's right fifth finger got wedged in between the cab door frame and the water fill tank valve resulting in a laceration.
220251810018M11524The employee chose a 4-foot pry bar instead of a 6-foot pry bar to open a valve on a silo pump. The employee strained and felt a pop in their shoulder. 
220251810019M12776Coworker closed pickup tailgate on ee's hand. Seen at clinic, xrays negative for fracture, released with restriction that did not preclude full duty. Ee seen on 6/27, released to restrictions that do preclude full duty. Site offering modified duty. Ee referred to hand surgeon.
220251810020M12135Employee was transporting a part (Core) by forklift when the part fell off the pallet during transport. The employee smashed their left hand between the part and pallet while lifting the part back onto the pallet.
220251810021M12305It appears that an employee experienced a personal medical event while at work as they were found unconscious leaning into a parked and shut off service truck. Employee was transported to a hospital after EMS reviewed EKG results.
220251810022M13327Employee was descending haul truck ladder steps. Employee miss judged placement of foot to ground and rolled left ankle as they stepped down to the ground causing a strain/sprain and abrasion of Left wrist palm side. X-Rays negative for fracture. Ground conditions dry, solid and smooth. Employee returned to work with restrictions.
220251810023M11253During screen maintenance the sharp edge of a metal panel caused an open fracture to the right index finger of the employee. 
220251810024M12836Graduate Engineer was tasked with getting a guide tube. While opening a new bundle of guide tubes with a pair of Klein tools the band snapped back, causing a laceration between the 4th and 5th fingers of the right hand. The engineer was not wearing gloves at the time of the incident
220251810026M10692EE experienced Heat Exhaustion due to temperatures in the 90's range 
220251810029M10331Clogged Chute on primary screener
220251810031M12355While attempting to pry against a stuck rotary mill, an employee propped a large pry bar in the inspection port, while positioning to look into the hole, the bar slipped out and fell onto right thumb causing a contusion and a fracture.
220251810032M12195Employee was changing the 40-04-1 belt to an air tugger in step 2 Agglomerator. Employee was kneeling down while rigging up the 40 belt. Employee felt a pop in their right knee when they stood back up. EMS was contacted
220251810033M11253The employee was lifting an empty 55-gallon drum (~48 pounds). During this lift, the employee felt discomfort in left biceps.
220251820001M11313Employee was found laying on the ground unresponsive in the shop, EE was then transported to a local medical facility via ambulance
220251820002M10752EE had an adjuster drop 3-4" on EE's hand fracturing EE's left pinky finger
220251820003M12315Employee removed rear tire from service truck to work on brake caliper. EE stood up and backed into the tire EE removed. EE lost EE's balance and in the process stepped down on EE's left foot which resulted in a lower leg fracture.
220251820004M12135Miner was entering the cab of a loader and shut EE's own hand in the door.  EE received medical treatment for a DISTAL PHALANX FRACTURE of EE's right middle finger, was given a splint, and placed on modified duty.
220251820006M13588Two employees were doing dry wall hole repairs. Employees came across an abandoned copper water pipe. One of the employees used a Sawzall to cut the pipe while the other held it in place. While cutting the blade slipped and lacerated three fingers on employees left hand holding the pipe. The employee's pinky finger had the tendon cut and cut into the bone.
220251820010M13097Employee was coming down the steps from the #1 screen. When EE got halfway down the steps a rock fell from the #2 conveyor, which is above the steps. The rock struck EE on the top of the head in the center. This caused a laceration on the top of EE's head, which required staples from the hospitals physician.
220251820011M10502Ladder twisted & fell; Low back & left hand sprain
220251820013M11704Employee was adjusting the cylinder head on a Clarkson valve on #1 secondary in precipitation. The weight of the cylinder head shifted and smashed EE's left index finger.
220251820014M12786Ee reported back pain from riding on metal buddy seat in haul truck. Seen at ER, diagnosed with non-occupational condition after MRI. Site did not report as diagnosis was non-occupational. Workers' comp denied claim, ee did not appeal, and filed claim for short-term disability.
220251820016M11203Employee experienced a personal medical emergency on the mine site resulting in hospitalization. (Infection in EE's leg)
220251820018M12816While conducting maintenance on an underground vehicle, EE was opening the lid of the ore hauler, the lid slipped and pinched their left thumb between the lid and the frame. EE suffered a partial amputation to left hand, left thumb. Restrictions are as follows: No use of left hand
220251820020M12135The employee was adding hydraulic fluid to a haul truck up on the quarry dust cell. Upon completion of the job, the employee rose up from a crouching position and immediately felt a sharp pain in their lower back.
220251820023M13678Loader 3222 was loading haul truck 3179 in the J2 Pit. As the loader approached the truck to dump a bucket, a rock rolled off the right side of the bucket and contacted the left bedrail, causing the truck move. The haul truck driver reported back pain and requested to be evaluated in the emergency room. Worker was placed on restricted duty for the rest of the week.
220251820024M12566The employee was working on the TDF dock, where they experienced a foreign body sensation in left eye while they were offloading tires. The employee did not report the incident until 6/23 until after  visiting the ER where they were given an RX antibiotic.
220251820025M12666Three employees were moving a 55 gallon drum of anti-freeze fluid with a dolly. One employee was pulling and two employee were pushing. The employee that was pulling, their feet slipped out from underneath them, causing the barrel to fall and injuring two employees.
220251820028M12476Employee was using a hammer in the process of changing wires out on a screen when they felt pain in right shoulder. They sought medical attention and worked full duty until June 25, 2025 when they were prescribed physical therapy and restrictions.
220251820029M12756Cutting with a torch, using a grinder, welder, and placing T-Bolts inside Kiln 7 cooler. Debris got into the maintenances workers eye. The maintenance worker noticed the eye irritation around 08:00 pm after being home for a few hours. Most of the work was performed overhead.
220251820030M11103Employee lost footing and when they grabbed the rail to steady themselves, they strained their right shoulder.
220251820031M12265While attempting to clear rock from underneath the conveyer, the employee slipped and caught themselves by grabbing onto the conveyer guard. The abrupt motion caused their torso to twist resulting in lower back/abdominal pain.
220251820032M12235Employee was exiting driver side of service truck and tripped on broken concrete and rolled ankle. Initial doctor's requested imaging on injured ankle. Results came back 6/25/25 and the employee was put on restricted duty. 
220251840002M10281Dehydration and Over Heating
220251840003M12195EE was removing placement bars on the reject chute cover. The last bar was under tension and when it released it struck EE in the face. EE sustained a broken tooth and a laceration to EE's mouth. EE received 8 stitches.
220251840005M12105EE was showing other employees how the computers are utilized in the office building. EE began to feel ill. ERT was contacted and EE was taken to the hospital for further evaluation. Diagnosed with dehydration.
220251840007M13408EE was dismounting a haul truck from night shift. EE was on the lower platform of the truck when EE's backpack became hung up on the handrail. As EE was trying to free the backpack, EE lost EE's footing and fell to the ground. EE sustained a laceration to EE's face and soreness in EE's neck. EE received 13 stitches and was taken off work.
220251840008M10582Employee strained shoulder while doing rotex screen change
220251840010M11744Employee was changing out bottom conveyor rollers.  Employee was placing the bad bottom roller into the work truck when EE's middle right finger was lacerated causing injury.
220251840011M10993EMPLOYEE STATED THAT EE IS EXPERIENCING BACK PAIN AND MUSCLE SPASMS FROM OPERATING MOBILE EQUIPMENT
220251840012M12185On 6/26/2025, employee alleged to the plant manager that EE had passed out/lost consciousness while performing clean up in the plant two days prior. This alleged incident was not substantiated during the investigation.
220251840013M13728Employee was installing the toggle seat in the jaw crusher when one of the come-a-longs hooks came out of the eyelet when EE was prying the opposite side into place. The loose end of the toggle seat swung down and over crushing the maintenance employees' arm against the side of crusher. No fractures, but there was damage to soft tissue, ligaments, & tendons in EE's arm.
220251840014M13077Employee inspecting shotcrete coverage on new air door install, & as EE grabbed the west de-energized air door, while pulling it open to inspect behind it, in doing so the the direction of air flow was east to west causing the east door to close resulting in EE's right hand to be pinched between the doors.
220251840016M12566EE and a coworker were using a pry bar to dislodge some rocks, slipped, and EE's finger (ring finger on left hand) got smashed in between the pry bar and a metal door.  EE applied first aid and returned to work.  Went in after work and received 5 stitches.
220251840018M11233While working on a repair at the wash plant, the employee stood up and hit EE's head on a ladder EE was using at the plant.
220251840020M12275Employee was climbing out of plant 2 tanks on a ladder with 3 points of contact. 1 point was plunger rod. The rod is bolted on the bottom. Employee slipped off plunger rod causing a rapid fall, cutting EE's leg, took 7 stitches
220251840022M11744Miner was raking ash at kiln hood when a piece of ash hit the end of the rake causing the rake to hit the miner on the chin.  Miner sustained a laceration requiring stitches.
220251840024M11654Employee went to change the cross-conveyor belt using a tool box knife to cut the old belt and pulled it towards themselves, cutting their thumb through their glove.
220251840026M13768As part of a routine inspection of a cyclone, the overflow pipe was removed & being reinstalled. The pipe was suspended by an overhead crane; another mechanic was pushing on the pipe to align the bolts. The pipe hung up, causing it to bounce. When it bounced, the nylon strap broke, & pipe fell, striking the mechanic's right hand between a pry bar & the overflow pipe flange.
220251840027M12696EE was changing oil on forklift, reached for drain pan, felt pop in shoulder. EE was seen at ER, diagnosed with pain, referred to ortho. Seen at clinic following day, suspected rotator cuff tear, released with restrictions. EE reports previous surgery to this shoulder.
220251840028M12275Upper Pier on K4 Kiln welding retention blocks. Stepping down from ladder and stepped on things underneath the ladder causing employee to twist and strain back. As of 6/24/25 Modifications to desk duty by Medical professional. 
220251840029M13558Employee was shoveling material at the secondary screen when they felt pain on left forearm and noticed swelling. The initial injury occurred on 06/20/2025 but EE declined medical treatment. On 06/23/2025 asked to see a doctor and was taken to a minor emergency clinic for treatment. Diagnosed with strain of muscle left forearm and place on restrictions.
220251840030M13678An employee observed an electrician's golf cart that was parked near the Phoist control room was on fire and notified their supervisor. The supervisor contacted CFD and verified that the EVAC system was activated. The supervisor immediately traveled to the location of the golf cart and found that the fire had been extinguished by employees using fire extinguishers.
220251840033M12325EE did ride-along in shovel at the Pipeline pit. EE reports ride was rough, causing them neck and back pain. Seen at clinic, diagnosed with cervical and thoracic spine strain, released with restrictions. Site offering modified duty.
220251840034M10692Employee was unloading a truck when they felt pain on right shoulder.
220251840035M11744A plant maintenance employee was splicing a conveyor belt when their foot slipped out from under them as they were dismounting off of the frame and strained their right knee.
220251840036M12806Employee was helping remove a panel from a screen when the screen panel jerked their arm down and over extending upper arm causing pain in shoulder. The incident occurred on 6/11/2025 but the employee's shoulder became worse over time and they had to receive surgery on 6/23/2025.
220251840039M10401Employee was sick from being dehydrated.
220251840040M12125EE was moving the 4 separator elevator gearbox with the help of another millwright on a wagon. The Millwright in the pulling positions twisted their knee and felt a sharp pain that travelled through knee and leg.
220251840041M10942Employee was turning a rock on the turn table when the rock rolled over smashing their fingers
220251840042M11444The underground mine had a cave-in and employee is experiencing ringing of the left ear and headaches caused by the loud noise and air pressure.
220251840043M11484The underground mine had a cave-in and the employee is experiencing ringing in the left ear and headaches caused by the loud noise and air pressure.
220251840045M11303The dynamic brakes faulted out causing the production hoist to be inoperable. Found switch in hoist operators booth in automatic. 
220251840047M13237EE called Clinic to report neck strain that occurred while pulling hose, prevented return to work the next morning. EE reports stiffness in neck that prevents turning of head left or right. EE was instructed to visit the Clinic for evaluation by company MD. EE evaluated and referred to clinic for evaluation and treatment.
220251880003M12967Ee was checking a piece of equipment, going to take cap off radiator. The cap popped and coolant splashed on ee's right wrist/forearm. Seen at ER, diagnosed with burns, released to full duty. On follow-up at clinic, released to restrictions and referred for therapy. Site can offer modified duty.
220251880004M12335Three employees were moving a 55 gallon drum of anti-freeze with a dolly. one employee was pulling and two were pushing . One of the employees that was pushing tried to stop the drum from falling, causing strain to LT shoulder area. 
220251880006M13828EE used a hammer to strike the head of a 10" chisel to free a stuck idler on a belt conveyor. When EE struck the chisel EE felt a sharp pain in EE's left forearm and EE's arm bled. EE was taken to the hospital where EE received treatment for a foreign body puncture (metal from the chisel head). EE received two stitches after the doctor tried to unsuccessfully to remove the metal.
220251880007M13808On 1/21/25 EE was lying on EE's back with 2" of clearance while replacing screens on C114 Screen. EE completed job and while lying on EE's back EE had to push self uphill using EE's feet and elbows. EE reported to supervisor a shoulder strain. On 3/20/25 EE saw doctor for first time. EE was given an MRI that revealed right shoulder labrum tear. Surgery was performed on 6/26/25.
220251880009M12135At approximately 10:30PM Friday June 27, 2025, a roof fall was found in 13w/95. Due to being above the anchor point MSHA was notified by phone. MSHA representatives where on site and issued a K-order on 6/30/2025.
220251880010M12596An employee was operating a Bobcat skid loader with a fork attachment to move a steel sawhorse when the sawhorse shifted and fell, striking another employee's foot who was nearby. The sawhorse landed above the steel toe portion of the injured employee's boot.
220251880011M12185Employee was pulling an air lance out of a bin filled with sand and they reported a sharp pain in the hand through their elbow. 13 days later the employee sought medical treatment and was given a brace for their wrist.
220251880012M12355Employee was working on switching out bags on a baghouse and was carrying a baghouse bag cage, took a step down onto uneven surface and rolled EE's ankle. There was immediate swelling and was taken to the ER. There was no broken bones.
220251880017M12355Employee was reaching into a partially opened tin of welding rods and the lid cut their arm above the wrist. Being in a hurry and not completely removing the tin lid caused the accident. Employee received 7 stitches to close the wound.
220251880018M12616The electric motor for the pump on the 1700 level lost one leg of the 3 phases. This caused the remaining two legs to heat up because they were drawing more amperage. The varnish on the coils and insulation started to smoke as a result of the motor heating up. 
220251880021M10932Employee was walking down incline and slipped but did not fall. Employee then felt back pain.
220251880028M11784While operating a loader, the operators bucket got hung up on a buried rock in the muck face. When the rock gave way, the loader jarred the operator causing a neck strain/sprain.
220251890001M13137Miner removed hard hat to check for a problem on main stacker feed belt when hard hat would not fit, when getting out, miner stood and hit EE's head on channel iron. Another EE checked cut and recommended urgent care. 4 staples where used to close wound. No duty restrictions recommended by medical professionals.
220251890002M12706Miner was working near the motor and drive belts to unplug a shoot. During troubleshooting they had the operator fire it up to see if it was good to go, during startup the turnbuckle that supports the motor broke causing the motor to swing striking EE in the lower back.
220251890005M12676While reinstalling hinged inspection door on main system fan housing, EE pulled awkwardly resulting in back pain.  EE sought medical attention and was prescribed medication and given restrictions.  Axiom was notified after the fact and is currently managing the case.
220251890006M11413Employee was loosening a bolt on a brake caliper of a pickup truck, when EE felt a pain in EE's back.  EE was diagnosed with a lumbar strain.
220251890007M11794Employee was trimming the front wallplate with a battery powered saw and while making a cut, the saw slipped causing a laceration to employee's thigh. Employee received 8 sutures.
220251890008M13678Employee was working on conveyor pulley & started to feel dizzy & nauseated. Temps were 90+ with Heat index 100+ Went to control room to cool off. After drinking fluids, EE vomited. As a precautionary measure, ambulance was called, EMT's checked vitals, all were ok. by that time employee had improved. Heat Exhaustion. Employee returned to work with no complications
220251890009M13207Around 9:30 am an Employee was loading a UTV on the service cage at the surface collar and the overhead door came down catching the buggy bending the door pulling it out of the track. The cage is used for either personnel or equipment and at no point were persons endangered. Operator is filing this report under duress.
220251890010M10542Lifting a tote of gravel into shaker strained shoulder
220251890016M1341861 was filling A fuel truck. They felt their back getting warm and saw that there was a fire. They exited the truck and ran a safe distance. Called the onsite fire department and also had the guard shack call the fire department. There were no injuries, and the truck was a total loss. Fire reported at 7:52 and MSHA was notified at 8:17 am.
220251890017M12606The driller was rigging out of 1482 taking a cable down from the cable hangers when they lost balance causing them to fall and cut left elbow. The employee was taken to the ER and received 3 stitches. They went back to work the same night with no restrictions.
220251890019M11113Electrical employee was walking out of Water Plant building and slipped on wet surface causing left leg injury.
220251890022M13187A plant employee was walking up the ramp to the 700 belt to inspect the grinding aid flow. While ducking under one of the newly installed beams for the weigh feeder, the employee raised their head and struck forehead on the second beam. The impact caused their safety glasses to shift and cut deeply on their forehead.
220251890023M13067While performing maintenance on a WA500 Loader, employee's wrench slipped off a drain plug, causing them to twist their back and pinch a nerve. They declined immediate medical attention but visited a doctor the following Monday. Employee was prescribed a muscle relaxer and is currently off duty recovering
220251890024M11193Recordable Standard Threshhold Shift of Left ear. Re-testing on 7/14/25 at 8:30am. ***Retest shows as non-chargeable***
220251890025M13057An employee suffered an accident at the repair workshop while using a piston impact tool. The tool slipped from hand during use, causing an injury to their hand. Employee was immediately taken to preventative care facility for medical attention and transferred to medical facility for continued treatment.
220251890027M11955Employee was attempting to manually slide a pallet (approx. 600 pound) inside a van to position for pickup by Lull/forklift. During this task, the IP experienced pain in their right bicep muscle.
220251890028M13518Employee was pushing a 55 gallon grease drum with a drum cart when the tire struck a bolt in the grating causing the employee to hit their ribs on the cart handle. The employee was evaluated on June 23rd and returned to work without restrictions. The employee was seen again on June 27th and was then placed on restrictions as a result of the injury. 
220251890029M13738EE stated that while in the process of backing the haul truck to empty it into the #2 pit, the rear of the haul truck entered the pit causing the cab of the unit to overturn on the passenger's side. EE was able to self-extricate from the haul truck. EE was observed by co-workers to have a laceration on head and swollen right shoulder area. EE reported pain in both areas.
220251890030M11904Employee was inspecting a drain pipe at track area, while standing on a mild slope. They slipped and fell, attempt to break the fall with their hands. They felt sharp pain in right shoulder.
220251900002M12927While picking up used dust collector bags off of the ground, a maintenance mechanics stepped on a piece of clinker.  This caused EE to lose EE's balance and twist EE's back while falling to the ground. On 7/1/25, medical evaluation was sought and the employee was placed on work restrictions.
220251900004M11714While working on the clinker transport system, a maintenance mechanic began to feel ill.  Reported condition to supervisor. taken to ER and diagnosed with heat exhaustion.
220251900005M13347Full investigation not complete.  found victim on EE's back in front of a dump truck.  It can be seen that a jack had slipped from under the axel and the bumper of the truck came down on the victim side.   the victim was putting the left front tire on the truck.  The tire had been removed because the wheel bearing had to be replaced
220251900008M11664Employee was attempting to check coolant on loader which resulted in coolant being sprayed on face and hands.  EE then jumped of work platform and injured ankle/knee.
220251900009M11614Employee was exiting the Komatsu 700 hammer equipment and while stepping down and holding the hand rail, the hand rail broke and the employee fell to the ground.
220251900010M11043Operator was helping reset the nose cone on the scalping deck, and EE's finger was pinched between both.
220251900011M11283Operator wasn't wearing EE's seat belt. EE hit a bump in the cut, and that caused EE to come in contact with the can controller.
220251900014M13778Employee was driving Dingo, backed into a metal post & caught their left foot between post & equipment. EE fell to the right, landed on cement, causing a small contusion on right elbow. EE pulled themselves up, hit the Forward controller & equipment moved, releasing foot. Removed their boot, found their ankle bleeding. Was taken in to be seen. No ligament or tendons damaged.
220251900017M11484Employee was changing out the water jug on the water dispenser when the bottle made contact with the employees chin causing a tooth cap to fall off.
220251900019M11634Miner was manually opening a dump train car when material sloughed down onto the door causing it to rapidly open jerking the miner's arms causing a shoulder strain
220251900020M13728Employee was transporting a tote of diesel fuel and got a flat tire on the 1-yard forklift they was using to transport the fuel. Employee was pulling into a cutout to get it out of the roadway and as they were pulling in they hit a bump and reached their arm out toward the rib and strained left shoulder. Employee ended up having to get surgery for a rotator cuff injury.
220251900021M11043Preparing to do clean up on top of a bin by removing the grating and stepped into a hole scrapping shin.
220251900022M11033Employee activated the spring return on the lubrication hoses and became tangled in the hose and fell. 
220251910002M13658Employee was retrieving garbage bags from a dumpster that had mistakenly been thrown in the wrong roll off. EE was using a grabber tool to retrieve the bags, as EE was pulling a bag towards the front of the dumpster, EE felt a pop and discomfort in EE's neck. Taken to the clinic on 7/7/25 and diagnosed with a strained muscle in EE's neck and placed on light duty.
220251910003M11704EE stated they were collecting quality control samples from the stage 6 sample port when they were splashed by hot material on their left hand, burning through the glove.
220251910004M13548Employee reported on June 28th that sometime during the evening of the 24th EE was bitten by an insect on EE's right forearm, and it progressively swelled up, EE sought medical attention. EE was taken to a clinic and treated for cellulitis. On the 29th the employee requested a hospital evaluation for continued swelling and was treated for inflammation.
220251910005M13538Employee is an electrician, and was working on wiring.  EE was using EE's knife, and poked EE's finger.  It broke the skin but did not bleed.  Then EE found a dead raccoon, that had been chewing on the wiring.  After consultations, there was a concern for the possibility of rabies.  Employee started a series of rabies shots as a precautionary measure.
220251910008M13077Employee was utilizing a prybar to assist with removal of motor for replacement when the prybar slipped and struck employee on the right side of the hardhat/head on the right ear causing a laceration to the upper portion of the right ear. The hardhat took the brunt of the force from the blow of the prybar.
220251910009M13849Employee was closing lid on a box truck when driver re-entered the cab and proceeded to drive away with employee still on top. Employee was caught by fall protection. Employee was Rescued via Emergency Ladder within Seconds. No Immediate Signs of injury at the time of the Accident, Employee was feeling soreness the next day and taken for Medical Evaluation 2 days after the incident
220251910011M12315The employee was picking up debris in the shop and got a metal splinter in EE's fingernail, which was removed by medical professional. (Note: The employee was provided with gloves but was not wearing them when the injury occurred.)
220251910016M12696Coming out of a trailer the employee tripped on the top step and fell to the ground on their right shoulder. The fall was 3 steps high and approximately 3 1/2 feet. This became a lost time incident when the employee received surgery on 7/2/2025 for a rotator cuff tear.
220251910018M13838While standing, individual attempted to lift a 4x8' sheet of plywood from chest height to overhead position. Plywood had dirt on it making it heavier than anticipated. Extra exertion caused a pulled muscle under left scapula around to under left pectoral muscle. Co-worker immediately checked individual for any sign of back injury before returning to the office to report incident. 
220251910020M10852During welding operations on the Primary Feeder, a mechanic sustained welder's flash.
220251920001M10632The shive belt and shive rolled over employee left pinky finger
220251920002M12055Employee used other means to access plant other than ladder. Still under investigation. Employee states EE twisted EE's lower right hand back. Employee did not report until the following day. No witnesses.
220251920003M11363Employee was pulling the chain on a come-a-long when EE stepped back to gain more momentum, employee felt a pop in EE's lower right leg.
220251920005M10291Employee was struck by idler.
220251920006M11754Employee was stepping off a loader and stepped on a mud ball. They ankle gave out. The employee sought medical treatment the following day and was placed on restricted duties.
220251950001M12055Employee performing maintenance on drag line brakes. Struck RT arm on expanded metal guard which caused a laceration. Employee sought medical treatment same day, received sutures. Reporting within 10 days.
220251950003M10973Employee alleges EE was grinding and sealing some material and some rust went into EE's left eye.
220251950006M13658Employee was moving core boxes from an elevated platform to bench and felt a pop in their right knee with minor discomfort. Continued to work for the remainder of the shift but knee progressively got worse through the night. On 7/10 at 07:33, IP arrived with supervisor at first aid exam room. EMT performed assessment and vital signs were normal. Referred to RMMC.
220251950007M10311Left thumb hit by hammer & pipe
220251950008M12536On May 7th a miner with a previously reported injury was sent to the doctor with complications from that injury. The visit resulted in a carpal tunnel diagnosis that requires surgery. the mine operator was not informed of the diagnosis until 07/02/2025 
220251950010M11504EE was on a 10ft ladder doing a oil change under machinery and the ladder shifted under EE's weight and EE fell on EE's front left side to the ground.
220251950011M11985EE was injured while washing out a dust bin when material buildup sloughed off and fell onto EE's left arm pushing it downward onto the steel opening causing a laceration to the bottom of the wrist.
220251950012M13267EE twisted knee while performing maintenance work on a screen (no report filed at this time. A couple days later, EE felt it "pop" again and was unable to get out of the loader due to the pain.  Incident was reported at this time and ee sought medical treatment. Was informed on 7/11 that EE had been put on work restrictions.
220251950013M13448An EE was trying to remove a bit from drill pipe on John Henry drill. IE put a pipe wrench on the bit & spun the wrench so that it was touching the ground.  IE stood on the pipe wrench to keep it from moving.  EE began slowly rotating the drill pipe & pipe wrench sprung upward & threw IE sideways causing EE to land on EE's side on the ground.
220251950014M13778Equipment Operator stepped off of excavator turned to walk away and stepped on a clay chunk on the ground, Stubbled but did not fall, upon catching EE's balance felt a pop in EE's left knee. Conditions in the bullpen area was dry. On 7/11/2025 Employee reported that EE's knee had gotten worse and was taken to the ER. Further treatment was given at ER EE was released to home.
220251950016M11894EE was cleaning up at the wet plant facility and felt something bite EE under EE's shirt. EE went to a medical facility where EE received treatment for a spider bite on EE's left upper arm.
220251950018M12155On July 12, 2025, at approximately 7:00 a.m., the powerhouse operator noticed that a fire in the powerhouse had started in a switch gear, causing damage in the electrical panels. The incident is under investigation.
220251950020M11093Employee was being loaded in haul truck when they felt pain in back - did not become reportable until 6/30/25
220251950021M12165The employee was operating a wheel loader to move Type III stone to the stockpile yard.  While digging into the pile, the loader jolted as the bucket came to a stop, and the operator felt pain in neck and upper back.
220251950022M10932Employee felt pain in back after getting off forklift - determined to be occupational illness
220251950023M10371Employee felt symptoms of dehydration
220251950024M12736Employee was putting guards on a conveyor with a drill and drill bits.  They slipped, and caught their left arm on some angle iron. They cut their left arm. They received a tetanus shot, they cleaned up the arm, bandaged it, and sent them back to work without restrictions.
220251950025M10331Employee began feeling dehydrated
220251950026M11935Employee was walking down to the pump house when they felt a sharp pain on left hand. That's when they noticed a Yellow jacket was biting their left hand. Went to ER and was given an injection.
220251950029M13818At approximately 04:30 am, Craftsman was walking from change house to truck shop through haul truck access road walkway. As they approached eastern side, they stepped on a rock and was knocked off balance, but not falling. The felt a crack/pop in lower back. The pain increased later in the shift. Supervisor was notified at 10:30am and then taken to clinic for further evaluation.
220251950031M12105While removing an expanded metal guard bent around a motor shaft, the guard flexed back to a straight position after the bolt was removed striking and cutting the employee's nose. employee received 5 stitches. 
220251950032M11423Using a large wrench and it slipped off a nut, momentum caused person to fall on back. After diagnostic visit (07/10) placed on restrictions. 
220251950033M10361twisted left ankle in hole by Pump 1
220251960001M11524Operator was cleaning up material spillage from the Mill White Belt, when they started showing signs of heat illness.  Employee was administered fluids.
220251960002M10973The employee was using a grinder to cut a piece of metal when it slipped and cut EE's upper knee.
220251960004M13007Miner was welding with a welding hood/shield on.  When EE was done, EE removed EE's hood and began to knock extra slag off with a hammer.  When EE struck the weld a shard projected back and struck EE's eye.  EE did not feel this until several days went by and did not go to the doctor until 7/1/2025.
220251960005M11764The employee had a knife in one hand with a piece of conveyor belt in the other . While making a vertical cut, the razor blade detached from the knife handle and cut EE's hand.
220251960011M11283EE was filling hydraulic oil in 651 scraper when hand got smashed by the 55 gal. drum. weather 79 degrees wind was blowing 3mph.
220251960013M13027While using a grinder the miner had a small piece of debris enter the corner of EE's right eye. The employee was wearing safety glasses at time of incident. Employee was taken to urgent care and released post eye doctor visit on 07/11/25. Released to return to work for next scheduled shift (07/14/25).
220251960015M10892Sprain on right shoulder occurred when pulling on a strap to a sling bag and strap broke.
220251960016M11834The EE was attempting to troubleshoot the dry plant generator when slipped and fell and struck their head. This resulted in a 1" laceration, which needed 2 staples to close the wound.
220251960017M12726Employee worked almost all of the shift, they reported during the day they were experiencing minimal urination stating heat seemed to be affecting them. Employee was taken to the office, given cool water, rest in air condition until they felt ready to return to the plant.
220251960019M11113Employee was servicing D10N dozer, stepping down from the dozer they twisted wrong and felt a pop in their hip.
220251960021M13508While walking to another area to weed eat around tank house they slipped on loose dirt & spread eagled legs on either side of the berm causing them to fall forward and hit their face shield & hard hat on the ground causing their neck to pop backwards as well as their groin to hit the rocks/gravel on the berm. It was hot and dry conditions that day.
220251960022M13849Conveyor belt had come to a stop, due to being overloaded with material. LOTO was performed, guarding was removed on the wing pulley. Employee used a shovel to remove material, and then they tried to scrape the rest of the material off pulley with right hand. It was at that time the weight conveyor to move backwards, causing the arm to be caught in between the belt arm, and pulley.
220251960023M11955Employee drilling a 1/2" hole. Drill bit snagged a thin wire and wrapped it around. when this happens the loose end of wire away from drill bit wrapped around employee finger causing a laceration
220251960024M11854Employee alleged that they injured their shoulder while running the loader on 6/2/2025 but did not report this injury until 7/2/2025 and became reportable due to restrictions on 7/3/25.
220251960026M11985EE was working on the Dewatering Wheel when their wrench slipped and struck them in the chin.  EE sustained a small laceration and was taken to the ER to be evaluated where they received 3 stitches.
220251960028M11233EE was shoveling material off of C-15 when they felt a pain in lower back.  Did not seek medical treatment until 7/15/2025.
220251960029M11524Employee was lying on their back trying to get a rock unstuck from a plugged chute when a larger rock rolled off the belt and hit them on the left knee.
220251970001M11834Miner was using a burner to burn granite. The miner lost control of the burner resulting in the flame blowing back towards them. Miner had burns on one leg from the knee to the waist.
220251970002M12606EE had just exited the excavator and walking down the slope to the Trommel when material gave way causing EE's knee to buckle. Conservative treatment provided up until 6/26 when EE received MRI results showing a meniscus tear. Resulting in an upcoming surgery.
220251970006M11524Helping wash material off mill head and put chains on head for lifting when chain head rolled on top of right foot. Cause a broken big toe on right foot
220251970008M10902Employee was bending over to set the impact down after bending over and tightening bolts. 
220251970010M12375EE turned around to exit the skid loader, EE stepped down from the platform onto the flat part of the bucket, EE's left foot somehow slipped from out beneath EE, and EE landed on the ground and heard a pop and EE knew EE hurt EE's ankle.
220251970011M11674Employees were positioning a roll crusher roller when the load shifted causing the roller to strike the injured employee's right foot resulting in three broken bones. 
220251970015M13568Employee was in the process of removing a gearbox from a shaft. While doing this, the employee bumped their right elbow on a cross brace of the structure. The next day the employee had tenderness and a knot. The employee was seen at a clinic and returned to work. Employee was referred to ortho and seen on 7-10-25, the employee was put on restricted work.
220251970017M12927Maintenance employee was pounding on a bearing assembly with a 16 pound sledge hammer.  After the job was completed they noticed pain in right wrist.  The next morning their wrist was stiff and sore.  The employee did report that their wrist had been sore with pre-existing pain for sometime.
220251970018M11293Employee exited the cab of a Cat 777 F haul truck, when they stood upright they bumped their head against the truck bed's canopy.
220251970020M13097At 14:50, IP had been clearing brush and felt a sting on their neck. IP told ERT/EMT that they were feeling numbness and tingling in extremities. IP stated they threw up after the sting. IP vitals were elevated. EMT transferred IP into ERT ambulance and transported IP to meet with UFA at Notch gate at 15:35.
220251980003M10812Employee was swinging a sledge hammer to try and break a gear box off of a shaft.
220251980004M10993IP was completing paperwork for light vehicle service and shut left pinky in door of light vehicle.
220251980005M12115Ee was moving auger and pinched right ring finger between auger and fitting on the pug mill belt. Was seen at ER, diagnosed with open fracture, referred to orthopedic hand specialist, released with restrictions.
220251980006M11003Customer (Dennis Trucking)  was found unresponsive and transported by ambulance where EE later died.
220251980008M13628While installing Tech screws into a panel, a metal shaving went in to employee's right eye. EE did not notice it until EE got in EE's car as was going home around 16:20. It felt itchy, and EE began rubbing it. EE didn't think much of it and EE thought EE would just flush it out when EE got home. The pain intensified, and EE called EE's supervisor to report it.
220251980010M11474Employee was removing a guard to begin maintenance on the ball mill when EE felt EE's knee pop. Atter evaluation initial diagnosis is a knee sprain
220251980015M10371Relay switches burned up in #3 Hoist.
220251980016M10371Relay switches burned up on #3 Hoist.
220251980022M13247Employee was digging out the sump pond near pump #1 with an excavator. While dumping the last pile, the rocks bounced off of each other and struck the front of the excavator, shattering the right side glass. This glass then struck the member on the hand and wrist causing a small (approximately 3") laceration to left wrist.
220251980024M13849Miner was appx. 30' away from a capacitor that failed resulting in an ARC flash. Miner denied any injury and refused medical evaluation. On July 8, 2025 miner reported ringing in left ear and shortness of breath from event that occurred on June 12, 2025 and was sent for eval. At no time was a workplace injury reported until July 8,2025. Injury is under compensability investigation.
220251990002M12526Operator was hauling mud in a 980H loader when EE hit a bump in the haul road and received a possible pinched nerve in EE's neck.  EE is seeing a physical therapist for pain relief. No time lost, no light duty restrictions, still working job of injury.
220251990004M11253Right hand pinky finger laceration when finger was pinched between bar and rotor while lowering the Blow bars on Hazmag K-853
220251990005M11464Miner was using a punch and hammer to remove a bolt in a screen cloth.  A piece of metal went through the miner's glove and imbedded in left hand.
220251990006M13127Employee was moving a section of 12" hose with the telehandler. They attempted to extend the boom out to place it down while on an uneven surface. The outriggers were not extended and the vehicle rolled onto its cab side. The employee was wearing a seatbelt but injured their leg from the impact of the rollover.
220251990009M13027HT driver stated their haul truck was getting loaded around 9pm last night and they noted neck and back pain at the time of the load. EE continued driving and had 2 subsequent loads that worsened the pain in low back and neck. Employee stated they had a hard time breathing due to the muscle tightness.
220251990010M13698Side dump driver was passing through the yard. EE passed out in the truck and veered off the roadway into pasture surrounding property. EE was taken to hospital by office employee. There were no contusions or lacerations on EE's person after accident happened. EE was traveling 16 mph when the incident occurred. Hospital found EE was anemic and given 2 pints of blood.
220251990011M13618While relocating the old stacker belt using a loader and an extended boom, the boom operator lost control, causing it to tip onto its side. The boom operator jumped from the cab and sustained an injury to the left wrist. Employee went to a specialist for further evaluation. Specialist documentation from 7-7-2025 confirmed limitations and brace to left wrist. 
220251990012M13388EE driving an artic truck went to grab drink bottle and dropped bottle. Leaned over to grab bottle, while still driving, and veered off road & hit tail end of a berm jarring EE & equipment. EE sustained head wound and fractured collarbone on left side of body. EE was rushed to ER (received staples & sling) & returned to work next shift.
220251990013M10983Miner was lifting a train door opening bar when the door bound causing EE to strain a back muscle.
220251990014M13197Operator was running the A-crane at Central Tankhouse. While hooking up the mist ball basket, a small piece of debris fell from the inside of their full-face Respirator into their eye causing irritation. They went to the clinic for treatment where a small scratch was found and prescription eyedrops were administered. 
220251990016M11894EE was cleaning out the hopper and alleges that they "passed out". This was unwitnessed. A coworker was asked to get EE water. This occurred towards the end of the EE's shift. Time unknown.
220251990018M13838EE's right hand was caught between the belts & the sheave while in the process of changing drive belts on final product pump. EE had to roll sheave in the opposite direction to remove the stuck hand. EE visited Clinic for after-hours treatment & returned to Clinic on 7/14/25, had decreased grip strength, swelling to thumb, ring & little finger. Hand was obviously painful to move. 
220251990019M13818EE reports a popping sensation & a sharp pain in right side after slipping in mud & nearly falling. EE denies fall explaining that it took effort to catch balance. EE completed shift & reported to the Clinic by phone on 7/14/25. Follow-up call on 7/15/25 morning = no improvement. EE reports that the pain has not improved with rest & states unable to do much because of the pain. 
220251990020M12095Operator was conducting remoting activities in an area known as the 2025 area when a large rock contacted the cab. Operator was found in the cab out past the designated no-go line and sustained fatal injuries.
220251990021M12897Employee had returned from taking samples, entered information, stood up from the chair and experienced a sharp pain run from lower left leg to lower hip area.  Employee was evaluated by an ERT member then taken to the ER for evaluation. Employee was taken off work until evaluated by PCP.
220251990022M12325Employee was lifting a return idler to carry down the tunnel when they felt a pain in lower left abdomen. Employee was taken to the ER, diagnosed with muscle strain and referred to PCP. PCP placed on restrictions. CURRENTLY ONGOING.
220251990026M13798Miner was working inside the Raw Mill on the seal air vertical pipe #3 roller. Employee was disconnecting the pipe and rolled the pipe around out of the way of the work. When they rolled the pipe, the pipe swung around so quickly that it pinned their left index finger between pipe and yoke of the #3 roller. The pipe mashed it at the nail and busted the end of the index finger.
220252020002M10832Miner injured middle finger of right hand between tailgate and bed of a dump truck.
220252020003M11504While performing maintenance on a conveyor belt, an employee was using a hammer when a metal fragment splintered off and lodged into their left thigh.
220252020004M13047EE was working on the Primary #1 Feeder Mount. A spring was broken on the right 3/4 inch bolt.  EE replaced the spring and was tensioning the guide nut, a worn portion of the bolt that was weakened failed, launching the weakened portion into EE's right cheek due to the stored energy of the upper spring.
220252020005M12355Ee was at the 1600 fuel bay. Lifted the fuel hose to attach to truck and felt a pop in EE's chest and right side rib area. Seen at ER, diagnosed with a chest wall strain, possible tear of pectoralis muscle. Released to restricted duty.
220252020006M12496Ee was lifting a piece of pipe off a pipe handler and EE felt a pop in EE's left shoulder. EE felt immediate sharp pain. EE was seen at the clinic, released to restricted duty, and referred for an orthopedic consult with suspected rotator cuff tear.
220252020011M10802A 40 ton haul truck caught fire causing the operator to endure smoke inhalation 
220252020013M10722Employee experienced pain in right shoulder while pounding down a chute.
220252020014M10802Process plant employee was performing clean-up work when they became overheated.
220252030001M12225Employee got into bed of service truck to ride to office. EE stated EE was sitting with EE's back to tailgate, tailgate popped open allowing EE to fall backwards onto ground, cutting back of head which required 2 stitches.
220252030003M12195EL EMPLADO ALEGA QUE DESDE NOVIEMBRE SE LASTIMO EL HOMBRO PALEANDO Y FUE EN 19 MAYO A SU MEDICO PRIMARIO Y EL LE IDICO QUE TENIA QUE REPORTARCE AL FONDO SEGURO DEL ESTADO, EL EMPLEADO LO NOTIFICO HOY 21 DE JUNIO DE 2025
220252030004M12776Employee reported to management on 4/1/25 of right and left hand/arm numbness. Nerve Conduction Study on 6/4/25 revealed right & left Carpal Tunnel Syndrome. EE had right hand surgery on 7/17/25 and will return to work after left hand surgery scheduled for 8/7/25 is completed.
220252030005M12045While descending a portable ladder, an employee missed the last steps and landed awkwardly on the ground, resulting in a knee injury. The employee was promptly attended to and received medical evaluation.
220252030012M12656The employee was in the cab of the radial stacker when the 2450-002 luffing system base failed at end of shift causing the stacker cab to drop to the right side. The operator in the cab, experienced some discomfort to the left leg after the luffing system failed.  
220252030013M10822Employee hit pothole in rubber tire injuring shoulder - became reportable 7/9/2025
220252030014M11864While descending the ladder on the screen plant, foot slipped off lower rung. Caught self with left hand causing shoulder strain and sprained EE's left foot/ankle when it hit the ground.
220252030015M11323EE had partial distal bicep tendon tear in the right arm requiring surgical repair. Injury determined to be the result of tendinitis
220252030019M10622Setting up screening plant, cleaning material from tail pully 
220252030026M10912Employee was connecting a flange to a pipe and was struck in the mouth by one of the bands.
220252030029M11093Employee was lifting a box weighing approximately 35LBS putting it into a pickup and felt a pop in left bicep
220252030030M11965Employee was traveling to sample pellets from line 4 and about the climb stairway from basement level, when they slipped on the pellets and mud at the base of stairway and twisted their left knee.
220252030031M12025Employee was driving lube truck and hit a rut in the road causing the seat spring to bounce. Employee was wearing hard hat and hit hard hat on the roof of the cab causing a neck strain. X-Ray negative. 
220252040002M13488large rock got stuck in the jaw of the crusher. A TM attempted to use a chain to wedge between the rock and the jaw dies to break it up. As the rock and jaw pulled the chain down the TM tried to pull the chain up, resulting in smashing EE's hand between the chain and the railing causing laceration to left palm and a fracture to the 5th metacarpal
220252040003M11935Employee was holding the liner for the hopper in place and slipped, causing their left palm to make contact with the drill bit that was coming through the hopper and liner, creating bolt holes.
220252040004M11263The employee was replacing a ground fault cable for a dredge, as EE was walking down a berm EE slipped and fell to the ground.
220252040005M13468A pit loader operator sprained their left ankle while dismounting their equipment. The employee was initially evaluated at the clinic on 7/7 and released to continue full duty with no restrictions. The employee was still experiencing pain on 7/21 and went back to the clinic, where they received restrictions and were prescribed physical therapy.
220252040006M13277An employee fell while dismounting their loader. The employee landed on their back in a sand pile. The employee's initial pain was a 3/10. After a week of self-care treatment, the employee was not improving, so EE was seen at a clinic on 7/21. X-rays indicate that the employee has a compression fracture on their L2 vertebrae.
220252040007M13758After loading at the ES59, the HT471 operator noticed lower back discomfort. The operator attempted to continue operating to see if the pains would subside. After about a half hour, and the pains continued, the operator reported the pains to their supervisor. The operator was assessed by onsite ERT's, EMT then RMCC where they were released back to duty with restrictions.  
220252040008M10932Haul Truck operator hit an unknown bump, a few minutes after began to feel pain in EE's back.
220252040009M11674Rubber tire driver hit a few potholes and felt a slight pain on EE's chest and low back. When the driver stopped to check equipment, EE felt dizzy and could not stand.
220252040011M13297Employee stated they were pulling electrical wire and slipped and fell on a rock landing on right shoulder.  Employee was pulling wire for a new construction crushing plant.  Employee said they were not injured.  Employee worked the rest of the day. Employee works half a day on Wednesday July 9th and complains of shoulder pain.
220252040012M13378EE was ball charging in the Mill. The bin became low. They used a ball to throw up into the bin to attempt to get more balls to come down. EE was wearing impact gloves. The balls started to come down and pinched their left pinky finger, causing a fracture to the distal tuft (tip of finger). Was released back to work wrapped with coban.
220252040013M11995Employee was walking from compressor to truck when they slipped in mud and rolled their left ankle. Treated and released to modified duty, no lost time, no lost wages restrictions being accommodated.
220252040014M11063EE felt pop and pain in right knee while climbing stairs and diagnosed with chronic degenerative condition
220252040015M12546Employee was walking around secondary area when they slipped falling forward. They stated that when they were falling hard hat fell off and strike their head. They had a open wound on their head and was taking to the urgent clinic for further evaluation.
220252040016M13598Silver Shaft hoist operator heard noise coming from the drum while the hoist was in operation. The hoist operator called maintenance to come inspect the hoist and they found that a saddle and both nuts on a Crosby clamp had come loose. The clamp that came loose was one of 4 extra clamps that were added to hold the tail of the rope on the inside of the drum.
220252040017M10642EE was shoveling material with a #2 shovel and felt groin pain. 
220252050002M12556EE had gotten off of the 336 excavator to turn off the crusher as rock was piling up on the belt. When approaching the crusher, EE slipped on a rock and hit EE's head on another rock when falling. EE had EE's hard hat on, but it came off during EE's fall.
220252050003M12285Employee reports EE was drilling a reamer hole when the steel shanked.  EE was contacted by an object in the shoulder but thought nothing of it.  Upon changing out EE noticed a small laceration that required one suture to close.
220252050004M11494Employee was changing roller frame and as they were trying to lower it to the ground, the frame twisted and caused a laceration to the employee's arm
220252050006M10752Material came loose from the North liner. Shutdown hoist to inspect shaft. 
220252050008M10762Work deck contacting brackets causing the production hoist to be inoperable.
220252050009M11945Miner attempted to carry 2 pallets downstairs. The pallets got caught on the handrail. Miner lost EE's footing and fell downstairs. The stairs were clean with non- skid diamond plate throughout.
220252050010M10902No contributing conditions. Miner bent over to pick up a drill bit and strained EE's back.
220252050012M11103Was replacing a lagging on belt when the metal bar slipped from EE's hand and fell forward hitting EE's cheek.
220252050016M12937At 5:02 p.m., the hoistman was raising the Service Hoist to the surface with one miner on the cage. The Shaft Crew had just finished installing a new remix on the bottom of the slickline, approximately 650 feet from the surface.  The hoist tripped out due to the electrical drive overheating. 
220252050019M10582Was pulling a pallet jack and strained their left shoulder
220252050020M11794Washing on Preheater tower Riser, as attendant was washing hot material blew back on to their hot suit and small amount fell into welding gloves causing burn to side of left hand.
220252050021M12085EE was cleaning out a scraper bowl when they slipped and fell backwards into the bowl.  EE was waiting on a doctor's appointment for follow up.  EE is now on injury leave awaiting further tests and treatment.
220252050022M11383Employee was changing out the teeth on the dredge and was using a hammer and struck their left thumb with the hammer causing a laceration.
220252050023M13698The inspection cover on the VSI was open, the employee bumped the plate causing the cover to shut. The plate struck the employee, resulting in a broken arm. Two conditions contributed to the accident (1) the inspection cover lacked an OEM locking mechanism to hold it safely open (2) the employee was new to the position and had not developed adequate safety awareness.
220252050026M12075While descending a stairway, the EE missed a step and landed hard on the outside of right foot, resulting in a fracture to the metatarsal bone. The fracture wasn't discovered until a clinic visit on 7/14/25.
220252050027M11914Employee was getting out of their truck to use the restroom and missed the first flex step and fell to the ground landing on their butt and lower back. Accident currently under investigation.
220252050028M11734While replacing a return roller, the employee loosened the bolts and the roller shifted and smashed the ring finger resulting in a laceration that needed medical attention. 
220252050029M12516Employee was shoveling dust with other employees in a tight location when they were hit on side of head by another employee causing their goggles to become dislodged.  When this happened, injured employee was exposed to dust that irritated their eyes.
220252060001M10652Miner struck thumb with a hammer while trying to unstick a valve.
220252060002M13378Employee was re-installing a bearing for a conveyor belt when EE felt something go in EE's eye. EE thought it was sand and didn't report it thinking it would flush itself out. On 7/21 employee's eye had become irritated and slightly swollen. EE was taken to MCH ER on 7/21 where a foreign object was removed. EE was given a full release.
220252060003M13698Moving the screener plant. EE had EE's finger in one of the holes and it was sharp, slicing the end of EE's finger. Left pointer finger. Was released to return to work the next day by the doctor as long as EE didn't use that hand. Company felt that was unsafe until EE had use of both hands. EE was on workman's comp until June 2nd 2025 and then returned fully to work.
220252060004M11474Employee was carrying fire extinguishers to the safety cage for inspection.  EE's elbow became sore with discomfort from lifting the extinguishers.
220252060005M11864Employee was holding a piece of angle and flipped it upside down to hold it in place to tack weld.  As EE flipped it over, EE's wrist felt a pop and sharp pain that ran up to EE's elbow.
220252060007M12055Miner strained EE's arm shoveling underneath the feeder hopper. Miner did not fill out an 801 until 7-23-25 when EE's arm hurt enough to see a doctor. The 801 was tendered the end of EE's shift on 7-23-25.
220252060008M10902EE was kneeling on left knee. When EE stood up and put weight on right knee, EE felt pain.
220252060011M10852employee was dehydrated while working and started shaking.  EE wanted to go to the ER
220252060013M12806Employee reported pain in right wrist while using a spade shovel to clean built up material in the tracks of the dozer. While chipping the material the spade hit some very hard material and sprained their right wrist. Employee was given a splint and physical therapy as treatment.
220252060014M13408Mechanic was inspecting a bolter to replace the striker bar.  The extractor and striker bar were resting on the rails when the mechanic placed their left hand on the extractor and right hand on the striker bar it rolled forward and off of the bolter resulting in a laceration and a tufts fracture to the distal phalanx on right ring finger.
220252060017M12245During loading of dollies onto the trailer, common practice to step over tongue of dolly to undo chains.  While stepping over, EE tripped and landed on the trailer deck injuring a finger.  Initial prognosis is broken finger.
220252060018M13608A loadout scale house operator smashed and caught left-hand ring finger as they were entering control room office. EE was taken to ER and followed up with an occupational doctor where they sustained a minor fracture at the tip of left-hand ring finger. The EE was not prescribed medication, nor was EE put on any restrictions and returned to work the same day.
220252060019M10792Employee walked down staircase, stepped in uneven surface rolling left ankle.  
220252060021M11704While waiting for the shift to begin the employee sat in a chair next to a cork board mounted on a wall. The cork board fell and struck the employee on the left shoulder.
220252060024M12686When doing alignment for the fan motor the rotor has to be spun. Employee was moving the rotor manually by pushing on the fan blades and felt pain in the right shoulder. THIS INCIDENT BECAME A RECORDABLE ON 7/24/25 WHEN THE EMPLOYEE RECEIVED RESTRICTIONS UPON SURGERY.
220252090001M12887Employee had a pain in EE's right shoulder after working, EE was unsure what work task caused the injury. Over the span of two weeks the pain became worse, so EE sought medical treatment. On 7/11/25 we were informed the EE was  Dx with a small rotator cuff tear. Reporting within 10 days.
220252090002M11925Employee was exiting a tool trailer onto the top of a 4ft ladder. EE lost EE's balance, jumped down and twisted EE's knee. EE sought medical treatment and on 7/11/25 EE was Dx with a ACL tear.
220252090004M10752Employee was using a utility knife to cut a piece of 6" rubber skirt board.
220252090006M11043Miner was determined to be over the 25 decibel threshold during hearing test. Sending back for retesting
220252090007M10782Miner was determined to be over the 25 decibel threshold during hearing test. 
220252090008M11283EE wiped EE's eye with EE's shirt sleeve and scratched EE's eye.EE was taken to the ER, where EE was given antibiotic eye drops.
220252090009M11063EE was washing out a screen deck. As EE was performing this duty EE felt a pop in EE's back, causing pain.
220252090011M13257On 2/28/25, an employee injured EE's right knee while unloading drums from a trailer. EE climbed over drums to access tie-downs and jumped onto the trailer bed, landing awkwardly. Initial care was conservative. PT was later tried for symptom relief. In July, surgery was required, and the employee is now off work recovering.
220252090012M13728Using grinder in mill room. After lunch returned to area & replaced conveyors. 2PM discomfort in eye & washed it w/eye wash. At 2:30PM clocked out as norm. Next morning clocked in norm for shift. Told us eye was irritated. Sent EE for medical assessment. Dr. removed small metal splinter from right eye. Splinter was residual that got into eye from wiping sweat from face.
220252090014M11303was replacing a grease line for the bearing on the Lippman impact and when EE went to turn around EE's foot was caught in grating.
220252090015M10952Employee was working on a dredge pipe, pipe moved causing injury to Left index finger and Thumb
220252090016M10341Employee twisted knee at sump pump
220252090018M11163Power failure due to loss of incoming power from city substation. Notified Cleveland Public Power to report outage. 
220252090025M10421Employee misplaced hand and smashed finger
220252090029M13107The employee sat in the passenger seat of the supervisor's truck while a CB was being installed. It was at this time the employee experienced a possible personal medical event and fell out of the truck, striking their head. This caused a small laceration/abrasion to the right forehead which involved swelling.
220252090030M10983A piece of loose material contacted the employee on the right arm and left leg. Required stitches.
220252090034M12836A mechanic was removing a driveline from a vehicle. While prying the U-joint away from the yoke the pry bar slipped off the yoke and struck the employee in the mouth. This resulted in a chipped tooth and a lip contusion.  Employee was seen by the medic and cleared to return to work.
220252090035M13267While changing out light fixture on the fuel island. The light was positioned in a way that the light was not illuminating the ground.  Once one bolt was loose, they proceeded to loosen the second bolt, and that's when the fixture containing the light pivoted in a downward manner, smashing the employee's right middle finger.
220252090038M13588MINER WAS SPOOLING IN A WINCH CABLE. EE WAS GUIDING THE CABLE WITH LEFT HAND AND CONTROLING THE FEED WITH THE CONTROLLER ON RIGHT HAND. AS THEY WERE ALMOST AT THE END, A U BOLT THAT WAS USED TO CREATE A LOOP AT THE END OF THE CABLE, CAUGHT THE CUFF OF THEIR GLOVE AND PULLED THEIR HAND INTO THE OPENING, THE U BOLT CAUGH THEIR MIDDLE FINGER AND LACERATED IT.
220252090039M13388Employee was clearing brush around electrical installations around the plant. They reported to the supervisor itching/burning eyes on 7/10. Employee rinsed eyes out and applied cooling packs but declined additional treatment. The following day 7/11 the employee was accompanied by Safety to the doctor where they were prescribed steroids.
220252100005M13097Replacement of shaker screen on the top deck of the wash plant. A torch was used to heat the bolts on the screen.  It was found that two of the bolts could be removed with an impact gun.  While torch cutting the first remaining bolt, it broke free and struck EE in the forehead under the brim of EE's hardhat.
220252100006M12866Upon performing a post blast inspection at the start of night shift, a miner identified material that had fallen approximately 50' from blast area.  Miner notified supervisor, incident was confirmed to meet the criteria of immediately reportable.  Area was barricaded to prevent entry. 
220252100007M11293Associate took off hard hat to fit in small area and when EE moved, EE cut EE's head on an edge of steel which required stitches.
220252100011M10812Employee was cutting metal when EE tried moving a piece EE felt pain in EE's arm.
220252100012M13758Teammate attempting to cut board on a benchtop in the maintenance shop. Using angle grinder, teammate worked on a section which was not properly secured. Unsecured section shifted caused mechanic to lose control of board. Holding the grinder in EE's right hand, reached out left hand accidentally made contact with the rotating wheel, resulting in lacerations to two fingers.
220252100013M13337The employee was carrying a Sib cardboard tube from the drying facility over to a shed. This was EE's first actual day on the job after completing EE's MSHA training.  EE answered with "it was bad luck." Other employees have stated that EE was complaining about EE's shoulder hurting and having troubles with it before EE began work.
220252100014M11454Miner was descending into the dredge hull when EE's foot slipped and EE fell against a piece of angle iron that punctured EE's left, front thigh.
220252100016M10582Employee was picking pallet off of floor and impaired back
220252100018M12025Was shoveling out mud out of the secondary crusher when the shovel hit the inside of the lip on the crusher causing the shovel to stop abruptly and bending their right wrist back causing immediate pain.
220252100019M11403Employee was climbing up steps of a rented loader, missed the top step, and fell to the ground injuring left hip, left knee, and left elbow.
220252100020M11293Employee burnt left forearm on take-up that was hot when trying to adjust for better position to cut bearing off PC3 tail pulley.
220252100022M11363While working on the Concrete Metso Hammers, a small piece of metal shaving impacted their left forearm causing a very small laceration.
220252100024M10161Scraper rollover
220252100026M12706EE was using a battery powered drill when the drill bit got caught on the steel causing the drill to quickly spin around.  This caused the bottom side of the drill to flip and impact EE at the top of their safety glasses, resulting in a laceration above their right eye.
220252100031M13798EE stripping motor leads with stripping tool. Cable jacket difficult to remove, so they took off a glove to use their thumbnail to peel jacket off. Gripped loose jacket with left hand, while holding stripping tool with right hand. Pulled jacket, when it broke free, left hand struck stripping tool, causing laceration. Seen at ER, laceration sutured, released to restricted duty.
220252110004M11574Employee was installing drive belts on CV22. EE was adjusting the motor mounts when EE's right index finger tip was pinched between the wrench and the mount.
220252110007M11273Employee was blowing themselves off with air hose after end of shift. Leading to foreign material getting into their right eye.
220252110008M12696An employee lost their footing while installing an access door on a chute. While attempting to prevent a fall, the employee used their left arm to brace themselves while still holding an impact wrench. The resulting force caused a fracture to the employee's left elbow.
220252110013M12345A miner was installing a ground support timber, and when attempting to reposition the timber with an axe, the miner pinched their right index finger between the axe and the timber, fracturing the finger. The finger required stitches. 
220252110014M12887Employee was helping install a plate in the top apron of the primary crusher when the plate they were holding slipped and came in contact with their neck. The plate had just been cut to fit in place and still was hot, welder was going to weld into place with employee holding it for them.
220252110016M10502Employee smashed finger removing rock from crusher
220252110020M12566Laborer was working with the vac truck and needed to cut the old hose off and add a new section. While cutting the bad section, employee was using a utility knife, cutting towards their body when the knife slipped and cut their hand, right above the wrist.
220252110022M12927Electrician was performing normal duties, troubleshooting a blower motor. It was hot in the area they were in and began to feel ill. They radioed that they needed help and when other employees got to them called EMS when they arrived they gave them fluids and determined they were dehydrated.
220252110023M11133Loss of power on surface and underground due to city outage. Reported to Cleveland Public Power (CPP) for repair.
220252120002M12205Miner was using a chair to reach an item on an upper shelf. The chair slipped out from under the miner causing EE to fall. The miner fell directly on EE's left wrist. Resulting in a fracture of EE's ulna and radius bones
220252120003M10963Employee was closing the roll up door at end of shift and some foreign material got in EE's eye.
220252120005M11664Miner was switching railcars, drove a buggy between a car being pushed and another parked, and was struck, causing EE's leg to be entrapped between the dash and seat.
220252120006M12806Production tech was removing a slurry hose for cleaning, EE had shut off all valves as well as open the pressure relief valve to get rid of excess pressure. When removing the camlock there was still residual pressure and caused slurry to spray on EE's face, chest and right wrist.
220252120007M12125Employee was cutting belting with a utility knife. The blade became hung up on the belt clips causing the knife to skip and make contact with the employees L lower forearm causing a laceration requiring sutures. 
220252120008M12395The employee was removing metal from a conveyor, and while going to dispose of it, the employee lost control of the metal object and pinched their hand between the metal and the handrail. This resulted in a laceration and a broken finger. 
220252120011M11253Maintenance Mechanic was moving 2 steel rings when they slid off of the forklift and struck the EE left leg causing contusion
220252120012M13177EE was inserting a keeper pin into the reclaimer sprocket, to prevent the sprocket from motion, so the necessary repairs could be made. As the pin was being inserted, the sprocket rolled, causing the pin to thrust upwards.  Pinching the EE's left index finger between the pin and the guard for the reclaimer sprocket.
220252120013M11744Mechanic from other operation was helping and strained their back while removing a side panel from an excavator. Reportable due to doctor prescribing prescription medication.
220252130003M13788EE was on the ground helping load a face for a shot. The EE stepped on a rock and twisted EE's left knee and fell to the ground. Work Care was called and recommended a clinic visit. The clinic did an x-ray and said nothing was broken and referred EE to an orthopedic doctor. EE visited the orthopedic doctor on 7/29 who placed the worker on restricted duty and physical therapy.
220252130008M11995After a series of self-care measures w/out relief, progressive medical treatment includes PT as of 7/31. On 4/17, emp. went to pick-up a piece of 3x3 angle iron and reported discomfort in EE's elbow.
220252130013M11253Operator was repairing skid steer attachment. EE was swinging a sledge hammer, and EE heard something pop in EE's bicep area.
220252130014M10582Employee suffering mental duress resulting from near miss.
220252130015M11133Employees has been diagnosed with "trigger finger" on EE's left index finger. EE had surgical repair on 7/30/2025
220252130017M10371Employee sustained a sprained finger.
220252130019M11433EE was servicing a pump. While doing so, the EE slipped catching their leg on a piece of angle iron resulting in a laceration needing sutures. 
220252130022M10522While walking they slipped on ice and bumped a knee.
220252130024M10812Stepping onto the steps to the cab of the haul truck and felt a pop in the groin.
220252130025M10792Dumping the truck when the load shifted to the back causing truck to roll over.
220252130026M11423Employee was driving the haul truck when they hit a bump in the road, felt back getting tight over the next 10 minutes after hitting the bump.
220252130027M13157On 07/29/2025 around 8:00 AM employee was working on the dredge loosening a hydraulic proportional control valve.  Employee was pulling the wrench with left arm and heard a popping sound.  Left forearm looks visually swollen. And they said that they have finger movement but cannot move the arm without severe pain.
220252130028M11363Employee was walking back from river pump on road, stumbled and caught themselves resulting in them placing all their weight on left leg
220252130029M12606Utility employee in ceramic manufacturing plant was responding to a plugged discharge chute to clear it. They reached up into the chute with right hand and contacted an operating rotary valve. They received lacerations to three fingers which required stitches.
220252130030M13147Employee had removed material from the Niro by raking it out of the Niro door. Employee was attempting to shut the Niro door by kicking it and sustained a knee injury. Kneecap was dislocated and employee was treated at a clinic. The kneecap was manipulated back into place and employee was put in a flexible brace.
220252130031M10421Driver fell from the top of their trailer.
220252130035M11754A fire developed under a alternative fuel (shredded tires) conveyor due to a piece of rebar accidently being added into hoppers and causing friction at the scavenger conveyor.
220252130036M11063ee was moving a diesel pump in the quarry. ee picked up the suction hose and felt a strain in their back. 
220252130037M13458Employee reached in to grab a porta power that they saw starting to slip. They put their hands in the line of fire and when the shoring spun it impacted their right thumb. Employee was taken to the local clinic where an X-ray showed an acute non displaced fracture. Employee was instructed to wear a finger splint and released to return to work.
220252160001M11935Extreme flooding event caused unexpected water in the mine. Mine is inaccessible and investigation/remediation is ongoing. No personnel allowed in mine until fully cleared to do so. NO INJURIES
220252160004M11003Tried to get down from haul truck, missed step fell on right hip and hit back of head on the ground.
220252160008M11664Employee got finger pinched by lever arm of shotgun. On 7/24 it was confirmed that the employee fractured the tip of their lt ring finger resulting in modified work. 
220252160009M12496Turned around on a catwalk and lost footing.  As falling hit right torso and right cheek on top of handrail.  Diagnosis contusion to both areas.  Was given restrictions from appt same day.  F/U appt on 08/01/2025 received "Return to Work Full Duty".
220252160010M10542The scraper fell off the push block while push pulling
220252160011M11303Employee was sawing a pc of slate, EE was carrying a scrap pc to the rubbish bin when it broke & part of it landed in EE's L foot.
220252160016M10461EE hurt EE's wrist shoveling under a conveyor.
220252160017M10612Getting out of work truck and stepped on a rock, twisting leg
220252160018M10502EE foot struck by forklift resulting in a fracture
220252160020M10712Elbow pain following manual handling of empty supersack fabric opening.
220252160024M10341Employee cut hand with razor knife
220252160025M13738During the harvest process at Tankhouse, ee had to remove a cathode, weighing approx. 152 lbs on the strongback prior to unloading. The ee lowered the strongback to approx. shoulder height to detach the cathode by removing the hanger bar. The loop failed and broke off, landing on the ee's foot. EE sustained a fracture and laceration. Received stitches and taken off work.
220252160028M13368Miner was lifting a roll of rubber hose into box of ORV and felt something pop in their arm.  A co-worker helped them remove their coveralls, they were in a great deal of pain so the supervisor transported them to the local ER. Miner was examined, and an MRI was performed confirming a torn bicep muscle.  Surgery is required to repair.
220252160029M13317Employee was cleaning a drain trough. when they went to replace the grate (80#) over the trough, they felt a strain in left shoulder. Reported to supv. Contacted clinic, who advised RICE and OTC ibuprofen. No restrictions at that time. At follow appt. 5/28, placed employee on weight restriction R arm- first day restricted 5/28/25
220252160030M11464Crew at the 1600 crusher plant were adjusting a motor . While the adjustment was taking place a washer from the motor struck the employees finger.
220252160032M11163Employee was hosing the ground under the catwalk and a 3/4" rock fell from a pile and struck them on their shoulder.
220252160033M11373Maintenance worker was trying to fix a water pump, and tried to remove the Allen screw and instead moved the pulley and sliced left palm.
220252160034M13568While exiting the CAT 980 loader, employee was using 3 points of contact and facing the machine as required. During the descent, they believed they were on the last step and attempted to place a foot on the ground.  However, they were actually on the second to last step and missed the final step, resulting in a fall to the ground that rolled their ankle.
220252160035M13297EE was removing a schedule 40 elbow while standing on scissor deck. The elbow came down on their hand, pinching left ring finger. EE was seen at the ER where the cut was sutured and EE was released to full duty. The EE initially reported that they tripped and fell, but this was untrue. EE issued an amended statement on 7/30/25.
220252160036M12897EE was cleaning the inside of light vehicle. While wiping down the back of the seat, a wire poking out of the back cut their right hand. EE was seen at a clinic, diagnosed with a laceration to the right palm, closed with stitches, released with restrictions that do not preclude full duty.
220252160039M12786After conveyor did not start, Employee went to check the reset button on the electrical panel.  When they bent down to see it, their hand was close enough to the panel that they believes sweat dripped from their hand and electricity jumped from panel to their left pinky finger.
220252160045M12215While disassembling a gear box from a super stacker, it was in park postion sitting on a pile of material, went to pull it off the shaft, when it fell it struck the employees foot rather than going into the loader bucket.
220252160047M11173Employee was cleaning out discharge end of quencher and hurt their ankle in the process, tripping over clinker balls.
220252160049M12085while sitting on their tool chest and not noticing the lid was not closed they placed a hand on the side of the lid and when their weight shifted the lid closed on their hand causing a laceration to a finger.
220252180002M12075Employee was attempting to get an ore bin to feed by poking the feed with a metal bar.  EE accidently hit a support beam with EE's hand pinching EE's finger between the beam and the bar and causing a bruise.
220252180003M11584Employee was weed-eating near the scrap metal storage area. EE tripped and cut EE's right palm on an aluminum truck fender. The laceration was sutured closed.
220252180004M11133Employee was using the elevator to go up to the 12 pack when the elevator stopped due to a limit switch failing. 
220252180005M10692Employee stepped incorrectly and sprained/strained their right ankle.
220252180006M11975Employee experienced muscle strain in upper forearm/elbow from repetitive use. Employee does not recall any one indecent/accident and feels the strain is from repetitive use of shovel and lifting. 
220252180007M11253Employee reports muscle spasms in lower back due to repetitive use of shoveling and bending, employee diagnosed with strain. 
220252180011M11293Employee sustained and unknown injury to the left forearm while manipulating a lifter bar from the inside of the #1 Balling Mill.
220252180014M12796employee was pushing a welding cart across the shop. one of the wheels fell into a  low spot/crack in the concrete causing the cart to tilt. Employee reactively reached out with EE's arm to try to catch it in case it fell and felt a strain in EE's shoulder. cart is appx 100 lbs.
220252180015M11774employee was using a long pry bar to hit the side of the chute to help clear the built up stone. EE was twisting while struck the chute and felt a sharp pain in EE's lower back.
220252180016M11413ee was moving a trash bin/dumpster out of travel way and slipped/tripped on steps resulting in ee falling and landing on buttocks/lower back.
220252180019M13448Employee was opening the manual slide gate on the clinker silo with a ratcheting wrench. They applied pressure to the wrench and the ratcheting mechanism wasn't fully engaged, allowing the wrench to slip and smash the employees ring finger between the wrench and the feeder structure. Employee was wearing leather gloves- 4 sutures in fingertip
220252180021M13538Became reportable on 7/28/25 when employee had hernia surgery. Employee was attempting to put return roller back into bracket by raising the roller with their legs. The roller then came out of the bracket on the right side and fell to the ground. The employee jerked their legs when the roller came out and they felt instant pain in the left groin area.
220252180022M12345Employee was attempting to open the service truck door. The door latch was stuck and the employee forcefully pulled on the door causing it to spring open. After the door sprung opened the employee noticed some soreness in their wrist.
220252180023M12005An employee was working on a diverter gate when the gate released residual pressure and made contact with the employee on both their hands and chest. This incident is under privileged and confidential
220252180024M13628Employee was using hammer when they felt discomfort in RT index finger. Received first aid treatment from a medical pro. on 7/30. X-ray conducted on 7/31. On 8/1 results communicated to employee, metal was removed, stitches were applied, and prescription was prescribed. Employee was released to full duty with no restrictions and a follow up to remove stitches.
220252180026M13357Employee overheated while lacing conveyor belt, claimed they got dizzy and sat down beside the conveyor road, did not communicate to anyone and called 911 themselves! Employee ate and drank throughout the day.  With a group of co-workers all day including the supervisor to allow breaks (water, shade, cooling) due to the extreme heat.
220252180027M11113The employee was performing routine preventative maintenance on a transformer when EE was fatally electrocuted.
220252180032M10973Air lance struck an employee in the forehead causing a laceration that required several stitches.
220252190001M11203Removing belly pan and it slipped when it came loose causing a laceration on index finger requiring stitches to finger. 
220252190002M13007Employee had just finished lunch and begun EE's normal job duties. While working from EE's desk EE experienced severe lower abdominal pain. EE notified EE's supervisor who then notified the General Manager. The General Manager placed a call to request an ambulance. EE was then transported to the ER.
220252190003M12385Employee was operating skid steer to dump trash bucket full of stone, bucket hit hard when coming down, piece of stone fell out and landed in employee's lap across right knee cap. Knee is swollen and has limited mobility due to swelling. 
220252190007M11654Employee struck the back of EE's left hand on metal supporting structure while ascending stairway.  Resulting in a fracture to the third metacarpal of the left hand.
220252190008M11243Miner was loading trash pallets into trailer, one fell back and hit left wrist and then pulled on arm straining left shouder
220252190009M10562Mined was operating street sweeper and jarred lower back
220252190010M13317Employee was cleaning catwalk and turned sending intense pain to EE's foot/ankle area making it hard to move and walk. Employee has had foot discomfort on left foot for a couple weeks and never told anyone. Employee was seen in ER, was given an injection for pain, and taken out of work for 1 day. EE was diagnosed with tendonitis.
220252190012M13057Miners were changing a conveyor belt on a hopper feeder.  Miner lost EE's footing and fell into the side of the hopper. A sharp piece of plastic from the hopper liner cut EE's forearm.  Miner finished the shift with a bandage and received nine stitches that afternoon.  Returned to work the following day.
220252190013M13267EE dumped a portable dumping hopper. EE was returning the dumping hopper to its upright position. EE had hand in a pinch area. While pushing down on the top edge of the hopper EE's hand/fingers were pinched between hopper and forklift load backrest . X-ray was negative. EE was put on restrictive duty by medical professional.
220252190014M10542Employee was walking, slipped, and broke thumb on rock
220252190015M11063The employee was tightening bolts on a compressor using a wrench when EE felt pain in EE's right shoulder.
220252190017M13247When working on mill chute EE turned to pick up tool, slipped and fell resulting in bruises and soreness. EE was seen by Dr., released w/ no restrictions on 7/24. Fllw up w/ 2nd Dr. on 7/29 released w/ restricted duty for lifting & tugging.EE has fllw up Dr. week of 8/4. EE has history of back problems prior to employment.
220252190019M11033Contractor employee was tightening bracket on the pulverizer when they felt their right thumb pull back
220252190023M12696While using a high pressure Jetstream system, the water/air did not completely dead head upon releasing the foot pedal controlling flow, the wand in use became dislodged from port of preheater and stream struck employee on the back of the left leg (knee and calf area).
220252190025M10983Employee's annual hearing test determined they have a Standard Threshold Shift in their right ear.
220252190026M10902Maintenance Mechanic was descending steps when they slipped and broke Fibula in Right Leg.
220252190028M13638Slurry pump B feeding the wash plant, plugged. After shutting down, the technician opened the pump drain on bottom of the pump housing. Due to the head pressure, water sprayed out of the drain. Since the pump was plugged, the water was extremely hot, burning the technicians arm. The technician was treated for second degree burns on left forearm at the hospital.
220252190029M11945EE was getting out of the forklift, they extended their arms up when they felt a pop in their lower back.  Supervisor was not on site and the communication misunderstood in regard to the injury.
220252190030M11945Two employees going against lockout/tagout policy to remove pieces of shredded belt on 3/4" conveyor belt resulting in a deep arm laceration that required surgery to re-attach muscle and tendons
220252190031M10271Stress of repetitive motion
220252200001M11333The employee was walking across the roadway underground to a power center to turn off a fan when EE rolled EE's ankle and felt a pop.
220252200003M11063Employee was pulling electrical wire in an awkward position when EE pulled a muscle in EE's left shoulder.
220252200004M13778Employee was helping to steady a machine pin while being struck with a hammer.  Employee was struck on the hand, which caused bruising and swelling.  Employee requested medical attention on the following day.  The clinic (Concentra) found a "crushing" injury to the hand, with a negative x-ray for fractures.  Employee was ice and ibuprofen, and a follow up for therapy/review.
220252200006M12536Worker was moving a knife valve in a the IT basket when the end of the chain EE was using fell through a grate. The IP attempted to readjust the knife gate by lifting and tilting it to unstick the chain when the worker felt a pop in their left shoulder.
220252200007M10912Employee received bruising on foot from lock ring striking it - became reportable 7/25/2025
220252200008M10912Employee's foot fell into sump dump causing discomfort in leg - became reportable 7/24/2025
220252200013M12085While dumping dirt from a 775 haul truck, the bed lowered rapidly and jostled the operator in the cab, causing what was diagnosed as cervicalgia.  However, they did not report the incident until 28 July 2025.
220252200015M11123A crew was cleaning the roofs above 9/10 kilns. While scraping the roof, wind blew material into employee's eye.
220252200021M13327Supervisor noticed smoke in the alternative fuel storage pile, instructed a loader operator to move some material to get to the smoking pile of material. The material was subjected to the atmospheric conditions, it was oxygenated, igniting the TDF. Local fire department was contacted and arrived on scene and extinguished the fire.
220252200022M13778Employee was wearing a full silver hot suit, pants, jacket and hood. While removing a hopper of hot kiln inlet feed from the discharge area, The pant of the hot suit raised above the employees boot due to the seated potion resulting in hot material in their boot resulting in a burn to the left foot arch area.  The employee also got dust in eye when they hastily removed hood.
220252230003M13808Employee was driving company unit L-27 mini loader when the right window swung open, then swung back and shattered causing glass to go all over employee causing minor cuts on right arm and hand. On 8/7/25 EE noticed EE's right hand was swelling up. EE reported the accident on 8/8/25, and went to urgent care. They put EE on antibiotics and gave no restrictions to return to work.
220252230005M12506EE was shoveling up a pile of salt by the crusher toward end of shift. EE's back started hurting and became worse over the next few days. EE went to DR 08/08/25 was given pain meds and placed on light duty. EE returns to DR in 1 week for revaluation.
220252230008M13237EE was installing buckets on an elevator when the EE's right hand slipped off the bar causing the bar to fall. When this happened the EE tried to catch the bar as it was falling and it ended up smashing EE's middle finger on EE's right hand. This injury resulted in the EE having to get five stitches in EE's middle finger.
220252230009M13307An employee was standing on VIS Crusher, trying to unclog/clean unit. The employee was holding a 1-1/2" water line, awaiting it to be turned on so that they could wash the clogged VSI. When the water was turned on, the employee lost their balance and fell onto the deck below EE, approximately 4.5 feet below where EE was working.
220252230010M13558Parked/unattended CAT D10 dozer was positioned on the coarse ore stockpile. The material beneath and around the dozer gave way, causing the machine to slide down into the coarse ore stockpile feeder area. At the time of the incident, no operator was in the cab, and no personnel were in the immediate vicinity of the sloughing event. No injuries reported.
220252230012M12145Employee was exposed to <2ppm of SO2 with caused throat  irritation. and agitated a preexisting condition unrelated to the mining environment.  Was treated at the onsite clinic. Prescribed an inhaler for treatment.
220252230013M13368While performing a normal task that involved pulling a hose using a specific tool ( Fork). The task required prolonged physical effort over the course of several hours, a blister developed on the operators right hand from repeated pulling motion. The blister became infected, requiring treatment from the onsite clinic with antibiotics.
220252230014M12145EE was walking in GEHO Sump area #1 when left foot slipped on a small rock causing EE to lose their balance and putting full weight on the left foot on the ground surface. This cause a left Achilles tendon rupture.
220252230016M10492EE was tightening a bolt and felt a pop in elbow.
220252230017M11894Team member installing new exhaust gaskets, bolting up the flanges when debris fell onto and behind safety glasses, into right eye.  Flushed eyes at the shop, debris remained behind eyelid.
220252230020M10902Employee was helping to get a blade unstuck and when it slid in mud and jarred their back.
220252230021M12165Employee was using carpenters knife to cut grease line when the knife slipped off the hose and cut left thumb knuckle. Did not require stitches, was placed in a splint to immobilize due to the location of laceration.
220252230022M12616EE was driving a T-post to anchor the dredge along the berm. When the T-post driver was lifted higher than post, upon downward strike the EE's hands were caught between the post and the driver. EE stated they were not wearing gloves at the time of the incident.
220252230023M11043Mechanic was adjusting blow bar and small piece of metal flew off blow bar and struck Mechanic in chest.
220252240002M12275EE states while moving a manlift from the operator's basket EE sustained an injury to EE's mouth. While the machine was in motion, EE hit a hole in the roadway resulting in a bounce causing EE's mouth to contact the man basket.
220252240003M11594Employee suffered minor hip and arm pain, due to rolling down from the top of a railcar while wearing fall protection. Employee came into contact with railcar.
220252240005M13197The Operator was loading a truck out of 8 silo.  EE attempted to hold the hose and ladder simultaneously.  Employee shoe slipped and gate sprung back into its original position. This resulted in a strained shoulder. EE was given instruction to take over the counter medication, and not to lift anything over than 10lbs.
220252240006M11123Loss of power due to transformer issue at neighboring business. Notified Cleveland Public Power (CPP) of issue. 
220252240008M10301Employee suffered hearing loss
220252240011M12937Employee was moving a mobile crusher when, after hearing a pop from the tracks, a sliver of metal struck them in left cheek causing them to bleed. Witness quickly applied a nearby rag and drove them to the hospital where the metal was removed, the wound was cleaned, and stitches were applied.
220252240012M10772Employee was working on air grease gun and line blew hitting them in the eye.
220252240013M12596An employee was attempting to clear a blockage in the dust collector chute. While reaching in to free a pole that was being used, the employee's glove became entangled in a rotating component of the equipment. This resulted in the amputation of three fingers.
220252240014M13448Using a cylinder hand cart to move a helium gas cylinder to the lab. Cart wheel caught a rock and stopped rolling. IW's momentum caused them to tip over the cart forward and left hand was pinned between the cart and metal grating. Left hand had a small diameter but deep laceration that required stitches to close. No lost days or restrictions.
220252240015M11814While operating the Caterpillar 988H loader joystick shifter and engaging the gear selection buttons the employee sustained a strained tendon at the base of left thumb in palm area.
220252240016M11814Employee was working with another employee trying to remove a pin holding the hydraulic cylinder on a rock hammer. The employee requested to seek medical attention on August 6, 2025
220252250004M11764Employee was disconnecting a 4" water line from the water truck when the water line flew back and made contact with the employee's mouth, cutting EE's lip and chipping a tooth.
220252250006M11634Employee was hosing a conveyor from a water truck.  EE was driving the water truck back to the garage when EE felt a sharp pain in the left shoulder on EE's back .
220252250010M12035EE was lifting 10 pound pipe when EE felt a pull and pop in right wrist on 1/13/25. At the time it required no medical attention. The company was made aware on 8/5/25 that EE requires surgery for injury.
220252250011M11103While the employee was working on the hopper area, supposedly a rock felt and hit EE in one of EE's shoulders.
220252250013M10792While working with a shovel in the plant area, EE felt a sharp lower back pain.
220252250014M11263Exiting water truck when knee gave way and lost footing.  Heard and felt knee pop out of place and could not put weight on it.
220252250015M10892Employee injured their ankle after falling approximately 3.5 feet off of a fixed ladder. 
220252250016M11814EE was traveling between number 2 and number 3 kiln at ground level when they slipped and fell. This fall caused their left leg to bend back under them and caused pain to left knee.
220252250018M11423EE was adjusting screen rail using a wrench. wrench slipped and hit them in the mouth. EE was referred to dentist for extraction and grafting.
220252250021M13668EE was working in center of track dozer replacing hydraulic hose. Describes being in awkward position, bent over, and then standing up and feeling shooting pain and having their back "lock up" when trying to stand up. EE has long history of back pain, with surgery and injections. Currently treating for this. Put on restrictions site cannot offer modified duty for.
220252250023M13107Was shutting off water pump after filling the water tuck. Was walking back to the truck, stepped on a rock, which caused them to stumble, they felt a pop and had some pain. Told a supervisor about it, thought they had sprain an ankle. As the day went on the pain became worse and they sought medical treatment.
220252260001M10902EE stepped backwards in JLG man basket, heel came down on a piece of strut, injuring heel.
220252260002M11474The plant operator was working with EE replacing a bearing at the head pulley of the sand stacker when EE cut EE's index finger on EE's right hand.
220252260003M10682Employee strained EE's wrist while changing out a bag in a baghouse.
220252260004M10973Miner was attempting to move a unit of wire panels by hand.  Afterwards felt discomfort in back. 
220252260005M13758EE was operating an 850 Hitachi Excavator in our Marblehead Pit. The employee noticed the engine compartment door had swung open. While walking on the catwalk to close the door, one end of said catwalk broke loose causing the EE to fall to the ground. EE struck EE's head on rocks below which caused a broken orbital bone, broken nose, and loose tooth, with head lacerations.
220252260007M12416EE jammed EE's finger while slamming the e-stop in the drill rig after EE had hydraulic hoses burst. EE also caught it in the metal loop on EE's wheel chock within a 20 minute time span. EE's thumb started bothering EE later in the afternoon
220252260008M12476While working on 1-1/2 # 2 screen. Employee slipped inside chute while unbolting old skirt. Employee used right arm to brace self causing injury to upper right arm/shoulder area. Employee did hit floor. No subsequent injuries due to hitting floor.
220252260009M10512EE's eyes burned after welding the portable hopper.
220252260010M12566Injured worker suffered a right hand injury while EE and a second worker were drilling out a piece of rubber conveyor belting.   Injured employee required four stitches to close wound, and was released by Urgent Care for return to light duty work same day.
220252260012M11313Employee was aligning a pump and felt a strain in their left shoulder. Doctor placed them on restrictions on 8/12/25 pending a MRI.
220252260013M13177A plant Mechanic employed by Concrete Supply was using a prybar to lift the side of a belt to place a roller and guard.  Holding the bar in position their shoulder popped and suffered a shoulder subluxation. Their arm is mobile but very sore. Sent to orthopedic doctor this afternoon to see if more damage was caused.
220252260014M13217EE was chipping concrete while in a batch truck. After they got out of truck, they felt stinging sensation on buttocks. They had somehow gotten cement material in underwear/under clothing causing burn to buttocks. Seen at Health, referred to ER for removal of cement. Released to restricted duty, working restricted duty.
220252260015M13388EE reports hoses being used in work area changes out to slightly heavier hoses. EE reports shoulder pain beginning over one month prior to seeking treatment. Reports pain in shoulder that was surgically repaired on 7/31/24, however they were released full duty effective 5/1/25. EE diagnosed with L shoulder pain due to cumulative trauma.
220252260016M13147EE was getting numbers off a piece of equipment when coworker approached them from behind.  Saw them and was startled, causing them to jump, landing awkwardly on the grating, and rolling right ankle. Seen at medical, diagnosed with a sprained right ankle, and released to restricted duty which employee is working.
220252260017M11494While swinging a sledgehammer at a wrench, the wrench slipped off the nut, causing the handle to come back and strike the left side of the EE's face.
220252270001M10522Laceration to left leg from contact with angle iron.
220252270006M12586At approximately 5:20am, while employee was conducting routine cleaning of spigots; a spigot came loose. This resulted in caustic contacting the right side of the employee body (right eye, right arm, right chest, right lower side of back, and right buttock).
220252270009M11574EE was operating a loader while working on a ramp in the plant yard.  The bucket was fully loaded, and fully raised when the loader tipped over on its side. 
220252270014M11504EE was pouring hyd oil into a crusher console when they tried puncturing a hole in the lid to increase flow, the knife folded cutting their right palm
220252270017M10451CLEANING/DIGGING ROCK OUT OF THE CONE CRUSHER
220252270018M13768Two employee's set the wastewater collection box on a steel plate to copy the bolt pattern to the plate for use as a cover for the other side of the Log Washer. Injured was squaring up the box on the plate when the lid swung down and smashed the tip of right index finger. At the hospital they found bone fragments missing. The finger nail was removed and they stitched it up.
220252270019M10942Employee was attempting to remove a wheel hub assembly when they felt a pop in their shoulder.
220252270020M13237As the employee was stepping out of the raw mill, the employee placed a hand on the raw mill tire hook and disrupted the accumulated dust causing it to become airborne. The airborne dust entered the airstream of the cooling vent fans and blew onto the employees face and under safety glasses causing dust to enter left eye.
220252270021M11714The employee was installing blades on a shredder in the resource recovery area. They slid a blade onto the shaft and pinched their finger between the blade and the spacer.
220252300001M12997Employees were using a come-a-long to move a water tank over a few inches to sit in place properly.  EE walked up on the job to give assistance. The chain that was around the structure's leg broke, striking the employee in the left eyebrow area.  EE received 3 sutures and was released to full duty.
220252300002M13297Miner picked up can of break cleaner out of service truck walking to back of truck and slipped on some rock causing miner to start falling.  Miner reached out with right hand to stop fall causing break cleaner can to hit rear bumper of truck.  The can exploded in miners hand causing lacerations to EE's index and middle fingers.
220252300003M10792EE injured EE's right wrist while shoveling; the shovel hit a rock in the dirt.
220252300005M12826Employee was cleaning the coal elevator and EE dropped EE's hammer into the elevator.  EE removed the lower access panel to reach in and retrieve EE's hammer.  When EE reached in, the control room operator started the elevator.  The employee received abrasions on EE's left forearm.
220252300008M12566On 8/7/2025, Mill control stated that an employee was stuck in the east freight elevator at the mill. MSHA was notified and at 1:06 pm the EE was freed from the elevator. Elevator company was dispatched to scene and freed the EE. Investigation is on-going.
220252300014M12596Third party temporary laborer hit their hard hat on the frame of a conveyor in the central crushing area. The impact resulted in a neck strain. this was not reported until the 12th, at which time the laborers company (ICR) sent them to their industrial clinic
220252300015M11133While working, the employee experienced pain in groin area. A doctor's examination identified an inguinal hernia.
220252300022M13458Weather: rain. Operator was exiting wheel loader. Operator missed last step on loader ladder causing them to fall backwards. Operator sustained laceration to head requiring two staples, laceration to right elbow requiring two stitches, laceration to left elbow requiring one stitch. Operator was seen at emergency room, not admitted to hospital.
220252310001M11714Employee tripped on a beam and reported sore pain in ankle and calf, at initial report thought to be a sprain. Later in the week, employee was diagnosed with leg fracture.
220252310003M10772Employee was exiting haul truck and missed the last step, causing EE to fall.
220252310008M13788While collecting material left over from a completed shaker screen change, the employee (EE) was in the process of moving a steel plate to be taken down from the tower. During the movement, the plate shifted unexpectedly and pinched EE's finger between the plate and the catwalk. The employee reported that EE removed EE's glove and noticed bleeding from the tip of EE's finger.
220252310013M12556EMPLOYEE WAS EXITING OUT OF SURFACE RECLAIM TUNNEL, BETWEEN THE STAIRS AND EXIT, TURNED RIGHT AND FELT PAIN ON THE INSIDE OF THE LEFT KNEE. THIS HAPPENED ON 05/19/2025. EE WAS NOT PLACED ON LIGHT DUTY.   EE HAD SURGERY ON 08/12/2025. EE IS NOW LIGHT DUTY.
220252310015M11764ee had just finished breaking a slab into blocks. ee was putting a Retractable back in the storage box it hit the top of the box causing it to come down and punch their finger.
220252310017M12395Employee was preparing to remove a tire on an articulating truck, and when placing the bead breaker in position, caught the tip of index finger between the bead breaker and the rim of the tire. Lacerated finger, requiring sutures to close.
220252310018M11995Miner was dismounting an excavator to help fuel. Miner placed right foot on the ground first not seeing a stone covered with dust. Miner rolled right ankle which resulted in a fibular ankle fracture.
220252310019M12836During cell maintenance, employee was in the process of repositioning lead anodes back into the cell when one shifted, pinching the employee's right middle distal between the anode and another surface, degloving their fingertip. Employee was seen by an orthopedic and taken off work.
220252310020M11263Employee stepped in the inlet side of the cell at the tank house. They fell forward and injured left wrist and right shoulder.
220252310021M12826Employee was cutting off excess threads on lacings to the underscreen belt. Employee was on their knees reaching up to the lacings with the grinder. When they came out from under the screen and stood up their back seized up from being in a awkward position resulting in back strain.
220252310023M10752Employee was exiting a Bobcat Skidsteer loader and rolled their left ankle.
220252310024M13438The employee received instructions for positioning and the order in which they were to perform drilling pattern. Employee positioned the outrigger in a position where the weight distribution was against them and when they adjusted position, the machine shifted causing the employee to suffer a bruise to left toe, left ankle and right shoulder
220252320003M13277Two trespassers were on site early in the morning and one male fell off the highwall from the level above. They were treated at the scene and left via ambulance. The immediate report hotline was called when we were made aware that the injuries were potentially life threatening. Extent of the injuries are unknown at this time.
220252320004M13087Miner was replacing drill bit on production drill when a metal piece chipped off a hammer they were using. The miner was treated with first aid. Later miner decided to have the metal flake removed from their leg and underwent removal procedure on 08/04/2025.This is being reported as a removal of the object.
220252320007M10902Finger got caught in a lifting cable while EE was attempting to lift up a saw floor track.
220252320009M13808Two employees setting up conveyor belt. They turned it on to check alignment. There was material still in the plant. A large rock on conveyor belt began to roll back towards employee, then made contact, causing abrasions & bruising to EE's neck & upper back. Employee was taken to local emergency room & released. Follow up with local clinic on Monday & placed on restricted duty.
220252320010M11484Employee alleges EE was replacing some belts using a pipe wrench and EE missed the handle smashing EE's right pinky finger.  EE received 3 stitches.
220252320013M11113Employee was stepping over a wash hose and caught the heel of EE's boot causing EE to fall onto EE's left knee.
220252320014M13057In the process of moving a pallet of rollers, one of them shifted and fell off the pallet. As the employee was attempting to get the roller back in position for the backhoe, it landed on EE's foot. EE sought medical treatment on August 18, 2025 and was diagnosed with a fracture and released to full duty.
220252320017M11444Electrician modifying a threaded nipple with portable bandsaw for conduit installation to transformer and lacerated EE's right middle fingertip.
220252320019M11694While removing the metal storm drain grating near warehouse employee felt a slip/pain in my lower back. Employee did not report the incident to management till 8/11/2025
220252320020M11153a miner was struck in the head from a falling object from a worker dropping screen material accidentally from above
220252320022M13728At 23:50, IP supervisor called to notify EMT of a minor medical. IP arrived and stated that on 8/5 at 06:30 while riding the shuttle up from Park at Lark, they felt pain and described the feeling like a bee sting in lower left abdomen between left hip and belly button which had been gradually worsening throughout the day. IP was referred to ER for further level of care.
220252320023M11834Employee was cleaning the right side windows on the outside of a Komatsu WA500 front end loader, when they fell from the top of the loader and landed on the ground next to the loader.
220252320025M11524Employee was diagnosed with a standard threshold shift by doctor on 08/12/2025. This hearing loss is consistent with noise induced loss in the left ear.
220252320027M12205There was no known event that caused an injury. the employee went to their own doctors because they thought they had appendicitis and turned out to be a hernia that was later determined by the doctors to be work related.
220252320028M11704Miner was going to wash the window of the CAT352 and when they stepped outside the Phoenix Plant they lost footing causing them to slip down landing on their right elbow.
220252320029M12716While lifting the lump basket from the loading opening of a bulk pneumatic trailer FLW experienced a "pop" in the center of the back. Continued working until about 10:00 AM until they determined they would require medical attention. Diagnosed with a "lumbar back strain".
220252320031M11544While installing a dag the chuck on the jackleg come loose bringing the jackleg back toward two miners. One miner was struck in the cheek with the jackleg
220252330003M12626An UG haul truck operator injured EE's back while dumping CRF material into an underground CRF bay. While the dump bed was raised up, it scraped the "back"/roof of the CRF bay, causing the cab of the truck to lift off the ground and then fall back to the ground.
220252330005M12616While attempting to loosen an air hose on a rail car with a 24" pipe wrench FLW overexerted self and irritated an existing condition. Incident resulted in a sprain/ strain injury to the right arm requiring modified duty work restrictions. Follow-up is required.
220252330009M11293While trying to access the 2nd deck of a 3 deck vibratory screen, employee slipped on a wet surface and twisted their right knee.
220252330012M10722Laying on right forearm when felt a pop in right shoulder while welding.
220252330013M10993While welding grating the bin over flowed dropping a small rock into the hood contacting right eye.
220252340001M13498EE states EE's hand was smashed by an unknown object when assisting with removal of welder from truck bed. EE stated on 8/7 and 8/8 that EE did not wish to seek medical treatment and no signs of injury were present. EE also stated that EE had previous injury to the same area of EE's hand. EE left site and sought treatment 8/9/25. EE resigned 8/20.
220252340002M11063EE slipped and fell and cut EE's right forearm. It required 6 stitches and EE was placed on modified duty.
220252340004M11504EE was clearing a chute over the feeder. When the material broke loose, the bar EE was using was forced up against an I-beam crushing EE's left thumb.
220252340008M10411Hand was caught between pry bar and motor
220252340009M11444Employee cutting underneath of catwalk on CAT 777 haul truck with 90 degree air die grinder cut top of left hand. Cut resulted in five stitches.
220252340010M10932Employee had a lid come free and had lime hit EE in the face, causing lime in the eye injury.
220252340014M10391Employee was walking and twisted ankle.
220252340015M12065EE was getting out of EE's excavator and slipped off the machine. EE tried to catch self and fell to the ground. EE's arm and shoulder started to hurt. EE was taken to be seen at a local urgent care clinic.
220252340017M11554While cleaning material up from a completed job a part that was unsecure moved striking the left middle finger tip causing a laceration requiring stitches.
220252340019M12365EMPLOYEE WAS USING A SPUD WRENCH TO BREAK A BUTTERFLY VALVE LOOSE WHEN IT MOVED UNEXPECTEDLY CAUSING THE EMPLOYEE TO CATCH A FINGER BETWEEN THE SPUD WRENCH AND THE HOUSING OF THE RSV.  THIS SPLIT THE FINGER OPEN AND IT REQUIRED STITCHES
220252340021M10912Tripped over ultra vac hose and used left arm to brace themselves.  Felt a pop in shoulder.
220252340023M13247Process attendant showed signs of heat exhaustion, including feeling hot and a headache when trying to unplug the kiln feed elevator with an air lance. They came down to the ground and their symptoms worsened, prompting EMS response. Employee was treated with an IV, diagnosed with heat exhaustion and released the same day.
220252340024M12686EE was providing a site tour to auditors. EE was walking out of the man van and twisted an ankle without feeling pain. EE notified supervisor was treated and released. On 8/13/2025 they were diagnosed with a nondisplaced microtrbecular fracture. EE was also issued PT.
220252340025M11353EE reported neck/back pain. States it is due to the bouncing of the dozer while operating. It has gotten worse overtime. Chronic issue.
220252340026M12395A Production employee was carrying a ladder across level ground when they stumbled and fell. They dropped the ladder and put their hands out to try and catch themselves. The impact with the ground caused a radius fracture of the left wrist
220252340028M10642Mine Ops Employee experienced heat dehydration/heath exhaustion.
220252340029M10802HT135 Operator pinched/lacerated finger by stuck/malfunctioning boarding ladder.
220252340030M12395Employee was attempting to cut a small diameter hose with a grinder.  The hose was coiled and when the employee cut through the hose it un-coiled and forced the grinder into their thumb causing a laceration that required approx. 5 stitches
220252340031M10502Employee rolled left ankle resulting in a fracture
220252370001M12195EE was performing site maintenance, driving a skid steer, when EE went to exit EE felt pain in EE's lower left back. Employee sought medical treatment on 8/18/25, where EE was ordered to do PT. Reporting within 10 days.
220252370003M11884Employee was working, trying to remove a "used shelf" from a scrap metal unit located in the dumpster at the secondary plant. When the shelf loosened, it moved and their finger got caught.
220252370008M11313Process operator received a right pinky injury when a pipe wrench fell from a worktable. This incident caused a restricted injury. 
220252370009M133472 MTMS were removing the outboard bearing on a dust collector. To free the bearing from the taper lock, the injured was using a 3lb. hammer while EE's partner held a chisel in a chisel holder against the bearing. During this process a piece of the chisel broke off and struck the injured resulting in a laceration to the left forearm.
220252370010M11053Employee was struck by foreign object in the eye during maintenance. Foreign object was removed from eye.
220252370012M11764The employee was operating a manlift and changing out a return roller. When EE turned the basket, EE caught EE's fingers between the rail of the manlift and conveyor structure.
220252370013M10241Employee was dehydrated 
220252370016M11063Affected employee was cleaning out #5 Mill feeder and injured EE's elbow (elbow contusion) in the process.
220252370017M13528A Fixed Maintenance employee assisting with re-installation of a return roller for a conveyor belt. While lifting roller back into position, the supporting bracket weighing 7lbs - 10lbs slipped out of place and fell approximately 29 inches. Bracket struck the back of the employee's left hand resulting in a fracture of the 4th finger on the left hand.
220252370019M10371Hearing test exceeded the 25 Theshold
220252370022M12616Employee was attempting to lift elevator door on man elevator and door stuck which caused EE to strain EE's back. Was still working at full duty, became a recordable on August 20, 2025. Prescribed medications and also limitations. Able to work with limitations.
220252370023M13648The crew was using a sky track with a man basket in an area where a conventional manlift could not be used due to ground conditions. While positioning the boom, a pinch point existed between the man basket and sky track backplate rack. The employee was unaware, and as the boom was raised, the basket shifted, catching and injuring fingers, requiring five sutures.
220252370026M10512Guard fell off cut right forearm required 8 staples
220252370028M11634Employee was using a hose to spray pump, employee was putting the hose away and their leg went through the hole on the grading causing leg abrasions and sore back.
220252370029M11674On 8/12 employee was descending tower stair case and slipped on step and twisted lower back. On 8/19 it was brought to our attention as they wanted to seek treatment .
220252370030M13728While EE was in the process of fueling an underground diesel mantrip, EE had stepped off of the vehicle, lost balance causing them to trip and injure right ankle. EE was taken to an offsite clinic for treatment & x-ray. The injury has been determined to be a severe sprain/strain to Right Ankle. Restrictions as follows: No walking on uneven surfaces and seated work only.
220252370042M11914A miner was operating LR 6507 in N2D loading muck cars. As they proceeded to dump a bucket ore into the muck car the park brake set causing them to hit their head off the window of the loader
220252370043M13207Employee placed hands on the fork of the hydraulic bowl adjustment ram in an attempt to free it and reposition it.  Another employee actuated the hydraulic cylinder of the ram, and it retracted before the employee could move a finger out of the way.  The tip of ring finger was crushed between the fork and the cylinder.
220252370045M13758While on ground level, the EE reached into an excavator for a hoodie, lost footing, and grabbed the handrail, injuring their left elbow. Sought treatment the same day and returned to work with restrictions that did not affect regular job duties. An 08/15/25 MRI showed a left triceps rupture requiring surgery. No equipment, compliance, training, or PPE issues were involved.
220252370048M13608The operator was utilizing the reed screen during work shift. At 12:30 pm the operator went to shut the screen off for the day. The operator approached the screen shutting the shake feature of the screen off. In doing so the operator removed their hard hat to get a better look at the hour meter of the engine and a rock vibrated off, hitting them in the head.
220252380001M13117EE stated EE was putting sand screens in wash plant, as the screen moved, left leg caught steel cross mender of wash plant. Laceration on lower left leg was about 6 inches long. The injury was not reported to the supervisor until 8/22/2025 when the EE was concerned about infection and wanted to seek treatment.
220252380002M13067Employee was cutting a pallet that was stuck between a feed conveyor and palletizer table. When the pallet was cut loose, the palletizer table the employee was kneeling on dropped 6-8" and the employee's knee struck the table. The employee sought medical treatment and was placed on restricted work duties.
220252380003M12446Employee had finished washing on a conveyor belt and jumped from the head pulley of the belt to the ground. Employee was unable to walk and sought medical treatment. Employee was placed on restricted work duties and diagnosed with a broken leg.
220252380004M11564While walking around a block and saw ee slipped on a small rock. While trying to catch self EE's wrist got caught on the block and EE's wrist was lacerated.
220252380006M10932Employee was pulling power cable with hot stick and fell on back - became reportable 8/9/2025
220252380007M10441Employee smashed hand between two air boats.
220252380008M12305Employee was working in the de watering screen and when they went to lift up a water sprayer it caught on floor level and an abrupt stop happened. They felt no injury but later that night around 7pm they started to have some pain.
220252380009M12716Employee was taking a guard off of the screening plant conveyor that is a part of the sand system.  When taking off the guard, right hand was between the framework.  The guard went across right hand causing some skin to get scrapped off the top of ring and middle finger.
220252380011M11454The employee fell while descending a stairway and sustained a hand laceration from the expanded metal stair runner. The injury required stitches.
220252390007M11554Employee was adjusting the bowl on Omnicone 1560 crusher when EE's right thumb was caught between two adjusting cylinders.  EE's right thumb was fractured.
220252390009M11724EMPLOYEE WAS USING A COME-A-LONG TO PULL A DENT OUT OF A FENDER TO ATTACH A HANDRAIL, WHEN THE COME-A-LONG SLIPPED OFF AND STRUCK THE EMPLOYEE ON THE LEFT SIDE OF THE HEAD.
220252390010M11043EMPLOYEE WAS CLEANING UNDER 1010 BELT LINE WHEN EE WENT TO STEP OVER A ROCK AND TWISTED EE'S RIGHT KNEE.
220252390015M12305Employee was trimming excess aluminum honey comb off of panels using 10lb Sawzall. Process involves a lot of bending, twisting which caused back strain. Injury was not reported until 8/21/25 when they were treated for back strain.
220252390016M11393EE was trying to clean the metal off of the magnet that leads to the VSI. They grabbed a piece of metal to pull off and strained their arm.
220252390017M12516Early morning, still dark outside. Operator made a mistake during start up and panicked. Tried to stop the plant after stacker malfunction and ran over uneven ground "water ruts" on backhoe. Injured back during rough ride and damaged the tire and rim.
220252390018M12486THE IE REPORTED BACK STRAIN ON 8/18/25 AT THE START OF SHIFT. IE STATED THAT THE INCIDENT OCCURRED ON 8/13/25. THE IE WAS REMOVING A BROKEN PALLET FROM THE BAGGING SYSTEM WHEN THEY FELT A STRAIN IN BACK. IE WAS SEEN BY PHYSICIAN AND TAKEN OFF WORK.
220252400003M11534EE struck a ceramic impact panel with a hammer in an effort to dislodge it when a piece of the ceramic went under EE's glasses and entered EE's left eye.
220252400005M11444The employee was using a knife to cut a hose (not the company approved safety blade). While cutting the hose the employee cut EE's left forearm.
220252400006M10562Employee has suffered a shift in their hearing baseline.
220252400007M11353While the employee was climbing down a fixed ladder EE slipped on the 3rd rung from the bottom and landed awkwardly on EE's left ankle.
220252400008M10832Shoveling gravel while back filing and the twisting motion caused EE's back to pop.
220252400012M13508Miner was dislodging accumulated material in a log washer with a " steel rod measuring approximately 8ft in length, which was inserted through an opening in the expanded metal cover of the feed head box on the log washer. When the material broke free the rod went further down the chute and caused the employees' left hand to strike the metal cover.
220252400013M12626On 08/22/2025 at 1300 an employee was inside tub of Grade 1 Disc filter north retrieving piece of cpvc pipe that was dropping the drain valve. The employee moved their leg against an agitator fin which cut their upper thigh resulting in 3 sutures to close wound.
220252400014M12576A maintenance apprentice was assisting with coal mill adjustments was injured after slag from nearby hot work ignited a gas leak in a burner pipe, causing a flashover and backflash through the kiln. The incident led to a diagnosis with lifting restrictions.
220252400015M13327A mechanic was performing adjustments on the coal and was injured after slag from nearby hot work ignited a gas leak in a burner pipe, causing a flashover and backflash through the kiln. The force caused the mechanic to fall back and hit EE's thigh on a nearby handrail resulting in a contusion. The mechanic was given restrictions.
220252400016M13337after drawing out feeder chute and running it dry, ee locked out belt and feeder and crawled up into chute to investigate a potential obstruction. After poking around with a pry bar, material from the overhead stockpile sluffed off and engulfed ee in the chute. EE was extracted and is recovering at home (lacerations and contusions)
220252400019M12085Employee was working on replacing skirting on this particular conveyor. Employee was kneeling down when they stood up and turned, resulting in a knee strain. As of 8/15/25 employee has an MCL tear right knee.
220252400020M13127During hot work on a coal pipe, slag fell into the burner pipe and ignited a combustible source, causing a flashover into the kiln. A backflash returned to the coal mill, where three other mechanics were working. The three mechanics were taken to the emergency room and were given diagnosis and work restrictions
220252400021M13548Operator was standing on third rung of 6' step ladder while attempting to open a steam valve with a pipe wrench. They were using one hand on wrench and holding onto an adjacent valve with other hand when valve broke loose and they fell backwards off ladder onto concrete floor. Bruised heel of left foot and lower back. X-rays did not show any fractures.
220252400022M11894Employee was rodding #4 rod mill. The rod hung up and employee attempted to push the rod with the heel of palm and caught right pinky between the rod and the roller. Fractured pinky finger.
220252400023M12516Employee was assisting in changing out a screen. While pulling on the screen to slide it up, they felt a small pop in right shoulder.  Diagnosed with shoulder strain and placed on restricted duty of no push/pull greater than 5lbs and no overhead work.
220252400024M13528El minero estaba limpiando con una barra de hierro el rodillo de la correa en movimiento.La barra se atasc entre el "drum pulley" y la polea. Fue expulsado de la plataforma cayendo al suelo a 8'aprox. Llam por telfono a otro empleado para ayuda, y de inmediato los mineros fueron a socorrerlo llamando la ambulancia, el cual lo traslad al Hospital.
220252400026M12876Quarry Superintendent and Operator were in the lower lot area of the quarry inspecting for a place to dig and haul sand with the excavator and haul truck. As they were walking the area inspecting for a spot to dig, operator stepped into a rut and rolled left foot and fell to the ground.
220252400027M11514EE chiseling pieces off standing stone, piece of stone fell towards loader and EE attempted to hold it up by pulling towards them causing a back strain
220252400032M11243Employee was exiting the bed of an F350 service truck when they missed a step, lost footing, and fractured their left ankle.
220252410001M10572Mounting a motor. Motor fell off of mount. Pinched finger
220252410003M13768Traveling between stockpiles to load customer trucks, employee traveled over a pile of stone placed in the yard to prevent customer trucks from traveling over a soft area and becoming stuck. The employee was jostled around and struck the right side of EE's head against the cab window breaking out the window, cutting EE's head and contracting an abrasion to the right cornea.
220252410004M10552Moving wooden pallet in shop caused lower back strain. 
220252410007M10983Haul truck driver was going to pit to get loaded, traveled over berm, truck landed on cab in water
220252410008M12716Madsen (contractor) Front end loader operator was cleaning material out of mono loadout silo 2. The material above the entryway came down on the front of the front-end loader and pushed the steering column and dash down into the operators' legs trapping EE in the loader.
220252410009M10642Non injury unplanned ignition occurred at the H7-6-CM1 Day Silo.
220252410010M13418Ee running CIL circuit. At B-train, head tank was alarming at 10 ppm. Ee left area. Later EE was collecting samples on the A-train and reported EE's legs felt tense affecting EE's gait, balance, and EE was confused and shaky. Ee was administered a cyanokit as a preventative measure, taken to the ER, was observed, and released to full duty.
220252410013M11514The employee was operating a haul truck and struck a pillar. Investigations led mine management to believe that the operator of the truck fell asleep. 
220252410015M12476Employee was grinding with a corded 4 1/2" grinder on a dust collector manifold replacement at the maintenance fabricating shop and got a piece of metal in their eye due to flying debris after removing their auto darkening hood and safety glasses.
220252410016M13368Employee was assisting in changing screens on a portable screen. When the employee grabbed the screen to pull it out of the deck their left index finger was threw the screen cloth. This resulted in the finger being smashed between the screen and the frame of the screen deck. Resulting in 6 stitches on the tip of the left index finger.
220252410017M13207Teammate initially reported being sick, but later disclosed an injury. They stated a foot was hanging off the forklift, and while traveling down a bay, leg was caught between the forklift and a pallet, injuring their ankle. They received medical attention and was diagnosed with a strained left foot and a pulled muscle.
220252410019M13067Miner A was chipping debris in the discharge area of the finish mill, when Miner B noticed a fresh wound on Miner A's right forearm. It is believed that material from the mill caused this laceration. Miner A was conveyed to the hospital and released later that day. Miner A returned to work the next day.  
220252410021M12085The employee was driving and hit a pothole when their seat bounced heavily, and the employee's head struck the ceiling of the cab causing a laceration. The employee received 8 staples to the top of the head. 
220252410022M10291Mild hearing threshold shift.
220252450001M12115While positioning a pinion for install for the Pebble Mill, an employee's finger was pinched between the pinion and a liner bolt on the Pebble Mill. The employee sustained a laceration to their left index finger
220252450002M11935Employee was removing rocks from between the intermediate conveyor belt and felt pain in their shoulder while using a prybar. They sought medical treatment and were placed on restricted duties.
220252450005M10702Employee was using a front end-loader to clean up along the high wall.
220252450006M11143After employee removed a 90 (pipe) on east surge basin pump. Wasps flew out and stung employee on EE's right hand.
220252450008M12175EL Seor Jose Valdes se disponia a conectar la correa manualmente cuando se quito el capacete para inclinarsehacia abajo y sufrio un impacto y se percata que una piedra le dio en la cabeza causando una herida abierta.
220252450009M12365An operator in a skid steer with an enclosed cab could not get the bucket lowered. To get the bucket lowered another employee was standing on the bucket and jumping on it. While jumping on the bucket EE felt a pop in EE's left achilles.
220252450010M10912Miner was kneeling down on concrete floor performing clean-up activities and injured knee. 
220252450011M11123An employee attempting to clear a jammed chain for a chain fall sustained a fracture to their left index finger.
220252450014M11063DEBRIS FELL INTO EE'S RIGHT EYE WHEN REMOVING AN ITEM FROM AN UPPER SHELF.  SUFFERED ABRASIONS TO THE EYE.
220252450016M12165Employee was operating an open cab haul truck and while turning a strand of wire from the wire mesh ground support on the rib caused a puncture wound to the back of the employee's left shoulder requiring two sutures.
220252450017M13638On the 23 of august 2025, at approximately 10:39am, a surface miner sustained a head injury after being accidentally struck by a sledgehammer that was in use during repair of entrance gate. The miner was moving a ladder when the sledgehammer fell from the top of the ladder, directly striking the top of their head. They suffered a scalp laceration with bleeding.
220252450018M10822Miner was lifting a belt from the ground when they fell backwards onto the ground.
220252450019M11935The employee was fueling Haul Truck 11 with Diesel Fuel when the hose popped off and splashed the employee in the eyes, face and chest. The operator was wearing PPE during the time of fueling. 
220252450020M13849While diverting material to another chute, a process attendant manually assisted a gate closure using a rock bar. During the attempt, attendant was using a strong amount of force to hit the gate. Their hand shifted and left pinky was caught between the bar and equipment, causing a laceration and fractured fingertip. Attendant was transferred to the local ER and received 7 stitches.
220252450021M13738EE completed putting pump PP131 online. They walked by pump and the spool piece around the intake started spraying hot slurry. Hit them on right arm and right side. EE reported injury, seen by on-site EMS, went back to work. EE went to clinic on 8/23, diagnosed with cellulitis. On 8/26 follow-up put on restrictions. Site offering modified duty. Became reportable on 8/23.
220252450022M11373Miner misjudged the fact they were on the second step when they were on the second to the last step resulting in a misstep to the ground.
220252450023M11914A Kiln laborer suffered a partial thickness burn to the palm of left hand. This injury happened while they were using a metal pipe to remove hot material from the discharge end of kiln no. 2.
220252450024M11834After filling a water tote secured in the back of a flatbed LV at the water stand , IP went to dismount from LV bed and felt a crack in their ankle which caused them to slip and fall.
220252450025M10912Employee was walking upstairs when they missed a step and hit their right knee on the step.
220252450026M11975Employee was changing a sump pump while working in a muddy area; irritation from right foot friction with muck boots resulted in localized swelling and redness.  Reported to supervisor on 08/25/25.
220252450029M12115Faults were occurring on Phoist that could not be cleared at approximately 11:35 pm. EVAC was called at approximately 12:05 am since we were still troubleshooting the issue and did not have control of the hoist.
220252460001M11614Operator rubbed EE's eye and got a small piece of metal in EE's eye.  Next day eye was swollen and doctor had to grind a piece of metal out of the operators eye.
220252460003M11874A miner was stripping electrical wires with a utility knife. The knife came out of the insulation as the miner pulled it down and came into contact with EE's right wrist, cutting the arm.
220252460007M10832EE was sepping down from equipment and lost traction causing a fall to the ground. 
220252460009M12746The operator was setting up to load/charge a round when the emulsion hose became stuck underneath the primer box lid. When the operator leaned over and moved the hose out from under the lid, the lid dropped down and pinched EE's testicles between the lid and the primer box.
220252460011M12446EE lost EE's balance while loading a floor shot and hurt EE's knee. EE was taken to the Occupational clinic to be evaluated and was diagnosed with a left knee sprain.  EE was placed on restricted duty until EE's follow up appointment on 9/5/25.
220252460012M12606Employee was walking backwards down the backside of the clinker dome access ramp when EE felt a strain in EE's right knee. The employee continued to experience pain in EE's knee and was referred to an orthopedic specialist for further diagnosis and evaluation.
220252460016M11694The EE attempted to climb the stairs to the work platform by the screens. The EE slipped and fell approximately 4' and fractured EE's medial malleolus of the left ankle.
220252460019M10772Employee was grinding to when the grinder slipped and hit the employees wrist
220252460022M12375Employee sustained a laceration to their right, middle finger from a fan that was not guarded.  The guard had fallen off.  A pre-shift inspection was not performed that day. Employee did receive medical treatment for the injury, offsite.
220252460023M12756The employee was cutting timbers for repair work when debris blew around safety glasses into their eye. The injury was reported the next day, on 8/22/2025, and the EE was taken to the doctor, where they received antibiotics and was placed on restricted duty by the physician.
220252460024M10882EE was replacing drive belts and caught left ring finger, resulting in the loss of nail.
220252460028M10692EE felt right knee pain while ascending stairs on the shuttle wagon. 
220252460029M11223Team members replacing return roller, shaft began to slip, team member grabbed the shaft, causing pain to the right wrist.
220252460033M11624Employee was cutting conveyor tail rubber with a utility knife.  During one cut they slipped and cut their left thumb requiring repair to the tendon and stitches.
220252460035M13458El minero observaba el ajuste del conveyor. El conveyor estaba prendida y al acercarse al Wing polley se le enrred la camisa ocasionando laseraciones en el brazo izq.,abdomen derecho y espalda baja. Witness pidi ayuda a supervisor y este lo llevo inmediatamente al hospital. Al minero le realizaron puntos de sutura y fue de alta el mismo dia.
220252470001M11985The employee was installing reflectors into berms and adding orange tape. While stepping back, the employee tripped over a rock and fell, landing on their left elbow, which resulted in a laceration.
220252470002M11754Employee was removing a large piece of sandstone from the primary pump. In the process of removing the sandstone the stone shifted causing the pinning of employees left hand. 
220252470003M1337811:40pm a fire was discovered on hot belt 3 due to leak-by from the clinker gate. When the material was moved outside, there was no visual verification it was still going to the belt. The area was evacuated, 911 was called, and fire trucks arrived shortly after. Power was shut off and locked out for safety. The fire was out by 12:13am.
220252470004M12596An EE and IE were working together to remove pins from a quick coupler. One of the pins was stuck and not moving. When it finally released, the pin shifted suddenly and pinched IE's right hand/knuckle against the frame of the quick coupler, causing an injury.
220252470005M13378On 08/23 IP reports climbing into engine of truck and stepped on a hose. Foot slipped and left ankle rolled laterally. IP completed shift but noticed left foot swelling and pain. Reports going to Riverton ED, had x-rays done which were reportedly negative and was given crutches and rocket sock. Was sent in by employer to RMMC on 08/27.
220252470006M11524IW was mounting haul truck after break. EE was not paying attention, EE was looking at EE's phone. EE bumped EE's head on the overhang of the truck bed.
220252470008M11524Blast drill technician was assisting in loading a new hammer bit onto the deck of the drill when the hammer slipped pinching EE's finger causing injury.
220252470009M11193Supervisor was working on the dozer and hit EE's left thumb with a rachet tool. It caused the finger to swell and hurt.
220252470010M11143Index finger on right had got caught in the chute of the bagging machine and finger was cut and torn from the bone
220252470015M11373Employee was carrying pin rollers when they tripped and fell on their shoulder. Employee tripped over grating outside the 4shaft airlock.
220252470018M11834The EE was loading lifters when a piece of rock (approx. 4'x 5' x 2') fell from the ceiling and struck the EE. The EE was not pinned under the rock. This resulted in a fatal accident.
220252480001M12045Miner was assisting partner in loading a pallet with a power cable on it.  While guiding the 2yd operator up to the pallet, the bucket of the loader contacted the Miner's ankle, resulting in a fracture.  
220252480002M13147Ee reports sitting in cab of haul truck when shovel loaded a large boulder on first and last bucket, jostling EE in the cab. EE reports feeling head and neck pain and then developing a migraine. Seen at clinic on 8/28, diagnosed with a cervical strain, released to restrictions. Site unable to offer modified duty.
220252480003M12416Employee fell, while inside of a fall protection cage, on top of a pneumatic trailer during the loadout process. During the fall, the employee struck EE's right side breaking 3 ribs and received other non-reportable contusions and abrasions.
220252480004M11644Conveyor belt broke on jaw, was replacing over another belt to be able to clamp onto it. Was draping belt and let go of it and the clamp/splice cut EE's right hand.
220252480005M13388Ee helping move brassboard weighing approx 200lbs from lineout room to the rear of flatbed truck. During team lift, in process of lowering brassboard onto flatbed, ee's left index finger was pinched between edge of brassboard and a toolbox on the flatbed. Seen at clinic, referred to ER for ortho consult. Fracture, released to full duty.
220252480006M11173EE was standing on the truck scale ledge talking to a truck driver.  When EE stepped off, EE injured EE's right knee.
220252480007M13057EE was walking from secondary shaker to the tool room when EE began to feel weak and thought EE might pass out. EE was told to rest in the office with AC. EE continued to feel worse and was taken to Urgent Care where EE was treated with an IV for dehydration. EE was then sent home to rest until 9/2/2025.
220252480008M11965Employee was helping change a shovel shank. When the support wedge came loose, EE's left hand was under the wedge and contacted EE's index and middle finger causing minor fracture on both fingers.
220252480010M12125Left forearm puncture wound, about 2cm deep, after loosing balance and hitting/piercing a 2" piece of medal. Sought ER treatment, tetanus shot, x-ray, a couple sutures. Returned to work full duty after treatment.
220252480012M13217A haul truck operator noticed redness and swelling on EE's forearm assumed to be from an insect bite or sting, on evaluation EE was referred to medical evaluation for a possible allergic reaction. EE was was diagnosed with an acute, localized reaction and prescribed a steroid and light duty for the course of medication.
220252480013M12826Employee was cutting a piece of 2" angle iron with a Milwaukee grinder. A piece of the grinder broke off and kicked back into the employee's right leg cutting EE's knee.  Grinder did have the guard on at the time of the incident.  Employee went to clinic and received four stitches.
220252480014M12846Employee was taking a blown hydraulic hose off from the front of rock drill, when the fitting broke loose, EE lost EE's footing and fell into slab bedding causing left great toe fracture and left shin laceration. Area where employee was standing was slippery due to the blown fitting.
220252480015M11985Miner cut their left pinky finger when they struck it with a hammer installing traffic signs in the plant. Miner was sent to urgent care where they were given stitches and placed on restricted duty.
220252480016M11564Employee was working on a diesel pump (west side alley by #1 settler) and tripped on a piece of two by four (wood) while walking. Which caused them to fall.
220252480020M11564When they placed a hand up to stop the door/panel from slamming, their left ring finger went into the hinge section.  When the door closed it caused injury.
220252480021M11113While walking down the haul truck stairs, the operator tripped and fell, resulting in a laceration to the knee.
220252480022M11073When checking spigots at tailings walking, they lost footing and fell into a ravine/ditch onto their chest.
220252480024M12235On 9/2/2025 two contractors were unable to lower the JLG manlift basket they had been working from due to a blown circuit power fuse. Another manlift was on site and it was used to transport the two safely to ground level. 
220252480026M11013During annual hearing testing the employee experienced a standard threshold shift in the right ear.  
220252510003M12095While lowering the bed prop on a haul truck the operator failed to move EE's hand, causing damage to EE's right thumb. As a result, the operator received four stitches and a splint for a fractured right thumb.
220252510004M13658Two maintenance employees were adding a return roller and brackets to BC-124. While putting the roller into the brackets one side went in with ease. That employee then went to help EE's partner by lifting the belt. The struggling employee hit the roller with EE's had causing it to fall out of the bracket and land on the side of EE's boot fracturing EE's pinky toe
220252510006M12416EE was pulling extra hose into a coarse material washer to wash it out for maintenance purposes and ran EE's right ring finger across one of the flights lacerating the fingertip. EE received 3 sutures making this accident reportable to MSHA.
220252510007M12295While employee was attempting to open a stuck valve, they felt a pop in their neck. Employee did not seek treatment until the following morning after having worsened pain.  They were prescribed medication and time away from work.
220252510008M11644While an employee was working on changing a tire on a haul truck the employee suddenly lost control and feeling in their right arm.  Also felt fatigued and nauseas.
220252510009M11113Employee was walking outside of the unload pocket when they stepped into a wash-out injuring their lower back. 
220252510010M11383EE was aligning strap with suction flex when left thumb got caught and crushed between the strap and suction flex as it was being lifted. 
220252510011M13718EE had parked EE's service truck at the shop. Was disembarking EE's truck using 3 points of contact. Boot apparently had moisture on it causing EE's foot to slip off last step. EE then lost balance and fell backwards in a sideways position and landed on EE's shoulder.  Step is in good condition and clean. EE worked the rest of the day and went to urgent care after work
220252510015M12195EE reports getting off the #3 dragline on the off-cab shoe ladder. When stepping off ladder left ankle rolled. EE unable to bear weight and had notable swelling in ankle. EE was sent to ER for evaluation by supervisor. 
220252510017M11073Employee was picking up a 5-gallon bucket of ore one handed when they felt a pop and pain in right shoulder
220252510018M11654Employee standing on the 6X catwalk cutting crown rubber to place in 6X shaker. Finger in glove in it ended up in the path of the blade, cut through Maxo flex gloves
220252510020M12315The employee's leg was struck by a shifting slurry hose while disconnecting a coupling. They went to a doctor and was diagnosed with a tear in their ACL. The injured employee had surgery on 9/4/25 which made this injury reportable.
220252510022M13127Employee was struck in the left leg by a screen that was dropped from an elevation. The screen contacted the handrail of the stairway, slid down the handrail, and struck the employee in the left leg as they were attempting to access the stairway. This resulted in an avulsion fracture to their left fibular head.
220252510023M12786An unplanned cave-in / release of material occurred underground during the second shift. During the second shift employees were loading shot rock and transporting to surface storage area when employees heard material falling and an accumulation of dust appeared in their area.  
220252510026M13678Operator saw flames on conveyor heading towards GAR bunker and radioed and contacted control room to shut down system, while operator pulled estop cord. Fire department was contacted immediately. Arrived on sight at approx.02:15 am. Plant fire suppression system went off, fire department stayed on sight till approx. 04:15 am to make sure fire was extinguished.     
220252520002M11333EE was working on EE's plant.  As the day wore on, EE noticed the pain in EE's knee was increasing.  EE was working on uneven ground.
220252520003M12486Employee was troubleshooting the MODCO Pod in product handling area when an air pulse blew lime dust into left eye. EE rinsed EE's eyes multiple times during the day and after shift change sought medical attention where EE was prescribed eye drops.
220252520004M11163Rock became lodged in lift arms of loader. Employee attempted to remove rock when it shifted and smashed EE's finger
220252520005M13718Employee was initially injured on 7/8 at 0830am as EE tweaked EE's shoulder.  This was initially treated as a first aid for a strained left shoulder with no work restrictions.  Based on radiation of symptoms to EE's right upper extremity and lack of pain improvement, an MRI was ordered which resulted in the reclassification from first aid to recordable was made on 8/6.
220252520007M12385At Tower 11 the employee was cleaning a jammed magnet separator using a high-pressure water hose. Upon activating the hose, the sudden pressure caused it to slip from their hand. The metal fittings on the nozzle struck and cut their hand.
220252520010M10872Smoke was observed coming from the surge tunnel.  The fire department was dispatched.  
220252520012M13518After retrieving a voided ticket from a customer truck at the ticket box, the employee started down a small gravel incline on the back side of the ticket box. The employee's left foot slid out from under them on the gravel as they were stepping forward, which caused them to trip and fall, resulting in dislocation and multiple fractures of the ankle.
220252530002M11995EE stepped out of a man basket and rolled EE's ankle after stepping on a rock. Went to Concentra, no lost time or restrictions, but was given crutches and a brace. Returned to work the following day.
220252530003M11393Employee was opening a manual valve on the bottom of the density tank in section 3/ calcination #5 filter when EE felt a pain in EE's back.
220252530004M12606Employee was performing housekeeping activities at the alumina tail pulley. These activities require the employee to pull a hose from the north side of the tail pulley to the south side. During this process the employee felt a pain in the middle of their back.
220252530005M10742Employee lost grip on bin handle, slipped, and fell fracturing right foot.
220252530006M10912Employee twisted with a piece of landscape stone / flatrock in hand hurting EE's lower back
220252530007M12927  Employee was breaking a sideline this process involves striking the wedges swinging the hammer with a side-to-side motion. While doing this the employee missed the wedge and struck the wall causing the hammer to deflect and rotated the employee rapidly causing a strain to the lower lumbar.
220252530008M13638Employee felt lightheaded, moved to EE's service truck to cool down, drank electrolyte drink. Contacted EE's supervisor, told them EE felt off.  was taken to break room where EE continued to hydrate and removed boots. decision was made by manager to transport EE to Hi Desert Medical Center where EE was treated for heat illness and released with no restrictions.
220252530009M13247EE was bagging on BGI when the air line for the pinch tube began to leak air. EE turned off the air line and leaned over to check the air hose & attempt to repair.  The employee put EE's left hand near the pinch tube clamp and EE's right hand on the spout which activated the pinch tube clamp which closed on EE's left thumb
220252530010M11293Spacer plate for the cable handler slid and smashed EE's finger against the shear resulting in a right ring finger tuft fracture.
220252530011M13628The miner was going to utilize a rare earth power lift magnet weighing approximately 65lb. They placed the strap of the magnet over right shoulder to carry it to a piece of steel, they then turned to walk and struck left foot on a sawhorse losing balance and falling onto the concrete floor with the left side of their body, the magnet landed on their right hip.
220252530013M10642a fire was reported at the land fill pit. no injuries occurred. 
220252530014M11383there was an above anchor point fall above the overcast near 2 northwest pump station. the fall damaged the overcast causing it to outgas.
220252530016M12045Employee was pushing a full oil cart through the PM stall next to a loader.  The cart shifted to the right and pinched the employee's right middle finger between the cart handle and the rim of the loader.
220252530017M11474Employee alleges they were cutting with a cutting torch and the slag ignited solvent nearby causing second degree burns to their forearms and neck.
220252540002M11894Employee was operating a stand behind skid steer. While backing up EE trapped elbow and hand between a structural crossbeam and the control support bar causing EE's wrist to bend backwards.
220252540005M12606Miner was contacted on the right lower torso/rib area with the airline spud and wingnut resulting in fracture to the ribs. The airline was caught on the cab of the mucker and was not seen by the miner until it had pulled tight and released striking the miner. 
220252540008M13849On 08/18/2025 @ 3:00 PM Geology teams entered XV 1457-320, where they heard ground support fail (1 split bolt). Geo Tech teams inspected the same day and ordered the heading shut down after the heading was bolted. On 08/19 mining crew completed ground support. No further access was granted until 09/08 when Geo Tech team entered to inspect, the FOG was discovered, MSHA was notified.
220252540009M11444The affected employee had their annual audiogram completed and it was reported to the mine that the employee has hearing loss in their left ear.
220252540010M11874Loader operator felt back pain, it was all of a sudden. They did not fall nor slip or do anything out of the ordinary. The pain grew more intense and they went to the doctor that evening.
220252540011M11283MCC building for primary crusher caught fire and burned down.  The MCC was located in an area that did not damage anything else.
220252540012M11103Employee was using a wrench to loosen a screen bolt. Pulled muscle in lower back resulting in restricted duty.
220252550002M11313While completing maintenance on conveyor a piece of metal flew off hitting EE in the arm. EE fell and injured left arm and shoulder
220252550004M10632Audiometric testing was done on 8/06/2025 showing hearing loss.
220252550006M13187While offloading material from a haul truck, a hydraulic cylinder broke, causing the bed to fall unexpectedly. The employee suffered a strained neck and was initially treated with First Aid. After five days, they sought medical attention, were diagnosed with an irritated nerve, and returned to work with restrictions.
220252550008M10782Employee was searching for a propane leak, slipped on a rock and twisted knee.
220252550011M12856ee was pulling the slack out of a wash hose when they felt a pop in their back. Incident occurred on 8/15/2025 - ee was evaluated by medical professional and released to work without restrictions. Pain was not getting better so went back to the doctor and was put off work on 9/8/2025.
220252550012M13518While employee was trimming belt edges on BC-1004, they had another employee switch out the blade on their utility knife because it was getting dull.  Once they resumed cutting, the new blade cut better than anticipated resulting in contact with their other hand, which resulted in 12 stitches.  Employee was wearing gloves while performing this task.
220252550013M13017In the Arturo pit at approximately 11:30 am, shovel 191 was working on the 5200-bench trim Pattern #19, cleaning up the blasted material. The shovel bucket made contact with explosives, causing it to detonate. This caused damage to the window. All employees were safe, and no injuries were sustained. 
220252550014M13007In the Arturo pit at approximately 01:30 am, shovel 191 was working on the 5200-bench trim Pattern #19, cleaning up the blasted material. The shovel bucket made contact with explosives, causing it to detonate. This caused damage to the window. All employees were safe, and no injuries were sustained.
220252550015M13027Ee removing haul truck tire on CAT 795. EE was trying to get rad gun on the nut to loosen them and improperly placed their right hand, accidentally hit trigger of rad gun with left hand, pinching right thumb between gun and hub of tire. Seen at clinic, released with restrictions and referred to ortho.
220252550016M13688EE helped two workers lift a 4x8 screw lid back on top of its housing at Silo 17 Screw Floor. EE and workers lifted the lid onto the housing and began to push it into place when they heard a pop and felt slight pain in left shoulder. EE asked to see a doctor after pain persisted for 10 days. EE had surgery on 09/02/25 to correct a torn rotator cuff and bicep tendon.
220252550017M10201Lifting a Poly Deck.
220252580001M11664Employee was working with a utility knife fixing a seat cover, the knife slipped from their hand, they tried to catch it and in doing this the blade cut their finger.
220252580002M11834While miner was working, miner tripped and fell on shoulder (left) and felt a pull Miner asked to go to Doctors on 9/4/2025 where EE was put on restricted duty and prescribed a sling.
220252580003M10983The miner was shoveling material in the pit when EE's left wrist bent backwards, causing a strain.
220252580004M11293EE moved rail loading chute to close lid on rail car. When moving the chute EE cut right wrist. EE was taken to ER for stitches. 
220252580005M12816IE and a Peterson CAT Mechanic were torquing bolts on a 980G at the wheel ends. On the last bolt when EE went to torque down there was a miss communication and IE had IE's middle finger on IE's right hand in the way and it got smashed on the downward movement of the torque wrench.
220252580008M11183Employee was flipping the cutting edge on front end loader and received a laceration to left hand palm from bolt head.
220252580009M10461Stepping off of ramp picking up air lance hose
220252580011M13668Operator was descending a ladder to inspect underneath the loader, the operator experienced a sudden failure in EE's right knee as EE stepped down with EE's left leg. This caused EE to lose EE's grip on the handrails and fall approximately 3 to 4 feet to the ground. EE landed on EE's back on a youth nerf football-sized rock located on the north side of the loader.
220252580012M12786Haul Truck operator on the 416 reported injuring their right wrist while fueling on the west pad at 6880 fuel island. The operator was pulling the fuel hose to the front of the truck when hose got stuck on the yellow bollard and pulled on their right arm, wrist, and shoulder.  
220252580018M13748Notified that an incident occurred. Upon checking near the main shop area, Miner 1 (an electrician) was found lying on the main floor, surrounded by fellow miners. It was determined that the 440 main breaker had experienced a catastrophic failure. Subsequent observations revealed that Miner 1 had borne the brunt of the failure and sustained 2nd-degree burns to both hands.
220252580020M12436Employee was cutting zip ties from a H.P. Guard when the knife slipped and EE cut EE's elbow. Basic first aid given and then taken for medical treatment. Employee received sutures on elbow. Release to return back to work same day. no lost time
220252580022M13307EE was entering the building on EE's way to EE's office when EE tripped on the steps going up to the door. This was on Friday. We considered it first aid. On Tuesday EE went to the Clinic for an X-ray. X-ray showed a fracture in EE's right foot. EE came back with restrictions. This is when it became an MTI and recordable to MSHA
220252580023M13518While conducting an end-of-month inventory of explosives supplies, Miner unlocked the powder magazine in Tunnel 1. Miner opened the door using their left arm to pull the heavy steel door open. As they opened the door they felt a pop, and a sharp pain in their left forearm. MRI results received on 9/9/2025 showing injury was a tear requiring surgery.
220252580024M10552Employee felt pop in shoulder lifting 50 lb bag of clay
220252580025M10482Employee picked up cribbing and felt pop in back
220252580026M10872Turning a piece of rail over and felt a pulling in left arm. No diagnosis at this time.
220252580027M12636Employee was performing housekeeping, when they picked up a cardboard box with parts from the floor. The box weighed approx. 35 lbs., employee complaint of lower back pain. Employee was taken to the ER for an evaluation and was diagnosed with a lower back strain.
220252580028M11133Employee smashed hand with drive line guard - Restrictions received same day of injury prior to next night shift.
220252580029M10712Employee fell onto idlers injuring leg - became reportable on 8/11/2025
220252580030M10391Employee was rough loaded in haul truck
220252580031M13558EE was working on greasing fine ore feeder motors. They picked up a grease gun & felt a pop in their elbow. They continued to work & grabbed the grease gun again & felt another pop with instant pain. They reported it to supervision & was seen at the clinic & released. On 9/10/25 they went back to the clinic & was issued restrictions for an elbow strain.
220252580032M11814EE was taking wire to a heading. Reports they were walking downhill, stepped wrong, straining ankle. Seen at ER, given brace and crutches, and released to return to work restricted.
220252580033M11514Hearing shift. EE has loud hobbies and prior hearing problems but audiologist did not confirm not work related. EE works in various areas of the plant.
220252580035M11373Operator on the 461 made a series of sharp turns by cranking on the steering wheel when the operator felt a pain in their right shoulder.
220252580037M11303Employee reported discomfort in RT foot after attempting to load an empty chemical tote into the bucket of a rubber tire backhoe. 
220252580039M10702Employee suffered fracture and laceration of finger closing dump gate.
220252580042M10702Employee suffered concussion like symptoms from being struck by object
220252580043M11303While inspecting a port on the tower the employee got hot dust in their face causing an eye abrasion and 2nd degree burns to face.
220252590002M11313The employee was hosing out tail pulley under pulvomatic crusher and a rock came out of the chute and hit EE on EE's left shoulder.
220252590003M13738IP took a break and when exiting truck, the wind pushed the door and pulled it out from their hand. IP described pain as sharp and achy. EMT referred IP to go to RMMC for further evaluation and left with supervisor. Worker has been able to perform all of their normal duties but was prescribed physical therapy on 09/12, escalating this to a medical treatment case injury. 
220252590004M10963Lost power to the mine due to an outage from Cleveland Public Power (CPP). Reported issue to CPP
220252590010M13838Employee lifting battery operated chainsaw up to work deck using a rope & it got caught on the edge of work deck, employee reached down with left hand grabbed the saw & in process safety switch & trigger engaged resulting in saw blade to contact gloved right index finger resulting in a laceration requiring sutures, given full work release making this a medical reportable incident.
220252590011M11935Employee was cleaning bolt holes for the grizzly bars and missed the laddy slipper with a sledge hammer smashing their right index finger. Employee was taken to clinic and had the nail removed.
220252590012M12406Miner was repairing a torn belt using a utility knife.  The knife slipped and punctured the top of miners right hand.  No other conditions such as weather were a factor. Miner received three stitches, reported back to work the next workday.
220252590015M10431Employee got foreign material in right eye.
220252590016M13267Employee was removing a bracket and a grease injector assembly from the center arm of a wheel loader. When they removed the bracket that was over their head they felt something pull in their left shoulder and arm gave out. They have pain in their left shoulder. They saw doctor on 8/5/25 and started restricted duty on 9/8/25.
220252590017M12025Employee was traveling on a haul road in a water truck when they hit an oversized speed bump and it catapulted them up and they hit the ceiling of the cab. Employee was not wearing a hard hat (no room).
220252600001M11584installing parts on plant equipment. Crowbar slipped and hit right hand ring finger and caused laceration requiring 2 stitches and dermabond along fingernail.
220252600003M13668The miner was performing routine housekeeping maintenance for a conveyor belt located inside a sloped steel tunnel. The miner lifted a piece of floor grating, tilting it to the side against tunnel wall and then shoveled material that was being accumulated underneath. The miner turned around briefly when the unsecured grating slid and impacted EE's left hand/wrist.
220252600004M13157After getting a bucket of material, the loader loading the haul truck backed up and turned too quickly causing the bucket of the loader to make contact with the truck bed.  This caused the haulage operator to suffer a back muscle strain.  Case went recordable on 09/13/2025 when the operator was given restrictions.
220252600005M11193Employee was using a utility knife to cut zip ties when they slipped and cut their right thumb which required sutures. 
220252600006M12395Employee was removing hardware from shovel dipper using a hammer when a piece of the hammer head broke off striking the employee in the left glute. The employee was seen in the ED where they received medical treatment and returned to work.
220252600009M13538Two employees were driving a shaft thru a gearbox to remove it. The injured employee was holding a pipe while another employee hit the pipe with a hammer to drive the shaft out. The pipe was driven sideways by a bad hammer hit and pinched the employees finger between the pipe and pulley, resulting in a laceration and fracture of the left ring finger. 
220252600013M11614Employee was bending over to pick up a piece of pipe when they felt a strain in their back.  Employee did not pick up the pipe only hurt their back bending over.
220252600016M1127320' x 10' x 2' piece of roof fell. Piece of rock  fell on boom of scaler and came thru windshield striking operator in the ribs
220252600018M10722Employee suffered muscle strain to right shoulder moving innate object. 
220252610001M11664Employee states EE was exiting the shift change van at the ready line when EE stepped out onto a rock and rolled EE's foot, falling and heard a pop in EE's left foot.
220252610002M12105EE was putting away supplies, lifted case of Anti-freeze, weighing approx. 50lbs. EE felt pain the day after completing the task, sought med. treatment on 9/10 & was removed from work. Reporting within 10 days.
220252610004M12636EE was performing maintenance on cone crusher replacing sheave. Sheave shifted off motor shaft. EE's left thumb got caught between impact driver handle & steel frame. Sought med. treatment same day, received stitches & removed from work. Reporting within 10 days.
220252610007M11504Employee grabbed a master link that was set on flange above EE's head and pulled cement dust into EE's left eye causing a chemical burn to the cornea.
220252610009M11955Drill mechanic's right pinky and ring finger were injured when a shock sub fell from the rigging contacting EE's hand. The mechanic was in the process of changing out the shock sub for the drill.
220252610010M10231Hearing shift of > 10db
220252610013M11033Employee fell off of the loader and injured shoulder.  Injury was not reported at time of the incident.
220252610022M13007Employee was using brass punch to remove rod screen arm bearing. During this activity a piece of the punch broke off hitting employee's tooth. The employee did not visit a dental office until 9/10/25, and at which time, the tooth was repaired. The office visit summary wasn't received until 9/16/2025
220252610023M11133EE was moving stone by hand to mouth of the splitter, pinches thumb between the stone and chisels on the splitter
220252610025M12897Employee was dressing lead anodes for cell maintenance. While installing side insulator (PVC) with a rubber mallet, the left side of the anode slipped off the strongback hook, striking the employee in the neck area. EE was taken to the ER and taken off work 2 days for concussion protocol.
220252610026M12436Employee walked up five steps to take a sample from a belt and once the employee had the sample they turned around and walked back down the steps reaching the bottom step, they reported that they stepped bad and their right knee began to hurt.
220252610027M11193Employee was surveying blast hole collar when survey rod hit something causing it to twist and tip back against thumb. 
220252610028M13027Haul truck 3175 dumped a load at the leach pad. After dumping, an employee noticed that 3175 had started leaking fluid. While descending the leach pad ramp, the driver of 3175 observed flames coming out from under the deck over the engine. The driver stopped the truck and safely exited the haul truck.
220252610029M12917Employee was using a cutting torch to cut scrap metal. The torch caused a small brush fire behind the employee which caught their pant leg on fire, burning through two layers of clothing. Employee sustained a partial thickness second degree burn on the back of left leg just above the ankle.
220252620001M10401Climbed on rollers, fell, ankle fracture
220252620003M11253Miner was performing hot-work inside an excavator bucket, with all prescribed PPE, and when EE stood up, EE bumped EE's head.
220252620004M13357Around 09:05 a haulage operator was being loaded by a shovel and got jolted from a big rock being dumped into the bed. IP arrived at first aid post at 09:36 and was assessed by an EMT. IP could not move head from side to side without pain. EMT sent the IP to RMMC for higher level of care. Pain is on left side of neck and upper trap. 
220252620005M12546Laborer was hooking up lift cable to lift a crusher head to a loader bucket tooth and pinched EE's right thumb between the cable and tooth. This cut EE's finger and ripped off EE's thumb nail. Hospital took X-Rays and pulled the nail and glue up the cut.
220252620006M11524While loading material onto the conveyor of TXS 3 in the NTV Flats dept, the stone tipped over, pinching EE's finger between the stone and the conveyor.
220252620007M12626A production loader operator was coming off the boarding ladder of the loader when EE stepped on a rock and felt pain in EE's leg. On evaluation EE was diagnosed with a muscle strain and issued restricted duty, EE's first shift of restricted duty was 09/05/2025.
220252620010M12005A mechanic was stepping onto a barge from the ground when their muddy rubber boots caused them to lose footing and slip and caught themselves by grabbing the handrail and hurting their right shoulder.
220252620012M12686A fire originated off-mine property when a private citizen parked their vehicle in tall, dry grass, igniting it. The fire spread onto the backside of the property, where no employees were exposed. The fire was contained and extinguished within 32 minutes of discovery.
220252620013M11604Employee was diagnosed with a standard threshold shift by a doctor on 09/18/2025.  This hearing loss is consistent with noise induced in the left and right ear.
220252620015M13257MTMs were changing rollers on a belt. They were dragging a roller with a rope and decided to each carry on one end. The roller weighs about 150#. The injured carried the back and felt a pain go through their left elbow area. The employee reported the incident to their supervisor at the start of shift the next day (9-12-25).
220252650001M12426Screen plant 'middle hopper'. Employee using tooling to remove material blockage, as the material stopped flowing. As the material dislodged, momentum forced employee's forearm, through tooling', into frame of hopper, resulting in laceration.
220252650002M10952Employee alleges EE was removing bearings and a piece of sliver steel went into EE's left hand.
220252650003M13177EE reports walking between truck and dragline and turning right ankle by stepping on uneven ground. EE states that EE reported it immediately and had applied ice to the area without relief. EE was brought to the clinic by supervisor. EE unable to walk normally due to pain and swelling to inside and outside of ankle.
220252650006M10381Employee rolled ankle at drill pattern
220252650007M11894Team member was assisting rolling pipes on the dredge. Tool became disengaged when team member went to pull down on handle, causing them to lose balance and fall backwards onto a metal box.
220252650011M12606We were building a new ramp at the quarry and as we were building the berms the operator got too close to the edge as EE was attempting to dump and the truck went over the side.  The equipment involved was a haul truck, manufactured by Caterpillar, Model 769D.
220252650014M10562Employee Strained arm while tightening a ratchet strap. 
220252650015M11654EE was running the loader , and when they were traveling from one end of the pit to the other to load trucks they hit a bump and the seat in the loader bottomed out.
220252650016M11824Employee was turning off the equipment and took a shortcut over the bottom of the ramp for the 2100. They lost footing and fell. When they fell, thier right ankle twisted and popped.
220252650018M10582Unchoking a chute with limestone. Jammed right shoulder.  
220252650020M11413Customer truck made a turn to back into pile and did not look both ways before moving into traffic road on site and ran into the water truck.
220252650023M11393A miner was conducting an inspection on an agitator. As the agitator turned, a bolt contacted the miner's finger, resulting in lacerations.
220252660004M12446Employee was moving too fast for the conditions.  Slipped with EE's left foot and fell to left buttock.  Caused swelling and the employee was taken to the ER.  Was admitted over night for observation and prescribed time off work until 10-1-2025
220252660008M12786Employee was Operating a haul truck being loaded by an excavator. Employee stated that the Excavator struck the haul truck on the back and caused an injury to Employees Neck/Back. Employee refused first aid and or urgent care. Employee later turned in medical paperwork to MSHA.
220252660009M12325Employee sprained EE's left knee, stepping up and over an air slide. EE's knee was treated as a first aid until 9/9/2025 when a visit to an orthopedic doctor resulted in physical therapy being prescribed to help strengthen the knee.
220252660010M13368Miner was on first floor of "New Office" working on a ladder changing a light.  Miners co-worker went to basement to retrieve another new light. Co-worker heard a thump and a bang on the ceiling. Co-worker found miner sitting slumped on the floor unresponsive. Started CPR, called 911, deployed AED but the miner could never be revived.
220252660011M13628Track drill operator during operation, finds the drill bit has been obstructed with mud, EE unscrews the drill bit to use a thin shaft to pierce the obstructed drill bit shaft, but was not aware than in the process of removing the drill bit, the shaft also unscrewed. While cleaning the drill bit shaft, the shaft came undone and pinched EE's right index finger.
220252660012M11373Good normal operating conditions. Operations were slowed from option to work was offered. Employee was found unresponsive in an outhouse.
220252660017M12947A Lube Technician was dismounting a dozer in the pit after servicing it, when stepping down they felt pain in their ankle and felt a pop. EE was sent to a provider for evaluation on 09/11/2025 and was diagnosed with a sprain injury and placed on crutches, first day of lost time was 09/12/2025.
220252660019M13728Operator was watering travel route from stripping area to spoil area. Operator made a pass up the hill and turned around to head back when they crossed into the area they wet prior. The truck began to slide, operator overcorrected turning the truck onto its side. When the truck overturned the operator hit their head against the truck ROPS. Operator did have seatbelt on.
220252660020M11914A contractor drill caught fire in the pit and burnt up. The fire was not able to be extinguished within 30 mins.  Due to the extent of the fire, the investigation into cause is still ongoing.
220252660021M10832While using water hose to clean under belt in stone tunnel, mud splashed onto hand.
220252670002M13257Contractor electrician and another EE went to the GFI, talked about what was happening w/dredge etc. They pulled the handle to trip fuses. EE opened the GFI door and talked about how everything worked. EE looked and tested the fuses down low w/EE's meter then went to test things up higher and that's when EE's meter blew up.
220252670004M11243Employee using cutters punctured themselves in the hand with the cutters leading to a laceration of their left index finger.
220252670006M11794Miner was processing a slab of stone on the hydraulic splitter when EE rolled the stone back a piece fell off and hit EE's steel toed boot on top and bruised the top of EE's foot.
220252670008M12185Miner was adjusting the distance of the forks of the fork-lift attachment on the Kubota SV95 Skid Steer Loader, the fork slid contacting the Miners right thumb cutting it. Miner then took self to the hospital for care.
220252670011M12576Employee was cleaning under the lime plant and fine material from the screw conveyor was coming down and the employee believes they inhaled some of the airborne lime.  The case did not go recordable until 09/23/2025 when the employee was given restrictions.
220252670013M12626Employee stepped onto driver's side tire to grab the vehicle chocks from the bed of the truck. While stepping off of the tire, the employee placed EE's foot onto a loose rock. When the rock spun out beneath the employee, the employee felt their right knee "pop".
220252670014M13558Two production assistants were trapped in an elevator at the cement silos. Plant personnel could not get the car to move. Otis Elevator was called for assistance. After opening the top trap door for a visual, the uninjured workers were able to exit safely using a 12-foot ladder lowered from the floor above. MSHA was immediately notified of the incident.
220252670015M10461Miner had recorded a Standard Threshold Shift 
220252670016M10461Miner had recorded a Standard Threshold Shift 
220252670019M12806Slick conditions on railcars because of the dew. EE was closing lids on top of the bulk car. EE was wearing fall protection. EE slipped and fell while closing lids. EE slipped and fell on top of the bulk car. EE broke their wrist while putting their hand down to catch themselves.
220252670022M12826While descending the screener stairs, the operator was carrying a chain hoist in one hand and using the other to hold the handrail. As they reached the bottom of the stairs, the operator stepped onto a hose that was lying across the walkway, causing them to twist their right ankle.
220252670023M13067EE knelt down to adjust hooder film. EE went to stand up and their right knee starting hurting. Their knee continued to hurt throughout the shift and the following days. EE called in sick their next shift to allow their knee to rest. EE saw a medical professional on 9/18/25 and was put on restricted duty.
220252670024M12125Employee sustained a nondisplaced fracture of right thumb (Distal Phalanx) when employee was ascending the stairs to access the belt 2260CON001 and the safety bar came down and smashed the employees right thumb. 
220252670026M11123Employee was loading a job box in the back of a service truck, job box slipped off forklift smashing left thumb.
220252670027M12516The excavator employee was running started to tram forward and would not stop after they let off the controls.  Employee made the choice to unbuckle their seat belt and jump out of the moving machine.  They went to urgent car and has a fractured foot.
220252670030M10742A miner smasher their thumb installing the end plate of a torque converter
220252670033M11053Employee claims they were jarred in the loader while coming down ramp, causing a strain of lumbar region.
220252680004M12486Employee was working on the screen deck changing out the screens. New screen was being put into place and employee was using a pry bar to guide into place. Screen slid off pry bar and came into contact with employee's forearm causing a laceration. 
220252680008M12385Preparing to move screen plant when employee stepped on berm and felt right knee pop. Continued to walk around and knee popped a few more times and was sore. Became reportable on 9/12/25 when employee had surgery for medial meniscus tear.
220252680009M11894The associate was climbing up the ladder of a Komatsu WA 500 and slipped of the ladder thus falling 4 - 5 feet. EE landed on EE's right elbow.  The elbow suffered abrasions and a contusion.
220252680012M10912Employee got their finger caught between a man door and a door jamb while closing the door.
220252680013M10912Miner was moving a wheelbarrow and hurt EE's back.  Medical exam called it a lumbar strain.
220252680018M12546Employee was using a poker bar during a gypsum starvation when material shifted pinching left hand between poker bar and bin chute. Employee went to the doctor on 9/15 was released to full work duty but was later prescribed an anti inflammatory on 9/22. 
220252680019M10993As an employee was attempting to climb into the back of a cargo trailer, their shoulder dislocated.
220252680021M12075On 9/15/2025, employee was placed on restricted duty. While employee was in the process of removing a pin with a hammer, a shard of metal entered their right upper arm. Restricted duty is being accommodated.
220252680023M10261Employee slipped and fell.
220252680027M11514The Miner tripped and fell on limestone surface which resulted in injury to their nose. Employee was treated and returned to work the next working day.
220252690001M10872Employee was tightening 2 1/2" bolts on a pump when EE felt pain in EE's right shoulder
220252690002M10872Employee was removing a tag off a chain valve when EE felt a pop in EE's left shoulder.
220252690003M110838 shaft hoist went down for an electrical fault. No one was on the cage or injured when the fault occurred. 
220252690004M12075Removing an umbrella stand from the back of the service truck. Set stand down on uneven ground, Stand fell striking EE's gloved Right inner thumb and palm. Suspected fracture confirmed by Ortho on 9-24-2025.
220252690006M10351Burn to foot that became infected. 
220252690008M11073Employee was walking in the work area when EE tripped and fell over a pipe that was in EE's path of travel.
220252690011M12035IP was setting up trip cable for remote mucker, while pulling bungee cord tight, cord slipped and hook pierced into left palm between thumb and index finger. 2 sutures applied to close open flap of skin.
220252690012M12005Employee was walking in front of the admin bldg. when their left foot caught the edge of the pavement and fell on their left side. Hurting their left arm and scraping the side of their cheek and chin.
220252690014M11965An employee was loading a face with explosives when a rock fell from the face and caused a laceration to the employee's leg. The employee received 7 stitches to the leg laceration at the Hospital.
220252690015M13748EE was pulling a Wright dump hopper from under the Clinker Cooler. While navigating through the "I" beams the hopper struck the edge of a beam causing the hopper to stop suddenly. EE's momentum continued backwards while gripping the hopper during which they heard a pop in left shoulder. EE immediately felt sharp pain in their shoulder/neck and reported it to a Supervisor.
220252690017M13388EE was leaning on rail while wiping a mirror on a piece of equipment. EE reports that they were leaning on the rail in order to wipe mirror down low. Felt their left rib pop and reports a deep breath hurting. Seen at ER, diagnosed with rib pain, and released to full duty. On follow-up, released with restrictions site cannot accommodate.
220252720003M10441Scratched by raccoon requiring immunizations
220252720004M12606Intern Process Eng. was providing help with racking of material. While doing so intern pinched EE's index finger on EE's right hand between the rake EE was using and metal door. This resulted in a cut to the back of EE's index finger which required 4 stitches.
220252720005M11674Employee was washing a glass in the sink when it broke causing a laceration to EE's right hand. Employee was treated at the local emergency room and received stitches.
220252720006M13027At 4:15am the hoistmen was attempting to clutch in when the weight brake set and EE could get it to release.  Maintenance was called and found that a safety was tripped causing the hoist to dump air pressure setting the weight brake. maintenance reset the safety bringing the hoist back into operation.
220252720007M12385Employee was cutting a slab of rubber with a dirty box cutter at Separator 2 area when EE cut self "on the last bit (end)" Employee was taken to emergency room where EE received wound cleaning and closure with staples to EE's right thigh.
220252720011M12476Loading raw coquina into crusher w/Trackhoe; material dislodged and slid into the cab area with a coquina rock, approx 25 lbs., hitting the operator in the right knee area causing pain. EE was taken to ER to be checked and discharged the same day.
220252720012M13137Ee stepped up on cribbing to look at site glass on hydraulic oil tank. EE was holding on to rear access handle on lube truck, the cribbing block rolled from under EE's feet, and EE fell. EE's shoulder dislocated midfall, and EE fell to ground. Seen at ER, referred for ortho follow-up, released with restrictions.
220252720013M12626Ee was using cutters to strip back insulation on a wiring harness. The cutters slipped, striking the ee on the right inner forearm. Seen at NNRH where the laceration was closed with staples and sutures and EE was released to modified duty. EE follows-up on 9/30.
220252720014M11003Loose dirt from the rain and mud caused the employee to slip, causing an abrasion of the right knee.
220252720015M11854While a miner was scaling the face, a rock 1'x6"x6" came loose and struck the miner's hardhat. The miner was taken to the hospital and was prescribed medication and time away from work.
220252720016M13588EE operating haul truck, backing under shovel 192. Shovel bucket made contact with the truck bed, jostling the EE in cab of haul truck. EE dumped truck load at 6098 dump, then went to Q2 and called supervisor to report. EE seen at clinic, diagnosed with C-spine strain and thoracic sprain, and released to modified duty. Site unable to provide modified duty.
220252720018M12716Operator fell due to loosing grip and footing while climbing down the stairs of Front Loader. Recent rainfall caused wet/muddy conditions in the job site area which contributed to the incident. Operator sustained minor injuries to leg, hip, and elbow due to the incident.
220252720020M11514An employee became ill after experiencing irritation from ammonia event. The employee was evaluated and was unable to return to work the following day.
220252720021M13758Mobile mechanic had been torquing a fastener on a loader bucket tooth when the hand tooling slipped, resulting in the mechanic twisting the left knee. "The accident occurred on 8/29/25, however, the EE was cleared to go back to work the same day. The EE chose to return to place of residence and got an off-site diagnosis, which was provided to the mine operator on 9/23/25."
220252720023M13478Two Mechanics were rebuilding a pump. While breaking the pump down to rebuild it, one mechanic was removing a socket from a cordless impact gun (the mechanic was wearing latex gloves and not cut resistant gloves). When the socket came off, the mechanics hand struck a sharp piece of piping resulting in a laceration to their right hand on knuckle.
220252720024M10632Soft tissue injury of the right knee stepping off of a ladder. 
220252720029M10542EE ran into a JLG man lift. EE was wearing a seatbelt.
220252730003M11534Employee was cutting sleeves off EE's t-shirt, and somehow managed to cut EE's left forearm with a utility knife, resulting in four stitches to EE's arm.
220252730004M13368While aligning a ring of anvils on a crusher, the employee (EE) used a chain that caught on the feeder, creating a pinch point. In trying to free it manually, the EE's finger was pinched, causing a crushing/laceration injury that required sutures. Contributing factors included the jammed chain, hand clearance, and exposed pinch point.
220252730006M11864Employee was tightening a bolt on a bar disintegrator when the wrench slipped off hitting the employee in the mouth causing a small cut on the upper part of the chin and a chipped tooth.
220252730007M13287While dumping a haul truck at the crusher, the employee (EE) began feeling sick with chest pains and nausea. EE parked the truck, notified EE's supervisor, and was transported to a medical facility. EE was treated and released the same day with possible heart palpitations and returned to work the next day with no restrictions.
220252730008M13418EE picked up a pump to place it back on a timber car. EE's foot was against the rail and when EE turned EE stumbled and felt a sharp stabbing pain in EE's back.  EE did not want to see a DR. After EE's days off, EE stated EE's back wasn't getting better. EE was taken to the doctor on 09/23/2025 and was placed on lite duty by the physician.
220252730009M11393Employee was driving through the yard in a service truck.  They struck a concrete block, resulting in a laceration below the right eyebrow.
220252730012M10792Employee  pinched EE's finger between two metal stands while moving the stands.
220252730013M11894While working to replace a cylinder on a motor grader, the associate pulled the cylinder back to realign it & pinched EE's finger between the cylinder block & the frame of the motor grader.
220252730014M11223Employee was cutting flashing with a knife, knife slipped and cut EE's leg.  Took several stiches to close the laceration.
220252730015M11173LOOSENING A BOLT WITH AN OPEN ENDED WRENCH, WHEN THE WRENCH SLIPPED OFF AND SMACKED EE'S HAND AGAINST A METAL OBJECT.
220252730016M12536ON 9-22-25 EMPLOYEE REPORTED HAVING A FOREIGN BODY IN EE'S (R) EYE FROM TORCHING HOLES ON A NEW CLAD INSTALL ON 9-19-25. THE FOREIGN BODY WAS REMOVED IN THE EMERGENCY ROOM ON 9-22-2025. EE WAS PRESCRIBED EYE DROPS AND WAS RELEASED TO FULL DUTY SAME DAY.
220252730017M12576EMPLOYEE WAS WIPING DOWN HUB SURFACE OF THE LEFT FRONT BRAKE ON 13060. ANOTHER EMPLYOEE WAS REMOVING DUO-CONE SEAL AT THE SAME TIME. THE DAMAGED METAL RING SPUNG FORWARD AND HIT THE EMPLOYEE IN THE RIGHT THUMB KNUCKLE CUTTING IT OPEN, RESULTING IN STITCHES.
220252730018M10692As the employee was ascending the ladder, felt a pop in left shoulder
220252730019M10772The employee was exiting the trailer when they fell and broke their left leg.
220252730020M10642Employee tripped and injured knee -- became reportable 9/11/2025
220252730021M10592Employee injured back after seat bottomed out on haul truck
220252730022M10461Employee slipped in mud and fell injuring back
220252730023M12887Employee was attempting to line up conveyor belt on wash plant, pry bar slipped & weight pushed wrench employee was using into their right thumb. Flowers was transported to ER via private vehicle. They received stitches, followed up with orthopedic surgeon was placed in cast for 6 weeks.
220252730027M13357Employee was climbing the ladder of 605-8 haul truck, while doing so the second rung of the ladder broke free from the left support. This caused the employee to drop roughly 12" to the first rung of the ladder, employee notified the mechanic and the supervisor who replaced the ladder. Employee was given days away from work by clinic.
220252730029M13698On September 22, 2025, an individual entered the facility's parking lot and illegally stole an employee's vehicle. The individual took the wrong exit and headed toward the plant area. The employee confronted them but was struck in the back of the head with a drill found in the vehicle, causing a minor injury. The individual was later arrested in the nearby community.
220252730034M13658Employee had to restack liners because the original pallet was damaged and needed to be replaced on another pallet, an extra task that can be avoided if the original pallets are better managed. When moving the concave liners from a damaged pallet, one of the liners shifted and crushed a finger, causing an open tuft fracture of right index finger with nail damage.
220252730035M12125A Mine Operations employee was riding the bus out to the 601 Park Up area when the bus hit a bump in the road causing a back injury to the employee. The employee was a passenger on the bus at the time of incident
220252730036M11744Employee was splicing wires with a utility knife. Blade became dull and slipped on the wires cutting left hand between thumb and index finger. Wound required three stitches. 
220253170001M10802Loading a gear box into a skidsteer bucket, stumbled and pulled shoulder muscle.
220253170002M12746EE while in the process of removing debris/sticks from sleeve of pump, EE tripped over a plate that is part of the sled and fell backwards into a washout landing on left side. EE reports neck, shoulder, mid & lower back pain with stiffness. EE reports previous back injury. 
220253170004M13628The employee was leaving Shovel 4 and 6 pit in 6th gear when EE hit a pothole in the road. The employee stated the truck bed raised up a little and came down, causing the seat to bottom out. The employee was seen by Occ Med on 9/23/25 and was released without restrictions. On 9/26/25, the employee was seen by Occ Med and was returned to work with restrictions.
220253170005M12786EE was swamping on the back of the track lowboy that was loaded with an electrical cabinet. The cabinet came in contact with the lockbox for the portal gate causing the lowboy to come to a sudden stop. The stop caused the employee to come in contact with the electrical cabinet.
220253170007M10852Employee was walking on the screen deck when EE hit EE's right arm on the come along.
220253170009M128462 PTCs were doing their routine afternoon cleaning of the 4th floor riser. EE had the NE top door open to start cleaning when the riser went positive for approx. 5-10 seconds. EE could not get out of the way quickly enough before hot gases slightly burned the right side of EE's neck.
220253170010M13558EE was walking around a screening tower and said EE tripped over EE's own feet falling to the ground. EE reported this two weeks later stating EE's knee had swelling and discomfort. EE was treated, has a follow up and restrictions until then making this MSHA reportable. Ee was terminated on 09/24/2025 as a result of a separate company safety infraction.
220253170012M10351Sharp piece of metal after grinding
220253170014M11975Installing a motor on a piece of machinery using a forklift.  Employee reached under the motor to straighten the mounting bolt and the forklift dropped the motor suddenly, catching EE's left thumb.
220253170015M13828A blast driller experienced an STS in EE's right ear confirmed by a retest that was reviewed by an audiologist. An internal investigation revealed a single event more than likely contributed to the STS. The event took place a few weeks prior to the initial hearing test. The blast driller was outside of the drill when air pressure was released while not wearing hearing protection.
220253170018M13217An employee was conducting an inspection of the burner in DR-8, Argo Kiln. The employee was wearing a Tyvek dust suit, N95 dust mask, gloves, a hard hat, and safety glasses.  As they were exiting the kiln, a small piece of dried soda ash struck their hard hat, and dust from the soda ash made contact with their left eye.
220253170019M12005Miner was struck in the arm and hard hat by a jack handle while setting track for saw.  Miner was transported to clinic to be evaluated out of precaution.  No significant injuries reported by clinic. 
220253170023M12706The employee was re-routing a cable on the port side of the dredge when wind caused the dredge to shift, resulting in movement of the port side swing sheave, which struck the employee in the face. As a result, the employee sustained a facial laceration and a broken jaw.
220253170024M12826EE was removing adapter fitting off 2" washdown hose used for cooling for belt cooking equipment in the Pellet Plant.  EE used 2 - 18" pipe wrenches to the reducing bushing & coupler to remove & replace w/washdown hose nozzle.  When applied pressure, EE felt pain in right shoulder.
220253170025M10993Employee slipped on ice and landed on their right elbow, resulting in pain in their right shoulder.
220253170026M11864The employee was walking to a piece of equipment in the early morning hours before full sunlight when they stepped on a rock, rolling their ankle which caused them to fall to the ground.
220253170027M10932Preliminary investigation finds employee operating loader over-traveled, falling down stope. 
220253170028M12967Ee was showering after work using Dawn dish soap. Soap fell off shelf, ee tried to catch it, squeezed soap in eye. Seen at clinic, diagnosed with irritation, put off work. Seen at Total Eyecare the following day, diagnosed with abrasion to right eye, put off work until full duty release on 9/30.
220253170030M12566EE was removing a 20" hugger with an impact when the nut came off of the bottom half of the hugger it dropped. The EE caught it and tweaked EE's back in the process. On 9/19/25 EE was seen and sent back to work. On 9/25/2025 EE was issued physical therapy.
220253170031M13838Employee rolled EE's ankle after EE stepped on a 2" hose that was laying on the concrete floor after stepping down from the crossover platform steps. Medical professionals were notified and employee released to full duty. On 9/27/25, employee felt discomfort return and advised EE to get an evaluation at a medical facility where EE was diagnosed with "other fracture of the fibula".
220253170032M12295EE was driving haul truck and began to experience lower back pain. EE was seen the following Monday on 9/22/2025 and provided a prescription anti-inflammatory and muscle relaxer. EE did not miss work or receive any restrictions. 
220253170036M11774EE reports pulling on a wrench and experiencing a pop in the right-side chest muscle. EE states pain with movement of arm. On physical exam there is a tender lump in the muscle.
220253170037M12225Employee was returning to the pit from primary. As EE neared the bottom of the long ramp, the auto retarder engaged which caused EE's shoulder belt to lock up and slip up EE's neck. Strain to unspecified parts of the neck.
220253170038M10852Fell, hard hat came off and rock fell from the overhead chute and hit me in the head.
220253170039M12476The miner was beginning to start going down the ladder. Missed the ladder rung and fell 11 feet onto the concrete ground below. The miner needed eight stitches to EE's head. Sustained a hairline fracture to EE's left arm and broke EE's right heel.
220253170040M11965Employee was walking down the office stairway and rolled EE's right ankle while taking EE's last step. Medical evaluation done the following morning revealed a closed fracture of EE's right ankle.
220253170041M10421Employee suffered a stroke while on shift 
220253170042M11644Employee was working in the milling room while concrete wall was being removed. Employee stepped on a wedge and rolled ankle. Employee informed company on 10/1/2025
220253170043M10862Repetitive motion of pulling supersucker hoses resulting in repetitive motion injury. 
220253170044M11935Miner was attempting to get a socket seated onto a corroded nut on a vic coupling by hitting the socket with a pipe wrench. EE missed the socket and struck EE's left thumb with the pipe wrench.
220253170049M13688IP was assisting with cable work walked up to cable truck after it stopped. pothead was on crane swinging. IP ducked to get out the way IP hard hat fell off and pothead contacted the back of IP head resulting in a 3 inch laceration. EMT used gauze pads and a head wrap to control bleeding. EMT recommended transport to RMMC for higher level of care to close the wound.
220253170050M10602Employee had neck pain after hitting hard knob in haul truck
220253170051M11383Employee was cleaning the basement at the lime plant and steam burnt a small hole through EE's boot, causing blistering on EE's left foot.
220253170052M11043Employee alleges EE was climbing on conveyor and EE grabbed the rail and crushed EE's left pinky finger.
220253170053M12426While conducting cell maintenance, electrolyte got in employee's boot. Employee completed shift and went home, called and reported irritation, and next day requested medical attention. Employee was given work restrictions. Currently ON GOING.
220253170054M13187At the beginning of dayshift grinding operator reported an injury that occurred before getting off work on 9/6/25. The grinding operator was trying to unsand a sump pump pipe in 2004 by hammering on it with a mallet. When swinging at the pipe, the operator smashed EE's right ring finger on an angle iron fracturing it
220253170055M12165Ee noticed rash on body. It continued to spread. EE was seen at Golden Health, blood draw showed elevated mercury level. Further testing being done to see if exposure caused rash. Reportable for occupational illness.
220253170056M13488EE was assisting a group of co-workers with moving a Knaack box into the Crush/Convey maintenance shop. EE was lifting on side of the box and then they realized they needed additional help due to the box being too heavy. After they were done the EE began to feel lower back pain. EE was seen and released. On 9/29/25 EE was issued Physical Therapy.
220253170057M13217EE was using a swing gate to access a ladder. When EE let go of the gate, it swung back closed. The EE's finger was struck and it began to swell. Near the end of shift the EE informed supervision of the incident. EE was taken to the clinic and x-rays were done. EE had fractured EE's middle finger. EE was taken off work.
220253170058M12917EE was working on cleaning out mixer. EE picked up a pry bar to break loose hardened material from mixer flights. While doing so, the ee hit the buildup of material and the force from pry bar hit EE in the face near EE's eyebrow / forehead area. EE suffered a laceration and needed stitches.
220253170059M13357Ee report on 8/1: driving water truck, right shoulder pain aggravated, steering also difficult to manage, aggravating left shoulder pain. Filed claim for benefits. Medical investigation concluded aggravation of pre-existing condition and acute on chronic recurrent rotater cuff tear. Accepted on 9/30, reportable for cumulative trauma.
220253170060M11023Mill Maint Employee sustained rope burn to their hand while changing out a return idler on 5 Belt XCC.
220253170061M10411HT135 Operator rough load injury by SH23.
220253170062M13307Associate was removing hydraulic pipe from excavator boom. When fitting was loosened, pressurized hydraulic oil (cold) sprayed EE in the face causing EE's hard hat to be pushed back and EE's safety glasses to come off. Associate flushed eyes with eye wash but was taken to Emergency Room for discomfort as a precautionary measure.
220253170063M12606EE was attempting to rotate a rotor shaft manually to grease the bearing housing. EE placed EE's hands on the belt to move the shaft and when EE pulled EE's pinky finger was pulled into the motor sheave causing a laceration and a fracture to EE's pinky finger.
220253170066M11113CARPAL TUNNEL RELEASE AND UNT RELEASE FOR BOTH LEFT AND RIGHT HAND. LEFT HAND 10/02/2025 RIGHT HAND 10/16/2025.
220253170068M13468Employee was bending over to pick up a trash bag from a box that was on the floor. The employee did not notice a metal pipe that was next to the box on the floor and as the employee bent down to pick up a trash bag, EE's left forehead came in contact with the end of the metal pipe resulting in a laceration to the top left side of EE's forehead.
220253170071M10983Employee was cutting sheathing from wires when tool slipped and cut EE's hand through EE's gloves.
220253170081M11133Injured was clearing dust chamber with a shovel when hot material entered EE's boot causing a burn to EE's ankle.
220253170083M11654Employee was walking up set of stairs to check on repair status of transfer chute transfer screw when employee looked up and a particle of lime dust entered EE's eye
220253170084M12426Employee placing pin in swivel plate on conveyor for transport being held by a skid loader when the skid loader raised off the ground causing the rack of the forks to contact EE's hand causing a laceration to EE's right middle and ring finger
220253170085M10842An LHD operator backed out of a head while mucking and ran over EE's partner's foot.
220253170086M12736While trimming stone with a masons hammer a piece of the hammer head chipped off and embedded into the inside of the employees left wrist. The Dr says it will need to be removed and surgery is scheduled on 10/7/2025. Employee is allowed to work until then with restrictions
220253170087M10752Tire Tech pinched hand with torque gun during maintenance activity on LDR1.
220253170088M10822MIS Employee sustained laceration using cable splicing knife to open a tablet box.
220253170090M13788EE was climbing down from EE's dozer and EE's foot slipped off of the foot rail. EE fell 2-3" feet to the ground and rolled EE's ankle when EE hit the ground. EE said EE's leg was sore but didn't require immediate medical attention. The next day EE went to the doctor and they said EE strained EE's knee EE was told to ice and wrap EE's knee, but was able to return to full duty
220253170091M12907Employee was breaking a sideline this process involves striking the wedges swinging the hammer with a side-to-side motion. While doing this the employee missed the wedge and struck the wall causing the hammer to deflect and rotated the employee rapidly causing a strain to the lower lumbar.
220253170096M12185The employee was tightening a come along while doing utility work when the come along broke and the hook struck the employees finger. The employees' finger was later on determined to have a fracture at local hospital. 
220253170097M12686The employee was working on disassembling the temporary hoist for an upcoming job after testing. A steel piece was being hoisted to be removed from the platform when it shifted and struck the employees hand against a handrail. The incident resulted in a broken finger.
220253170098M12436Quarry worker, was cutting rock with the grinder, wiped EE's safety glasses with EE's glove and took them off, and wiped EE's eye while getting the silt off EE's face with EE's glove, which EE thought was clean and pushed debris into EE's eye.
220253170099M12375Employees were working on replacing some pipe on the dredge and while using a pry bar to pry a gasket off, the bar slipped and hit the miner in the face causing a laceration right under the left eye which required a total of 12 stitches.
220253170100M13748Employee was assisting shop welder with hydraulic hammer housing being repaired. Employee used overhead crane to lift one end of hammer housing to enable cleaning and new seal prep. A lifting eye that was tack-welded to the end of the housing, broke free causing the hammer housing to fall to the floor and crush the employee's toes. Employee was wearing safety toed shoes. 
220253170101M12436Employee was doing daily inspection on jaw crusher, when a haul truck dumped its load at the top of the ramp. The material surged from the primary into the grizzly feeder and then a rock came out and struck employee on the back of the hardhat.
220253170102M11654Employee was operating a Loader when they drove over uneven ground, causing pain to their lower back. They were diagnosed with a back strain and issued restrictions.
220253170104M12726Employee was walking up stairs in Raw Mill Building and felt a pop in their knee. The following shift (9/27/25) the employee sought medical treatment and was placed on restricted duties. This is a potential aggravation of a previously reported self care injury on 5/28/25.
220253170105M12646ON 9/26/2025, EMPLOYEE RECEIVED MEDICAL TREATMENT FOR (L) KNEE AND WAS PLACE ON RESTRICTED DUTY WHICH CANNOT BE ACCOMODATED. THE EMPLOYEE REPORTED NUMBNESS TO THE BACK OF THE KNEE AND EE WAS DIAGNOSED WITH (L) KNEE DERANGEMENT. NOTE: EE REPORTED THE NUMBNESS LATE.
220253170107M10301Employee was moving some chain
220253170108M11594This is a personal issue on this employee from pre-existing condition. EE was preparing to gather EE's tools when EE slipped and felt a pop in EE's groin area.
220253170109M12325A maintenance mechanic was inside the discharge chute of Ball Mill #5 and was using a 12-pound sledgehammer to break a chute liner loose when EE's footing slipped mid swing and the hammer hit EE's right knee causing a chip fracture.
220253170110M13037EE was replacing battery while standing on operator platform of equipment when they rotated with battery in hand causing their foot to slip off the platform and going between the track and engine compartment body. EE was initially released to full duty and later placed off work by the medical provider.
220253170111M11053Employee was taking apart a 3-inch hose and the camlock struck EE in the lower lip, causing a laceration.
220253170112M12836EE had opened the haul truck hood with a crowbar, and then EE was attempting to use the bar to prop the hood open while EE was filling the truck with antifreeze. In the process, EE shifted position and the crowbar came loose and crushed EE's hand between the hood and the engine bay.
220253170113M13067Employee was moving breaker from waist level off of plant kat onto plastic cart which was at knee height and approximately 2 feet away from plant kat. Breaker weighed approximately 120 pounds; the lift was assisted with another employee.  The employee felt pain in their left bicep while moving the breaker
220253170116M13378On 9/28/25, EE slipped in a small hole and injured EE's knee while getting out of EE's vehicle for work. EE reported it to team lead at 12:00 PM; TL informed supervisor at 6:24 PM. EE requested medical attention the next day, was evaluated, given medication and work restrictions that didn't affect equipment duties. Released on 10/2/25.
220253170120M11534A large piece of rock fell from the ceiling at an intersection. Some of the rock struck the drill. There were no injuries associated with this incident. 
220253170122M10552EE injured left thumb while operating mini track loader
220253170123M12416A miner was turning a pipe with a pipe wrench in one hand, and their other hand on the top of the pipe where an elbow was located. The pipe turned faster than the miner expected, and the miners thumb got caught in the elbow, bending it back.
220253170124M13337Mechanic was climbing down ladder of a under ground haul truck when EE stepped off the ladder on to the ground EE's knee twisted. EE had a small tear in EE's meniscus. EE worked full duty until the date of EE's surgery in August. it took a a while to schedule because it was out of state and EE had to lose weight before the surgery.
220253170126M11023Miner pushed loose forks together on telehandler and fractured right pinky finger between metal forks.
220253170128M12395While using a come-a-long to raise and align a loader bucket cutting edge, the hoist hook slid, pinching the employee's gloved finger. Employee was diagnosed with an open phalange fracture, received sutures, and released with restrictions.
220253170129M13368Two employees were bolting in a narrow belt line area when the bolter tripped the e-stop cable. While discussing reset options, one employee attempted to squeeze through a tight area. While doing so, the bolter shifted, pinning them between the bolter and rib. They called for help, and the other employee moved the bolter to free them.
220253170130M10822Nopak valve for south gate failed causing the production hoist to be unavailable. 
220253170131M10121Hearing loss
220253170132M12927Employee was fueling the excavator.  EE spilled some fuel and then slipped in the fuel and fell off.  EE hit the fuel truck and then the ground.  This caused some shoulder pain.  EE went to the Emergency Room in Salt Lake City and cleared EE to come back to work on 9/30.  Nothing was broken.
220253170134M11724Employee was assisting with installing a tail pulley on P-3.  The tail pulley rotated and pinched the tip of EE's right pinky finger.  The would required stitches to close.
220253170136M13087EE reports low back pain that began while working on a pump this morning. EE describes middle of the back pain that is keeping EE from being able to move or bend in any direction. EE states unable to work with the pain. EE reports previous low back problems that normally resolve with prescriptions and rest.
220253170138M11494Employee was walking to EE's haul truck when EE stepped on a frozen puddle of ice.  EE slipped and fell straight backwards and injured EE's shoulder.
220253170140M11133Employee was picking up a chunk of salt to place on a conveyor.  Chunk of salt fell on left foot, causing bruise.
220253170142M12957The employee fractured the right thumb when it got pinched between two cables while using the crane and wrecking ball to scale down the west car dump pocket. The cable got hung up on a protruding stud and the employee attempted to move cable. The employee was wearing leather gloves at the time.
220253170143M11504While attempting to cut a conveyer belt to replace it. the Cutting wheel a Maintenance Tech was using jumped forward causing it to strike there thumb.
220253170144M13307Employee was operating 631K Scraper. The Employee was going down the hill from the new strip and hit a dip which caused EE to lose EE's footing from the brake peddle which made the scraper accelerate speed going down the hill; when EE reached the bottom of the hill EE was able to stop the scraper but said EE had lower back pain.
220253170145M10922Employee was pushing forks together on a telehandler when EE felt a pain in EE's left bicep.
220253170146M12596Employee was working in the shop and in the proximity of another employee that was welding. Injured employee states EE sustained flash burns from the welding operations. Employee was seen at a medical facility and given eye drops to use for the next few days.
220253170147M13648Customer was using 773 haul trucks to be loaded with boulders from LVP pit to be taken off site. During execution the trail haul truck lost brakes on a downhill slope between 6-10 degree decline. The trail truck struck the lead truck pushing it under LVP dozer trap. 911 called immediately and flight for life was dispatched. Front miner has broken ribs and back. 
220253170150M12476While using pry bar to perform work on the conveyor, the employee felt a "pop" in their upper bicep/shoulder area. Employee did not seek medical attention until 10/2/25. Medical evaluation revealed a partial bi-cep tear. PT prescribed and attended
220253170152M10812Employee was walking down stacker and missed a step - became reportable 9/24/2025
220253170154M13097EE was working on balling floor by "A" bentonite feeder in the Pellet Plant to address a bentonite delay. EE turned to leave the bentonite feeder when right pant leg hooked on a piece of angle iron structure near floor. EE fell on their left side & knee contacted the floor grating causing pain to left knee. 
220253170155M10351Employee fell while climbing ladder
220253170156M10682EE was inspector bucket elevator and slipped on mill ball on ground.
220253170157M11674Miner was putting guard back on conveyor and pinched their finger. They were seen at medical facility and received four stitches to the top of their left index finger.
220253170158M13778Injured MTM was sitting in a spare 3rd stage mainframe in the zinc shop installing a horse collar liner. EE was operating the overhead crane with EE's right hand and repositioning a horse collar liner for final placement with EE's left hand when EE's left fingertips became pinched between the bottom of the tub and the liner. This resulted in a fractured left middle fingertip
220253170160M11333ee was placing foam between stone slabs when several fell, pinning EE's left leg between the stone and the trolley the slabs were on.
220253170161M11594Maint Tech was climbing a step ladder, lost their balance and tried to catch their self. Employee's wrist contacted a piece of metal which caused a laceration.
220253170162M11834Laceration to thumb requiring stiches.  During LOTOTO, employee stepped into help with project installing v-belts on CV7 conveyor. EE pulled the belt, and it got caught on EE's thumb.
220253170166M12506Injured was reinstalling Raymond mill panels using a 2-ton overhead chain hoist.  The chain hoist trolley over-traveled the end of the beam and fell, striking injured on side of head and shoulder, causing EE to strike EE's face on the mill structure.
220253170168M13828Employee was on platform of 980 wheel loader cleaning the front window when EE slipped and lost EE's grip on the hand-hold.  EE fell over the side, hitting the wheel well and then to ground.  The wiper dispenser wasn't working well.  The platform footing may have had dew causing the slip but not identified at time of inspection.  Employee later complained that EE's back was sore.
220253170169M12897Miner was called in to repair the splice in a belt. After completing the repair and reassembling the equipment, the miner checked the belt's operation. While inspecting the belt, the miner accidentally stepped on some clinker on the ground, causing them to slip and hyperextend their knee.
220253170170M13368Miner was replacing rear belt skirting. After removing the old skirting, the miner used it to trace and cut a new piece. As the affected miner was starting to cut the new piece, the knife slipped and embedded itself about an inch into their leg. The miner was taken to urgent care, where they received four stitches just above the knee.
220253170171M12115Lifting a 4d battery out of a komatsu 480 loader. EE hurt EE's lower back during this. Drove self to the dr. @ 11 am that morning and got x-ray. Had an MRI scheduled that friday. x -ray showed herniated L5 disk.
220253170172M12265Distribution employees were moving railcars in the Canyon and noticed a grass fire, fire department was called after it started spreading. No injuries and no damage to any equipment. Fire put out in approximately 50-55 minutes
220253170176M11894The employee experienced physical strain due to the repetitive pulling of the wire, which was built up in a chute that was plugged in an awkward position, and required a medical evaluation.
220253170178M10682Employee tripped over piping on ground - became reportable 9/25/2025
220253170179M10993Skip came out of the guide in #3 shaft. we still had the other side of 3 shaft working and #4 shaft
220253170180M11985EE was installing belt on pulley. EE's finger became caught between the pulley and the belt, amputating the tip of EE's right ring finger. EE was taken to the hospital for treatment. Taken off work.
220253170181M11454At 4 am a haul truck operator began to feel itchy. EE went to the restroom and discovered red bumps (rash) on EE's body. EE notified supervision.
220253170183M12846Two employees were performing maintenance on a conveyor belt. One employee was on top of the conveyor removing a flexco while the other began drilling a punch hole. During this process, the drill made contact with the first employee, causing a laceration to their right middle finger.
220253170185M11423The worker did not maintain a safe distance from the operating crusher, exposing self to flying rocks, which have contributed to the incident.
220253170192M13237Operator was mucking mud with excavator (Cat 365) when a hydraulic cylinder next to the cab burst.  The window was shattered, and the operator was sprayed with hydraulic oil.   Operator went to the hospital where EE was given a return to work without limits.  EE chose to take the week off work.  No injury, near miss only.
220253170194M11834A single miner was involved in an elevator entrapment when an elevator malfunction occurred. Miner was safely removed and the elevator was repaired, inspected and returned to service.
220253170195M13688Employee was lifting a belt clamp/valve into position then pulled to tighten on belt line, causing an injury with pain to the left lower side of back. EE was treated by a medical professional for sprain/strain, and prescribed medications/pt. Restrictions are as follows: No lifting/carrying over 20lbs, no pushing/pulling, no reaching below waist, no stooping/bending.
220253170196M12606A fire occurred on a Komatsu 930E Surface Mining truck. The area was secured to prevent harm from potential hazards for the duration of the exposure. External fire response agencies were immediately contacted and extinguished the fire when conditions allowed. 
220253170202M12115While exiting light vehicle on driver's side, employee stepped onto pointed edge rock, right ankle twisted resulting in subsequent fall to ground. Injury sustained was right ankle avulsion fracture distal fibula
220253170203M12065EE had their pinky pinched in between a piece of a wear steel plate and the side wall of a chute. Injury did not become reportable until treatment by a physician on 10/7/2025 where restrictions were issued.
220253170204M10802Employee hit soft spot in road and felt back spasm - became reportable 9/26/2025
220253170205M10882Employee had back pain after hitting pothole in haul truck - became reportable 9/15/2025
220253170206M10562Employee overexerted themselves trying to get out of mud
220253170207M10542Employee struck hard knob in rubber tire injuring back
220253170208M1167410/10/25 around 9:50am nice day sunny temp was 70dgrees. blasting crew was setting off a shot when fly rock struck the blast shelter and scared EE into a panic attack.
220253170210M11894EE was rolling a pulley, and it fell off the pallet and when EE went to pick it up, EE's right pinkie finger got caught between the boom and the shaft. Causing a laceration needing stiches.
220253170212M10963ee was climbing up stairs; reached out to grab the handrail and felt pain in middle back area.  
220253170213M13758Employee was injured when EE fell through an elevated platform in a restricted area of the underground mine after EE climbed over a berm to access the restricted, inactive area in violation of the mine's rules and EE's training. The employee was not authorized to enter the restricted, inactive area and was not performing any work activity at the time the accident occurred.
220253170215M13227Miner was working in Kiln 1 ballroom doing routine housekeeping, EE went to lift by self a 3x3 door (weight 50 pounds) used to return cleanup material to the silo. About an hour later EE felt a sharp pain in EE's groin and a dull pain in EE's lower abdomen. EE continued to work and finally reported the incident at 4:50pm
220253170216M11293This report is being filed due to hearing loss detected during annual audiometric testing. Loss was found in employees Left ear. 
220253170218M13418Miner was injured while using a scaling bar to remove loose rock while loading a header.  The bar glanced off the rock and hit EE on EE's right thumb.  EE was taken to be evaluated and was diagnosed with a contusion and placed on restricted duty. Restrictions do not prevent EE from driving a truck, which EE has been doing without incident.
220253170220M12235The employee was walking around EE's service truck walking on uneven surface throwing away trash, flashing, and old bearing housing that were in the back of the service truck, when the employee felt a pop in EE's left knee.
220253170221M12646EE reports that EE was walking in the mine area and stepped on a spot that moved under EE's foot causing foot to twist. EE reports pain in foot and unable to walk due to pain. EE states that EE has recent problem with foot, but that the current pain is much worse.
220253170223M10912EE pinched EE's left pinky finger while setting a large wooden block into a metal container
220253170225M11564While cleaning a chute with water the individual had wet high alkali material get behind EE's safety glasses and into EE's eyes causing minor chemical burns
220253170228M10461EE was lifting vactor hose and felt back pain.
220253170230M11975Employee was adding coolant to a CAT 980M when the hood came down quickly and knocked the employee back into the catwalk /fender support where the hood came down and rested across employee abdomen.
220253170231M11634Employee was attempting to close the door on the freight elevator and got EE's hand caught between the inner and outer door, resulting in a fracture to EE's finger
220253170232M11333Employee was working in the shop and helping replace a cutting edge on a loader bucket when the cutting edge dropped on to EE's foot.
220253170239M10973Employee smashed finger in the door while exiting the crusher tower after operating rock breaker.
220253170241M11624Employee was removing worn cutting edges from front end loader using cutting torch to remove old bolts when cutting edge fell landing on left foot breaking 5 toes
220253170243M10311changing blow bars on equipment
220253170246M11233EE was working on an engine mount when the wrench slipped and struck the EE in the R eye causing a laceration and bruising.
220253170247M11644Employee was lifting scale parts off a pallet when EE's left thumb got stuck between two parts. EE went to the ER and hand specialist. EE has a break in EE's thumb.
220253170249M11584Employee missed a step while climbing off the back of EE's mechanic's truck. EE fell to the ground, hitting EE's elbow. X-rays showed EE fractured EE's elbow.
220253170251M13017A miner was using a stand-on skid steer to perform housekeeping around a transition point of two outdoor conveyors when they struck their hard hat on the end of a pipe. The miner was taken to the emergency room where they were diagnosed with a head and cervical spine injury and prescribed lost time. 
220253170252M12125Coworker was removing a screen from the storage rack. The cut edge of the screen slipped from EE's hands and fell forward, striking EE in the forearm. This caused a 3" cut to the coworker and required 4 stitches.
220253170253M11203EE states while performing arc flash study, stepped over a pipe, heard a pop on knee, injured L knee causing swelling.  
220253170254M11935IW was in the process of loosening a hydraulic coupler on a boom cylinder when EE was sprayed with hydraulic fluid. This resulted in a laceration on EE's nose, and hydraulic fluid in EE's eyes.
220253170256M11904MTM was changing all-thread to level the thickener rake. When employee was finished, EE felt pain in EE's shoulder. Employee climbed down from the job and reported the incident to supervisor
220253170257M13357043-06-1 conveyor belt where employees were doing work to the belt and changing rollers. Employee was helping clean up and pulling out a return roller from under the belt at which time EE felt pain in EE's left bicep. Other employees were also present at the time of the incident. Employee said EE is unable to straighten EE's left arm
220253170260M13207EE drove a stake body truck down to level 12. EE exited the vehicle and then reached back in to turn off a strobe light. While reaching, EE stepped in a 6" hole and tweaked EE's back. Appears to of strained a muscle. Upon clinic visit, EE was deemed unable to currently work. Missed workdays and likely light duty ahead.
220253170263M13047Employee was troubleshooting an issue with a California Pellet Mill.  Two employees were rotating the pellet die when the glove of one individual became caught between the rolls and the die pulling the employees left middle fingertip into a pinch point causing a laceration and fracture of the fingertip.
220253170264M11995Employee was operating the mobile crusher in the pit on a 980H loader.  They stopped the loader to get out.  They climbed out of the loader and their back started hurting.  They did not fall or slip.
220253170266M11013Slip, Trip, Fall, in the plant while walking across damaged concrete. EE fell and broke EE's clavicle
220253170267M11093EE was hammering a bearing sleeve. The bearing broke and struck EE's hand causing a laceration to EE's finger
220253170273M13087An employee was climbing a vertical ladder to access the head section of a conveyor to perform a scheduled bearing replacement. While climbing the ladder with 3 Points of Contact they lost their grip and fell backwards from their position, and the left torso area contacted the railing of an adjacent ladder.
220253170278M12556Maintenance was changing a vertical driscoll pipe. The rigging let go and a miner was struck by the pipe from behind. Bump on the forehead, sore neck, shoulders and upper back. EE did not seek medical until 6/8/25, that is when EE was put on restrictions.
220253170279M12476While an employee was exiting a bolter, their tool belt caught on the grab bar railing resulting in the employee twisting their back in an awkward motion. Employee was evaluated the following day for worsened pain resulting in days away from work.
220253170280M13047Shovel operator stated jarring their left shoulder while operating the shovel mining out a ramp, and experienced left shoulder pain on 02/19/2025. Employee has a history of left shoulder injury. Employee continued to work full duty until receiving medical treatment for their left shoulder on 10/08/2025.
220253170281M10862Piece of metal got into employees' eye sometime during shift, unknown how it happened.
220253170285M11454Employee was cleaning metal off of the metal magnet. While trying to remove a bolt from the magnet the employee finger poked by a piece of steel.
220253170286M12927The injured miner was replacing dead batteries on the repeater in the quarry. EE jarred EE's right shoulder and felt pain. EE went to physical therapy and was eventually recommended surgery to repair a torn rotator cuff. The surgery occurred on 10/16/25 making this an MSHA reportable injury.
220253170287M11554While installing a shock brushing in truck 143's lower A arm, EE went to knock it in with a hammer, EE missed striking EE's Right thumb. received 6 sutures
220253170289M10822Repetitive actions, Sweat, No cut resistant gloves utilized, straight blade knife.
220253170292M11213While working on Plant 3, using a Porta Power Ram EE bent over to make repairs and felt EE's lower back spasm and tighten
220253170296M13127I injured my left hand on October 9th, 2025 at approximately 8:30am while trying to hitch a boat to my work truck to move it. I was trying to lower the tongue of the trailer using the hand crank on the leg, when suddenly the leg folded under and the trailer smashed down on my left hand slicing my middle finger.
220253170299M11303Operator jumped off equipment from approx. 3 ft after incident. Felt pain in right knee from twisting motion when contacted ground
220253170300M12035Worker was splitting a dozer track, when the track came apart EE's left ring finger was pinched in-between track pads causing injury to finger which required sutures and the tip of the bone was fractured
220253170303M11484Employee was walking in tunnel when EE slipped on EE's left foot and EE's right foot stayed put. EE felt a pop in EE's right knee and felt pressure.
220253170307M10622Loader operator was jolted in loader and suffered head injury.
220253170308M12235At this time the employee started removing the lead from the light and then that's when a big piece of dried up lead fell from above the light fixture and landed on EE's left thumb, that EE had holding onto the ladder with.
220253170310M13187Sep 26, 2025: Employee felt knee pop pulling lift stand, notified supervisor of soreness. Visited clinic, advised knee brace, returned to work. Sep 27-28: Knee swollen, moved to Planning Bay Office. Sep 29-Oct 2: Evaluation. Oct 2-16: R&R. Oct 13: Doctor notes surgery needed, light duty. Oct 17-: Planning Bay Office.
220253170311M13297EE was engaged in the task of removing a slurry pipe at the Boar Hammock Mine. EE attempted to cross over the pipe to reach the other side. Instead of stepping over the pipe, EE stepped onto the pipe to cross. The pipe had a slippery residue on its surface, causing EE's foot to slip. EE heard and felt a "pop" in EE's left knee.
220253170313M13127During the operation of a track drill, one of the drill bits was positioned outside the storage channel. The operator requested EE's coworker to activate the drill changer lever while EE manually held the bit. Upon activation, the operator's right thumb was caught between two drill bits, resulting in an injury.
220253170318M12375Craft A was turning a half inch ratchet while Craft B was holding the torque multiplier using an extended handle and wrench. Craft B's hand slipped, and the craft's middle finger was pinched between the wrench and the wall of the tank.  
220253170320M11995Reported a sore wrist from using a shovel and felt a pinch in EE's wrist.  EE states EE was using a shovel in a pile of aggregate to put into a 5 gallon bucket to test.  EE is a quality control tech.
220253170321M11073USING EXTRACTOR BIT TO DRILL OUT BROKEN BOLT, BIT SNAPPED CAUSING HAND TO SLIP DOWNWARD AND CUT TOP OF HAND
220253170323M11333Employee was descending stairs from the crushing plant control room when EE slipped and hit EE's elbow on the stairs as EE slid down.
220253170324M12676While performing the daily safety checks on the hoist, the hoist operator pushed the emergency stop button to test the weight brake and the hoist tripped on an E-stop fault. Electricians assisted the operator in resetting the hoist.  Hoist was back online at 5:53 pm.
220253170329M11774Coming from EE's vehicle with personal items and fell at or on the landing/platform/porch at the door to the office. EE tried to catch self and injured EE's shoulder and/or arm.
220253170331M10892As employee was poking bar in to silo to free up material EE felt a pop in EE's shoulder.
220253170333M12907Employee was walking down staircase when EE stepped on second to the last step, the stair broke resulting in EE's left foot going through the step and hurting EE's ankle. Employee seen and released to full work duties. Employee had follow-up and seen 10/16/2025 and went on restricted duty.
220253170334M12977A small grass fire started at the Quarry due to unknown reasons. There where no employees working at the time of the fire and Local fire department extinguished the fire after being called by an individual passing by. Quarry employee was called in to establish a fire break in case of re ignition.
220253170335M11093EE was in the screen replacing panels, using a pry bar and hammer, hammer slipped and hit EE in the left knee
220253170337M11814An employee was using a break-over binder and chain to secure poly pipe to a float, the chain slipped, causing employee to fall awkwardly, (same Level) breaking EE's lower left leg.
220253170340M11213ee was assisting with a belt pull. When pushing on the belt, felt a pop in EE's knee. was evaluated and was put off work.
220253170341M11063During Technical Ropes Training the employee was beginning to repel of the edge when their knee gave out. 
220253170342M11313EE was assigned to drain and refill the jaw crusher oiler, as EE was holding the bucket in place, EE felt EE's lower back give out.
220253170343M12536Employee was doing a brake inspection of a Trailer when EE was measuring the slack adjuster a small chunk of dirt fell between EE's safety glasses and EE's eye causing scratches on EE's eye. we took EE to urgent care where the prescribed EE antibiotics.
220253170344M11794The employee was bent down picking up extra bolts when they felt a pop in their knee as they stood up. It was determined that the employee tore their meniscus and needed surgery. 
220253170345M10922Miner bumped EE's head on equipment frame exiting a skid steer. Miner was wearing a hardhat.
220253170347M11494Roof fall occurred in L5/C84. The area had already been barricaded due to poor roof conditions. Following the fall the barricaded area was extended. 
220253170348M11894A Dozer Operator with 24 years of experience, was dismounting the dozer before EE's lunch break. Employee stepped from the track down to the first step, left shoulder popped as EE descended
220253170350M13578MMG's were removing the 5B rougher drum in the east side of the Concentrator to repair the tub. They used OH crane to remove drum to set the magnetic rougher drum on ball mill floor cover. The cover became stuck to bottom of drum. MMG jumped on 5ft pry bar placed between cover & drum (@ angle ~4-5" from ground), when cover released, EE injured right foot.
220253170351M11454The employee was moving thin sheets of metal (not wearing the appropriate PPE, cut-proof gloves) and cut EE's finger, resulting in five stitches.
220253170354M12015Employee sustained a laceration to the left ring finger while attempting to remove a grinding-aid lance from #3 Finish Mill. Employee was taken to the ER for further evaluation and received 4 stitches.
220253170355M11083EE was cleaning pellet mill turbilizer & one of the blades on the machine cut EE's right hand and smashed it
220253170356M12967Forklift operator was moving a concrete block when it slid from the fork and hit EE on EE's right foot. Foot was swollen and EE was taken to the hospital by EE's Supervisor. Foot was not broken but it was advised to stay home for the time being and come back in one week to check EE's foot again.
220253170357M10371Employee injured knee going up stairs
220253170359M11213Broken rib resulting from slip and fall onto horizontal scaffolding bar. Thought it was just back pain and reported late.
220253170363M11053A roof fall occurred in M2 in by of the C33 Cross cut. This area was Barricaded at the time of the fall. 
220253170365M11754Employee was performing cleaning and maintenance.  They began work around 7 pm and was discovered by coworkers on the ground below the area of work.  It is believed they fell.
220253170366M10251Lumbar spine discomfort. 
220253170368M10792Employee was walking on a flat even surface and their knee popped and gave out.
220253170369M13107The employee reported that while climbing down from an excavator, they experienced back pain upon reaching the ground. At the time of the incident, the employee declined medical treatment. The following morning, they requested to be evaluated by a physician and was referred to an occupational health facility.
220253170373M12987EE was cutting water line hose at wet plant with a utility knife. EE was holding hose up while cutting towards themselves. EE hand slipped at cut their arm. EE was taken to medical facility where they received 4 stitches on left forearm. EE was discharged and returned to work with no restrictions.
220253170374M10852Employee was pulling in a line out of the river and felt a sharp pain in their elbow.
220253170375M13468While removing an alternator along side another employee, the other mechanic was pulling the detached alternator through the top of the machine, while injured was pushing through the bottom. It slipped out of the other mechanic's hand and fell down smashing injured employee's right middle finger between the alternator and the engine mount bolt.
220253170376M11644Miner was dropping the axle on a trailer and was preparing to cut the U-bolts when they bent forward at the waist and began experiencing extreme pain in lower back.
220253170377M11383Employee was walking across the bucket to work on the haul back and slipped on the bucket and hit their head causing a gash and concussion
220253170379M13398Metal shaft roughly 3" in diameter and 8' long was wrapped in cardboard and leaning against a non-operational conveyor at the 1400 Crusher plant. While removing the packaging from the shaft, the shaft fell and struck miner's left foot. Miner was not wearing required steel-toe boots. Injury resulted in open and non-displaced toe fractures
220253170382M10832Employee was reeling in a water hose on a water truck and sprained their shoulder. 
220253170383M11393Employee was bagging 25lb bags at the Rotex #1 bagger system.  They experienced lower back pain and was diagnosed with a lower back strain.
220253170384M11003EE was getting out of equipment, stepped on a rock, which caused them to slip and twist right ankle.
220253170385M12626Employee was busting up rocks with a sledgehammer and putting pieces on the belt to clean the tunnel. Reported to manager that they felt a twinge in abdomen after they finished the job. Before starting their next shift, employee was seen by telemedicine. Hernia.
220253170387M11824Employee was pushing up on a conveyor belt trying to get additional clearance to remove a roller. After releasing the belt employee felt a popping and burning sensation in their hand
220253170390M12606it was a clear day and the injured employee was changing a light on a haul truck. They asked another employee to lower the hood and the hood was heavier than the employee thought and it hit the injured employee in the right forearm and a laceration was caused.
220253170392M11303Employee was installing a tail pulley on portable screening unit when pulley slipped and pinched their fingers on their left hand.
220253170393M12686An employee was moving a 3-inch pump. The employee mis stepped into a soft spot, and right leg got stuck approximately 8 to 10 inches deep in the mud. When the employee pulled their leg out of the mud, they felt their right knee pop. The employee is now using crutches
220253170394M10391employee cut knuckle with utility knife
220253170395M12796Employee fell while walking through a doorway. They reached out to catch themselves, but their hand gave way and they struck their elbow onto the concrete, resulting in a hairline fracture of the elbow. Fall was from same elevation with no obstructions or material in their path.
220253170396M11323Employee alleges left thumb was pinched between handrail and production equipment. Employee lost thumb nail and received 4 stitches.
220253170398M11193While using an Iron Worker to punch out a metal plate. The Iron Worker dye broke and struck the employee in the chest. 
220253170399M10842Employee was sprayed with 50% caustic. The caustic contacted the corner of left eye.
220253170401M13588EE was inside manlift basket using a steel lance attached to a vacuum hose to clear material from apron feeder below. While vacuuming the material the hose became stuck and EE tried to free it by yanking on the lance. The hose broke free and EE's hand flew back striking the corner of the basket's railing breaking the 5th metacarpal bone in EE's right hand.
220253170403M11965Worker was mounting the MuddOx and felt a back spasm when sitting down.  Location was lower left backpain.  Initial spasm was very painful and got a little better after walking for a little while.
220253170405M13037EE was assisting maintenance with the demo of dewatering screen and stepped on rotted flashing covered in sand to pass a piece of pipe to another employee. The EE landed on their right hip and fell into the adjacent sump that was full of water. The EE did not want to seek medical treatment until 10/15.
220253170407M13658Operator in Training (O1) was tasked with wash down duties on the north side of the Mill Washer Building. While performing the assigned task O1 used both hands to close a 2" ball valve with an oval handle. While closing the valve, O1 felt a pop in their left ring finger. O1 was evaluated at an offsite facility, where imaging revealed a chipped bone in the finger.
220253170408M13237EE was putting a gold bar into the cleaner slot and they caught a finger between the cleaner slot and the gold bar. EE was seen at health, diagnosed with a crush injury to the left middle finger, and released to modified duty, no use of the middle finger of the left hand. Site offering modified duty, EE currently working.
220253170411M11914EE stepped on wire panel while surveying and cut right index finger. Laceration to tip and pad of right index finger sutured, EE released with restrictions and site is offering modified duty.
220253170413M11694The employee was working on mineral separators when they stepped on a mesh cleaning ball and twisted their right knee. They did not fall but, felt soreness the next day.
220253170414M12756EE walking up stairs at the mill, carrying a flat of water. Felt a pop in knee. They saw dr, released to full duty. EE requested follow-up as it was not getting better. Following MRI, on 10/09/25, found ruptured ACL, making this reportable. EE scheduled for surgery 11/13/25.
220253170416M12345EE was taking a foot off a striker bar and hit a finger with a hammer. EE was seen at clinic, diagnosed with left index finger crush injury, dead skin debrided, finger splinted and must use splint at work. Xrays negative for fracture.
220253170418M10932Miner was torching on old storage bin and heard a pop, fell to ground and injured right knee.
220253170419M12325As employee was making their rounds in the grinding tunnel, a grinding ball rolled down the tunnel, striking them in the left calf. EE was taken to the ER, diagnosed with a contusion and placed on restricted duty. CURRENTLY ONGOING.
220253170420M12075Miner was inside Stedman crusher preparing to weld on reel. As they stood up, they placed a foot on the reel, dislodging wedge and rotating reel upward catching their leg and pushing it up against the apron.
220253170421M12636While installing banjo bracket and arm on the shovel sticks, using a come along, the come along chain failed and the bracket and arm contacted the employee's right wrist area. EE was taken to the ER, diagnosed with a fracture and taken off work. CURRENTLY ONGOING
220253170423M12836IP stated that they were at the mine sampling and due to the wet conditions, they lost their balance and fell down. The IP continued working throughout the shift and then advised another employee later in the day that their ankle was sore and went home. Seen at clinic on 10/16/2025.
220253170424M10952Mill Maintenance Employee sustained crush injury during maintenance activity on the XCC 2 Belt.
220253170425M10712Employee was using a hammer on a metal bolt when debris went into R eye
220253170426M10702Mill Maint Employee's hand pinned by concave liner at primary crusher.
220253170427M10662Mill Maintenance Employee struck by chute liner at GL 3/4/5 chute.
220253170429M13458Un atascamiento en la boquilla #3 de la BC-M cuando encuentra que tiene unas piedras obtruyendo, una procede a utilizar barra para desalojar la piedra. Realizando un tipo de apalancamiento ejerce presin sobre la barra en direccion hacia el cuando de momento esta se va en blanco, lo que hace que la mano derecha choque con la pared del bajante.
220253170430M11914TM was unhooking a pickup truck from a trailer and when the jack popped off the ball the trailer moved forward and smashed their left index finger between ball on the truck and trailer frame.
220253170432M10612Employee cut finger with knife - (website was down to report)
220253170433M13368While driving a kubota utv, some salt dust fell in eyes and when they went to wipe the dust from their eyes, they swerved to the right and drove into a chunk of salt and rolled the utv onto it's side. When they rolled the UTV, their mine belt had a harness ring on the back and that's what they landed on, fracturing their L2 vertebrae.
220253170434M12746While doing maintenance on the undercutter, EE and another miner were driving a cylinder pin out and the hammer EE was holding while another miner was hitting it with another hammer, and their arm was forced down onto the cylinder, cutting their forearm requiring 3 stitches
220253170435M13748Volvo 330 was tracking from new shot to medium stone fill to load a sales truck. Euclid End Dump sitting 5/10 min, was radioed to move forward to let truck through. Euclid backed into cab of Volvo 330 crushing cab, broken windows, broken door. Operator of Volvo was able to jump out of equipment (was not injured). Operator of Euclid was suspected on being phone distracted.
220253170437M12696Employee was exiting a truck when the slipped and caught themselves with their right arm. The employee initially reported it as a Report Only injury. Since the injury occurred the employee has felt more pain and the injury has turned into a Restricted Work on 10/16/25.
220253170438M12516Ee was throwing away a piece of hardline. When EE went to push the hardline over into the dumpster, it slipped and crushed EE's hand between the hardline and the Dumpster. Seen at the clinic, released to restrictions, and referred back to orthopedics.
220253170439M11444The employee was completing their workplace examination on the scaler when they tripped and fell on a mud mound causing an injury to their knee.
220253170440M12195Ee was drilling and stopped to install collar pipe in face and rock fell, hitting ee on head. Seen at NNRH, diagnosed with lacerations on scalp and face, treated with staples and sutures. Released to full duty 10/22/25.
220253170441M13327On 10/17 ee working with other ee unloading cement chute from pickup. While moving it, ee felt cramp in lt arm, and coworker reports ee "exclaimed loudly" and let go of chute. Ee said EE felt pain in EE's arm. Ee did not report this to site until 10/23. Seen at clinic, diagnosed with possible biceps tendon tear, referred to ortho.
220253170442M11694After welding on the Omni Short Head crusher, employee was grinding down the weld when a piece of metal slag flew behind EE's safety glasses and landed in the right eye.
220253170444M12035Ee was using band saw to cut cap hooks. EE's glove got caught in the band saw and cut EE's finger. Seen at ER, laceration was closed with sutures, released with restrictions. Site offering modified duty.
220253170448M11824Employee was installing a blank in the meal pipe. While pushing blank in and didn't realize a finger was in the bolt hole. When blank finally went in it cut tip of right ring finger.
220253170449M11363WHILE CHANGING SCREENS A TOOL FELL FROM AN EMPLOYEE'S GRIP AND HIT ANOTHER EMPLOYEE IN THE MOUTH.  THE LIP LACERATION REQUIRED STITCHES.
220253170451M12135As EE was reassembling the silo pipes, EE attempted to use an impact tool and wrench combination to tighten a bolt. The impact torqued the wrench, and EE's little finger was pinned between the wrench and the pipe.
220253170453M11233Employee was dismounting a ladder. As they descended, they missed the 2nd step catching themselves with their right wrist. 
220253170454M10471Employee fell while descending from 988k loader
220253170460M11343There was a piping failure in the southeast corner of the lower impoundment that allowed water to flow out into the evaporation lake. 
220253170464M10922Employee was loading pallets on a telehandler and tripped and fell, cutting EE's right hand.
220253170469M13788On 10/03/25 at 8:35 am, the coal mill operation began. At 9:26 am, the control operator noticed a fire on the coal mill line. Employees secured the area and tried to extinguish it. When it persisted, the Hygiene Fire Dept. was called at 9:44 am and arrived at 9:56 am. MSHA was notified the same day and visited on 10/06/25 to review the area and follow up on the investigation.
220253170470M12436Employee was stuck in the Step 1, 2 Agglomerator basement elevator. The employee became trapped at 902 AM. Security and safety were eventually notified. First responders arrived shortly after 930 and were able to get the employee out at 940 AM
220253170472M12526While travelling in the elevator car, there was a power failure, caused by a failed weighted power cable, which led to an employee being trapped inside the elevator car.  After the Amrize technical team arrived, the employee safely exited the elevator.
220253170475M11133A miner was going to unplug the Jumbo when they rolled an ankle on a small rock causing a fracture in their ankle
220253170478M11373Employee was clearing and spraying head pulley on tunnel conveyor when conveyor was started and right hand was caught and crushed fingers
220253170479M13237The employee was simply walking through the Maintenance Shop holding a box cutter they had just got out of the vending machine. Upon inspection of the box cutter, they noticed a foreign object (possibly glue) on the blade. They proceeded to wipe the blade off on their left sleeve, when they cut/punctured their wrist area.
220253170481M12255A haul truck was backing into the crusher dump pocket and did not notice a loader already in the dump pocket. The truck's rear tire came into contact with the rear of the loader, jarring the operator in the cab of the loader.
220253170483M11614The employee was hauling material down a steep slope at the quarry when they lost use of the brakes and the vehicle turned over, resulting in a fractured finger.
220253170484M12325After completion of maintenance work on an elevated area, the employee was lowering a tool bucket down with a rope, the tail end of the rope became entangled in a shaft pulling the rope tight and cutting employees right ring finger.
220253170489M12285While taking apart a connection for conduit, two MTEs were trying to loosen the connection with channel lock type pliers. The channel lock type slipped, unsure if the conduit or tool contacted the injured left side of the chin. 
220253170492M12987Employee was standing on a piece of metal that was being bend so it wouldn't move and with hands on the frame of the conveyor above. An employee struck the metal with a hammer causing employee # 1 to lose balance. Hand was holding on the conveyor frame which put weight on wrist (left) injuring it.
220253170493M10482Team member felt pain in wrist after shoveling. 
220253170497M13007Employee was adjusting lifting shackle and overhead crane hook during lifting operations. The employee's right index finger was pinched between lifting shackle and overhead crane hook. The employee suffered partial traumatic transphalangeal amputation of right index finger with nailbed involvement. 
220253170498M12055Standing at ground level putting a bar back on grizzly screen. Was trying to guide the bar in to the bolt holes, lost footing and fell back to the ground and the bar fell on employee. Lower back/butt sore.
220253170499M11033Employee was locked in the stone silo elevator between floors due to an overload condition on the motor
220253170501M11283Stepping off of a 1 foot platform in the Bagging Facility rolled left ankle resulting in a sprained ankle and hairline fracture.
220253170503M12546Operator was trying to pull the fuel hose to the haul truck. The fuel hose was caught on something, so the operator walked over to unhook the fuel hose and tried to pull the hose again, this time falling and landing on the right hand, injuring the wrist.
220253170504M10702Employee was rough loaded in haul truck - became reportable 10/16/2025
220253170506M12375Miner was shoveling under the portable plant screen due to a belt overload. The area under there has a low ceiling and is awkward. When miner was bent over shoveling, they heard/felt a pop in their back. Right hand side on the belt line.
220253170508M12065ee was removing idlers from conveyor for a belt change. when they went to move the idler to the floor, their finger got pinched/rolled in between the cans causing a laceration / split to right pinky finger.
220253170509M12796Employee was ascending steps at #4 spray dryer area to take the chute out of the car so it could be dropped down. As employee was ascending the steps they tripped and sustained an injury to right knee and right hand. They will have to see and orthopedic surgeon about their hand.
220253170511M11253Employee was clearing a blockage from the suction hose on the vacuum truck, when their left arm had been drawn into the hose.
220253170512M10852While removing a guard on a motor to measure a sheave, employee smashed left finger. 
220253170515M12977Excavator Operator got out of the machine, went down to stock pile coming off the conveyor of a screen to check material they were screening. The Loader Operator went into stock pile not seeing the man and started to take a bucket out and hit the man on the ground. I believe sun caused blindness.
220253170516M12315While operating a Club Car the employee reached out to push some vent line out of the way.  In the process they received a laceration to the forearm.  The laceration required 5 sutures to close.  Employee was issued a full release.
220253170518M10932Employee cut their left forearm with a razor blade stuck in a pallet resulting in 4 stitches.
220253170520M11123A pump had stopped working so water had built up on the floor causing a slippery surface on a step of the drill.
220253170524M12516EE was removing wire from conveyor belt. While pulling wire with force, the wire gave way, ee fell back onto metal stairs, hitting head and neck. Seen at NNRH and then Health. Released with restrictions until 11/1/25, when EE is released to full duty.
220253170525M13357The employee sustained a left forearm laceration while using a pair of scissors as a draw knife to cut scrap cardboard into smaller pieces for disposal. The employee was pulling the scissors toward themselves when the scissors slipped and cut into their forearm, 4" above the wrist and glove, causing a laceration requiring 4 stitches.
220253170526M12155After utilizing a welder to weld plug holes in the feeder, eye began to bother them. They flushed their eyes and later that night was unable to open them so they sought medical attention and was given prescriptions.
220253170527M13167EE was working on a pressure washer. They plugged it in and was checking belts. They leaned over onto the power button. The washer turned on, and the pulley belt pulled their glove in, amputating the tip of their left middle finger. Seen at ER, diagnosed with traumatic partial amputation, released to modified duty.
220253170529M11193while climbing on the ladder, lost footing and slipped off ladder, falling to the ground landing on ankle, and backside
220253170531M13127A Haul Truck Operator was climbing from truck to the ground using the handrails and 3-step boarding ladder when they fell from the second step to the ground. They were transported to the hospital for evaluation and was placed out of work for a suspected concussion. Their first shift of lost time was 10/19/2025.
220253170533M12215EE reports cleaning the bottom floor of the Mogensen building when two palm size rocks fell from the Mogensen screener and hit the EE in the upper back and neck area. EE complains of continuous pain, soreness, and injury.
220253170534M10772Employee sprained right ankle when getting off of forklift at propane tank.  
220253170535M10993Miner accessed nose of drop deck trailer and fell ~4 feet to ground below and fractured left wrist.
220253170540M11023Employee was removing bolts from the pit pump when the wrench slipped and made contact with their lip.
220253170543M12185Employee stated that while coming out of a kneeling position they felt their knee "pop". Employee stated that there was no signs of swelling and that there was no pain. Employee finished out the remainder of the shift.
220253170546M12586Lab tech was in the laboratory, walking into the mill testing area from the main room. When transitioning through the doorway from the main room into the mill testing area, the miner slipped on the tile walking surface causing the miner to fall to the floor.
220253170547M13408Employee hauling wet plant waste from plant area to dump with CAT 775D haul truck with tailgate. Employee began traveling on primary roadway when the weight of the plant waste shifted towards the back of the truck bed resulting in the front end lifting off the ground. When front end came back down it bounced twice before coming to a halt.
220253170550M12696At 11:20pm, a non-conforming item went through high speed shredders at Green America facility which resulted in a fire.  Contacted MSHA at approximately 1130pm to notify them of the incident.  Fire department arrived on site at 12am to assist with putting out the fire.
220253170555M11534Employee assisting another employee in turning a wheel valve with a pipe wrench. Employee slipped off of platform and struck mouth on pipe wrench handle.
220253170556M13147Employee was exiting the skidsteer at the sand plant, when their right foot slipped in between the equipment bucket and cab. Their body then fell forwards. The employee reported a pop in their knee and sought medical treatment. The employee was diagnosed with an unspecified injury and placed on restricted duties.
220253170557M11914The employee bumped into the chute gate valve an activated the chute gate, which struck a scaling bar they were using to relieve muck. The end of the bar caught their left cheek and cut them.
220253170558M11263A miner overheated during the shift, cycled round with minimal breaks. Started cramping and went to hospital to get iv fluids.
220253170560M13237On 10/27/2025, a haul truck operator experienced a jolt during loading but reported no pain. On 10/28, they noted ongoing discomfort and declined medical care, stating Tylenol was helping. On 10/30, symptoms persisted and they requested evaluation. Diagnosed with muscle strain; prescribed muscle relaxers for use off duty.
220253170562M11123Employee stood up from a squatted postion using both legs and felt a sudden pop in left knee with onset of pain.
220253170564M10872Working in the garage on a truck the die grinder slipped cutting employee's right hand.
220253170565M13438While the Mobile Equipment Mechanic was in the process of closing one of the Shop sliding doors with left hand, their left thumb was located between the side of the left door and the right door, resulting in the thumb being pinched between the two doors when at the closed position. The injury required closing lacerations of the thumb tissue.
220253170566M12446Plant Electrician was responding to a pump outage and was walking to the area when they took a step off step onto a concrete walkway and slipped.  The employee fell backwards and fell against the corner of the fiberglass step, breaking one rib.
220253170567M12997Employee was using an air lance with 90 psi air to clear a chute plug in the #4 Finish Mill feed chute. The employee lost grip causing the air lance to hit them in the mouth. They initially declined medical attention. On 10/24/2025, they requested to be seen at the emergency room due to mouth pain.
220253170568M12676employee reported to the site for shift start at 0400.  Employee was in the employee break room at 0345 and other employees noticed they seemed off and when they were communicating with them they determined they should call 911.  Paramedics came and took the employee
220253170570M10922Employee was gritting their teeth while loosening a bolt. Employee chipped and bottom tooth.
220253170571M11053Quarry worker swung the hammer trying to split a rock, and missed the wedge, hit their left pinky finger.
220253170572M11754Handle on trailer slipped while lower mast arm, sticking employee on lower face below the lip. Employee given 4 stiches to close the laceration and returned to full duty work.
220253170574M11935Employee and coworker were working on screeners when the employee started to climb up to a work platform. They placed left foot on the first step, then slipped, twisted, and strained upper leg.
220253170577M13828Two EEs had been tasked with relocating a portable dewatering pump due to insufficient rainfall over the past few months. The EE's were uncoupling the intake line when the hose fell, and the metal flange locking collar struck the EE's hand. The EE suffered a laceration during the event and immediately went to the clinic, where they received five stitches and restricted work duty.
220253170579M10732For unknown reason, haul truck veered over the berm and into quarry lake.
220253170581M13207On 9/22/2025 While attempting to open a door that was stuck employee felt a pain in their elbow. Employee chose not to be evaluated at the time and do first aid measures on their own. On 10/27/2025 employee went to the clinic was seen by a Doctor who diagnosed employee with Tennis elbow and prescribed a steroid pack.  
220253170582M12395Day of incident and on, the injury was treated as a first Aid. EE's injury became a modified work duty on 10-29-2025.  Equipment Operator was descending the ladder and missed the last step causing EE to fall and injury EE's right shoulder.
220253170584M10902Electrical contactor failed causing the production hoist to be unavailable for operation. 
220253170585M11945Auxiliary Cage (MaryAnn Cage) was shut down at approximately 6:00 pm on October 30, 2025 due to accumulator leak of the hydraulic power unit. Accumulator was slowly leaking off nitrogen charge. 
220253170586M10622Employee was hit by 25lb bucket - became reportable 10/20/2025
220253170589M10471Body mechanics / preexisting medical conditions
220253170590M11494EE backed up to berm to dump fill over embankment when haul truck went over the berm and down the embankment. EE had several bruises and broken ribs.
220253170591M11403Employee was washing haul truck when lost balance and struck right side of chest on scaffold planking fracturing two ribs and injuring knee.
220253170592M11103Employee was adding a fellow employee who had fallen to their feet and injured their head/neck and lower back.
220253170594M13849Employee was unloading a haul truck at a stockpile.  The truck bed raised about 4 feet then stopped and would not go any further.  When the driver switched the dump switch to neutral to lower the box, the box dropped with no hydraulic cushion.  When the box made contact with the frame it shook the truck.  After the incident the employee complained of soreness in thei back and neck.
220253170595M10922Employees knee buckled while descending the stairs and employee fell and twisted their knee.
220253170596M10983Operator slipped dismounting a motor grader, lost grip on the ladder and fell on the grader blade.
220253170597M13618A cement truck driver operating within the area of a mining operation turned vehicle on its side while trying to get ahead of a rock truck using a common dirt service road. This was a single vehicle accident with no injuries and only the cement truck was damaged. The driver was evaluated by Mount Vernon Fire Dept (MVFD) Unit 493 and refused further treatment.
220253170599M12145The employee was descending the ladder from the top deck of the cone when a hand slipped approximately midway down, causing them to fall to the deck below. Reported to management 10/30 when diagnosed with a hernia.
220253170600M10772EE was removing a loader bucket pin when it slipped and fell on their finger.
220253170601M11323EE was cleaning rock using pry bar.  Pry bar slipped, pinched left thumb between bar and framing, resulting in left thumb contusion.
220253170602M10672EE was removing a bucket pin which slipped and fell on their finger
220253170604M10702While cutting flashing, accidentally cut left hand with a razor knife.
220253170606M11814While lifting the longwall crusher into the cage using the overhead crane, the crane faulted.  Had to get equipment to replace the fuse to continue loading and hoisting the crusher.
220253170607M11193Employee was doing maintenance work on a wing pulley by using a sledgehammer when a small piece of metal hit their eye.
220253170608M13668Injured person was working on the hydraulic system of a D8 Bulldozer in the morning. Had to access the system below the floorboards of the equipment, and was working in an awkward position. Later in the day, they experienced pain in side/stomach and left work to seek medical care. At the hospital the employee was evaluated for back pain and prescribed hydrocodone.
220253170609M10391Employee was rough loaded in haul truck
220253170611M12696EE was operating the Kubota SCL-1000 Stand-on Compact Loader. The EE was backing up and made contact with a stairway handrail striking left leg. EE was taken to a emergency facility for injury evaluation. EE was placed on two day restriction resulting in leg contusion.
220253170613M13187Employee was working on the long reclaimer. Employee went to reposition and while doing so slipped and left butt cheek landed on the point of a metal plate. This caused a 2cm puncture to butt cheek. This didn't become a medical until they went to wound care and they started packing the wound. This started on Oct 29th
220253170616M11514Employee was changing springs on the 8x20 screen.  Employee was trying to remove the spring when the chain broke allowing the spring to pinch a finger.
220253170619M11914Loader operator drove to Central Control for a pre-shift safety meeting. While exiting the payloader, the operator missed stepped on the last rung and fell backward, landing on the left hip. 
220253170620M13768INCIDENT HAPPENED 08/13/2025 NEVER PLACED ON LIGHT DUTY. RECEIVED PHYSICAL THERAPY-FULL DUTY. PRESCRIPTION ISSUED ON 11/06/2025. FULL DUTY. EMPLOYEE WAS HELPING PACK A PALLET WITH TWO SMALL CYLINDERS, TRIPPED OVER A PALLET, AND FELL ON TRUNK. PALLET FELL TO THE GROUND. THE ZIP TIE HOLDING THE CYLINDERS ON THE PALLET BROKE, ONE ROLLED OFF ON EMPLOYEES R. ANKLE AND LOWER LEG.
220253170623M11574While dismounting Dozer 01, the employee led with their left foot onto uneven ground. Upon contact, they experienced pain in the left distal quadriceps area.
220253170624M12556The Employee was caring an electric winch onto the Raw Mill to help with the Discharge grate job.  While descending the steps to the mill The Employee trip and fell on top of the mill with the winch in hand.  They injured their left ankle during the fall.
220253170627M10772Miner pulled himself up by grabbing onto a pipe and felt a pop in their hand.
220253170629M11103Employee was getting out of loader stepped on first step and fell backwards. Employee has had lower back pain.
220253170630M13307EE states they were grinding a handrail by VSI crusher when a piece of metal went into eye. EE stated they were wearing proper PPE for the task. EE sought medical treatment the following night where the foreign body was removed from left eye. EE did not report the initial incident or subsequent medical treatment to the employer.
220253170631M13678The crew was working on pulling power cables getting the plant set up. When two employees were pulling cable through a hopper extension. One employee was pulling cable with their hand resting on the back of the conveyor. The hopper extension slipped out of workers causing it to fall onto the resting employees fingers lacerating their middle, ring, and pinky finger.
220253170634M11093Employee was shoveling carryback material from under a conveyor belt tail area and felt pain in lumbar spine.
220253170638M11995THE MINER WAS WORKING ON AN EXCAVATOR, WHILE REPLACING A HYDRAULIC HOSE AND WHILE LOOSENING THE HOSE, THE PRESSURE BUILT UP AND THE FLUID HIT THE MINER IN THE FACE AROUND THE LOWER LIP AND CHIN AREA.
220253170640M11624Employee was working on 154 plant weather was sunny temp was 82 degrees. the plant was clean of debris. Employee was bent over went to stand struck head on I-beam
220253170645M11043Employee was screwing into plastic reputs. Due to prescribed antibiotics employee developed Photophobia.
220253170646M10842Employee was utilizing a shovel to clean around plant when they strained their back.
220253170654M12195Employee was working on a chute during maintenance. That evening they noticed something in their eye. They went to OMP and was evaluated for foreign body in eye that the dr removed and prescribed prescription eye drops.
220253170655M11193Stepped off of forklift onto uneven ground causing a minor fracture to left foot injured employee is on restricted duty
220253170656M12305When shovel dipper was coming out of the bed of the truck, a rock came out of the dipper and struck the dovetail, jarring the driver. Driver was taken to the ER and given time off, missing next shift, fully released on 11/03/2025.
220253170657M13327Operator was working on drain hatch for Zn stock tank. Operator had difficulties removing bolt. They then asked for help from another operator to cut bolt. They started cutting the bolt with pliers, as the cut was being made the sawzall blade jumped and hit the operator with the pliers in the hand causing a cut requiring stitches.
220253170658M11013EE had been using a pry bar on a head pully to rotate it and it slipped when they gave it a good tug.
220253170663M11724Employee notified me @ 8:25 am that they had hurt their shoulder shoveling under a belt line. They said they thought that they had pulled something in their right shoulder.
220253170664M13297Employee was pulling a sample from Rotary Kiln 2. The sample window would not stay up. Employee opened the access door to pull the sample. When employee closed the door, they pinched right pinky finger between the latch and coal pipe support. This resulted in an open fracture and laceration to the tip of the right pinky finger.
220253170668M11774While setting up a chain breaker to disconnect the drive chain on an Elevator, the handle of the tool detached and struck the employee in the mouth, resulting in a chipped tooth
220253170669M11894Miner shut down the Astec Wash Plant for maintenance, after approximately 30 minutes the miner removed the radiator cap when anti-freeze splashed out and on the miners hand, arm and face.  
220253170671M11293Was changing a hydraulic motor on telesmith while loosening bolts my finger got smashed while holding bottom nut removing bolts .
220253170672M12796Employee was climbing the ladder to the 901 Dust Collector, at the top, hand grip slipped causing the employee to fall forward causing a laceration to arm pit on the metal latch for the safety chain. The laceration required the employee to undergo a procedure to close the wound.
220253170673M11754Employee became entrapped in the Step 1, 2 Agglomerator basement elevator. The main gate was notified at 852 AM and the employee was able to safely exit the elevator 927 AM.  
220253170674M13217The injured employee was throwing away scrap metal (metal, rollers, etc.) into a dumpster. The employee had the truck parked next to the dumpster. When they went to throw something in, they said they "felt a pop in their back". The employee was taken to the hospital for examination. The doctor stated it was back spasms.
220253170676M12315While operating a WA 500 loader, the operator went through a small dip at an angle causing the loader to rock. Although employee was wearing a seat belt, the operator was thrown off balance and hit their head on the side RH window.
220253170677M11914Employee was changing v-belts on hummer screen when the counterweight moved. The employee's glove was caught by the v-belt causing a finger to be pinched between the belt and the belt pulley.
220253170678M12155While installing a timing belt on a screen, the counter weight came down pinching employee's middle two fingers on left hand between counter weight and flange. Diagnosis: Open fracture; injury of nail bed of finger.
220253170679M12245Employee was going to grab something off the desk in the PM tent. Tripped and hit the corner of the desk. They informed a coworker who brought them to H.E. Shop. Employee went to the supervisors office and then to the clinic
220253170680M12035The injured was putting the thimble on the new skip and noticed that it needed a couple more shims. While pushing the pin out, thumb entered the hole and was injured between the thimble and the draw bar.
220253170681M13408Employee was working on the Silo spout 7B, was in man lift with another employee untangling cable.  Started to get cable untangled and used spud wrench to turn motor until cables untangled. When they untangled it activated the slack sensor and motor was energized and began to spin spud wrench cutting employee left arm top of wrist 3" down
220253170691M11233Employee was changing a plugged Niro lance when it sprayed hot slurry on the upper inside of arm, resulting in burn injury.
220253170692M11614Miner was using a prybar. Prybar slipped, striking miner in face/right eye, causing them to fall on their back. Fractures to right orbital socket, 2 broken ribs.
220253170694M10672Employee was walking up stairs when they felt a sharp pain on calf.
220253170696M13778The back in 4SB and 27WB fell above the anchorage and was discovered at approximately 9:30am on 11/3/25. Workplace exams from the intersection showed no hazards at approximately 4pm on 11/1/25, so the accident occurred sometime between then. The area was immediately barricaded off and it did not block travel routes or impeded escape. No miners or equipment were hurt/damaged.
220253170697M10502Employee driving haul truck hit another haul truck
220253170698M11604EE stepped out of the lull (left leg first), and did not realize they were stepping off into a low spot or hole. As the EE exited, they rolled their left ankle.
220253170702M13438A temporary EE stated that sharp pain was felt while working with a second EE to install new bags onto cages for a dust collector. The injury was reported at the end of the shift and the EE declined treatment. The next day, the EE stated that the pain was bad. The EE was seen at a doctor for lumbar pain, which resulted in work restrictions. 
220253170703M11894While an employee was walking to their vehicle at the end of shift, they slipped and fell from the ice and snow. Employee was evaluated for continued pain and was given time away from work.
220253170705M13748EE and cohorts had lowered the counterweight following a repair from the previous day. EE went up in a manlift to observe operation when they became entangled in moving machine parts of the 48-inch conveyor. EE was degloved from the shoulder to the forearm, has multiple fractures including wrist, thumb, scapula and shoulder. This injury will require skin graphing as well.
220253170707M12335While an employee was walking underground, they tripped on a rock and fell on their knee. Employee received first aid at the time of the incident and was later taken to the hospital for worsened pain resulting in time away from work.
220253170708M12005Haul truck CAT82 was in the process of being loaded by Shovel 44 when, during the initial bucket load, a concealed boulder within the material struck the truck bed, resulting in a rough loading event.
220253170711M11083While standing near a loader, the employee jumped back and twisted EE's ankle when the loader moved forward.
220253170713M10562Grinder slipped while in use, causing laceration to leg.
220253170714M11413CAT79 experienced a rough load event while being loaded by Shovel 44, positioned on the outer edge of the cut and working in course material.
220253170715M11864Employee was guiding a forklift moving a heavy motor. the motor became lodged on the floor of a connex, and in attempting to dislodge the motor, it rolled on the top of their right foot.
220253210001M13778Cutter AGG driver (NOT Heidelberg employee) proceeded to the pit loading area and exited the truck to correct an issue with the gate locking system. While attempting to engage the gate latch manually, the latch moved unexpectedly, causing the gate to slam shut and crush the end of the driver's middle finger. The driver immediately left the facility to seek medical attention.
220253210002M11083Employee was lifting a water bag off of trailer, it slipped from EE's hand and hit EE's right foot/ big toe.
220253210005M10963EE entered haulage path on vehicle and found backfall across road impeding pathway. Stope: 40ARM
220253210006M10722Employee pinched finger of left hand between frame and wrench of lathe. 
220253210008M10592Employee step down from front end loader and rolled ankle. 
220253210011M13247Injured worker was working on hopper underneath the 6x16 screen. The job was welding patches. EE had EE's back leaning against the wall with one leg extended and the other one bent while welding. When the job was done, EE extended EE's legs, and EE's knee was numb. And started feeling like EE pulled something on EE's back.
220253210013M10441Employee fell backwards and hit head on rock
220253210014M11744Employee was diagnosed with a hairline fracture of the right foot with restrictions. This was caused by the employee foot bending when the crusher rotor rotated unexpectedly.
220253210015M10872Employee tripped on det cord injuring wrist and shoulder - became reportable 10/31/2025
220253210016M12907The employee was helping a mechanic repair a piece of equipment. While holding the nut on one side of a bolt, the mechanic tightened the bolt from the opposite end. The employee did not maintain a secure grip on the bolt, resulting in the bolt slicing the side of their right middle finger.
220253210017M13257Employee was assisting with repairs to the dredge using a cutting tool and torch to remove a bolt. Bolt head was struck with sledgehammer causing bolt to shear and fragment penetrating employee in lower abdomen. Employee was taken to ER and transferred to another hospital where employee is currently having emergency surgery
220253210023M12666Miner was emptying dust collector, material flushed going in both eyes under glasses. Miner sent to emergency room, both eyes flushed out, eyes drops prescribe making this a reportable injury. Miner was released to full duty on 11/7/2025 after follow up appointment.
220253210025M10652Lifting bucket of dirt for lab testing reinjured shoulder strain.
220253210026M10952Employee filled water pump with gasoline while unit was on. Gas ignited and burned both arms.  
220253210028M12385Employee was removing old rails from the inside ring that belongs to the mill crusher. When needing to reach the top rails the employee rolled the ring and as it took off it caught their hand between the ring and a tote that was close by.
220253210029M13157EE was pulling with pry bar and thought they had aggravated a previous back injury. EE later found out that it was a new injury right above existing one requiring surgery. EE reported surgery on 11/5/25. EE had surgery on 11/12/25 resulting in lost time incident. Employer was not aware of new injury until 11/5/25.
220253210030M13688Emp was stuck by a angle iron brace that was being used to hold up a roll of belting. The angle moved and the piece struck them in the left shoulder causing them to fall to the ground.  They worked the rest of the shift and went to the ER after the shift.  They treated them for left shoulder and elbow pain.  Employee was placed off work until next Tuesday, 11/18/25.
220253210032M11534Mechanic was using a chain hoist, working on a Cat Artic truck, as they were working the handle on chain hoist they pulled a muscle in their left forearm
220253210036M12937Employee was hosing in the crusher bowl when the employee tripped and fell landing on their left knee. Employee continued to work and felt something running down their leg when they observed a cut below the left knee. Employee was evaluated at the ER and received medical treatment (stitches).
220253210040M11504A mechanic was attempting to remove a zip tie on a plug while using a utility knife when it made contact with their left middle finger, lacerating it.
220253210041M10922Crusher was running when employee walked underneath and was struck by a rock that rolled off
220253210043M10421Had a standard threshold shift in Left ear
220253210044M11183Employee was working from the 2nd or 3rd rung of a ladder when it slid out and they fell off and landed on their side.
220253230008M13167Employee was cleaning out the bottom level of the feedend and removing unused metal from feedend area. As EE was dragging the piece of metal out, EE tripped over another piece of guarding EE had previously moved into a pile to dispose of. EE fell onto a piece of angle iron on the pile and cut the back of EE's knee.
220253230011M12115Employee was lifting up a 3/4 ton come-a-long to another employee when EE strained something in EE's neck and shoulder on EE's left side.  Employee went to clinic on 11/10/2025 and was placed on restricted duty.
220253230012M10612Mill Ops Employee tripped over feed cart track, rolled ankle.
220253230013M11393Operator was removing a guard on the crusher plant when the final bolt slipped and the corner of the guard fell against EE's lip cutting it
220253230014M10983EE fell from the top of the engine, sustaining a nasal fracture and a laceration to EE's forehead.
220253230017M11203Docking lift gate level pulled in right index finger of EE into roller. Amputation of right index finger at 2nd knuckle.
220253230018M11153Pry bar slipped while pulling material out of the cone pinching arm between the pry bar and the guard. Injured arm.
220253230019M10973The miner was cleaning up the walkway when EE picked up a large rock and felt a pop in EE's back.
220253230022M13788Employee had bolted the face up tight then backed out roughly 50', was reloading bolt supplies when a piece of material fell from in between the roof bolts. It struck the cab and broke over the side striking the employee who was on foot next to the cab/engine bay checking the water level. Employee received laceration to their head and leg which were closed at the hospital ER.
220253230023M13568An employee was a passenger inside of a fellow employee's personal vehicle that was involved in an incident on the quarry road headed to return to work from their break. Employee initially declined medical treatment but, on the 12th, requested to been seen by medical professionals. Employee was diagnosed with a mild concussion and was given restrictions.
220253230025M12876A process attendant clearing material under the East/West CCDC screw reached into a leak hole, where their finger contacted the moving screw, amputating its tip. They reported the incident immediately, received first aid, and was taken to the ER for a tetanus shot and further treatment.
220253230026M13768On 10/30 employee had filled crusher with diesel & was descending the ladder. As EE was stepping down their foot slipped causing them to hang onto the handrail by their right arm. First aid was administered from that day forward. On 11/14 EE requested to go to the clinic. Diagnosed with strain of their right shoulder rotator cuff. Prescribed medication and physical therapy.
220253230027M11574EE was walking on even ground near the oversized conveyor and slipped on a slick spot causing them to twist their left ankle and fall to ground (same level).
220253230028M13748Employee was using an angle grinder kneeling on the ground grinding a piece of steel. the grinder had guard in place and a handle. when finished they went to get up with the grinder in right hand the grinder still had some momentum and struck left hand index finger. They called the supervisor and went to urgent care and received 8 stiches. Employee was wearing C.R. gloves
220253230029M11784There was a roof fall in the tailgate of the longwall measuring 15ft to 20ft long and 7ft to 8ft high. The fall did not restrict ventilation, cause injury, or impede escapeways. 
220253230030M10471A gust of wind blew debris into employee's eyes
220253230032M12015EE was using a cat telehandler to move urethane sheets from the shop to chem ad, load shifted and EE stopped and was attempting to readjust the load when they heard a small pop in their right shoulder.
220253230033M13728Employee was removing accumulated metal from the magnet. During the removal of a large piece of metal, the angle iron shifted and struck the employee on the left side of the head below the hard hat brim. Employee sustained a laceration requiring a staple and a tetanus shot. The next morning, the Coworker reported dizziness and nausea and was diagnosed with a concussion.
220253230034M12426Employee was building plow assemblies on metal table, when attempting to flip it, the plow slid and flipped rapidly which caught a finger resulting in a smashed finger and laceration.  Employee was wearing work gloves during time of incident.
220253230036M13297On November 10th at about 2:30 PM one of our van shipping employees received a laceration to their left thumb/palm. The employee was attempting to open a pair of bundled shipping ratchet straps. When the employee attempted to open the packaging, the knife slipped, striking the palm area of left thumb. Resulting in a laceration.
220253230039M12836The EE was inspecting the wet plant hopper belt, when they lost balance and placed left hand on the belt. This resulted in their hand being caught between the belt and hopper frame. The injury sustained was a laceration to the left palm and contusion to the upper side of their hand.
220253230040M12355On 11/14/2025 at approximately 9:24 am a person drove off the roadway into our pond. They were not an employee. No employees/owner were present when this accident occurred. It is being investigated by the Hillsdale County Sheriff Dept.
220253240001M11253Lost the kiln mcc and lost power to kiln draft, and the atox feed belt caught fire. Fire was controlled in about 15 minutes. 
220253240002M11133Employee was unloading pipe off a flatbed trailer when EE lost EE's footing and fell, falling on EE's right side.
220253240004M12255Conditions were dry and no adverse conditions were noted. EE was ascending the ladder on HT-29 (777g CAT HAUL TRUCK) in order to enter the cab. EE felt a pain in EE's rt knee while climbing.  EE notified pit foreman via text.
220253240005M12205EE was walking out of The office and took a bad step. EE fell landing on EE's knee and wrist. EE notified EE's supervisor in which EE decided to go to the doctor to get checked out. The doctor diagnosed a sprained wrist.
220253240006M11213Employee was operating a small front-end loader.  Employee said while operating the unit, EE received a Perianal Abscess.
220253240007M10391Brush fire near the south berms of pit.
220253240008M10582Employee received a laceration to the head after falling. 
220253240010M11674At approximately 7:25AM ground fall was reported in the TQR 3910 MBY001. The ground fall occurred at the face in that heading, approximately 150 tons of material fell.
220253240011M135182 employees were working on a palletizer, but only one of them had it locked out. When the locked out employee was done, they asked the other employee if they were clear, and heard "yes". The other employee was still working, and when the machine  was started, their right hand was caught, amputating the index finger, and degloving the middle finger.
220253280002M11103Drilling hole in rubber gasket which slipped out and struck employee's hand causing laceration on right thumb.
220253280007M10662Concussion from rolling water truck - became reportable 11/10/2025
220253280008M10431Climbing down ladder felt pop in right knee
220253280009M11654During routine crusher maintenance, a fire started in the #1 screen deck. Fire extinguishers were used but not effective. 4 people were treated for smoke inhalation.
220253280010M11654During routine crusher maintenance, a fire started in the #1 screen deck. Fire extinguishers were used but not effective. 4 people were treated for smoke inhalation.
220253280013M11684EE was adjusting the press when EE stepped back and slipped, falling to the ground.  EE injured EE's ankle, knee and back and was put on light duty.  Diagnosis pending.
220253280014M12045At approximately 8:25am, the supervisor was notified that an a ground fall had occurred in an inactive drift near the face. The wire was hanging down and SX ground support bolts were attached to the wire.
220253280021M10802Employee was struck in the head by another employee sustaining a nasal fracture.
220253280022M12446Employee was using water hose to clean out under crusher when there was a change in water pressure causing employee to fall forward. Employee received 5 stitches to LT eyebrow. Discharged to full duty with no restrictions and no prescriptions. 
220253280025M11494Employee was walking on slightly uneven ground and felt a slight pop in left knee. Physical therapy on 11/20/25 made it become a reportable incident.
220253280027M11103While walking downstairs, team member slipped exiting the last step which made them fall against the handrail.
220253280029M12646Employee was injured when they fell walking to the troop carrier. Injury became reportable on 11-18-25 when an orthopedic specialist diagnosed a left shoulder partial rotator cuff tear and left shoulder proximal humerus fracture. Physical therapy was also ordered.
220253280030M10522Employee felt pain in back after hitting a hard knob
220253280031M12195Employee was cutting an all-thread bolt with a handheld grinder. The grinder kicked back and cut them on the left leg above the knee. Employee was check by a medical professional and returned back to work that same day.
220253280032M11604EE was removing a punch plate from the shaker tower when the plate moved unexpectedly pinching two middle fingers on right hand against the frame of the shaker.
220253280033M12295While EE was cleaning material off a catwalk a rock from an overhead conveyor fell and struck them in the back of the head as EE was bending over causing a laceration. The EE received staples at a local clinic to close the wound.
220253280035M11073Employee was climbing into a rock truck when they felt something pop in lower left leg and had severe pain.
220253280036M11113The miner was working on changing a cone liner on a crusher.  Daylight hours, no precipitation. 0-7 mph w winds
220253280037M13027On November 20, 2025, at about 3:00 p.m., the Maintenance Clerk was repositioning a 24x20-inch picture frame when it broke. Falling glass struck the employee's left kneecap, causing a one-inch cut. The incident was reported immediately. The employee received four stitches; no restrictions were issued.
220253280038M12295EE reports left knee turning wrong when getting out of work truck, and ee heard a pop. On C4, EE reports stepping on a rock. Seen at clinic, released with restrictions. Diagnosed with strain, and additional diagnosis pending MRI.
220253280039M13237The employee slipped while descending two steps on the north mezzanine floor in Coloring. During the fall, they lost right-hand grip on the handrail, fell backward, and struck the corner of a toe board with the upper left side of their back. The injury resulted in fracture of the left thoracic 8-9 ribs and a bruised lung.
220253280048M11925Employee stepped in a hole causing them to lose balance.  They fell backwards and attempted to catch themselves with left arm extended.  They suffered a wrist injury when contacted the ground.
220253290001M12195Two employees were clearing material from the feeder box. While using hand tools to remove remaining buildup, an employee's right little finger was caught in a pinch point on the feed box cover, resulting in a fracture.
220253290002M12195Employee was using an 8-10 lbs. hammer to assist with the removal of a tooth off a loader bucket. A piece of the tooth broke off, roughly 2-3 mm in size, and struck the employee on the back lower side of EE's right leg.
220253290005M11043Employee was cleaning deck when EE got up, EE hit EE's shoulder on the corner of the power screen frame.
220253290006M11093After kneeling down while performing maintenance work on a conveyor belt, employee experienced knee swelling.
220253290007M11604Employee was climbing down the stairs on Loader at the end of EE's shift. EE let go of the rail to close the door of the cab and fell backward on to the ground.
220253290008M11474Employee is a Stone Splitter.  The employee was splitting stone with a chisel and hammer when they missed the mark and hit their left pinky finger.
220253290011M10471Employee was climbing up ladder on haul truck. 
220253290012M13378Employee accompanied another employee and a lead employee to go over some program reset training on the refinery retort. While programing the retort with the lead and other employee observing, EE paused, looked straight in the air, began whispering something, slowly stepped in circular motion and fell face forward going into a seizure.
220253290013M12335Ee tripped on a backpack someone had left in the walkway. EE fell and hurt EE's right shoulder. Seen at ER, released to full duty. On follow-up EE was released to restrictions, and referred for PT if EE does get progressively better.
220253290016M13388Employee punched in at 7:00 a.m.  They reported to the trimming machine and at 7:30 a.m. they tripped on a floor mat in the trimming shed.  When they tripped, their hand fell into the blade when they tried to catch themselves. Their right hand has three broken fingers. They went to a doctor and was told they should be out for 6/8 weeks.
220253290017M11914The employee was pressure washing silo #6 and was found with their head and right arm in the silo with salt buildup on their head and right arm. The employee was pronounced dead at the scene.
220253290021M13087Employee was making a shovel cable connection when the cable rolled, pulling the employee's left arm forward. The employee experienced left arm pain and was evaluated at the local ED where images revealed an injury to their left bicep. The employee was prescribed work restrictions and is being accommodated.
220253290022M11083While lowering a light on a electrical box, the light came down and hit their jaw, fracturing a molar tooth.
220253300002M13097The employee and EE's crew were lifting and setting a landing and steps in place between the scale and the office. During the task, EE felt something in EE's abdominal area. EE went to the doctor, and they confirmed it is a hernia that will require surgery at some point. We don't have a date for surgery yet.
220253300004M13788Employee was changing out return rollers on a belt. Employee was lifting return roller on the one side into place on bracket. The roller slipped and dropped to the floor 12 inches smashing the right ring finger fingertip between the floor and edge of roller causing multiple fractures and laceration to fingertip. Employee was sent to VRMC and returned to work with restrictions
220253300007M12636The employee was assisting in installing a new drop pipe. The pipe remained secured but shifted from its placement, and the employee on the ground had a hold of it to keep it from swinging and felt the impact of the pipe shifting and felt discomfort in EE's back.
220253300008M11975EE was dragging 4" bulk hose across barge deck to tank for hook up.  Upon getting close to tank, EE turned to hook up hose, striking the fill line with upper center part of forehead along hair line
220253300009M13558Approx. 10:39pm on 11/22 we were contacted by Thornton fire dept. with a request for access to recover the body of an individual who had jumped to their death from Interstate 80/94 Tri-state tollway. The body was located approx. 150' below the road surface and was not accessible from the quarry & Was NOT Part of Mine Property according to Property Maps.
220253300010M13818On 5/13/25 EE lifted an oil bucket onto a truck with right arm and felt pain in shoulder. EE told their supervisor but didn't seek medical evaluation. When the pain persisted EE requested a doctor's appointment and was seen on 06/25/25 where they were treated for strain of rotator cuff & prescribed PT. EE had MRI on 8/1 and then surgical repair of right rotator cuff on 11/20/25.
220253300011M11313Employee stepped off of the frame of the shovel and as EE stepped down, EE lost balance and fell as EE felt strain to EE's left leg
220253300012M10842shift supervisor noticed top of telephone pole in Quarry on fire while doing rounds.
220253300013M13368Employee was demoing an out of service AC unit. Employee unbolted and removed the first section of the AC frame, set it on the floor, and reached for an impact. When they reached for the impact, they tripped and fell down to their left knee. Their left knee and shin landed on the piece of demo that was on the floor and cut their shin.
220253350001M10702While freeing up a brake system, piece of rust got into employees eye.
220253350004M12506Equipment Operator using pressure washer to wash Front End Loader. Tried using pressure washer to wet a rag that was being held in their right hand while holding pressure washer wand in their left hand. Injected water into their right middle finger. 
220253350005M12796While standing at the control panel of a portable screen a large rock fell from the top surface and struck the top of EE's hard hat.  The hard hat shell contacted EE's head, causing a cut to EE's scalp.  The impact knocked EE down and caused pain to EE's back and right shoulder.
220253350007M10682Employee was hit in head with shovel - became reportable 11/12/20205
220253350008M10812Employee fell dismounting power step on haul truck - became reportable 11/12/2025
220253350009M10532Natural Causes possible Heart Attack to loader person
220253350011M10121Hearing loss
220253350013M10532Climbing down a ladder attached to a bucket elevator.
220253350015M11474Coworker was replacing bolts on the D8 cutting edge when their left middle finger was cut on a sharp metal edge. The injury required five stitches.
220253350016M13327Employee was removing a belt wipe for replacement and was holding an end wrench on a stuck nut while another employee used an  electric impactor to the bolt end for easy removal. The injured employee was holding the wrench loosely and the wrench spun with the nut striking the end of right thumb, fracturing themost distal phalange.
220253350017M10722Miner climbed above heights and fell 4ft, resulting in Patella fracture.
220253350018M11764Replacing return roller on locked out conveyor belt system when jack failed and belt pinned hand against roller. No broken bones, pinched muscles and loss of sensation to hand.
220253350019M13498EE was washing out the raw mill posimetric chute with a water lance. The water hose became entangled with the door, causing the door to begin closing. The door struck the employee's right right wrist resulting in a contusion. The injury became reportable on 11/18/25 when the doctor performed professional medical treatment during a follow up visit.
220253360003M10772Using box knife to make hole in belting. laceration to right thigh, 2 staples
220253360007M12175EE was cleaning the debris off of the hopper grizzly. When finished EE decided to step/jump off of the ledge onto a sandpile 2-3' below. When landing EE's foot landed on small rock causing EE to roll/break EE's ankle.
220253360009M11283Employee was prying on a part.  The part gave way, causing the employee to step backwards into a hole, sustaining a knee sprain.
220253360011M12866while loosing a bolt the bolt broke loose and teammate fell forward and stated EE felt pain in EE's left hip. teammate was seen and released to full duty and was seen again on 112625 due to more complaints of the affected area. released with a steroid shot. to full duty no restrictions
220253360017M13037Noise came from primary screen area. Shut down primary screen. Yard loader saw missing bolt. Plant shut down for repair. Employee entered steps to screen and called noise coming from crusher. Was told to leave area b/c it was unsafe while crusher was coasting down was hit in buttocks. No visible marks.
220253360020M11784Employee was installing a drive belt on the primary grizzly feeder with two other employees. During the task, their left thumb became wedged between the drive belts and a pulley,
220253360021M11444Employee lacerated forearm just below the elbow while running the bagging machine in the Fine Grind Plant.  The wound required sutures to close.
220253360022M13077A contract truck driver was delivering Ione clay to the plant. After dumping almost all of the material from the end dump trailer. The driver climbed inside the trailer to remove some material that was stuck to the bottom of the trailer. The driver was found unconscious and unresponsive inside the trailer.
220253360023M12716While two employees were working around a tail pulley of a conveyor belt, there was miscommunication between the guys on the ground and the plant operator. This resulted in the belt turning on and grabbing one of the employee's sleeves, pulling them into the tail pulley.
220253360024M13247On 12/1/2025 MSHA was notified that the vertical shaft hoist was being taken out of service due to intermittent issues. The brake alarm was resolved after adjustment per manufacturer specification. There was also a problem with a control wire, which was changed out with a spare. No miners were injured due to this incident.
220253360025M12015Miner was spinning off fuel filters when the tip of their left middle finger got pinched between the filter and the filter housing.  This resulted in a non-displaced tuft fracture of left middle finger
220253360026M11654After operating hours and after employees were gone for the day a plane crashed into the crushing plant. The occupants of the aircraft were pronounced dead on scene.
220253370001M12917Employee was in the process of installing a continuous miner bit insert using a brass hammer. A piece of the insert broke off and pierced the employees hand becoming embedded. Employee taken to the ER and given two prescription medications. EE was referred to a surgeon for removal of metal.
220253370003M11073Employee was attempting to lift the end of a office desk and pulled a muscle in the left arm. Lifting item.
220253370004M12726Employee was walking on flat ground to check a fire extinguisher. EE felt EE's knee twist and notified management. First doctor said it was not work related.  The company was notified on 11/23/25 a second doctor deemed it work related. Employee will have surgery 1/6/2026.
220253370007M12526Employee was washing out under the cone crusher to prepare for maintenance. While performing the task, employee slipped and fell landing on EE's ribs. Was seen at local ER and prescribed pain medicine. Was able to return to work with zero restrictions.
220253370008M11353While climbing into the D8 dozer, an employee's foot slipped. As a result, their weight shifted onto their left shoulder, causing pain.
220253370010M12526Employee was chasing threads on an impeller when the employee's shirt sleeve was caught in the vane of the impeller. At contact employee pulled away thus dislodging impeller which caused it to hit employees left side rm and the left side of their face.
220253370011M10732STS confirmed by audiologist on confirmation test. No referral required. 
220253370013M10201unknown at this time
220253370014M12275The employee was offloading EC2 into the storage silo when a band clamp broke off, causing the hose to come loose from the connection and blow dust on the employee's face. As a result, the employee did get CKD dust in left eye.
220253370016M12235The employee was climbing down off of a railcar and made it to the ground and slipped. They cut left leg on an unknown object. They reported to their supervisor and was taken to local emergency where they received stitches.
220253370017M12957Excavator operator on stripping crew was stepping down out of the excavator when they felt a pop in left calf area of leg.  The employee let their supervisor know and continued to work the remainder of the shift. The injury increased in pain and the employee was sent to the occupational clinic.
220253380001M12496Employee was cranking a cable winch to pull the dust stacker conveyor sideways. The cable guide bar on the winch failed. The broken bar flew up striking the employee on the right side of EE's face causing a laceration, fracture and right eye injury.
220253380002M12786On 12/1/2025, (reported 12/3/2025) Miner was removing belt clips over K1stone tunnel belt with a grinder. Small piece of debris went under eye protection hitting EE's right eye. Attempts to flush eye were unsuccessful, employee received additional treatment at local eye doctor.
220253380004M10471Employee fell off EE's chair hurting EE's back.
220253380006M13788Employee had cleared a jam from the cone crusher and was making sure it was going to run correctly. While observing the cone crusher a piece broke off and became lodged then ejected striking the employee in the hard hat. Employee states that they had a severe headache, legs felt weak and they were sensitive to light. Went to emergency room and was diagnosed with a concussion.
220253380007M12716When driving the work boat in the fog, the operator was driving to the shore and could not see the dredge anchor cable, the cable traveled over the hoist crane at the front of the work boat then struck the operator in the face, causing a abrasion to EE's eyebrow and ear.
220253380008M10812Employee was getting off the Crain and slipped. They fell, landing on their butt.
220253380009M12776Miner was checking oil on the D8 Bulldozer and they slipped on the tracks. Their foot went between the tracks and cab, and their ribs hit against the grab handle. They injured their ribs. 2 weeks later on 12/1/25, they sought medical care and were prescribed a muscle relaxant.
220253380010M12375While assisting a subcontractors employee experiencing a medical emergency employee felt pain in lower back. Employee tried to manage the pain by stretching and doing at home exercises. Employee requested medical treatment on 11/17/2025.
220253380012M11744Miner was shoveling rock into buckets at the tail end of the limestone tunnel and hauling the buckets outside the tunnel to dump. Miner hurt their lower back in the process. 
220253380013M12496while turning power back on during a planned outage the generator for hoist shut down causing the hoist computers to shut down. This required the hoist computers to be rebooted causing the sync switch to fault out. The hoist was down for 37 minutes.
220253390002M10892Driving haul truck across pit. Hit a pothole strut broke and tire went under the machine.
220253390003M11393Coming off hill with loader, hit a pothole with loader, bucket went into ground causing EE to be thrown forward and hit the steering wheel.
220253390008M12205EE was working in an electrical panel while setting up a new crushing facility. The breaker below the one EE was working on blew up and burnt EE's hand. The manager of the facility was nearby and took EE to the hospital.
220253390011M11053Employee was walking around screen conveyor tail pulley when EE tripped over the guard and hit EE's knee.
220253390013M10692Employee missed hand rail on haul truck and fell and fractured pelvis
220253390016M13307There was no accident. Employee was seen slumped over in front of the dump truck. Witness asked if they were OK. Employee stated they couldn't breathe and started to faint. Witness called 911 and stayed with employee until EMTs arrived. Employee was alert and conscious when EMTs arrived. Employee was transported to the hospital.
220253390017M12556EE repairing track on CAT track loader. EE was hitting a pin with a sledge hammer, Pins held track segments together. Two small pieces of metal flaked off and went into EE's left hand. EE worked 7/15, had surgery 7/16. Out 7/17-7/18. Light duty 7/21-7/25.
220253390018M12866Employee was using a hammer to dislodge oversized rock in a screen cloth to begin shift. They removed safety glasses when they could no longer see through them due to steam. Employee proceeded with the task, and a rock was projected toward their unprotected eye resulting in the injury.
220253390022M13277The employee was walking into the scale area of the office and tripped over a mat in the office causing them to fall against the counter, breaking their arm. They also hit their nose and head. They never lost consciousness and were transported to the hospital for treatment. They are doing well and a full recovery is expected.
220253390023M11985Employee was working at the secondary plant, Scree #3 middle deck using a cutting torch. The torch cut off, employee bagan to wipe th etip, the torch backfired and caused a burn to their left wrist.
220253390029M10812Fire in coal mill dust collector was reported to MSHA phone hotline. No injuries.
220253390032M11383employee was helping step Eco blocks up for new crusher and got EE's left leg caught between two blocks and hurt both left knee and ankle.
220253390033M12546Mechanic was removing teeth off of a bucket using an 8lb sledge. There was no specific incident of injury but the mechanic explained that EE's elbow became sore, EE's grip strength became diminished on the right side, and pain worsened through the night.
220253390035M11494Employee was the pipe trailer deck unloading pipe when a pipe slipped out from under EE, when EE tried to catch self EE landed on EE's right shoulder
220253390036M12466Employee was attempting to slide a drain grate with EE's hands reaching into the grate.  The grate moved and EE's left index finger was pinched between the grate and a metal tab holding the grate down resulting in a laceration requiring stitches.
220253390037M11013Smashed finger between steel frame and prybar while trying to remove built up material from a roller.
220253390038M10692While shoveling pit on VS2, employee felt a pain in EE's right elbow.
220253390041M12796Employee was removing debris from cutter in cutless area. When removing a large rock the rock shifted, smashing the employee's left middle finger.  Employee was wearing gloves. Went to clinic for evaluation and received five stitches. Employee was also placed on restricted duty.
220253390043M11904Unsafe walking surface.  Slipped and landed with chest onto a small mound of stone while carrying a grease gun.  Grease gun was between chest and mound of stone. Pain in right side of chest.
220253390044M11313Miner was sealing a new airlock door and the door came into contact with left ring finger causing a tuft fracture to the fingertip.
220253390045M12556While climbing down from a ladder, miner grabbed an unsecure handle and was thrown off balance. Miner proceeded to jump off ladder and land on their feet due to off balance. Upon impact, miner fractured their right ankle. Height was approximately 6ft-9ft.
220253390047M10832EE was laying concrete and got it on their leg. EE was took to DR. and was treated.
220253390048M11273EE was on the 5th floor of the mill washing when a rock (4" + size) came down from the 6th floor striking EE on the Left Elbow 
220253390050M13057Sections of the back between 01SB-02SB and 10EB-11EB fell past the anchorage zone at some point in time and was discovered on 12/3/25. The entire area has been bermed off since 2020 so the area is considered inactive. All entrances to the entire bench cell have been barricaded against entry at this time.
220253390051M10832Kiln #1 baghouse ductwork unplanned ignition. The pressure resulting caused damage.
220253390052M13718DZ599 operator was backing up in second gear when the park break self-engaged causing the dozer to come to a complete stop resulting in the operator's experiencing whiplash to their neck. IP received no treatment and declined care. On 12/04/25, IP was using a track hoe and caused aggravation that worsened with time. Sent to RMMC for care and was prescribed medication. 
220253420002M10572Employee injured finger when shroud material fell onto it
220253420003M10431Employee slipped when dismounting equipment
220253420004M12355While the IP was loading snow covered drill steel onto their Light Vehicle, the steel slipped from their right hand, forcing the left hand into a plastic bucket, injuring their middle finger. (Fracture of the bone under the fingernail)
220253420005M12746Employee running loader underground and claimed they were jerked side to side due to the abrupt transitions in the roads.  They noticed possible hernia on 11/26/25 and reported to management on 11/29/25.  Employee was seen by a physician on 12/1/25 and placed on light duty.
220253420006M11253Employee slipped and fell while walking around equipment during fueling. Employee's left wrist was injured breaking the fall.
220253420007M11393During the time of the incident the temps were in the mid 20's and it had snowed earlier in the day, resulting in slippery track conditions
220253430004M11854While stockpiling with a front-end loader, miner felt miner pain in lower back.  Towards end of shift, pain had worsened.  By next morning, pain had increased causing miner to go to ER.
220253430006M12295Employee experiencing shoulder pain on 12/3/25 from a preexisting injury that occurred on 4/18/25. Employee slipped on ladder descending from 70-ton truck. Right hand slipped, quickly re-grabbed rail, felt pain in right shoulder.
220253430008M11784Employee was fueling front end loader and walked away from the equipment and when EE heard the fuel overflowing ran to stop it, stepped on a rock and employee sprained the ankle.
220253430010M11734Mechanic was climbing out of bucket elevator and felt a pop in the right knee. Employee was still able to perform task and did not miss work until surgery date of 12/4/2025.
220253430013M13267An employee experienced a sudden and severe cardiac event while at work. Coworkers immediately called for help and initiated emergency response procedures. Despite rapid assistance from onsite responders and EMS, the employee did not survive. The incident appears to have been a medical emergency unrelated to work activities.
220253430014M13107A mechanic was cleaning dirt from an oil drain plug using a screwdriver when a piece of debris dropped into their eye, resulting in material becoming embedded. The employee was immediately taken for medical evaluation. The metal fragment was removed, and antibiotics eye drops were administered and prescribed.
220253440001M13177Being trained in shut down for days end & accessing issues/repairs for next days start up - operator in process of shutting down power. New EE stepped onto conveyor beltline still running, other EE motioned EE to get down & new EE slipped and hit conveyor belt which carried EE down to pinch point trapping EE's foot.
220253440004M13718Employee was attempting to clean a return roller on conveyor under the HP 300 crusher, against company policy, without utilizing lock out tag out training. EE was using a bar to scrape mud off the return roller. The bar was caught between the roller and moving conveyor belt, pulling the EE's left arm into the pinch point and resulting in broken bones and a dislocation.
220253440005M13828Miner was finished tightening a flashing on Powerscreen 1400 portable tracked screen plant. Said EE stumbled, probably on a rock, when turning towards EE's service truck and caught self from falling with R arm using service truck to keep from falling. This is EE's account of what happened. EE did not report this until next day. Inj to shoulder. EE placed on lite duty for 60 days.
220253440006M11383Employee went to flip the switch on the disconnect box to start plant components when they cut their finger on a sharp edge of the switch.
220253440009M12586Miner had removed the steps to close the door of the control van. Miner re-entered the control van. As miner was exiting the control van, miner attempted to jump to the steps and missed the landing. The miner landed on the right foot and injured their ankle.
220253440010M11554EE was walking inside the revolving frame of the dragline and stepped on one of the floor lids, causing EE to lose EE's balance. EE fell and hit EE's side.
220253440011M11013Employee experienced Personal Medical causing them to injure their foot while stepping out of shower.
220253440014M11093The employee was exiting breakroom walking back to sweeper truck, during snowstorm slipped and fell on snow. 
220253440017M11534Miner was cleaning the tower using a bar and a sledgehammer. Miner hit the bar with a hammer; a piece of metal broke off and flew into the miner's eye.  
220253440018M12696Ee dropped drill bit. When EE lifted it back up, EE felt a pop in EE's right biceps tendon. Seen at clinic, referred to ortho. On 12/5, ortho confirmed MRI results show full tear of right biceps tendon, and ee scheduled for surgery on 12/30. Ee working restricted duty.
220253440021M11233While a Hitachi EX 5600 hydraulic shovel was digging in a shot pattern it is suspected it contacted an undetonated booster.
220253440022M10542Employee smashed finger - became reportable 11/25/2025
220253440023M10301Employee cut finger with knife
220253440025M10963EE slipped on ice, fell between two boulders, rolled over top of them, and landed on their back.
220253440030M13317Employee was attempting to open the back door of a UTV, and the front seat passengers opened their door to assist. Employee was able to get their door open before front passenger exited the UTV and placed their hand on the door jam. During this time the front seat passenger closed their door and smashed employees' thumb in door. 
220253440031M13207Employee was changing screens and had one slip and hit their back, at the time of the event they felt ok but after the shift their neck, back and shoulder started hurting so they went to the dr. they did x-rays everything was clear and employee was released for full duty the Monday after Thanksgiving at the same visit.
220253440032M13277The injured employee and another employee were attempting to clear out a plugged jaw discharge chute. While hitting the chute with a sledge hammer in order to dislodge the plug, the injured employee hit the edge of the chute, pinching a finger between the chute and the handle of the hammer, fracturing the tip of their finger.
220253440033M13097A 793 C haul truck was ascending a ramp loaded and lost traction. EE attempted to back up down the hill and contacted a berm which overturned truck.  A bucket truck was used to help the EE exit the truck. The EE was entrapped in the cab more than 30 minutes. EE was suspended pending outcome of investigation.
220253450003M13678EE was cleaning debris under the bottom conveyor of crusher, when EE step out away from crusher and watching rollers the step fell down towards head. Leaning down hardhat fell off. 2nd staff assisted the staff that was hit by step, secured the wound area with gauze as it was bleeding. 2nd staff got EE to a unit and rushed to ER for treatment. 15 min from pit to ER.
220253450004M13658EE is believed to have received insect bites on 10/11/25. On 10/14/25, the EE sought treatment due to swelling, redness and itchiness at the bit site. EE received a steroid injection, prescription antibiotics and was advised to go home and rest. EE went to urgent care for follow-up on 10/16/25. Operator notified on 11/17/25, when urgent care invoice was received.
220253450008M10642Large rock flew off of table after chopped and hit arm directly.
220253450013M12556Employee arrived to work for the start of day shift. On their way into the truck shop from their personal vehicle, the employee slipped and fell on ice in the parking lot and broke their hip. Employee was transported to the hospital for medical treatment.
220253450014M11965Employee experienced a presumed personal medical emergency at the start of their shift resulting in cardiac arrest. Emergency services responded, however, resuscitation efforts were unsuccessful. 
220253450016M10371EE slipped and fell on EE's right hip
220253450017M12045Employee was cutting metal on the metal rack, after the metal was cut through the cut end came up and contacted the employee's lower lip. The lower lip was bruised, and two lower front teeth were chipped.
220253450021M12987Electrician had the dredge control panel propped open. The prop failed causing the panel to slam down striking EE's left arm just above the wrist. Urgent Care assessed injury as a contusion with no broken bones and directed right handed duty only until follow up appointment to reassess the injury.
220253450022M13347Employee was in the Fabrication shop getting metal supplies for pipe rack when an 8 foot square tubing slipped off rack and struck right foot. EE was taken to medical facility day of injury. EE received second opinion on 11/30/2025 from medical professional where X-ray resulted in fractured #5 Metatarsal. EE is placed on light-duty.
220253450023M12195EE was cleaning a lime discharge chute. The chute went positive, and lime shot into the EE's left eye. Seen at ER, diagnosed with chemical burn to left cornea, transferred to eye specialist. Released to full duty 12/11.
220253450024M12997Employee was on a work platform prepping bags for the packer. An airline came off the packer placer arm. The employee saw the adverse condition and quickly came down the three steps from the work platform. The right gastrocnemius muscle ruptured when the employee stepped down onto the cement floor.
220253450026M11203emp was cleaning mud from dozer tracks with shovel at end of shift and struck a bolt causing jarring motion in arm/elbow
220253450027M11053End of cable slipped out, whipped back, and hit employee in the eye while feeding it into a wedge socket.
220253460001M10973While performing start of shift hoist checks, the weight brake would not release once it was set.
220253460002M13237EE was installing air header onto existing HDPE pipe valve. EE tightened the vic between the valve and header. EE realized the header needed to be rotated so EE used the impact and started to loosen the bolt. EE inadvertently loosened the bolt on the charged side of the valve causing the header to break free from the vic.
220253460003M11584Operator was stepping off of pickup truck and right food stepped in a hole and rolled right ankle, resulting in a sprain.  restricted duty began on 12/11/2025
220253460004M12245Mechanic was moving a loader cutting edge from a pallet onto the forks of a forklift and when dropping it onto the fork EE's finger was caught smashing EE's right index finger and causing a laceration which required sutures.
220253460005M11644Operator was walking on uneven ground and felt pain in their knee. After evaluation employee was placed out of work by the medical provider beginning on 12/10/2025.
220253460006M10963Employee prying a cylinder pin and the pry bar slipped and struck their wrist, hand and forearm.
220253490006M10983Employee was climbing ladder out from rod mill, right knee buckled and now is swollen and painful.
220253490008M13067Employee was removing roof bolts from pushed up scaling pile, after EE placed a bolt into the bucket of the loader EE was operating, employee tripped or lost EE's balance and fell to the ground at the base of the pile striking EE's head on a rock, employee suffered laceration to eyebrow and a broken nose.
220253490009M12135STS on EE's Audiogram. The standard threshold shift for EE may or may not have been from the workplace. EE wears hearing protection onsite. This may be from being around loud engines and shooting firearms offsite.
220253490010M11864EE was walking to tool-house, on recently cleared snow, slipped and fell on shoulder.  EE went home that night with mild discomfort.  Came in the next morning wanting to get checked out.
220253490011M11484OPERATOR HAS A BACK ACHE FROM THE SEAT CUSHIONS BEING WORN OUT. OPERATOR CANNOT WORK BECAUSE OF THE BACKACHE. THE CUSHIONS HAVE SINCE BEEN REPLACED.
220253490012M13518Ee was walking to clear plugged chute. EE reports rolling EE's ankle on an unseen object. EE reports hearing a loud pop in ankle. Seen at ER, xrays negative for fracture, given ace wrap and crutches, released to restrictions. Site cannot offer temporary modified duty. EE released w/restrictions, site is offering modified duty. EE has no missed time.
220253490014M11393While shimming the jaw, EE reached up to grab the hoist, and some loose fine material fell and got behind EE's glasses and got in EE's eye.
220253490017M12466The incident occurred on 12/1 but employee didn't report it until close of shift on 12/2. Employee was clearing a head pulley when they pulled a rock out another fell smashing their left pinky causing a fracture.  Our employee was wearing gloves.
220253490018M12516Two workers were attempting to get a coupler off a plastic pipe. One worker's hands slipped as they tried to turn the coupler and their left ring finger hit a pipeline component or the pipe wrench causing two cuts to this finger. Sutures were applied.
220253490019M10902Was replacing a hydraulic hose when it slipped out of their hand and hit them on the nose.
220253490020M13748Mechanic was lifting a tire and wheel off a tire machine and felt a pop sensation in their lower right abdomen.  Employee went to the clinic for medical evaluation as needed then reported back to work.  The employee was seen by their primary care physician on December 3rd for additional evaluation.  It was then determined that surgery would be needed to repair the injury.
220253490021M12746Operator disconnected the winch cable from the roll off dumpster. Then, the operators right foot/boot/ice cleat caught on the corner of the dumpsters frame causing them to lose their balance, tripping backwards and landing on their elbow/ shoulder straining their shoulder. 
220253490022M13668Employee was welding wear iron on an excavator bucket when a wind shift reduced ventilation, leading to fume inhalation. The employee reported shortness of breath and chest pressure and received first aid on site before being transported to the ER. The employee was released the same day, cleared to return to work the next day, and diagnosed with airway irritation.
220253490023M11303The IP is employed as a mechanic and was leaning over vehicle trying to loosen seized bolt when had onset of lower abdominal pain.
220253490024M13287The IP reports that they were walking on the stair after MSHA class for lunch when they felt their Right knee "catch" and began to be painful with weight bearing and lateral movement. Progressively gotten worse. The IP was notified they needed surgery 11/14/25, did not return to work on 11/27/2025. The IP had surgery 12/12/25.
220253490025M11203Employee was walking down a walkway stepped down off a step planted their foot and slipped. Causing their ankle to roll.
220253490026M11484Employee was shoveling along side the crusher when a rock 28" x 30" x 4 1/2" fell and landed on their ankle. Causing a sprain/strain to their ankle.
220253490027M10792Roof fall at 17hg return 3 entry xc 5. Roughly 10' high 20' wide and 30' long. 
220253490028M12516There was a roof fall in 18H 3 entry xc 5 intersection. It fell on the belt line and monorail in the entry. The fall was roughly 10' high, 30" long, and 20' wide.  No injuries, no trapped miners, and no disruption to ventilation on the longwall face. 
220253500001M10612Getting off the guard of the conveyor and sprained left ankle
220253500002M13287Employee was greasing the conveyor belt without following proper safety protocol, specifically failing to perform a lock-out/tag-out on the equipment before commencing work. Simultaneously, coworker turned the plant equipment on, unaware that employee was working on the conveyor. This resulted in employee's arms being crushed.
220253500003M10862EE was cutting skirt rubber with a utility knife and slipped cutting EE's right thigh.
220253500004M11674Employee felt soreness in left shoulder after using a 4' bar and 8 lb. sledgehammer.  THIS INCIDENT BECAME A RECORDABLE ON 12/8/25 WHEN EMPLOYEE RECEIVED RESTRICTIONS.
220253500005M11945The employee's left leg slid out and the right foot stayed planted. The employee caught self, but felt a pop in their right knee and maneuvered to the ground until emergency response was called.
220253500007M11273Employee was setting up service cart and took step back into crack causing them to roll ankle. Became reportable on 10/31/2025.
220253500008M11113No unsafe conditions were present. Employee was doing basic clean up and back became painful after shoveling.  
220253500010M13267EE was preparing to weld inside Screener 724 during light rain, with a tarp placed over the screener to keep the area dry. Before work began, a chunk of ice fell from the top of the birdhouse, slid down, and struck EE while EE was inside the screener, causing minor injuries to EE's chest wall, right upper arm and lower back.
220253500012M13388While service tech was performing the pre-shift maintenance the crusher. Exc opr was standing near the crusher 4-5 ft away in the area previously cleaned by the excavator, near rock pile. While EE was waiting for others to finish cleaning, A large rock slid off and struck the employee's right foot and caused two fracture and laceration.
220253500013M11484EE slipped on a patch of ice falling onto EE's right hand that was holding a hammer. EE fractured the middle, ring, and pinky fingers of right hand.
220253500014M1342812-2: Tech reported to supervisor feeling knee pop/pain while squatting to pick up a tray off the floor. 12-3: Tech had knee evaluated & diagnosed w/knee sprain-full duty. 12-10: Day before returning to rotation, follow-up for worsening pain/numbness & requested off-duty until MRI. Lost time began 12-11 pending MRI & follow-up appointments.
220253500016M13227Employee was climbing down two steps off the ANFO rig, placed EE's left ankle on the ground (approximately 12 inches from bottom step) and it rolled when EE released the handrails on the step. Immediately reported to management and eventually found to be non-displaced fracture of the lateral Malleolus of the left fibula.
220253500019M12395Employee was cleaning a chute and their hand was jammed into the side of the chute opening, causing a cut on their right index finger.  The employee received 4 stitches at the ER. No restrictions were issued and returned to work full duty.
220253500024M12706A miner fractured their hand when it was pinched between a drill steel and the rib/wall. This occurred when a drill steel fell into the slushing lane and got stuck between the ribs. the miner tried to pry the steel free when the steel pinched their hand against the rib.
220253500032M13849The employee was working on hands and knees on and off for several hours and when they stood up they felt discomfort in right knee. Employee was working with other employees changing out plastic coated screens in a shaker deck assembly. No visible bruising, light to moderate swelling with pain realized behind the kneecap.  Unable to keep full weight on right leg without discomfort.
220253510001M11363While operating a stand-on skid steer in reverse, the employee made contact with a piece of metal causing bruising to their right thigh.
220253510002M13788IP completed loading railcar & advised trackmobile operator they were ready to move car while trackmobile Operator was pressuring up air system IP decided to go back on top of the car without notifying trackmobile Op. IP was strapped into fall arrest system which caused them to be drug across the top of moving cars. IP suffered a fracture to a vertebrae and bruising to torso.
220253520004M13227EE was trying to climb into the truck and had EE's hands on the handrail. EE had to pull self up to the next step and started to feel sharp pain in EE's right hand going all the way to EE's arm. After miners latest doctor visit, Miner has been put on "Do not Work" status per miners Medical provider until next evaluation.
220253520005M11844Had gone to get a tool, walking across the concrete pad between the crush and feeder, fell off the concrete slab. When EE fell EE scaped right knee, ripped my pants and scaped my knee.
220253520006M13478An employee was hooking up a drum basket to a forklift, EE bent down to lift and slide the right-side fork to align with the basket, when EE lifted the fork, EE felt like an impact to EE's lower back. EE was taken to the Tooele Utah hospital where EE was diagnosed with lower back muscle sprain. EE received 2 injections for pain and inflammation.
220253520007M12596EE on 12/16/2025 reporting back pain, due to an injury on 12/13/2025. They started changing a return roller and felt pain and reported to supervisor, but thought was going to be alright. On 12/16/2025 employee is requesting medical care and taken to local ER.
220253520009M10692Employee allegedly struck in head by chain causing cut on forehead.  
220253520010M10752Cable tray slipped from hand and employee tried to catch it pulling on arm.
220253520015M11083Patrick Lovins was working on the jaw of crusher and injured their left ring finger resulting in 3 stitches.
220253530001M11143while leaning forward EE felt a pop in EE's lower left leg. was medically evaluated and was diagnosis as a strain.
220253530003M13267The employee was assisting in loading an X-ray machine into the back seat of a pickup truck. The weight of the machine shifted in EE's hands unexpectedly, resulting in EE's hand being pinched between the corner of the machine and the center B pillar/door jam of the vehicle, resulting in a laceration to the right ring finger.
220253530006M11504Injured was working with another employee to lift a 200lb roll from cart to material lift. When twisting at the waist, felt a pop in lower right back.
220253530007M11834Employee was lifting a desk with other employees into the back of a pick-up truck. When the employee bent down to lift and stood up, EE felt pain in EE's back and down EE's right leg.
220253530010M13808Employee was using an utility knife to cut a hose off the radiator of a portable water pump. EE was cutting with right hand, they allowed their left hand to get in the way. The blade passed through the hose and made contact with left thumb. Employee was taken to clinic where they received 5 stitches. They returned to work after leaving the clinic. No restrictions, no lost time.
220253530011M11444Mine Maintenance Employee lost balance and fell backward onto dipper floor when pry bar slipped out of leverage point, injured hip and shoulder.
220253530012M12646On 12/18/2025 the vertical shaft hoist (primary escapeway) was taken out of service due to not being able to close the surface landing door. No miners were in the mine when this issue was found. It was determined a bolt on the landing door track needed replaced.  
220253530017M13618Injured MTM was installing a drive sheave on a pump with a partner. The MTM's partner was installing the sheave while the injured MTM was pushing on the guard. The injured MTM's right pointer finger was in the pinch point of the guard hinge. When the injured MTM felt the pain from the guard pinching their finger, they pulled it out while it was still pinched.
220253560003M11413Employee was working in a 5-man team to screw bowl of crusher in place. While exerting force with EE's arms EE's right shoulder was strained.
220253560004M13548Employee was attempting to remove a screen from the lower deck, when the screen became stuck. The employee chipped out some frozen material and EE attempted to remove the screen again. As the screen came loose, the employee jolted backwards and hit EE's head on a crossmember in the screen. The employee decided to seek out medical attention on 12/17/25.
220253560005M12426At the end of the employees shift, EE was exiting the skip and debris blew into the employee's eye from under EE's prescription safety glasses. EE was seen by a eye specialist who removed a rust particle. EE was released with no restrictions.
220253560006M12796Employee was exiting the loader, and EE's foot missed the last step on the ladder.  Employee fell to mine floor, landing on EE's back.  Initial medical evaluation was for a sprain/strain, but a follow up appointment on 12/16/2025 with X-rays determined EE sustained a broken rib.
220253560010M13027Ee reported to company on 12/12 that on 12/7 EE was lifting and moving a spool of wire repeatedly throughout the shift. EE reports feeling pain that day and the next day. On 12/11 EE went to ER. On 12/15 EE filed a claim for workers comp for the incident, and on 12/19 it was accepted by workers' comp.
220253560011M13147Ee loading a 16' bolt into resin head and centralizer. Coworker pressed button, closing centralizer on ee's hand. Ee seen at clinic, laceration to pinky. Pinky buddy taped and laceration closed with steristrips. On follow-up, antibiotics given for infection, finger redressed and buddy taped. Ee working full duty.
220253560013M13297EE kicked frozen outrigger pad with right leg. EE initially felt no pain but 8-10 hours later, noticed some pain and swelling of the right knee. EE was accompanied by safety to an orthopedic clinic for exam the following day where they were prescribed steroids and given no lifting/pushing/pulling restrictions pending follow up.
220253560014M10932EE slipped down an icy stair way and landed on their arm, resulting in a dislocated shoulder.
220253560015M11724Office cleaning contractor sat in their truck to take a break and was found approximately one hour later deceased. Originally, a report was submitted to MSHA on 11/20/2025.
220253560018M12586EE was changing out water pump when water from the pump splashed them in the face. They continued to work, finishing out the shift. The following day, they went to the clinic, was diagnosed with bilateral conjunctivitis. Released to return to work full duty.
220253560019M12646Employee was installing a door on an elevated building, they used a dead blow hammer to help knock door frame in place, when they hit the door frame the door bounced back and upon trying to catch the door they fell backwards and sprained right ankle when catching.
220253560020M10702Employee had MSHA STANDARD THRESHOLD SHIFTS (STS) during hearing test.
220253560022M12135Employee was uncoupling line inside storage room and a piece of metal on the pipe clamp cut their pinky finger while they were lifting the line. Employee was taken to the emergency room and given five(5) stitches.
220253570001M10441Walking - stepped on a rock or piece of ice.
220253570002M11063Cleaning up around equipment, struck overhead support causing skid loader window to break, glass into eye.
220253570005M11083Employee said they were lifting a box of 8 gauge shells weighing 50 lbs. and  felt pain in their lower back.
220253570006M10983Employee was cleaning a catwalk with a crowbar, missed their spot and hit themselves in the cheek.
220253570007M13838EW was operating 336F#1 CAT excavator with rock breaker. EE was found unconscious by co-worker #1 at approx. 2:00PM. They called coworker #2 for assistance coworker #2 arrived at approx. 2:06PM and they got EE out of excavator. Coworkers began CPR. An ambulance was called at 2:11PM and arrived at approx 2:30PM and crew took over. Ambulance left the site with EE at approx. 3:00 PM.
220253570009M13718A maintenance crew was working on separator rotor cage. While lifting it with steel chokers, one of the steel chokers failed.  Consequently, the other choker broke causing the cage to drop approximately 3 feet. As the cage fell, a maintenance repair got EE's fingers between the cage and the fan shroud where EE's hand was sitting, causing severe lacerations to 3 fingers
220253570010M10502The separation of the rib/arch struck the employee
220253570012M11504Third party Audiologists confirmed  a reportable hearing shift  of the right ear on 12/16/2025. This is a MSHA reportable STS shift if 25 dBA or more.
220253570014M12606EE reports walking to open valve to fill water tank, when right foot slipped on slippery ground causing right knee to twist while trying to maintain balance and not fall. EE describes right knee pain that prevents normal movement and prevents ability to work. 
220253570015M13849An employee was standing at the muster point, preparing to leave for the day. A wind gust blew debris into EE's right eye. Employee said safety glasses were worn. Employee attempted to wash out debris. EE still felt grit in the eye & went to Monahans ER. EEs eye was flushed & EE was released with no injury to the eye, a full work release with no restrictions, & an eye prescription.
220253570018M11333While attempting to hammer a pin back in place on the conveyor, the employee hit EE's right thumb instead of the pin with the hammer.
220253570019M11995Employee was welding new bars to rebuilt grizzly bars when clamp slipped off piece to weld to bars and fell on finger resulting in stitches to left index finger. Welding gloves were worn at the time.
220253570020M13568Employee was performing an inspection on the 90CR001 horizontal shaft impact crusher during a shift change. Upon inspection of the HSI Crusher, the employee found blow bars backed off and was in the process of torquing them when the employee fell approximately 4' onto the underlying 90CV001 belt. Employee received right ankle, shoulder and head injuries.
220253570021M12656Employee was removing a motor and agitator from flocculant machine, when lifting it out it started to slip forward and employee tried to catch it, upon doing so the guard caught the palm of EE's hand cutting it, requiring 5 stiches. Employee was not wearing gloves.
220253570022M11925An employee was cutting a hole in a urethane cover with a blade to access the fill plug when the blade slipped and cut into their hand, causing a laceration between the thumb and index finger.
220253570023M13508While walking to the HT629 at Shannon Q-Point, the dayshift operator tripped on a rock and fell forward. At the time of incident, the operator was wearing their backpack, carrying a water bottle and an additional bag full of cleaning supplies. The operator stated they normally use a flashlight while walking but were not at the time of this incident
220253570027M13097Employee was helping to dig out a conveyor when they walked around the skid steer and stepped on the skid steer bucket when they slipped and fell on the bucket causing their hard hat to fall off and hitting their head on the bucket bolt. This caused a laceration on the top of their head requiring 15 staples.
220253570029M11794Using a wrench to loosen bolts on a waterline. Wrench slipped off bolt pinching their left ring finger between the wrench and pipe flange. Resulting in a fracture of their finger.
220253570030M10692The employee struck their finger on a piece of steel while shoveling.
220253570033M12646Crane Operator was preparing the rig to be strapped to the truss. They placed a shackle on top of the metal beam to position themselves for rigging. The shackle off the beam and fell approximately four feet, striking the employee on the back of right index finger.
220253570034M11313EE was taking a track pad out of equipment, and believes they injured themselves when they were knocking the pins out of the track.
220253570036M11203EE was climbing off the dozer and went to sit their cooler down on the track and slipped falling and hitting their head.
220253630001M12856An employee was riding the elevator down from the 10th floor and the elevator stopped at the 2nd floor. The outer door would open but the inner door would not. The elevator company was notified, and the employee was eventually able to pry the inner door open and successfully get out. 
220253630002M10752A splice atop a SoCal Edison pole arced and caught line insulation on fire.
220253630008M13849Underground mechanic was traversing from the continuous miner onto a 4 foot tall step ladder. The mechanic had EE's left foot on the top step and was placing EE's right foot on the next step. When EE put EE's weight on EEs right foot, the ladder shifted and EE fell approximately four feet to the ground, landing on EEs right shoulder. This injury resulted in a fractured collar bone.
220253630009M10562Employee slipped on frozen ground and broke their ankle.
220253630014M12045At approximately 3:00pm the service cage was downed due to the brakes being applied and not releasing during a pm of the conveyance hoist. A relief valve was not releasing pressure to release the brakes. 
220253630015M12586Employee was attempting to clear a blockage in a chute with a pry bar and missed the chute striking their right ring finger on the side of the chute wall. Initially first aid only, doctor visit on 12/23 found fracture in finger on x-ray making it reportable.
220253640002M13478While cutting steel with a torch under the primary crusher, sparks caused employee's pants to catch fire near EE's ankles. The fire watch told EE EE was starting to burn EE's pants, so EE stopped cutting and put fire out. Employee received burns on both ankles and calf area. EE will be a lost time from 12/24/25 and will be reevaluated on 1/2/26.
220253640003M11704While walking the third floor of the secondary crusher area, the employee reported stepping on an uneven surface and subsequently experienced a sensation in the left leg.
220253640005M11844EE was throwing a piece of metal in the bed of truck and felt a small strain by EE's groin on right side then a bump came and it is hot to touch now. EE will be out of work for 3 days.
220253640006M10832ratchet slip while tightening hand railing on haul truck. 3 stitches to left thumb.
220253640008M12806Miner was scaling with a scaling bar and a rock fell onto the scaling bar and the weight of the rock resulted in downward momentum of the bar and the employee pinched their right hand between the scaling bar and the mine floor resulting in a fractured pinky finger and metacarpal.
220253640009M10562Employee twisted knee while climbing stairs to the lab. 
220253640011M13508The operator was driving a surface loader and hit a bump, which jostled them. They didn't immediately feel pain and finished the shift, but at the start of shift the following day they reported soreness in their back to their supervisor. They were sent to the hospital, where the doctor wrote them out of work for two days to rest their back muscles.
220253650003M12756Employee was retrieving tools from the RM500 milling machine and, as they were descending the ladder, their pant leg got snagged on the ladder step and EE lost EE's balance, falling approx. 5 feet to the ground.  They landed on their right wrist, resulting in a wrist injury.
220253650004M12576Employee was walking from the shop office back to the garage. There is a small depression where the concrete slabs meet, and the employee tripped and rolled their right ankle. Employee was immediately taken to ER and will be out of work due to restrictions.
220253650007M12135Employee was manually sliding a piece metal off the forks of a forklift when the metal rotated and slid off striking the employees left foot above the steel toe resulting in a hairline fracture of the metatarsal. 
220253650009M12035Employee reported neck pain while using an LHD to clean up faces for drills and augers. Upon evaluation, the employee was diagnosed with a fracture. Work relatedness determination was made on 12/29/2025.
220253650011M10592Employee fell on ice exiting EE's car upon arriving to work
220253650016M11935While disembarking a man van, a dayshift haul truck operator stepped into a low, rocky spot and rolled their ankle. The operator stated they felt immediate pain and sat down and asked for help.
220253650018M13257Employee was splitting flagstone with a chisel and hammer the stone they were working on opened up. When employee took the chisel out of the opening of the split rock, the rock closed on their right index finger. A rupture wound from the pressure exerted on the finger and a small tip fracture was the result of the incident.
220253650019M12195EE reported a rash on legs, seen at clinic on 12/2, diagnosed with rash. On 12/23 follow-up, diagnosis changed to chemical burns, EE put on restricted duty, making this reportable. Site offering temporary modified duty.
220253650021M13828Millwright was working out of a Manlift. They knelt down on left knee and put all of their weight on a bolt that was laying on the floor of the basket. This caused pain in their knee. This happened on 10/14/25, they did not report it to employer until 11/5/25. Once they sought medical they were sent to Physical Therapy on 12/17/25 which at that time made it a reportable incident.
220260020002M13568Employee was cleaning the tracks of the bulldozer with a shovel.  EE heard a pop and experienced pain in EE's right arm.  Employee continued to work unrestricted until EE went to an orthopedic specialist on 12/30/2025.  EE was diagnosed with a tear of the right rotator cuff.  The extent of the tear is unspecified.  The employee is now on restricted duty.
220260020004M11233During a bi-yearly chest x-ray a miner was thought to have a spot on EE's lungs that is consistent with "Chronic Silicosis"
220260020005M12055A haulage operator was performing their walk around of the HT630 in the 15 shovel tiedown area when they stepped on lose material in the parking ditch and slipped. This caused a strain in their lower back.
220260020007M10702Miners finger was caught in a belt being tested on an air compressor. 
220260020008M11985Employee was carrying a bucket of stone down the pit ramp and slipped and landed on their elbow, which resulted a bump on their elbow. The bucket of stone was to prevent slipping in other locations.
220260020009M1380812/16/25 EE cut L. index finger when they were rolling O2 tank off of cage and hit it on metal. No medical services were requested. 12/23/25 EE notified safety about cutting their finger on 12/16/25. It was swelling, tender and hard to move. EE had been using antibiotic ointment on the cut. EE seen company doctor and was issued a prescription on 12/23/25. EE is still full duty.
220260020010M11454Getting out of the loader one foot on the ground they turned to step away their other foot caught on the step causing them to fall to the ground.
220260050004M13448Bolter operator and mechanic were aligning carousel on bolter. Ee using a short scaling bar to rotate carousel for alignment. While pulling back, the bar slipped off the carousel collar, causing ee to stumble backwards and fall, hitting EE's head on bolt rack on front of bolter. Seen at ER, lac closed with staples, released with restrictions.
220260050007M10832Employee was grabbing a propane tank and it slipped and landed on their right foot.
220260050008M12395EMPLOYEE WAS PERFORMING REGULAR TASK OF LOADING A TANKER TRAILER WITH MAGNETITE UNDER THE #4 TANK.  EMPLOYEE WAS UNLATCHING THE LAST LATCH ON THE LID OF THE LOAD PORT WHEN THEY FELT SOMETHING PULL IN THEIR STOMACH,WITH A BURNING SENSATION.
220260050010M11614The employee fell while traversing an irregular surface. They put their arms out to catch themselves and sustained a closed fracture to the left radius and ulna.
220260050011M12496The employee was operating a WA600 loader and, while moving backward to forward on level ground, experienced neck & shoulder pain. This became reportable on 12/30/2025 after the employee was placed on restrictions following an orthopedic evaluation.
220260060001M12656EE strains right wrist when rear fender EE is holding with right hand suddenly sags while attempting to latch it back after checking oil level.  Injury originally classified as First Aid by Physician / Restrictions were added by Orthopedic Specialist on 12/23/2025.
220260060002M13708A miner was working at an electrical panel when they attempted to wipe sweat from beneath their safety glasses with their left hand. They did not realize that they were holding a small 14-gauge jumper wire, which contacted the white area of their left eye causing visible redness and slight bleeding. The miner was seen at a clinic and received prescription medication. 
220260060004M12846Two employees were working together to clean up some using a forklift to maneuver drill steels. The employee on the ground had their hand on top of a drill steel when another shifted and moved towards the other steel catching their finger between the two drill steels and crushing it.
220260060005M11363Employee was stepping over a pipe when EE struck EE's right knee on the flange connection and cut through EE's pants, cutting EE's knee.
220260060006M10672Employee slipped and fell due to icy accumulation at the exit door.
220260060007M10111icy walkway
220260060009M11413Employee was operating a 992K loader while loading customer trucks when EE heard a "pop" in EE's right wrist while using the control handles.
220260060011M11714While descending a fixed ladder on the plant the EE reached the lower level and misplaced their right foot on the edge of the concrete causing them roll their right ankle.
220260060013M13548Employee at Mechanicsville Sand and Gravel Site sustained a left foot injury sprain/fracture. Injury happed while exiting the plant access point. Employee stepped down from the concrete step/edge on to uneven ground/material and immediately felt pain and discomfort. Employee went to the local ER, and an Xray was taken and confirmed a left foot fracture
220260060015M10812Van moved before employee sat down and the employee hit their face on the window.
220260060016M10963Employee stepped from the engine hood cover to the cab access platform and sprained right ankle.
220260060018M11353Employee was pulling hose and foot got stuck in mud causing them to fall forward onto their knee. Incident became reportable on 2/12/25
220260060019M11574An employee tried to cut a hose with a utility knife and slipped, causing a laceration to the left middle and index finger. Went restricted duty on 1/30/2025
220260060021M10822Employee struck left hand with a hammer while performing winter plant maintenance.
220260060022M12205Employee was backing away from dryer crusher and their elbow got caught on the clamshell door and when it did it put their wrist in a bind around the control lever guard of the walk behind skid steer they were operating.
220260060023M12486Operator was in the process of clearing the OLD 101 Belt under the Secondary crusher area from a product plug. As EE was walking around the area next to the Old 101 Belt EE slipped fell in Mud due to previous rain, landing wrong on EE's right ankle
220260070003M11293Employee was operating a Haul truck when EE struck a dip in the road which cause EE's arm to jerk resulting in left shoulder pain
220260070007M12536A 3 inch diameter poly water pipe located in a plugged sump shifted, causing the pipe to flex while the employee was inspecting the plugged sump, this resulted in the pipe to contact the employees chin resulting in a laceration which required stitches. 
220260070010M11644Employee was at primary crusher for plant 17 checking for leaks on a skid steer when a rock came out of the crusher causing a small laceration above their left eye.
220260070012M13718EE was exiting a Broderson mobile crane and caught their foot on the bottom edge of the Broderson doorway. The EE tripped and fell approximately 18-20 inches striking their left knee on the ground. The fall caused a minor scrape to their left knee, at a follow up appointment on 1/6/2026 the diagnosis changed to a closed nondisplaced transverse fracture of left patella.
220260070021M10952Mechanic sustained a hand laceration while replacing air filters on haul truck within the bay. 
220260070022M11644Operator of a haul truck fell while cleaning windows on the truck deck, striking their right wrist against the windshield. Received work restrictions on 12/29/2025.
220260080003M12315During routine maintenance of the secondary slitter, the mechanic was adjusting the cutting wheels. While loosening the set screw, the employee's right hand thumb area made contact with the cutting blade, resulting in a laceration.
220260080005M12626Employee slipped on muddy surface near crusher after rainfall, injuring left wrist. Walked to break room, notified coworker, and was taken to Hospital. Treated and released same day; prescribed pain medication and muscle relaxer, making this a recordable injury.
220260090002M10993While welding the employee noticed irritation to one eye and realized EE had something in EE's eye.
220260090003M11183ee was throwing scrap steel into the skip when EE reaggravated a strain in EE's shoulder that occurred the day before.
220260090006M13017Injured employee was holding a truck part while another employee used Sawzall to cut the mounting bolts.  The  sawblade slipped and cut employee across back of Left hand, through gloves.  The employee was seen by on-site medic and referred to further care.  EE received suture to close the laceration.
220260090014M12265Pulling dump truck out of tailing shed. Got out to make sure the tailgate was latched. As EE walked to the rear of the truck EE's feet slipped out from under EE on the icy surface. When EE fell EE landed on EE's left shoulder.
220260090024M11824Due to personal medical illness, employee fell out of pickup truck parked at electrical room in the secondary plant. They suffered a laceration to the forehead and received stitches.
220260090026M11353On 1/5/2026, management was notified of an alleged injury. The employee reported back pain as a result of operating the water truck.   
220260090031M11524A retired employee claims hearing loss due to occupational exposures over 30 year career. Employee says this was identified in a 2024 occupational exam.
220260090032M13818Employee got a piece of debris in right eye. Employee was using an angle grinder to cut bolts from the broken elevator buckets in order to install new ones. They were wearing safety glasses. They said their eye was irritated but didn't think they needed medical attention. They reported the next morning, they wanted to go to urgent care. Urgent care physicians removed the debris.
220260120002M12987EE states that while pulling water hose to back to hose reel on water truck that the EE's foot hooked a frozen clump of material, causing a fall to the ground on EE's left side. EE was seen at urgent care and was issued restrictions due to limited mobility and pain in left shoulder and left thigh.
220260130002M12806On 12/31/2025 at approx 7:42AM the IS belt on the Powerscreen 1700X stopped. EE then approached the machine and found a rock stuck that stopped the belt. EE reached in to pull the rock loose, the belt then took off and injured EE's hand. EE failed to stop/lockout/tagout the belt.
220260130017M12335Employee was installing a head nut to a cone crusher. The employee had EE's fingers in a pinch point between the nut and the cone itself. Once the nut set into place it pinched the employee's right ring finger, resulting in fracture.
220260130021M13778Employees were changing plant screens. While carrying the screens up the stairs employee strained their back. There were 3 employees carrying the screen. One on either side and employee was supporting the middle section.  The employee at the front of the screen lost grip causing the screen to slip.  Employee attempted to catch the slack and tweaked lower back in the process.
220260150002M12616EE was fabricating frame work in the fab area. A piece of steel fell over while EE was kneeling and grinding on the frame. The piece struck EE on the back of the head between the top of the welding helmet and the strap requiring stitches due to head laceration.
220260150021M12796Climbing down the loader ladder using 3 points of contact and when their left foot touched the ground they let go of the ladder - they rolled an ankle when they touched the ground (must have stepped over a rock or in a small hole).  Tried to walk it off but was in too much pain.
220260200055M10702Employee slipped and fell on the snow on the way into the scale house.
220260210002M13448Employee was discarding sand samples into a 5 gallon bucket for disposal back into a sand pile. The employee was in the process of throwing the discarded sand back into the trash pile when they felt a pop in their leg area. Employee was sent to clinic for eval. First aid pulled muscle was diagnosed. Went back 1/14/26 for eval and has hernia. 
220260210006M13257EE was drilling holes to install guard when the drill caught metal and twisted in their hand causing injury. The EE strained their right wrist. The EE did not report their incident until 08.18.2025 after seeking medical attention on 08.17.2025. Injury was inadvertently entered as an OSHA incident and is now being corrected.
220260220001M12145Employee knelt down in maintenance shop to pick up a 2.5 gallon jug of oil.  Employee stated they felt a pop in their knee.  The employee has now (Jan 2026) completed an MRI and received a steroid shot in the knee.
220260220014M11133Employee was checking dust curtain, as they were walking, they tripped over a rock and sprained their left ankle.
220260230004M12626Miner was moving a haul truck wheel chock and felt pain in EE's left shoulder. EE missed no days of work but has now been put on restrictions from EE's Dr. that won't allow EE to perform EE's work duties and will be off work until further notice as of 1/20/2026.
220260230020M10642Incident occurred while installing a new pressurized air system.
220260260005M11774Employee was dismounting portable metso jaw crucher ladder to go to the other ladder on the metso and tripped. The employee scraped their left forearm which required 6 stitches.
220260280004M13849Multiple employees were conducting maintenance on the Sandvik Crusher at Tower 1. Two employees were working on the platform approximately 3 feet above the ground surrounding the crusher, one employee lost footing due to loose material and fell. Plant management and safety were immediately notified, Core Health was contacted, and the employee went to a local clinic for monitoring. 
220260280011M10732Employee suffered a personal medical event and went into cardiac arrest. 
220260290008M11073Employee coming downstairs of a haul truck, their knee popped resulting in 2 tears that require surgery.   
220260300002M11574EE was putting a piece of steel in the steel dumpster and it caught onto EE's glove, causing EE's right ring finger to get smashed between 2 pieces of steel.
220260350013M12927EE was at SD-1 Substation skid placing a 480VAC breaker into cubicle. EE backed truck into position approximately 6-8 ft. from cubicle w/breaker in the box of truck. EE carried breaker to the cubicle, crouched down to insert the breaker into cubicle & felt burning sensation/pain in left arm.
220260350017M12175While cleaning a back-up camera, employee fell approximately 3 feet from the side ladder, striking EE's left shoulder. The employee received only diagnostic care until January 21, 2026, when EE began physical therapy.
220260350026M13077Employee lifted 80-170 lb liners for mill #3 outage and developed right-hand pain after a popping sensation. On May 8 the tendon tightened again; diagnosed with trigger finger. Surgery occurred 1/8/26, with no use of the right hand until 3/11/26. Employee has returned to work with restrictions on 2/2/2026.
220260350035M11904Employee felt pain in neck and shoulder when they manually closed a rail car door on October 20, 2025.  They sought medical attention on January 29, 2026 and was prescribed physical therapy.
220260350056M10912Installing a starter in truck. When they finished the job they felt discomfort in their arm
220260360008M12305Employee slipped and fell on a patch of ice exiting a doorway on the silo tops near belt conveyor 12. Employee reported incident 1/5/26, sought medical 1/28/26 and was placed on restrictions on the follow up appointment on 2/3/26.
220260370021M12015EE was trying to cut rubber flashing with utility knife, when EE's hand slipped and cut EE's left hand. EE went to local walk-in clinic where EE received 3 stitches and returned to work the next shift.
220260400017M13297Miner was offloading screens to change and wrist popped, it was a pre-existing injury. Miner is currently seeing if the pre-existing injury will require surgery and is working full hours at this time. Only limitations are they can lift no more than 5 lbs. They changed their job duties for personal reasons not due to the injury.
220260420008M12806EE reports via phone that while working to replace the dump cables on the #3 dragline, when beating them out of their sockets and missed the swing. EE reports that this missed swing caused the movement to snatch the EE left's shoulder. EE reports left shoulder pain with movement.
220260430004M13177Employee was carrying a ladder and felt a sharp pain in EE's wrist. Employee iced EE's wrist.  Near the end of January the employee felt that it wasn't getting any better and decided to have it checked and ultimately have surgery.  Had surgery on 1/28/26 and returned to work EE's next scheduled day of work, 1/31/26.
220260500014M11173During the night shift, while operating the fuel boat, employee believes they pulled a muscle in their left shoulder.
220260510006M10722Stepping onto boat and step gave away and fell onto left side, rib area.
220260560016M11033Below freezing temperatures, leading to icy areas on the slope. The employee fell, jarring their back. 
220260700004M11674Employee was attempting to move a spout with EE's right leg when EE felt pain in EE's right calf. Employee began physical therapy on 03/02/2026 making this reportable.
220260710014M11023Swelling taking off a bearing. Bearing broke loose and hit their right foot causing swelling/bruising.
220260780021M13508The employee was doing a ground level repair to a water valve. While exiting the repair area, they attempted to step over a water pipe and a connected hose. Their feet did not clear this structure, and they lost balance and fell onto a concrete slab causing injury to their right shoulder.  No safety rule violations were attributed to this incident.
220260790023M12846Employee sought medical attention from EE's personal physician for shoulder pain.  Compensable determination for WC was made on March 10, 2026--making it reportable at that date.  Employee uses pole to poke feed through feeder and has performed this task over many years of employment
220260790024M11193EMPLOYEE FELT SICK AT THE END OF EE'S SHIFT. EE WENT TO THE ER AND FOUND OUT EE HAD BRONCHITIS. EE RECEIVED MEDICATION.
220260790025M13247EE called in to HR 12/21/25 and reported that the issue they was currently collecting short-term disability benefits for was actually a work-related condition due to dehydration, working in high heat and use of a respirator. They filed a workers' compensation claim which was denied. To date, EE has not appealed the denial.
220260790026M11754Ee was drilling and dirt/dust went in right eye. Seen at Golden Health, diagnosed with irritation only, no injury, and given prescription antibiotic as a preventative measure.
220260820002M11584Employee felt pain in the left arm when helping move a window a/c unit.  THIS INCIDENT BECAME A RECORDABLE ON 3/13/26 WHEN THE EMPLOYEE RECEIVED RESTRICTIONS.
220260890032M13818Employee experiencing pain and loss of strength in both hands.  After initial review by Occ Med department at local hospital, employee was referred to Orthopedic Surgeon for review of symptoms.  Surgeon found that employee had carpal tunnel in both wrists recommended surgery.  Surgery was performed on the right hand on 3/20/26 with surgery to follow on the left hand on 4/3/26.  
220260990041M13798Employee was walking along the combing on a barge that was brought in and rolled EE's ankle.  At the time there was just some swelling and no further treatment.  Employee stated in March EE was still feeling pain periodically.  An MRI was ordered and referral to an Orthopedic.  The Orthopedic surgeon provided a prescription for Physical Therapy on 4/6/2026 to strengthen ankle.
220261050002M11644Employee was lifting a barrel of grease into position.  While doing so their foot slipped on truck surface causing body to reflex and drop the barrel into position.
220261170018M12215On 3/3/2026 claimed to be injured from an incident where they aggravated a per-existing injury on 9/9/2025. After investigation the company administered workers compensation. Employee lost time after injury was reported. 
220261240006M11684While using an air lance to clear a chute the employee got clinker dust into EE's eyes.  EE's eyes were flushed and EE was administered an antibiotic eye drop medicine.
220261400005M12676While loading coal on the pile, the operator backed down ramp and turn too soon causing loader to lay over on its side.  Employee refused treatment initially, but was taken for evaluation the next shift.  Operator was diagnosed with a concussion and given medication.
220261590002M13598While walking into a building, a miner slipped on a walkway and attempted to brace themselves to prevent a fall. Miner was able to stop the fall but reported right shoulder discomfort. Physician approved to continue work without restrictions. After continued soreness an MRI resulted in a slight tear on 5/29/2026. Operator received documentation on 6/2/2026.
220261620009M11494Material handler used a shackle to open a slide gate where EE smashed EE's left thumb between shackle and slide gate.  Xray showed a slight fracture.
220261770002M11343An employee of Performance Tire & Service in Carroll, IA, came to replace a bad payloader, resulted in the payloader collapsing on EE.
220262370006M13788Employee was counting parts when a pallet tipped and moyler bit fell on their right foot. Employee was wearing safety toed boots w/metatarsal protection. Employee was brought to the ER for X-rays which were negative for fracture. Employee worked full duty until orthopedics follow appointment on 7/23/26 revealed nonhealing metatarsal fractures and were prescribed restrictions.
220262430007M12015Employee complained that EE was unstable, overheated, and was really red faced.  We called 911 and the employee was taken to Mountain west medical center emergency department. EE was released that day.
220262460019M10963EE diagnosed with arthritis and complains of wrist pain with no specific work event or incident.
220262530023M13057EE was in white ford for 2hrs, clutch went out, pre-shifted another truck, #c-24, and worked for 5.5 more hrs until EE went into turn with excess speed and rolled onto the trucks passenger side while heading to stockpile. Resulting in EE getting thrown into the passenger side due to not wearing seatbelt.
